NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
84 reportsClear category filter97,500 miles · Nov 29, 2010
Engine And Engine Cooling
WHILE DRIVING IN NJ, THE MANIFOLD BLEW AND MADE THE VEHICLE INOPERATIVE. LUCKILY, MY MECHANIC CAME AND TOWED THE CAR TO HIS GARAGE. THE MECHANIC PERFORMED A PRESSURE TEST AND DETERMINED THAT THE 'PLASTIC MANIFOLD' HAD BLOWN. THE ORIGIN OF THE FLUID LEAK WAS BEHIND THE ALTERNATOR. THEN WE DID SOME RESEARCH AND FOUND OUT THAT THI…
Read full complaint
WHILE DRIVING IN NJ, THE MANIFOLD BLEW AND MADE THE VEHICLE INOPERATIVE. LUCKILY, MY MECHANIC CAME AND TOWED THE CAR TO HIS GARAGE. THE MECHANIC PERFORMED A PRESSURE TEST AND DETERMINED THAT THE 'PLASTIC MANIFOLD' HAD BLOWN. THE ORIGIN OF THE FLUID LEAK WAS BEHIND THE ALTERNATOR. THEN WE DID SOME RESEARCH AND FOUND OUT THAT THIS WAS A PROBLEM BACK IN 2004-5. I NEVER KNEW, NOR WAS I NOTIFIED ABOUT THIS PROBLEM. I AM THE ORIGINAL OWNER OF THE CAR. THE CAR WAS JUST INTO THE FORD DEALERSHIP TO DIAGNOSE A "CHECK ENGINE" LIGHT ON, NO DISCUSSION WAS MADE ABOUT THIS MANIFOLD PROBLEM ... THEY EVEN CHECKED FOR ANY PREVIOUS TECHNICAL BULLETINS. SO, NOW WHAT HAPPENS?
NHTSA ODI #10368849
90,000 miles · Jun 14, 2010
Engine And Engine Cooling
I OWN A 1997 CROWN VIC LESS THAN 100 THOUSAND MILES. BOUGHT THE CAR 2 YEARS AGO AT DEALERSHIP IN LOUISVILLE KY. FOUND OUT THERE WAS RECALLS ON VEHICLE AFTER PURCHASE WAS TOLD CARMAX WAS GOOD. NOW HERE I SIT WITH A CRACKED INTAKE MANIFOLD WHICH WAS RECALLED, BUT NOONE EVERY FIXED IT. SOMEONE SHOULD BE RESPONSIBLE FOR THIS, YES WA…
Read full complaint
I OWN A 1997 CROWN VIC LESS THAN 100 THOUSAND MILES. BOUGHT THE CAR 2 YEARS AGO AT DEALERSHIP IN LOUISVILLE KY. FOUND OUT THERE WAS RECALLS ON VEHICLE AFTER PURCHASE WAS TOLD CARMAX WAS GOOD. NOW HERE I SIT WITH A CRACKED INTAKE MANIFOLD WHICH WAS RECALLED, BUT NOONE EVERY FIXED IT. SOMEONE SHOULD BE RESPONSIBLE FOR THIS, YES WAS A RECALL SHOULDN'T THERE BE A LAW TO MAKE SOMEONE STAND BEHIND THE CRACK INTAKE MANIFOLD THIS WAS A 1 OWNER WHEN I BOUGHT IT WITH ONLY LIKE 60000 MILES,. *TR
NHTSA ODI #10336134
60,140 miles · Dec 8, 2009
Engine And Engine Cooling
I WAS DRIVING HOME FROM WORK AND THOUGHT A COOLANT HOSE HAD RUPTURED BUT AFTER HAVING THE VEHICLE TOWED TO MY MECHANIC'S PLACE OF BUSINESS WAS TOLD THAT THE INTAKE MANIFOLD HAD CRACKED AND REQUIRED REPLACEMENT. AFTER RESEARCHING I FOUND THAT FORD HAD ISSUED A RECALL FOR ONLY A FEW MODELS EVEN THOUGH MOST OF THEIR 8 CYLINDER 4.…
Read full complaint
I WAS DRIVING HOME FROM WORK AND THOUGHT A COOLANT HOSE HAD RUPTURED BUT AFTER HAVING THE VEHICLE TOWED TO MY MECHANIC'S PLACE OF BUSINESS WAS TOLD THAT THE INTAKE MANIFOLD HAD CRACKED AND REQUIRED REPLACEMENT. AFTER RESEARCHING I FOUND THAT FORD HAD ISSUED A RECALL FOR ONLY A FEW MODELS EVEN THOUGH MOST OF THEIR 8 CYLINDER 4.6 ENGINES UTILIZED THE SAME DEFECTIVE "COMPOSITE" INTAKE MANIFOLD. MY CROWN VICTORIA IS A 1997 WITH 60,000 ORIGINAL MILES! *TR
NHTSA ODI #10294878
201,000 miles · Dec 29, 2008
Engine And Engine Cooling
WHILE CHECKING THE OIL IN THE CAR, WE NOTICED A CRACK IN THE INTAKE. I WAS WONDERING IF THERE HAS BEEN A RECALL FOR THIS PROBLEM LIKE WITH THE FIREBIRD INTAKE RECALLS. *TR
NHTSA ODI #10253137
67,660 miles · Sep 27, 2008
Engine And Engine Cooling
INTAKE PLASTIC MANIFOLD CRACKED CAUSING LOSS OF COOLANT. VEHICLE HAD 67660 MILES ON IT. THIS IS THE SECOND CROWN VIC WE HAVE OWNED AND IT WILL BE THE LAST. THE FIRST ONE'S TRANSMISSION WENT OUT JUST AFTER THE WARRANTY RAN OUT. WE HAD TO BUY A SECOND CROWN VIC DUE TO THE STEERING MODIFICATIONS NECESSARY FOR MY WIFE TO DRIVE AND …
Read full complaint
INTAKE PLASTIC MANIFOLD CRACKED CAUSING LOSS OF COOLANT. VEHICLE HAD 67660 MILES ON IT. THIS IS THE SECOND CROWN VIC WE HAVE OWNED AND IT WILL BE THE LAST. THE FIRST ONE'S TRANSMISSION WENT OUT JUST AFTER THE WARRANTY RAN OUT. WE HAD TO BUY A SECOND CROWN VIC DUE TO THE STEERING MODIFICATIONS NECESSARY FOR MY WIFE TO DRIVE AND THE CROWN VIC IS THE ONLY CAR AT THE TIME THAT COULD BE MODIFIED TO THE NECESSARY STANDARDS. *TR
NHTSA ODI #10243636
91,000 miles · Aug 28, 2008
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE ENGINE THEN BEGAN TO OVERHEAT. THE CONTACT PULLED OVER TO FURTHER INSPECT THE VEHICLE AND NOTICED STEAM NEAR THE ENGINE. THE VEHICLE WAS TOWED TO A DEALER AND THEY STAT…
Read full complaint
TL*THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. THE ENGINE THEN BEGAN TO OVERHEAT. THE CONTACT PULLED OVER TO FURTHER INSPECT THE VEHICLE AND NOTICED STEAM NEAR THE ENGINE. THE VEHICLE WAS TOWED TO A DEALER AND THEY STATED THAT BECAUSE THE INTAKE MANIFOLD WAS MADE OUT OF PLASTIC, IT FAILED. THE CONTACT WOULD HAVE TO PAY OVER $3,000 TO HAVE THE ENGINE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 91,000.
NHTSA ODI #10240063
65,500 miles · Jun 3, 2008
Engine And Engine Cooling
I RECENTLY DETERMINED THAT I NOW HAVE A LEAKING FRONT COVER/INTAKE MANIFOLD GASKET/CRACKED INTAKE MANIFOLD ON MY 1997 FORD CROWN VICTORIA 4.6 LITER V-8 WHICH WILL REQUIRE IMMEDIATE REPAIR. HAD THIS DEFECT MANIFESTED ITSELF BACK IN 2005, I WOULD HAVE BEEN COVERED BY THE CHAMBERLAN V. FORD SETTLEMENT BUT CLASS MEMBERS HAD TO SEEK …
Read full complaint
I RECENTLY DETERMINED THAT I NOW HAVE A LEAKING FRONT COVER/INTAKE MANIFOLD GASKET/CRACKED INTAKE MANIFOLD ON MY 1997 FORD CROWN VICTORIA 4.6 LITER V-8 WHICH WILL REQUIRE IMMEDIATE REPAIR. HAD THIS DEFECT MANIFESTED ITSELF BACK IN 2005, I WOULD HAVE BEEN COVERED BY THE CHAMBERLAN V. FORD SETTLEMENT BUT CLASS MEMBERS HAD TO SEEK REIMBURSEMENT BY MARCH 16, 2006. SINCE MY 1997 FORD CROWN VICTORIA HAS ONLY RECENTLY STARTED LEAKING COOLANT, I GUESS I WILL HAVE TO FORK OVER THE REPAIR MONIES MYSELF. IS THERE ANY CHANCE OF FORD REPAIRING THIS MANUFACTURING DEFECT GRATIS? F
NHTSA ODI #10229722
100,000 miles · May 14, 2008
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT FELT A STRONG GUST OF HEAT COMING THROUGH HER VENTS. SHE PULLED OVER TO THE SIDE OF THE ROAD AND HAD THE VEHICLE TOWED BACK TO HER RESIDENCE. THE VEHICLE WAS UNABLE TO BE DRIVEN. A LOCAL MECHANIC CAME TO SERVICE THE VEHICLE AND IN…
Read full complaint
TL*THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT FELT A STRONG GUST OF HEAT COMING THROUGH HER VENTS. SHE PULLED OVER TO THE SIDE OF THE ROAD AND HAD THE VEHICLE TOWED BACK TO HER RESIDENCE. THE VEHICLE WAS UNABLE TO BE DRIVEN. A LOCAL MECHANIC CAME TO SERVICE THE VEHICLE AND INFORMED HER THAT THE PLASTIC INTAKE MANIFOLD CRACKED AND NEEDED TO BE REPLACED WITH AN IRON INTAKE MANIFOLD. THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE. THE MANUFACTURER HAS NOT YET BEEN NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 100,000. UPDATED 06/17/08. *LJ
NHTSA ODI #10227738
100,000 miles · Sep 13, 2007
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1997 FORD CROWN VICTORIA. WHILE DRIVING 50 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE VENTS. SHE PULLED OVER AND EXITED THE VEHICLE BEFORE IT CAUGHT FIRE. THE VEHICLE DID NOT HAVE INSURANCE AND WAS TAKEN TO THE JUNK YARD. THE CURRENT AND FAILURE MILEAGES WERE 100,000.
NHTSA ODI #10202891
8,590 miles · Sep 1, 2007
Engine And Engine Cooling
INTAKE MANIFOLD ON MY 1997 FORD CROWN VICTORIA CRACKED ALLOWING COOLANT TO LEAK INTO MANIFOLD. THERE WAS A CLASS ACTION SUIT IN 2005 WHICH I NEVER WAS TOLD ABOUT. *TR
NHTSA ODI #10201674
Official recalls
8Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Mar 14, 2005
ON CERTAIN PASSENGER VEHICLES BUILT WITH ELECTRONIC TRACTION CONTROL, THE REAR BRAKE LINE MAY CHAFE DUE TO CONTACT BETWEEN IT AND A FLOOR PAN STIFFENING RIB, AND A BRAKE FLUID LEAK MAY OCCUR.
Consequence & remedy
Consequence: THE BRAKE PEDAL MAY DEVELOP A "SPONGY" FEEL AND DROPS OF BRAKE FLUID MAY BE OBSERVED BENEATH THE VEHICLE. OVER TIME BRAKE PERFORMANCE MAY BE COMPROMISED AND STOPPING DISTANCES COULD BE EXTENDED WHICH COULD LEAD TO A CRASH.
Remedy: DEALERS WILL INSPECT THE SUBJECT VEHICLES FOR CONTACT BETWEEN THE BRAKE TUBE AND FLOOR PAN STIFFENING RIB. IF CONTACT IS EVIDENT, BUT NO ABRASION OR LEAKS EXIST, THE BRAKE TUBE WILL BE REPOSITIONED TO PRECLUDE FURTHER CONTACT AND POTENTIAL ABRASION. IF INDICATION OF ABRASION OR A LEAK IS EVIDENT, DEALERS WILL REPAIR THE BRAKE LINE. THIS CAMPAIGN BEGAN ON JULY 15, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Nov 6, 2003
ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.
Consequence & remedy
Consequence: IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Dec 16, 1998
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
Mar 4, 1997
VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA03012 · Rear Brake Line Failure
Opened Jul 25, 2003 · Closed Apr 11, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Service Brakes, Hydraulic:fluid
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
IN A LETTER DATED FEBRUARY 25, 2005, FORD MOTOR COMPANY (FORD) NOTIFIED ODI THAT IT WOULD BE CONDUCTING A CUSTOMER SATISFACTION PROGRAM (FORD NO. 04B26) TO CORRECT A REAR BRAKE LINE CHAFING CONCERN IN APPROXIMATELY 44,000 MODEL YEAR (MY) 1997 FORD CROWN VICTORIA AND GRAND MARQUIS NON-FLEET VEHICLES EQUIPPED WITH ELECTRONIC TRACTION CONTROL THAT WEREBUILT AFTER MARCH 19, 1997.THESE VEHICLES HAVE AN ADDITIONAL REAR BRAKE LINE AND A MASTIC PATCH CAUSING REDUCED CLEARANCE FROM A STIFFENING RIB IN THE FLOOR PAN.ODI?S ANALYSIS SHOWED HIGHER COMPLAINT AND WARRANTY RATES RELATED TO REAR BRAKE LINE FAILURES IN THIS POPULATION THAN IN OTHER SUBJECT VEHICLES AND PEER MID-SIZED PASSENGER CARS THAT WERE EVALUATED DURING THE INVESTIGATION.VEHICLES INVOLVED IN FORD?S PROGRAM WILL HAVE THE REAR BRAKE LINES INSPECTED FOR CONTACT WITH THE FLOOR PAN STIFFING RIB.IF THERE IS CONTACT, BUT NO ABRASION OR LEAKAGE, THE BRAKE LINES WILL BE REPOSITIONED.IF THERE IS ABRASION OR A LEAK IS EVIDENT THE BRAKE LINE WILL BE REPAIRED.IF NECESSARY, BOTH OF THE REAR BRAKE LINES WILL BE REPLACED. THOUGH FORD DOES NOT ADMIT TO A SAFETY-DEFECT IN THE SUBJECT COMPONENTS, ODI BELIEVES THAT THE FACTS IN THIS INVESTIGATION SHOW OTHERWISE BECAUSE THE INSUFFICIENT CLEARANCE IN THE ROUTING OF THOSE BRAKE LINES MAY RESULT IN LEAKS IN THOSE LINES THAT MAY RESULT IN INCREASED STOPPING DISTANCES.ODI IS DESIGNATING THE CAMPAIGN A SAFETY RECALL (NHTSA RECALL NO. 05V-086).BECAUSE OF THE LOW RATES OF BRAKE LINE FAILURES IN THE REMAINING SUBJECT VEHICLES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED IN THOSE POPULATIONS AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THOSE VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
RQ03004 · Rear Brake Line Failure
Opened Mar 11, 2003 · Closed Jul 25, 2003
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:fluid; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (4)
Service Brakes, Hydraulic:fluid
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
ODI HAS RECEIVED 40 COMPLAINTS ALLEGING REAR BRAKE LINE FAILURE IN THE SUBJECT VEHICLES, INCLUDING 8 THAT HAVE BEEN RECEIVED THIS YEAR.AN ADDITIONAL 192 REPORTS AND 478 WARRANTY CLAIMS HAVE BEEN RECEIVED FROM FORD.A LEAK IN THE REAR BRAKE LINE CAN CAUSE EXTENDED STOPPING DISTANCE.A SEARCH OF ODI'S COMPLAINT DATABASE FOR PEER VEHICLE COMPLAINTS, USING THE SAME BRAKE LINE FAILURE CRITERIA AS FOR THE SUBJECT VEHICLES AND THE SAME MODEL YEARS (1995-97), IDENTIFIED ONLY 1 COMPLAINT INVOLVING GENERAL MOTORS CAPRICE/IMPLALA/88/98/REGAL VEHICLES AND ONLY 2 COMPLAINTS INVOLVING CHRYSLER LH-CARS.THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER EVALUATE THE FREQUENCY, SCOPE, AND CAUSAL FACTORS RELATED TO REAR BRAKE LINE FAILURES IN THE SUBJECT VEHICLE POPULATION.
EA03001 · Cng Tank Explosion
Opened Jan 27, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
IN SEPTEMBER 2002, A FUEL CYLINDER IN A NATURAL GAS POWERED VEHICLE (NGV) EXPLODED DURING A FIRE.FORD AND VRTC TEST ENGINEERS JOINTLY EXAMINED THE INCIDENT VEHICLE AND REVIEWED TESTING TO DETERMINE WHETHER THE PERFORMANCE OF THE PRESSURE RELIEF VALVE (PRD) WAS PROPER.THE PURPOSE OF A PRD IS TO PROTECT A COMPRESSED NATURAL GAS TANK FROM OVERPRESSURE BY ALLOWING THE CNG TO VENT WHEN THE TEMPERATURE REACHES A SPECIFIC POINT.THE PRD WAS REMOVED FROM THE FAILED TANK AND SUBJECTED TO A YIELD TEMPERATURE DETERMINATION TEST. IT WAS CONCLUDED THAT A DIRECT FLAME (FROM THE INTERIOR OF THE VEHICLE) ONTO THE CYLINDER (LOCATED BEHIND THE REAR SEAT IN THE TRUNK)COMPROMISED THE HOOP STRENGTH OF THE NATURAL GAS CYLINDER, THUS ALLOWING THE CYLINDER TO FAIL PRIOR TO THE PRD RELEASING AT ITSDESIGNED TEMPERATURE.AS A RESULT OF THIS TESTING AND REVIEW OF THE INVOLVED VEHICLE, FORD HAS DEVELOPED AN INSULATOR TO INSULATE THE NATURAL GAS FUEL TANK FROM A LOCALLY DIRECTED FLAME PROJECTING FROM THE INTERIOR OF THE VEHICLE.INSULATORS WILL BE INSTALLED BEHIND THE BACK SEAT ON SUBJECT VEHICLES TO PREVENT FUTURE FAILURES OF THIS TYPE. FORD'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
RQ03002 · Ball Joint Separation
Opened Jan 3, 2003 · Closed Jun 3, 2003
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
SEE ATTACHED REPORT.
PE02071 · Cng Tank Exploding In A Fire
Opened Oct 1, 2002 · Closed Jan 27, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
AN EXPLOSION OF A COMPRESSED NATURAL GAS (CNG) TANK SHOULD NOT BE ABLE TO OCCUR, AS THE TANK IS FITTED WITH A PRESSURE RELIEF DEVICE (PRD). THIS PRD SHOULD RELEASE THE CNG IN THE TANK, PRIOR TO THE PRESSURE REACHING THE TANK BURST PRESSURE.THE PRD DID NOT RELEASE IN THE SUBJECT WISCONSIN POLICE CRUISER EXPLOSION.NHTSA HAS RECOVERED THE PRD VALVE FROM THE TANK THAT EXPLODED AND TESTING WILL BE NECESSARY TO ESTABLISH WHY THIS TANK SAFETY VALVE DID NOT RELEASE IN THE VERY HIGH TEMPERATURE FIRE THAT OCCURRED IN THE POLICE CRUISER.THERE IS ONLY THE SINGLE KNOWN EVENT, BUT DUE TO THE CATASTROPIC FORCE OF SUCH AN EXPLOSION AND THE POTENTIAL FOR INJURY AND LOSS OF LIFE, THIS INVESTIGATION IS BEING UPGRADED.
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
PE98041 · Front Seat Anchor Bolt Failure
Opened Jul 23, 1998 · Closed Sep 29, 1998
Status: closed (inferred from source dates) · Seats
THE DRIVER'S SEAT, OF THE SUBJECT SPLIT-SEAT CONFIGURATION, IS SECURED TO THE VEHICLE FLOOR PAN WITH FOUR BOLTS.A SINGLE BOLT IS LOCATED AT BOTH THE FRONT AND REAR OF EACH OF THE TWO SEAT TRACKS.THESE TRACKS ARE LOCATED ON EACH SIDE OF THE SEAT.IF THE OUTBOARD-FORWARD BOLT FAILS, THE SEAT IS RETAINED BY 3 REMAINING BOLTS.WHEN RETAINED BY 3 BOLTS, THE REARWARD MOVEMENT OF THE LEFT SIDE OF THE SEAT BACK IS LIMITED TO APPROXIMATELY 4 INCHES.THIS WAS DETERMINED BY FORD TESTING AND CONFIRMED BY ODI.THIS MINIMAL MOVEMENT SHOULD NOT CAUSE A DRIVER TO EXPERIENCE DIFFICULTIES CONTROLLING THE VEHICLE.FORD HAS DEVELOPED A KIT TO REPAIR THE SEAT BOLT BOSS, CONSISTING OF A LARGE, 3/16 INCH THICK WASHER, CONTOURED TO FIT INSIDE THE FLOOR PAN SEAT BOLT BOSS REINFORCEMENT.THIS FIX WAS ADDED TO PRODUCTION VEHICLES IN SEPTEMBER, 1997.FORD IS CURRENTLY PREPARTING A TECHNICAL SERVICE BULLETIN, TO BE SENT TO BOTH DEALER AND OPERATORS OF POLICE VEHICLES, ANNOUNCING THE AVAILABILITY OF THE KIT FOR IN-SEVICE REPAIRS.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THESE MODELS IF WARRANTED BY THE CIRCUMSTANCES.
Illustration