Engine And Engine Cooling. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports20 fire reports36 injury reports

Power Train complaints

128 reports

Clear category filter

Mileage unknown · Nov 19, 2001

Power Train

DURING NORMAL OPERATION OF VEHICLE TRACTION CONTROL LIGHT ON INSTRUMENT PANEL ILLUMINATES AND WILL NOT GO OFF. DEALERSHIP HAS YET TO EXAMINE VEHICLE FOR THIS PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK

NHTSA ODI #899227

Mileage unknown · Oct 31, 2001

Power Train

CONSUMER RECEIVED RECALL NOTIFICATION 98V233000. PREVIOUS DEALERSHIP INFORMED CONSUMER PARTS WERE NOT AVAILABLE, AND WOULD BE CONTACTED WHEN SERVICE COULD BE PERFORMED. SINCE THAT TIME, DEALERSHIP CLOSED ITS OPERATION; MARKSVILLE FORD, MARKSVILL LOUISIANA. CURRENT DEALERSHIP INDICATED COMPUTER SHOWED SERVICE WAS PERFOR…

Read full complaint

NHTSA ODI #898544

Mileage unknown · Oct 1, 2001

Power Train

THE VEHICLE WAS IMPOSSIBLE TO PLACE IN EITHER FIRST GEAR OR REVERSE DUE TO WORN OUT CLUTCH. *YH

NHTSA ODI #563591

Mileage unknown · Sep 17, 2001

Power Train

WOULD BE DRIVING AT VARIOUS SPEEDS AND NOTICED THAT SPEEDOMETER WOULD INDICATE A DIFFERENT SPEED; EITHER HIGHER OR LOWER THAN ACTUALLY TRAVELING. HAD TAKEN VEHICLE TO DEALER, AND MECHANIC TEST DROVE VEHICLE. HAD SPEEDOMETER REPAIRED UNDER WARRANTY. PROBLEM HAS SINCE REAPPEARED.*AK

NHTSA ODI #896386

Mileage unknown · Aug 27, 2001

Electrical SystemPower TrainSuspension

Read full complaint

THIS VEHICLE HAS BEEN A "LEMON" SINCE PURCHASED NEW IN AUGUST, 1997 FROM SAM GALLOWAY FORD IN FORT MYERS, FLORIDA. FROM THE BEGINNING, THE CAR DROVE "ROUGH" NOT SMOOTH. THE VEHICLE CONSTANTLY WAS VIBRATING, AND SIMPLY GOT WORSE OVER TIME. THE VIBRATIONS WOULD OCCUR AT SPEEDS AS LOW AS ABOUT 40 MILES PER HOUR, INCREASING THE FASTER YOU DROVE. YOU COULD ACTUALLY FEEL AND SEE YOUR BODY SHAKE. THE RIDE WAS THE TOTAL OPPOSITE OF A SMOOTH ONE. ROUGH AND BUMPY, EVEN ON SMOOTH, FLORIDA ROADS. THE VEHICLE FELT LIKE YOU WERE "PUSHING" OR "FORCING" IT TO DRIVE. THE GEAR SHIFT HAS ALWAYS BEEN DIFFICULT TO MANUVER, GENERALLY STICKING WHILE TRYING TO CHANGE GEARS. A COUPLE OF TIMES, THIS NEARLY CAUSED AN ACCIDENT, DUE TO THE INABILITY TO CHANGE GEARS. WHEN REPORTED TO FORD, THE ONLY RESPONSE THAT THAT "PER THE MANUAL, THE TRANSMISSION NEEDED SOME TYPE OF OVERHAUL, AT A COST OF ABOUT $500. ALSO, SEVERAL TIMES, THERE WAS SMOKE AND A BURNING RUBBER TYPE SMELL EMITTING FROM THE AIR VENTS. THIS WAS BROUGHT INTO FORD SEVERAL TIMES, AND NOT FIXED. THE FINAL TIME, THE ENTIRE CAR FILLED WITH SMOKE--I CALLED THE SERVICE MANAGER, MARLON HANSON, FROM THE VEHICLE ON MY CELL PHONE, BECAUSE I WAS SCARED THAT THE CAR MAY BURST INTO FLAMES. HIS REMARKS MADE IT SOUND LIKE "NO BIG DEAL" JUST BRING IN THE CAR. MEANWHILE, I HAD TO PULL OVER, I WAS SO SCARED, NOT KNOWING IF THE VEHICLE WAS GOING TO START ON FIRE OR EVEN BLOW UP. THIS VEHICLE WAS BROUGHT IN TWICE MORE FOR THIS REPAIR, AND FINALLY APPEARS TO BE FIXED. WE WERE TOLD THAT IT WAS SOME WIRING THAT WAS BURNING, OR STARTING ON FIRE. OUR ONLY COMPENSATION FOR THAT WAS A FREE RENTAL CAR, AFTER I PRESSURED THE SERVICE MANAGER. THE CASSETTE PORTION OF THE RADIO BROKE EARLY ON. NEVER ADDRESSED THAT ISSUE WITH DEALER OR FORD. STEERING COLUMN IS INCREASINGLY DIFFICULT TO MANUEVER-VERY HARD TO TURN. AIRBAG WARNING LIGHT INTERMITTENDLY COMES ON, AT ANY SPEED. TIRES HAVE BEEN REPLACED, BUT NEWER TIRE KEEPS DEFLATING--PER TBS, COIL SPRING PROBLEM?*A

NHTSA ODI #751179

Mileage unknown · Jul 9, 2001

Electrical SystemEngine And Engine CoolingFuel System, Gasoline

WHILE DRIVING AT ABOUT 5MPH AND MAKING A RIGHT TURN RIGHT FRONT WHEEL CAME OFF DUE TO LOOSE LUGS: NUTS. DEALER HAS SEEN VEHICLE. *AK CONSUMER STATES THE VEHICLE HAS EXPERIENCED PROBLEMS WITH THE FOLLOWING: FUEL FILTER, SPARK PLUGS, TRANSMISSION, CV BOOT, BRAKES, AIR FILTER, WIRE, ROTORS NEED TURNING, TIMING GEAR, TIMING BELT…

Read full complaint

NHTSA ODI #892195

Mileage unknown · Jun 28, 2001

Electrical SystemParking BrakePower Train

Read full complaint

TRANSMISSION HAS A DEFECT, THERE IS A SLIP WHEN YOU APPLYING GEARS. ALSO, BRAKE PEDAL GOES ALL THE WAY DOWN TO THE FLOOR, AND GRABS A LITTLE BIT. DEALERSHIP IS AWARE OF PROBLEM. BRAKES HAVE FAILED, ON ONE OCCASION CONSUMER ALMOST HIT A CHILD, BRAKE PEDAL SLIPS FROM UNDER FOOT. EMERGENCY BRAKE IS ONLY EFFECTIVE 50 PERCENT OF THE TIME. TRANSMISSION INTERMITTENTLY CHANGES GEARS ROUGHLY, AT TIMES JARRING OCCUPANTS IN THE VEHICLE. POSSIBLE ELECTRICAL PROBLEM: LIGHT OF THE CLOCK HAS BURNED OUT TWICE, CONSUMER STATES THERE ARE SHORTS IN THE DASHBOARD, CAUSING THE HEATER OR A/C TO ONLY HAVE ONE SPEED WORKING, DOME LIGHTS WORK INTERMITTENTLY, LIGHT UNDER DASH WORKS INTERMITTENTLY, WARNING BELL DOES NOT CHIME ALL THE TIMES IT SHOULD, CONSUMER STATES A SENSOR CAUSES HEATER TO ACT AS THE AC AND VICE VERSA. HINGES NOT MADE PROPERLY, CAUSING DOOR MOVEMENT WHILE OPENING/CLOSING, DOES NOT STOP WHEN IT SHOULD. SEAT BLET RETARCTION DOES NOT HAVE ENOUGH ELAST, CAUSING IT NOT TO RETRACT PROPERLY, HAS GOTTEN CAUGHT IN THE DOOR JAM. ALARM SYSTEM HAS FAILED. WHEEL COVER CRACKED WHEN A TIRE WAS BEING CHANGED AND ANOTHER ONE FELL OFF, CONSUMER WAS NOT AWARE OF THE TIME OR PLACE IT FELL OFF. *SLC

NHTSA ODI #891622

Mileage unknown · Jun 16, 2001

Power Train

WHEN I PUT THE CAR IN REVERSE IT TAKES A LONG TIME TO BACKUP. *AK

NHTSA ODI #746928

Mileage unknown · May 20, 2001

Power Train

FAILURE OF CD4E TRANSMISSION REQUIRING RE-BUILD.*AK

NHTSA ODI #745566

Mileage unknown · May 10, 2001

Power Train

WHEN TURNING OR BEARING TO LEFT THERE WAS A LOUD GRINDING NOISE. SOUND GOT LOUDER, AND VEHICLE STARTED PULLING TO LEFT. CONSUMER WENT TO FIRESTONE TO HAVE VEHICLE CHECKED OUT FOR VIBRATION. FIRESTONE TOOK IT FOR A DRIVE TO LISTEN TO IT. BEARINGS AND SEALS WERE SHOT, AND NEEDED REPLACEMET. ALSO, LUBRICATION HAD DRIED UP…

Read full complaint

NHTSA ODI #887927

Official recalls

01V255000 · Suspension:front:springs:coil Springs

Aug 8, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence & remedy

Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V350000 · Fuel System, Other:storage:tank Assembly

Oct 30, 2000

VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

Consequence & remedy

Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V243000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Sep 8, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.

Consequence & remedy

Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.

Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.

99V194000 · Vehicle Speed Control

Jul 20, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

98V028000 · Exterior Lighting:headlights

Feb 10, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence & remedy

Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗