Engine And Engine Cooling. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports20 fire reports36 injury reports

Fuel System, Gasoline complaints

62 reports

Clear category filter

Mileage unknown · Dec 1, 2000

Fuel System, Gasoline

UNABLE TO FILL GAS TANK WITHOUT GAS OVERFLOW, OR GAS FEEDBACK, SHUTTING OFF FUEL NOZZLE. ATTEMPTED TO TURN FUEL NOZZLE, IN EVERY POSITION TO NO AVAIL. CALLED A FORD DEALERSHIP AND THEY SAID NO RECALL, JUST A SERVICE BULLETIN. THIS IS DANGEROUS AND FRUST. *AK

NHTSA ODI #737146

Mileage unknown · Dec 1, 2000

Fuel System, Gasoline

I WAS UNABLE TO REFUEL VEHICLE AT ALL, I TOOK VEHICLE TO NOURSE FAMILY FORD OF DELAWARE, OH, FOR REPAIRS, THEY REPLACED THE FUEL NECK TO TANK. *AK

NHTSA ODI #737133

Mileage unknown · Nov 28, 2000

Fuel System, Gasoline

PROBLEMS OCCASIONALLY WITH DIFFICULITY FUELING--SPEWBACK OF GAS AND PREMATURE CUT OFF OF PUMP . ON OCCASION IT HAS TAKEN ME 20 MINUTES TO FILL THE GAS TANK BECAUSE THE CAR WILL ONLY ACCEPT A SMALL AMOUNT OF GAS AT A TIME. *AK

NHTSA ODI #736974

Mileage unknown · Nov 27, 2000

Fuel System, Gasoline

MORE OFTEN THAN NOT, WHEN I PUT GAS IN MY CAR, THE CAR KICKS THE PUMP OFF AT LEAST TWICE, SOMETIMES MORE THAN THAT. A FEW DAYS AGO, I BECAME FED UP BECAUSE IT STOPPED AND SPEWED GASOLINE BACK ONTO ME, RUINING MY PANTS. THIS HAS HAPPENED MORE TIMES THAN I CARE TO COUNT. I PUT 25, BUT IT IS JUST AN ESTIMATE. I AM WORRIED THAT …

Read full complaint

NHTSA ODI #736937

Mileage unknown · Nov 27, 2000

Fuel System, Gasoline

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ODI #736879

Mileage unknown · Nov 24, 2000

Fuel System, Gasoline

WHEN FUELING IN HOT WEATHER, GASOLINE DOES NOT FLOW FROM PUMP NOZZLE INTO TANK. PUMP SHUTS OFF EVERY FEW CENTS, AND GASOLINE SPURTS BACK OFTEN. DEALER CLAIMED TO FIX, BUT PROBLEM PERSISTS. *AK

NHTSA ODI #736837

Mileage unknown · Oct 26, 2000

Fuel System, Gasoline

EA00025, WHILE REFUELING IT WON'T REFUEL OR IT'S VERY HARD TO FUEL VEHICLE. COMMON PROBLEM. *AK

NHTSA ODI #873896

Mileage unknown · Aug 23, 2000

Fuel System, Gasoline

WHEN PUTTING GAS IN TANK IT BEGAN TO SPITTING THE FUEL BACK OUT AFTER A FEW CENTS. IT TAKES AT LEAST 10 MINUTES TO PUT 5$ WORTH OF GAS INTO VEHICLE. DEALER HAS BEEN CONTACTED. *AK

NHTSA ODI #868400

Mileage unknown · Aug 14, 2000

Fuel System, Gasoline

VERY DIFFICULT FILLING GAS TANK, WHEN FILLING PUMP KEEPS SHUTTING OFF , AT TIMES GAS WILL COME RIGHT BACK OUT ALL OVER THE SIDE OF THE CAR. *AK

NHTSA ODI #727909

Mileage unknown · Jul 17, 2000

Fuel System, Gasoline

THE PART FOR THIS CAR IS BACK ORDERED AS OF TODAY NO PART AVAILABLE. CAR IS NOT OPERATIVE. BACKORDER IS WHO NATION AND CANADA. PAYING FOR A VEHICLE THAT YOU CAN'T EVEN USE. NO SAFETY DEFECT LISTED IN SUMMARY. *AK

NHTSA ODI #725589

Official recalls

01V255000 · Suspension:front:springs:coil Springs

Aug 8, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence & remedy

Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V350000 · Fuel System, Other:storage:tank Assembly

Oct 30, 2000

VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

Consequence & remedy

Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V243000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Sep 8, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.

Consequence & remedy

Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.

Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.

99V194000 · Vehicle Speed Control

Jul 20, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

98V028000 · Exterior Lighting:headlights

Feb 10, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence & remedy

Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗