Engine And Engine Cooling. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

50 crash reports20 fire reports36 injury reports

Engine And Engine Cooling complaints

132 reports

Clear category filter

32,000 miles · Apr 17, 2005

Electrical SystemEngine And Engine CoolingInjury

Read full complaint

DEALER TOLD ME ELECTRICAL SYSTEM HAD A SHORT. O2 SENSOR & COMPUTER IN CAR. THE CAR HAS HAD TO HAVE THE O2 SENSOR REPLACED 3 TIMES ($1200.00 CHARGED BY TO ME BY DEALER EACH TIME) AND THE COMPUTER RESET. *AK MY COMPLAINT IS THAT I SHOULD NOT HAVE TO PAY TO HAVE THE ELECTRICAL FIXED AND THE O2 CENSOR REPLACED AGAIN (4 TIME!!)... THE TURN SIGNALS WORK AND THAN DO NOT .. I HAVE BEEN TOLD A SHORT IS IN THE CAR BUT FORD WILL NOT FIND FOR FREE.. I AM TIRED OF FIXING THIS CAR PLEASE PLEASE HELP

NHTSA ODI #10118008

85,000 miles · Apr 5, 2005

Engine And Engine Cooling

WHILE DRIVING VEHICLE SHUT DOWN. VEHICLE WAS TOWED TO THE DEALER, AND THE ENGINE WAS FOUND TO BE DEFECTIVE.*AK

NHTSA ODI #10117478

72,000 miles · Mar 3, 2005

Engine And Engine Cooling

Read full complaint

CHECK ENGINE LIGHT ILLUMINATED 9/04 AND I TOOK MY 98 FORD CONTOUR TO MY MECHANIC WHO DIAGNOSED IT AS NEEDING A NEW CATALYTIC CONVERTER. I TOOK IT TO FORD IN 3/05 (BECAUSE MY MECHANIC SAID IT COULD WAIT AWHILE) AND THEY DIAGNOSED A DIFFERENT CODE AND REPLACED THE MANIFOLD. AFTER PAYING $600.00 TO FORD, THE LIGHT CAME ON AGAIN AFTER 45 MILES. TOOK THE CAR TO AUTOZONE AND THEY DIAGNOSED A CATALYTIC CODE. I HAD TOLD FORD THAT WAS THE PROBLEM BEFORE I BROUGHT IT IN AND NOW THEY WANT ME TO RE-DIAGNOSED WITH THEM OUT OF POCKET. *JB

NHTSA ODI #10112470

Mileage unknown · Jan 12, 2005

Engine And Engine Cooling

THE CONSUMER BELIEVES THAT THE RUBBER ODOR HE SMELLED INSIDE THE PASSENGER COMPARTMENT OF THE VEHICLE CAME FROM THE BELTS IN THE ENGINE. *NM *JB

NHTSA ODI #10109474

72,000 miles · Sep 22, 2004

Electrical SystemEngine And Engine CoolingFire

SMOKE THEN FLAMES CAME FROM THE ENGINE COMPARTMENT AND WITHIN 5 MINUTES OF PARKING IN THE GARAGE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE, AND INDICATED THAT THE FIRE OCCURRED BECAUSE OF AN ELECTRICAL SYSTEM FAILURE.*AK

NHTSA ODI #10094067

Mileage unknown · Aug 10, 2004

Engine And Engine Cooling

WHILE DRIVING CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE WAS TAKEN TO A GARAGE FOR INSPECTION, AND MECHANIC DETERMINED THAT THE ENGINE WIRING HARNESS NEEDED TO BE REPLACED. *AK

NHTSA ODI #10087641

93,000 miles · May 17, 2004

Electrical SystemEngine And Engine CoolingFuel System, Gasoline

Read full complaint

INTERMITTENTLY WHEN THE GAS PEDAL WAS APPLIED, THE VEHICLE FAILED TO ACCELERATE. THIS OCCURRED BECAUSE OF AN OBSTRUCTION IN THE FLOW OF FUEL TO THE ENGINE. THE DEALERSHIP HAS SERVICED THE VEHICLE 5 TIMES. THEY HAVE REPLACED THE FUEL PUMP, THE FILTER AND THE OXYGEN SENSOR. THE PROBLEM STILL EXIST. THE DEALERSHIP REFUSED TO SERVICE THE VEHICLE ANYMORE BECAUSE THEY INDICATED THEY HAVE DONE ALL THEY COULD DO TO CORRECT THIS PROBLEM. *NM THE VEHICLE LEAKED OIL OVER THE ENTIRE ENGINE, THE FUEL PRESSURE DROPPED WHEN THE VEHICLE WAS DRIVEN ON MOUNTAINOUS AREAS, A SHORT WAS FOUND, AND WIRES WERE FOUND CHAFFED. *SC *JB

NHTSA ODI #10065523

Mileage unknown · Jan 15, 2004

Engine And Engine CoolingEquipmentFuel System, Gasoline

Read full complaint

WE HAVE A 1998 FORD CONTOUR. THE CHECK ENGINE LIGHT GOES ON. IT FIRST CAME ON IN OCT 01 WE TOOK IT TO THE FORD GARAGE IN DELHI. THEY SAID IT NEEDED A CAM SENSOR/ SOLENOID SPROCKETS ETC. SINCE THAT WAS A LOT OF MONEY WE DECIDED TO TAKE IT TO CANADIAN TIRE TO SEE WHAT THEY THOUGHT. THEY THOUGHT IT WAS A CAM SENSOR. WE HAD THEM PUT THAT IN. $58. MILEAGE 111346. IT WORKED FINE FOR A COUPLE WEEKS. WE COMPLAINED TO FORD AND FOUND OUT ABOUT THE AWA.. AFTER WARRANTY ADJUSTMENT. THIS HAD NOT BEEN MENTIONED EARLIER. SO WE A NEW SOLENOID SPROCKET ETC. PUT IN BY FORD,, (JAN /02) . HOW IT CAME TO THAT MILEAGE WHEN CTC HAD IT BACK IN NOV/ 01 AND THEN IT WAS* 11134*???? THEY ALSO HAD IT IN DEC AND THE MILEAGE WAS 112279.) THAT BAFFLES ME. THE CHECK ENGINE LIGHT WAS TO SURFACE AGAIN. MY DAUGHTER HAD THE CAR AT SCHOOL SO SHE WAS FINALLY ABLE TO TAKE IT TO OUR GARAGE IN MAY/28/02 AT THAT TIME THE GARAGE CHECKED #3 CYLINDER CAUSE OF OUR CHECK ENGINE CONCERNS.. COST 39.10. NOTHING WAS DONE AT THAT TIME. THE ENGINE LIGHT CONTINUED TO STAY ON. FINALLY WE TOOK IT IN AGAIN ON OCT 24TH AND ANOTHER CAM SENSOR WAS PUT ON. $144.46. MILEAGE 130776. ON NOV,.5TH /02 TOOK IT IN AGAIN AND THEY SAID IT WOULD REQUIRE AN EXHAUST CAMSHAFT AND SOLENOID GASKETS AND SEALS. WE AGAIN ASKED ABOUT THE AWA AND THEY SAID NO IT WAS NO LONGER COVERED. THEY SAID THAT THE LAST SOLENOID WAS ONLY COVERED FOR 20,000 KM. HAD THEY DETECTED THE PROBLEM BACK IN MAY WHEN WE BROUGHT IT IN AND HAD THEY WRITTEN DOWN THE CORRECT MILEAGE THEN IT WOULD HAVE BEEN COVERED UNDER WARRANTY. SINCE WE DID NOT REALLY FEEL THAT THE SOLENOID ( AND REALLY DIDN'T WANT TO PAY $1000 FOR FIXING IT AND THEN FINDING OUT THAT THERE MIGHT BE ANOTHER PROBLEM) WAS THE PROBLEM, SINCE WE HAD ALREADY HAD THAT REPLACED ONCE WE CONSIDERED TAKING IT TO A GUY THAT USED TO WORK AT FORD. (HIS WIFE DRIVES A CONTOUR) HE CHECKED THE CAR FOR SURGES. SCAN TESTED IT TRIED VARIOUS COMPUTER PARTS RECHECKED VALVE. ETC,, BUT IT ALL PROVED NEGATIVE.

NHTSA ODI #10071340

71,000 miles · Nov 19, 2003

Engine And Engine Cooling

WHILE DRIVING AT ANY SPEED, THE VEHICLE WOULD INTERMITTENTLY STALL AND THE CHECK ENGINE LIGHT WOULD STAY ON. THE DEALER INFORMED THE CONSUMER THAT A NEW ENGINE WAS NEEDED. THIS VEHICLE HAS BEEN REPAIRED FOR THIRTEEN RECALLS SINCE OWNERSHIP BY THE CONSUMER. *AK *LA *JB

NHTSA ODI #10043985

63,000 miles · Oct 20, 2003

Electrical SystemEngine And Engine CoolingParking Brake

THIS CAR HAS BEEN NOTHING BUT PROBLEMS, SPRINGS, BRAKES LAST 4 MONTHS,WATER PUMPS WENT AT 63,000, TIRES WEAR OUT IN LESS THAN A YEAR, TEMPERATURE GAUGES DO NOT READ RIGHT. ENGINE RACES, SOLENOID WENT....VERY EXPENSIVE TO FIX. I DO NOT UNDERSTAND WHY EVERYONE IS HAVING THE SAME PROBLEMS BUT NO HELP? *LA

NHTSA ODI #10043239

Official recalls

01V255000 · Suspension:front:springs:coil Springs

Aug 8, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.

Consequence & remedy

Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.

Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V350000 · Fuel System, Other:storage:tank Assembly

Oct 30, 2000

VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

Consequence & remedy

Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V243000 · Air Bags:frontal:sensor/control MODULE-INACTIVE

Sep 8, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.

Consequence & remedy

Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.

Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.

99V194000 · Vehicle Speed Control

Jul 20, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.

Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

98V028000 · Exterior Lighting:headlights

Feb 10, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence & remedy

Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.

Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗