NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
130 reportsClear category filterMileage unknown · Jul 9, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
WHILE DRIVING AT ABOUT 5MPH AND MAKING A RIGHT TURN RIGHT FRONT WHEEL CAME OFF DUE TO LOOSE LUGS: NUTS. DEALER HAS SEEN VEHICLE. *AK CONSUMER STATES THE VEHICLE HAS EXPERIENCED PROBLEMS WITH THE FOLLOWING: FUEL FILTER, SPARK PLUGS, TRANSMISSION, CV BOOT, BRAKES, AIR FILTER, WIRE, ROTORS NEED TURNING, TIMING GEAR, TIMING BELT…
Read full complaint
WHILE DRIVING AT ABOUT 5MPH AND MAKING A RIGHT TURN RIGHT FRONT WHEEL CAME OFF DUE TO LOOSE LUGS: NUTS. DEALER HAS SEEN VEHICLE. *AK CONSUMER STATES THE VEHICLE HAS EXPERIENCED PROBLEMS WITH THE FOLLOWING: FUEL FILTER, SPARK PLUGS, TRANSMISSION, CV BOOT, BRAKES, AIR FILTER, WIRE, ROTORS NEED TURNING, TIMING GEAR, TIMING BELT, AND VEHICLE WILL NOT START. *SLC
NHTSA ODI #892195
Mileage unknown · Jun 28, 2001
Electrical SystemParking BrakePower Train
TRANSMISSION HAS A DEFECT, THERE IS A SLIP WHEN YOU APPLYING GEARS. ALSO, BRAKE PEDAL GOES ALL THE WAY DOWN TO THE FLOOR, AND GRABS A LITTLE BIT. DEALERSHIP IS AWARE OF PROBLEM. BRAKES HAVE FAILED, ON ONE OCCASION CONSUMER ALMOST HIT A CHILD, BRAKE PEDAL SLIPS FROM UNDER FOOT. EMERGENCY BRAKE IS ONLY EFFECTIVE 50 PERCENT…
Read full complaint
TRANSMISSION HAS A DEFECT, THERE IS A SLIP WHEN YOU APPLYING GEARS. ALSO, BRAKE PEDAL GOES ALL THE WAY DOWN TO THE FLOOR, AND GRABS A LITTLE BIT. DEALERSHIP IS AWARE OF PROBLEM. BRAKES HAVE FAILED, ON ONE OCCASION CONSUMER ALMOST HIT A CHILD, BRAKE PEDAL SLIPS FROM UNDER FOOT. EMERGENCY BRAKE IS ONLY EFFECTIVE 50 PERCENT OF THE TIME. TRANSMISSION INTERMITTENTLY CHANGES GEARS ROUGHLY, AT TIMES JARRING OCCUPANTS IN THE VEHICLE. POSSIBLE ELECTRICAL PROBLEM: LIGHT OF THE CLOCK HAS BURNED OUT TWICE, CONSUMER STATES THERE ARE SHORTS IN THE DASHBOARD, CAUSING THE HEATER OR A/C TO ONLY HAVE ONE SPEED WORKING, DOME LIGHTS WORK INTERMITTENTLY, LIGHT UNDER DASH WORKS INTERMITTENTLY, WARNING BELL DOES NOT CHIME ALL THE TIMES IT SHOULD, CONSUMER STATES A SENSOR CAUSES HEATER TO ACT AS THE AC AND VICE VERSA. HINGES NOT MADE PROPERLY, CAUSING DOOR MOVEMENT WHILE OPENING/CLOSING, DOES NOT STOP WHEN IT SHOULD. SEAT BLET RETARCTION DOES NOT HAVE ENOUGH ELAST, CAUSING IT NOT TO RETRACT PROPERLY, HAS GOTTEN CAUGHT IN THE DOOR JAM. ALARM SYSTEM HAS FAILED. WHEEL COVER CRACKED WHEN A TIRE WAS BEING CHANGED AND ANOTHER ONE FELL OFF, CONSUMER WAS NOT AWARE OF THE TIME OR PLACE IT FELL OFF. *SLC
NHTSA ODI #891622
Mileage unknown · Jun 27, 2001
Electrical System
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #747495
Mileage unknown · Jun 8, 2001
Electrical System
WIRING HARNESS LOCATED BEHIND THE HEADLIGHT SWITCH MELTED, CAUSING FAILURE OF HEADLIGHT AND PARKING LIGHTS. DEALERSHIP REPAIRED THIS PROBLEM, AND MANUFACTURER INFORMED CONSUMER THAT HIS VEHICLE WAS NOT INCLUDED IN RECALL 99V103000. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #890010
Mileage unknown · May 16, 2001
Air BagsElectrical SystemVehicle Speed Control
AIRBAG LIGHT IS ON/ HORN, AND CRUISE CONTROL ARE NOT WORKING. CONSUEMR STATED THIS WAS SAME PROBLEM AS STATED IN RECALL 99 V 243 000. CONSUMER WAS SCARED THAT AIRBAG MAY DEPLOY IN FACE.*AK
NHTSA ODI #888377
Mileage unknown · May 16, 2001
Electrical SystemInterior Lighting
THE SHORT CAUSED THE DASHBOARD LIGHTING AND BACKLIGHTS NOT TO FUNCTION. *AK
NHTSA ODI #745413
Mileage unknown · May 11, 2001
Electrical System
FUSE BOX MELTED DUE TO A LOOSE WIRE. DEALER HAS INSPECTED VEHICLE.*AK
NHTSA ODI #888051
Mileage unknown · Mar 12, 2001
Electrical SystemEngine And Engine CoolingEquipment
FIRST DAY CAR WAS BOUGHT ENGINE DIED, TOOK TO DEALER, AND THEY GAVE CONSUMER ANOTHER CONTOUR. CURRENTLY, VEHCILE WILL SHUT OFF IN MIDDLE OF INTERSECTION. DEALER REPLACED TRANSMISSION, AND ENGINE WAS ACTING UP. *AK CONSUMER STATES VEHICLE HAS BEEN IN 3 TIMES FOR TRANSMISSION PROBLEMS, IT JERKS AND VIBRATES, CONSUMER DOES …
Read full complaint
FIRST DAY CAR WAS BOUGHT ENGINE DIED, TOOK TO DEALER, AND THEY GAVE CONSUMER ANOTHER CONTOUR. CURRENTLY, VEHCILE WILL SHUT OFF IN MIDDLE OF INTERSECTION. DEALER REPLACED TRANSMISSION, AND ENGINE WAS ACTING UP. *AK CONSUMER STATES VEHICLE HAS BEEN IN 3 TIMES FOR TRANSMISSION PROBLEMS, IT JERKS AND VIBRATES, CONSUMER DOES NOT THINK THAT DEALER REPLACED TRANSMISSION LIKE THEY SAID. 1 TIME FOR ENGINE PROBLEMS. CONSUMER HAS BEEN IN 2 ACCIDENTS DUE TO SUDDEN ACCELERATION. FRONT SWAY BAR REPLACED, STEERING WOULD SHIMMY AND RATTLE. BLOWER MOTOR ASSEMBLY REPLACED, DUE TO RATTLING NOISE IN AIR CONDITIONER, ALSO CYCLING SWITCH REPLACED DUE TO AIR CONDITIONER NOT COOLING. LEFT FRONT SEAT BELT BUCKLE ASSEMBLY REPLACED, BELT WOULD NOT BUCKLE. STARTER FAILED AND WAS REPLACED. ENGINE LIGHT ILLUMINATED, DEALER FOUND LOOSE CONNECTION AT ACT. REAR STRUTS REPLACED, NOISY. *SLC
NHTSA ODI #882762
Mileage unknown · Mar 12, 2001
Electrical System
MY CAR FREQUENTLY SMELLS LIKE AN ELECTRICAL FIRE. I HARDLY EVER DRIVE IT. I AM ESPECIALLY CONCERNED ABOUT THE RECENT ARTICLES ABOUT POSSIBLE FIRES IN CONTOUR MODELS. I WOULD LIKE MORE INFORMATION ABOUT THIS SITUATION.*AK
NHTSA ODI #742327
Mileage unknown · Mar 7, 2001
Electrical System
WIRING HARNESS PROBLEMS ARE SAME SYMPTOMS AS MENTIONED IN INVESTIGATION # EA01001. HAS REPLACED WIRING HARNESS 8 TIMES. *AK
NHTSA ODI #882371
Official recalls
9Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND THE DISTRICT OF COLUMBIA. THE FRONT COIL SPRINGS MAY FRACTURE AS A RESULT OF CORROSION IN HIGH CORROSION ENVIRONMENTS. DEPENDING ON THE LOCATION OF THE FRACTURE, A BROKEN SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: SOME TIRES HAVE DEFLATED DUE TO CONTACT WITH A BROKEN SPRING.
Remedy: DEALERS WILL INSTALL SPRING CATCHER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Jul 9, 2001
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 30, 2000
VEHICLE DESCRIPTION: BI-FUEL VEHICLES. THESE VEHICLES MAY HAVE A FUEL TANK FILLER PIPE GROMMET THAT COULD HAVE BEEN DAMAGED DURING THE INSTALLATION OF THE BI-FUEL SYSTEM. IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE. DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Consequence & remedy
Consequence: IF THE GROMMET IS DAMAGED, FUEL COULD LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FILLER PIPE GROMMET.
Mar 9, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
Sep 8, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSOR WIRING PIGTAIL INSULATION CAN BECOME BRITTLE AND CRACK OVER TIME DUE TO ACCUMULATION OF WATER IN THE PIGTAIL PROTECTIVE CONVOLUTE IN COMBINATION WITH HIGH UNDERHOOD TEMPERATURES RELATED TO THE ROUTING OF THE WIRING PIGTAIL NEAR THE RADIATOR. THIS CAN RESULT IN ENVIRONMENTAL STRESS CRACKING OF THE INSULATION.
Consequence & remedy
Consequence: IN SOME CASES, THE AIR BAG WARNING LIGHT CAN ILLUMINATE AND THE AIR BAG SUPPLEMENTAL RESTRAINT SYSTEM DISABLED.
Remedy: DEALERS WILL INSTALL AIR BAG SENSORS WITH REVISED WIRING INSULATION. IN ADDITION, VEHICLES WHICH HAVE THE AIR BAG WARNING LIGHT ILLUMINATED WILL HAVE A NEW AIR BAG DIAGNOSTIC MONITOR INSTALLED.
Jul 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ACCELERATOR CABLE MAY HAVE BEEN MANUFACTURED WITH A BURR ON OR NEAR THE END OF THE CABLE SLEEVE INTERIOR. THIS BURR COULD FRAY THE CORE WIRE RESULTING IN THE ACCELERATOR NOT RETURNING TO IDLE WHEN THE ACCELERATOR IS RELEASED.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN THE THROTTLE STICKING, BINDING, OR CAUSING HIGH ENGINE RPM.
Remedy: DEALERS WILL INSTALL A REVISED ACCELERATOR CABLE THAT HAS A FLARED CONDUIT SLEEVE END AND MOLDED ON END FITTING.
May 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
Sep 18, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
Feb 10, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TEXT AND/OR GRAPHICS FOR THE VEHICLE HEADLAMP AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES ARE NOT SUFFICIENTLY CLEAR. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY BE CONFUSED BY THE AIMING INSTRUCTIONS PROVIDED IN THE OWNER GUIDES CAUSING THE HEADLAMPS TO BE IMPROPERLY AIMED.
Remedy: OWNER GUIDES CONTAINING REVISED AIMING INSTRUCTIONS WILL BE MAILED TO OWNERS OF THESE VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
EA00025 · Fuel Expulsion During Refueling
Opened Oct 4, 2000 · Closed Jan 25, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00027 · Fuel Expulsion During Refueling
Opened Jul 10, 2000 · Closed Oct 4, 2000
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
SQ98002 · Fuel Gauge Does Not Read Below 1/4
Opened Jan 27, 1998 · Closed Jul 31, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
FORD'S SERVICE BULLETIN DATED DECEMBER 8, 1997, POINTS OUT THAT THE FUEL GAUGE WILL NOT READ ABOVE 3/4 TANK OR BELOW 1/4 TANK OF FUEL.THE ERRONEOUS FUEL GAUGE READING WILL INDICATE SIGNIFICANTLY MORE FUEL RESERVE THAN ACTUALLY PRESENT IN THE FUEL TANK.ODI HAS ONE COMPLAINT WHERE THE DRIVER ALLEGED THAT HIS VEHICLE RAN OUT OF GAS DUE TO A FALSE FUEL GAUGE READING.THIS INVESTIGATION WASTO ASCERTAIN FACTS CONCERNING THE PROBLEM EXPERIENCE, SCOPE, AND RATIONAL FOR ELECTING NOT TO CONDUCT A SAFETY COMPAIGN.
Illustration