Electrical System. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports10 fire reports7 injury reports

Electrical System complaints

41 reports

Clear category filter

Mileage unknown · Apr 30, 2003

Electrical SystemFire

ELECTRICAL FIRE INSIDE CAR ABOUT 2 YEARS AGO. ELECTRICAL SYSTEM DOWN A/C DOES NOT WORK, BACK WINDOW SWITCHES DO NOT WORK, KILLED BATTERY AND ALTERNATOR.

NHTSA ODI #10016788

Mileage unknown · Jul 31, 2002

Electrical SystemInterior Lighting

TAIL LIGHTS AND INTERIOR DASH LIGHTS WENT OUT WITHOUT WARNING. THIS WAS DUE TO LIGHT SWITCH HARNESS CONNECTORS MELTING, SHORTING OUT THE WIRES.*AK

NHTSA ODI #8015232

Mileage unknown · Dec 11, 2001

Electrical System

WHILE DRIVING ABOUT 65 MPH ELECTRICAL SYSTEM DID NOT WORK. IT NOT SHOW ANY INFORMATION, AND THERE WERE NO LIGHTS. CONSUMER HAD TO RESTART ENGINE TO MAKE IT WORKS AGAIN. PLEASE PROVIDE MORE INFORMATION.*AK

NHTSA ODI #8000577

Mileage unknown · Sep 27, 2001

Electrical SystemEngine And Engine Cooling

WATER PUMP ASSEMBLY AND TIMING BELT WERE REPLACED. *SLC

NHTSA ODI #563480

Mileage unknown · Sep 18, 2001

Electrical System

WIRES INSIDE OF BATTERY WERE DEFECTIVE. WHEN HE STARTING VEHICLE IT WOULDN'T START AT ALL. DEALERSHIP WAS AWARE OF PROBLEM.*AK

NHTSA ODI #896470

Mileage unknown · Sep 14, 2001

Electrical System

WIRES ATTACHED TO ENGINE WERE MISSING AND DEFECTIVE. DEALERSHIP WAS AWARE OF PROBLEM. *AK

NHTSA ODI #896350

Mileage unknown · Sep 6, 2001

Electrical SystemPower Train

VEHICLE STALLS OUT WITHOUT WARNING, REPLACE SENSOR, IAC VALVE, MASS AIR FLOW SENSOR, TRANSMISSION, SHIFT ASSEMBLE.

NHTSA ODI #9004255

Mileage unknown · Aug 13, 2001

Electrical SystemVisibility

DURING REPLACEMENT OF HEATER BLOWER SWITCH CONSUMER NOTICED THAT ELECTRICAL WIRES WERE MELTED TOGETHER AND CHARRED BLACK. DEALERSHIP HAS NOT EXAMINED VEHICLE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK

NHTSA ODI #894186

Mileage unknown · Jun 6, 2001

Electrical SystemExterior LightingInterior Lighting

Read full complaint

I CARRIED MY CAR TO THE DEALERSHIP FOR RECALL SERVICE. THE DEALERSHIP NEVER COMPLETED THE RECALL WORK, BUT DID BILL FORD FOR IT. THE DEALERSHIP LATER OFFERED TO FIX THE SYMPTOMS THAT THE FAULTY PARTS WERE CAUSING FOR A FEE OR $279. I DID NOT HAVE $279 AT THE TIME TO PAY FOR THE SERVICE SO I PURCHASED THE PARTS FOR $101. AFTER I HAD INSTALLED THE PARTS, I SAW A NOTE IN THE PACKAGE THAT DESCRIBED WHAT THE DEALER SOLD TO ME. THE DEALERSHIP ACTUALLY SOLD ME THE RECALL REPAIR KIT. I HAVE THE DOCUMENTATION AND ORIGINAL PART TO PROVE THIS IS THE CASE. *AK ALSO TAIL LIGHTS AND DASH LIGHTS ARE INOPERABLE,HEAD LIGHT SWITCH HAS BURNED OUT, CONSUMER STATES HE SHOULD BE REIMBURSED FOR THE WARRANTY WORK , CONSUMER STATES HE HAS IN HIS POSSESSION THE RECALLED PART AND THAT HTE DEALERSHIP DID NOT PERFORM THE WORK, THAT THEY CLAIM THEY REPLACED, EVEN THOUGH THE WARRANTY WORK WAS NOT PERFORMED BY DEALERSHIP THE FORD MOTOR COMPANY WAS BILLED FOR THE WARRANTY REPAIRS.*JB

NHTSA ODI #746500

Mileage unknown · Apr 12, 2001

Electrical SystemVisibility

HEATER FAN CONTROL SWITCH BEGAN SMOKING AND SHUTDOWN WHILE VEHICLE WAS IN OPERATION. CONSUMER HAS TAKEN VEHICLE TO PRIVATE MECHANIC, WHO INDICATED THAT DEFECT RESULTED FROM FACTORY WIRING HARNESS BEING TOO SMALL A GUAGE OF WIRING TO CARRY ELECTRICAL LOAD. REPLACEMENT WIRING HARNESS WAS OF A HIGHER GUAGE. PLEASE PROVID…

Read full complaint

NHTSA ODI #885770

Official recalls

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

97V203000 · Fuel System, Other:storage

Nov 17, 1997

VEHICLE DESCRIPTION: BI-FUEL VEHICLES MODIFIED TO RUN ON EITHER GASOLINE OR COMPRESSED NATURAL GAS (CNG). THE NATURAL GAS FUEL TANKS HAVE A SOLENOID SHUT-OFF VALVE THAT STOPS FUEL FLOW FROM THE FUEL TANK IN THE EVENT OF CERTAIN MODERATE TO SEVERE COLLISIONS. IF THE VEHICLE IS IN A COLLISION AND THE NATURAL GAS FUEL LINE IS DAMAGED, THE SYSTEM COULD LEAK NATURAL GAS.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: FORD HAS REQUESTED OWNERS OF THESE VEHICLES TO HAVE THE CNG FUEL SYSTEM DISABLED UNDER A PREVIOUS RECALL CAMPAIGN AND TO ONLY USE GASOLINE FUEL UNTIL A PERMANENT CORRECTIVE ACTION IS DEVELOPED. OWNERS ARE BEING ALERTED TO THIS SOLENOID VALVE CONCERN AT THIS TIME. THE TIMING OF CORRECTIVE ACTIONS IS BEING DELAYED TO ALLOW BOTH CONDITIONS TO BE REMEDIED AT ONE TIME. IN THE MEANTIME, THERE IS NOT RISK AS LONG AS THE NATURAL GAS SYSTEM HAS BEEN DISABLED AND THE VHEICLE IS ONLY OPERATED ON GASOLINE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗