NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
44 reportsClear category filterMileage unknown · Aug 12, 2005
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
CONSUMER HAS HAD NUMEROUS PROBLEMS WITH THE 1996 FORD CONTOUR.*MR THERE HAS BEEN SO MANY RECALLS ON CONSUMER'S VEHICLE THAT SHE WASN'T AWARE OF BECAUSE THE MANUFACTURER NEVER SENT NOTICES. SINCE THEN CONSUMER HAS BEEN PAYING FOR ENTIRE FULL PRICE AND IS ASKING FOR REIMBURSEMENT. HOWEVER, THE BIGGEST PROBLEM WITH THE VEHICLE I…
Read full complaint
CONSUMER HAS HAD NUMEROUS PROBLEMS WITH THE 1996 FORD CONTOUR.*MR THERE HAS BEEN SO MANY RECALLS ON CONSUMER'S VEHICLE THAT SHE WASN'T AWARE OF BECAUSE THE MANUFACTURER NEVER SENT NOTICES. SINCE THEN CONSUMER HAS BEEN PAYING FOR ENTIRE FULL PRICE AND IS ASKING FOR REIMBURSEMENT. HOWEVER, THE BIGGEST PROBLEM WITH THE VEHICLE IS THE GAS FUMES WHICH IS LEAKING THEREFORE LEAVING POISONOUS CARBON MONOXIDE FUMES COMING IN THROUGH THE HEATER VENTS. THESE HARSH CHEMICALS ARE DAMAGING TO THE LUNGS, BRAIN, RESPIRATORY SYSTEM AND ITS MAKING CONSUMER VERY TIRED AMONG OTHER SYMPTOMS. *TT
NHTSA ODI #10134493
Mileage unknown · Jun 25, 2005
Electrical SystemService Brakes, Hydraulic
MAJOR HARNESS & ELECTRICAL WIRING WHICH IS UNDER RECALL THAT THE FORD DEALERSHIP WILL NOT HONOR.
NHTSA ODI #10126566
90,000 miles · Jun 22, 2005
Service Brakes, Hydraulic
LEFT AND RIGHT FRONT ABS STATORS HAVE CRACKS WHICH ARE CLEARLY VISIBLE. THIS CAUSES THE ABS SYSTEM TO ACTIVATE ON A LOW SPEED STOP. AT ABOUT 40 MPH THE ABS LIGHT COMES ON AND THE SYSTEM DOESN'T WORK.THE BRAKES WORK IN REGULAR MODE.THIS WAS DISCOVERED ON 6/21/05 BUT HAD BEEN HAPPENING . MECHANIC CHANGED AN ABS SENSOR WIRE WITH A…
Read full complaint
LEFT AND RIGHT FRONT ABS STATORS HAVE CRACKS WHICH ARE CLEARLY VISIBLE. THIS CAUSES THE ABS SYSTEM TO ACTIVATE ON A LOW SPEED STOP. AT ABOUT 40 MPH THE ABS LIGHT COMES ON AND THE SYSTEM DOESN'T WORK.THE BRAKES WORK IN REGULAR MODE.THIS WAS DISCOVERED ON 6/21/05 BUT HAD BEEN HAPPENING . MECHANIC CHANGED AN ABS SENSOR WIRE WITH A CUT IN IT . HAD TO LOOK FURTHER TO FIND CRACKED STATORS.MECHANIC SAID THAT THE FORD DEALERSHIP HE CALLED ADMITTED THERE WAS A PROBLEM WITH SOME MODELS,CRACKED STATORS ON WINDSTARS,OFFERED NO SOLUTION. I CALLED MY FORD DEALER AND WAS NOT HELPED .A PART LIKE THIS BEARS NO WEIGHT AND SHOULD NOT BE FAILING.THE CRACKS MAKE THE COMPUTER THINK THERE IS A REASON TO ACTIVATE AND THEN AT 40MPH TO SHUT DOWN.THE REAR STATORS WERE NOT CHECKED FOR CRACKS YET. THANK YOU
NHTSA ODI #10126299
151,000 miles · Jan 26, 2005
Service Brakes, Hydraulic
WHILE DRIVING 25 MPH DRIVER ATTEMPTED TO APPLY THE BRAKES AND VEHICLE CONTINUED TO ACCELERATE. AS A RESULT THE VEHICLE WAS TOWED HOME, AND THEN TO THE REPAIR SHOP. *AK
NHTSA ODI #10108974
Mileage unknown · Dec 6, 2004
Service Brakes, Hydraulic
WHILE DRIVING 20 MPH CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. VEHICLE VIBRATED UNCONTROLLABLY. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE BRAKE VACUUM HOSE NEEDED TO BE REPLACED AND REPLACED IT. HOWEVER, THE PROBLEM RECURRED. *AK
NHTSA ODI #10103201
49,000 miles · Jan 15, 2004
Engine And Engine CoolingEquipmentPower Train
THIS CAR HAS LESS THAN 70000 MILES ON IT. WE HAD TROUBLE WITH THE FUEL DOOR, FRONT WHEEL BEARINGS, BRAKES, DOOR HANDLES, TRANSMISSION, ELECTRIC WINDOWS, AND NOW AS A SPECIAL TREAT THE ENGINE FAILED. THIS CAR HAS BEEN THE WORST INVESTMENT THAT MY WIFE AND I HAVE EVER MADE. I HAVE HAVE OWNED SEVERAL CARS AND TRUCKS WITH 200000 PLU…
Read full complaint
THIS CAR HAS LESS THAN 70000 MILES ON IT. WE HAD TROUBLE WITH THE FUEL DOOR, FRONT WHEEL BEARINGS, BRAKES, DOOR HANDLES, TRANSMISSION, ELECTRIC WINDOWS, AND NOW AS A SPECIAL TREAT THE ENGINE FAILED. THIS CAR HAS BEEN THE WORST INVESTMENT THAT MY WIFE AND I HAVE EVER MADE. I HAVE HAVE OWNED SEVERAL CARS AND TRUCKS WITH 200000 PLUS MILES ON THEM AND NONE OF THEM HAVE EVER BEEN AS PROBLEMATIC AS THIS AUTOMOBILE.
NHTSA ODI #10069333
Mileage unknown · Nov 24, 2003
Electrical SystemExterior LightingPower Train
PROBLEMS WITH 1996 FORD CONTOUR FRONT BRAKES, TRANSMISSION, FUSE BOX, HEATER BLOWER MOTOR, ELECTRICAL AND STEERING AND SUSPENSION. *MR FOR THE SECOND TIME, THE VEHICLE HAD PROBLEMS WITH THE BRAKES MAKING A LOUD RUBBING SOUND, THE STABILIZER BAR WAS REPLACED AND NEEDS TO BE REPLACED AGAIN. THE TRANSMISSION WAS LEAKING, WATE…
Read full complaint
PROBLEMS WITH 1996 FORD CONTOUR FRONT BRAKES, TRANSMISSION, FUSE BOX, HEATER BLOWER MOTOR, ELECTRICAL AND STEERING AND SUSPENSION. *MR FOR THE SECOND TIME, THE VEHICLE HAD PROBLEMS WITH THE BRAKES MAKING A LOUD RUBBING SOUND, THE STABILIZER BAR WAS REPLACED AND NEEDS TO BE REPLACED AGAIN. THE TRANSMISSION WAS LEAKING, WATER WAS INSIDE OF THE HEADLIGHT SEALS, WHICH MADE THE LIGHTS VERY DIM, THE SELECTOR MODE SWITCH ON THE HEATER MOTOR BLOWER DID NOT WORK PROPERLY, WHICH MADE THE HEAT NOT WORK AT A 100%. THE UPPER BALL JOINTS, RACK AND PINION AND WHEEL BEARING WERE ALL DEFECTIVE. *JB *NM
NHTSA ODI #10048678
20,000 miles · Oct 12, 2003
Service Brakes, Hydraulic
WHILE DRIVING THE ABS LIGHT ILLUMINATED ON THE DASH INTERMITTENTLY. WHEN THIS OCCURRED THE ANTI LOCK BRAKES ENGAGED PREMATURELY. THE ABS WOULD THEN DISENGAGE AND THE BRAKES WOULD LOCK UP. *AK *TS *NLM
NHTSA ODI #10038196
95,000 miles · Jan 3, 2003
Service Brakes, Hydraulic
THE CALIPERS ON THE FRONT DISK BRAKE SYSTEM TEND TO WANT TO ROLL INWARD OFF OF THE ROTORS ON BOTH SIDES OF THE VEHICLE. THIS HAS HAPPENED TWICE TO DATE. VEHICLE: 1996 FORD CONTOUR
NHTSA ODI #10000717
Mileage unknown · Oct 10, 2001
Service Brakes, Hydraulic
ABS FAILED TO STOP VEHICLE AFTER BRAKES WERE APPLIED. VEHICLE STARTED SLOWING UP AFTER ABS LIGHT CAME ON. BRAKE PEDAL WENT TO THE FLOOR. EVENTUALLY WAS ABLE TO STOP VEHICLE. BEEN TO MECHANIC 4 TIMES, MASTER CYLINDER PROPRTIONAL VALVE WAS REPLACED TO CORRECT PROBLEM, WHICH STILL WAS PRESENT. *AK CONSUMER STATED THIS HAS BEEN…
Read full complaint
ABS FAILED TO STOP VEHICLE AFTER BRAKES WERE APPLIED. VEHICLE STARTED SLOWING UP AFTER ABS LIGHT CAME ON. BRAKE PEDAL WENT TO THE FLOOR. EVENTUALLY WAS ABLE TO STOP VEHICLE. BEEN TO MECHANIC 4 TIMES, MASTER CYLINDER PROPRTIONAL VALVE WAS REPLACED TO CORRECT PROBLEM, WHICH STILL WAS PRESENT. *AK CONSUMER STATED THIS HAS BEEN AN REOCURRING PROBLEM.*SLC
NHTSA ODI #897580
Official recalls
8Jul 9, 2001
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Nov 6, 2000
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Consequence & remedy
Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
Mar 9, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
Sep 13, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FUEL FILLER PIPE VENT HOSE MAY HAVE LESS THAN THE INTENDED LEVEL OF OZONE RESISTANCE, WHICH COULD RESULT IN THE HOSE BECOMING BRITTLE AND CRACKING.
Consequence & remedy
Consequence: A CRACKED HOSE COULD RESULT IN FUEL LEAKAGE WHEN THE VEHICLE IS BEING FUELED.
Remedy: DEALERS WILL INSTALL A FUEL FILLER VENT HOSE CONTACTING THE APPROPRIATE BLEND OF PVC AND NITRILE RUBBER.
May 5, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
Sep 18, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
Dec 8, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.
Nov 17, 1997
VEHICLE DESCRIPTION: BI-FUEL VEHICLES MODIFIED TO RUN ON EITHER GASOLINE OR COMPRESSED NATURAL GAS (CNG). THE NATURAL GAS FUEL TANKS HAVE A SOLENOID SHUT-OFF VALVE THAT STOPS FUEL FLOW FROM THE FUEL TANK IN THE EVENT OF CERTAIN MODERATE TO SEVERE COLLISIONS. IF THE VEHICLE IS IN A COLLISION AND THE NATURAL GAS FUEL LINE IS DAMAGED, THE SYSTEM COULD LEAK NATURAL GAS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: FORD HAS REQUESTED OWNERS OF THESE VEHICLES TO HAVE THE CNG FUEL SYSTEM DISABLED UNDER A PREVIOUS RECALL CAMPAIGN AND TO ONLY USE GASOLINE FUEL UNTIL A PERMANENT CORRECTIVE ACTION IS DEVELOPED. OWNERS ARE BEING ALERTED TO THIS SOLENOID VALVE CONCERN AT THIS TIME. THE TIMING OF CORRECTIVE ACTIONS IS BEING DELAYED TO ALLOW BOTH CONDITIONS TO BE REMEDIED AT ONE TIME. IN THE MEANTIME, THERE IS NOT RISK AS LONG AS THE NATURAL GAS SYSTEM HAS BEEN DISABLED AND THE VHEICLE IS ONLY OPERATED ON GASOLINE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
PE98063 · Headlight Switch
Opened Dec 3, 1998 · Closed May 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
ODI OPENED THE PRELIMINARY EVALUATION ON DECEMBER 3, 1989 BASED ON FIVE CONSUMER COMPLAINTS, ALL OF WHICH MENTIONED CONCERNS CENTERED ON THE DASHBOARD-MOUNTED HEADLIGHT SWITCH.THESE CONCERNS INCLUDED AN ALLEGATION OF THE SWITCH CATCHING FIRE, AN ALLEGATION OF HEADLIGHT LOSS, AND THREE ALLEGATIONS OF INSTRUMENT PANEL AND TAIL LIGHT OUTAGES.THREE OF THE REPORTS SPECIFICALLY IDENTIFIED THE HEADLIGHT SWITCH AND ITS ASSOCIATED WIRING AS HAVING BEEN HEAT DAMAGED.FORD INVESTIGATIONS HAVE FOUND THAT OVERHEATING OF AN ELECTRICAL TERMINAL AT THE HEADLIGHT SWITCH CONNECTOR CAUSES LOSS OF THE INSTRUMENT PANEL AND TAIL LIGHTS.FORD WILL REMEDY THIS CONDITION IN 1996-1998 MODEL CONTOUR AND MYSTIQUE VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT FROM APRIL 20, 1995 THROUGH AUGUST 12, 1998 AND AT THE CAUTITLAN, MEXICO ASSEMBLY PLANT FROM JUNE 13, 1995 THROUGH AUGUST 24, 1998 UNDER RECALL 99V-103.THE REMEDY INVOLVES REPLACEMENT OF THE HEADLIGHT SWITCH CONNECTOR AND IF NECESSARY, THE SWITCH ITSELF.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration