Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

34 crash reports24 fire reports24 injury reports

Engine And Engine Cooling complaints

123 reports

Clear category filter

Mileage unknown · May 13, 2000

Engine And Engine Cooling

PISTONS AND RINGS WERE BOTH SHOT IN THE MOTOR, BUT THE MOTOR HAD OIL AND FULL COMPRESSION. *AK

NHTSA ODI #722642

Mileage unknown · Mar 22, 2000

Engine And Engine CoolingPower TrainUnknown Or Other

CONSUMER TOOK CAR IN FOR 4TH RECALL REPAIRS. THIS ONE WAS FOR THE ENGINE WIRES. DEALER FIXED PROBLEM. CONSUMER PICKED UP CAR, AND ON THAT SAME EVENING ENGINE CHECK LIGHT CAME ON. TOOK IN VEHICLE FOR SERVICE, AND SPEEDOMETER STOPPED WORKING. COULDN'T TELL HOW FAST CAR WAS GOING. ALSO OVERDRIVE LIGHT STARTED TO BLINK ON/OFF.

NHTSA ODI #858976

Mileage unknown · Mar 21, 2000

Electrical SystemEngine And Engine CoolingSuspension

CONSUMER BOUGHT VEHICLE IN SEPTEMBER. SHE WENT OUTSIDE THAT MORNING TO START IT UP HER VEHICLE AND SHE NOTICED A KNOCKING NOISE COMMING FROM UNDERNEATH THE HOOD. THE DEALER REPLACED STARTER AND WATER PUMP BUT PROBLEM STILL EXIST.

NHTSA ODI #858948

Mileage unknown · Feb 26, 2000

Engine And Engine Cooling

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ODI #719325

Mileage unknown · Feb 14, 2000

Electrical SystemEngine And Engine CoolingSteering

Read full complaint

OCCASIONALLY, WHEN THE VEHICLE ROLLS THROUGH A PUDDLE, THE STEERING WILL FAIL AND THE BATTERY LIGHT WILL APPEAR, WITH THE ENGINE ALMOST STALLING. THIS HAS HAPPENED WITH THE CAR GOING AS FAST AS 35 MPH AND AS SLOW AS 5 MPH. THE PROBLEM HAS BEEN REPORTED TO THE DEALER ON SEVERAL OCCASIONS, AND THE DEALER HAS REPORTEDLY CONTACTED THE MANUFACTURER REGARDING THIS PARTICULAR PROBLEM. ADDITIONALLY, THE FIRST TIME THE VEHICLE WAS TAKEN BACK TO THE DEALER TO REPORT THE PROBLEM, THE SERVICE PERSONNEL WAS AWARE THAT THE PROBLEM EXISTED WITH THE SPECIFIC MODEL. AFTER REPEATED RETURNS TO THE DEALER (AT LEAST THREE SEPARATE COMPLAINTS), THE DEALER INFORMED US THAT THE PROBLEM WAS FIXED AND THAT THE CAR WAS EVEN "DRIVEN THROUGH SEVERAL PUDDLES" WITHOUT ANY STEERING FAILURE. THE LAST TIME THE VEHICLE WAS TAKEN IN WAS APPROXIMATELY AUGUST, 1999. THE WARRANTY HAS SINCE EXPIRED, AND THE DEALER SAYS THAT IT IS OUR RESPONSIBILITY TO PAY TO HAVE THE PROBLEM FIXED. UNFORTUNATELY, WE HAVE TAKEN THE CAR BACK SEVERAL TIMES, AND THE PROBLEM STILL EXISTS. ON 02/13/00, THE VEHICLE AGAIN EXPERIENCED STEERING FAILURE.

NHTSA ODI #718762

Mileage unknown · Feb 14, 2000

Engine And Engine Cooling

WATER PUMP IMPELLER BROKE INTO TWO PIECES IMEEDIATELY PARALIZING THE ENTIRE ENGINE COOLING SYSTEM. THIS DEFECT, TO THE BEST OF MY KNOWLEDGE IS COMMON FOR FORD CONTOURS EQUIPPED WITH 2.5L V6 DURATEC ENGINES. ALTHOUGH NOT DIRECTLY RELATED TO PASSENGER SAFETY IN THE TRADITIONAL SENSE, THIS DEFECT IS POTENTIALLY VERY DANGEROUS. I TH…

Read full complaint

NHTSA ODI #718758

Mileage unknown · Dec 12, 1999

Engine And Engine Cooling

Read full complaint

THIS IS A LEASED CAR. I TAKE GOOD CARE OF IT, BRINGING IT TO A MECHANIC EVERY THREE MONTHS FOR A "CHECK UP" THERE WERE NO WARNING SIGNS. THE CAR SIMPLY STOPPED. I HAD IT TOWED TO A SHOP AND NOW IT IS COSTING ME $ 3000.00 TO FIX THE TRANSMISSION. I CALLED FORD AND BESIDES BEING NASTY AND RUDE, WAS TOLD THAT THERE WAS NOTHING THEY COULD "DO". NO WARNING LIGHTS, NOTHING. JUST A DEAD CAR. MY MECHANIC IS HAVING A VERY DIFFICULT TIME FINDING PARTS TO REPLACE THE TRANSMISSION. I AM VERY ANGRY! *AK

NHTSA ODI #715963

Mileage unknown · Oct 25, 1999

Engine And Engine Cooling

WHILE DRIVING AT HIGHWAY SPEEDS THE FROST PLUG RELEASED, CAUSING ANTI- FREEZE TO SPILL AND VEHICLE TO STALL OUT AND DIE. THERE WAS NOT INDICATION THAT THE ENGINE WAS OVERHEATING. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK

NHTSA ODI #851598

Mileage unknown · Sep 30, 1999

Engine And Engine Cooling

WHILE TRAVELING VEHICLE STALLED WITHOUT ANY INDICATIONS. AS A RESULT, WHEELS LOCKED UP. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ODI #849389

Mileage unknown · Sep 22, 1999

Engine And Engine Cooling

THEROMSTAT IS CAUSING THE CAR TO OVERHEAT. *AK

NHTSA ODI #843860

Official recalls

01V230000 · Electrical System

Jul 9, 2001

ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.

Consequence & remedy

Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.

Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.

00V367000 · Engine And Engine Cooling

Nov 6, 2000

VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.

Consequence & remedy

Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.

Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.

00V075000 · Service Brakes, Hydraulic:foundation Components

Mar 9, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.

Consequence & remedy

Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.

99V247000 · Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

Sep 13, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FUEL FILLER PIPE VENT HOSE MAY HAVE LESS THAN THE INTENDED LEVEL OF OZONE RESISTANCE, WHICH COULD RESULT IN THE HOSE BECOMING BRITTLE AND CRACKING.

Consequence & remedy

Consequence: A CRACKED HOSE COULD RESULT IN FUEL LEAKAGE WHEN THE VEHICLE IS BEING FUELED.

Remedy: DEALERS WILL INSTALL A FUEL FILLER VENT HOSE CONTACTING THE APPROPRIATE BLEND OF PVC AND NITRILE RUBBER.

99V103000 · Exterior Lighting:headlights:switch

May 5, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.

Consequence & remedy

Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.

Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.

98V233000 · Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 18, 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.

Consequence & remedy

Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.

Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.

97V225000 · Vehicle Speed Control:cables

Dec 8, 1997

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.

Consequence & remedy

Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.

Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.

97V203000 · Fuel System, Other:storage

Nov 17, 1997

VEHICLE DESCRIPTION: BI-FUEL VEHICLES MODIFIED TO RUN ON EITHER GASOLINE OR COMPRESSED NATURAL GAS (CNG). THE NATURAL GAS FUEL TANKS HAVE A SOLENOID SHUT-OFF VALVE THAT STOPS FUEL FLOW FROM THE FUEL TANK IN THE EVENT OF CERTAIN MODERATE TO SEVERE COLLISIONS. IF THE VEHICLE IS IN A COLLISION AND THE NATURAL GAS FUEL LINE IS DAMAGED, THE SYSTEM COULD LEAK NATURAL GAS.

Consequence & remedy

Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: FORD HAS REQUESTED OWNERS OF THESE VEHICLES TO HAVE THE CNG FUEL SYSTEM DISABLED UNDER A PREVIOUS RECALL CAMPAIGN AND TO ONLY USE GASOLINE FUEL UNTIL A PERMANENT CORRECTIVE ACTION IS DEVELOPED. OWNERS ARE BEING ALERTED TO THIS SOLENOID VALVE CONCERN AT THIS TIME. THE TIMING OF CORRECTIVE ACTIONS IS BEING DELAYED TO ALLOW BOTH CONDITIONS TO BE REMEDIED AT ONE TIME. IN THE MEANTIME, THERE IS NOT RISK AS LONG AS THE NATURAL GAS SYSTEM HAS BEEN DISABLED AND THE VHEICLE IS ONLY OPERATED ON GASOLINE.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗