CONSUMER HAD TAKEN VEHICLE TO DEALER FOR RECALL 00 V 367 000/ ENGINE COOLING FAN REPAIRS. AFTER CONSUMER TOOK IT BACK TO DEALER, THEY FOUND OUT A BARE WIRE WICH WAS CAUSING PROBLEM. A GENERAL MANAGER SAID THAT THEY COULD NOT BE RESPONSIBLE FOR WHAT HAD HAPPENED, THEREFORE NOTHING COULD BE DONE.*AK CONSUMER STATES AFTER VE…
Read full complaint
CONSUMER HAD TAKEN VEHICLE TO DEALER FOR RECALL 00 V 367 000/ ENGINE COOLING FAN REPAIRS. AFTER CONSUMER TOOK IT BACK TO DEALER, THEY FOUND OUT A BARE WIRE WICH WAS CAUSING PROBLEM. A GENERAL MANAGER SAID THAT THEY COULD NOT BE RESPONSIBLE FOR WHAT HAD HAPPENED, THEREFORE NOTHING COULD BE DONE.*AK CONSUMER STATES AFTER VEHICLE WAS RETURNED IT BEGAN TO OVERHEAT, THE CHECK ENGINE LIGHT WOULD COME AND FUSES WERE BLOWN, CONSUMER WAS INFOMRED THAT THE REASON THE FUSES WERE BLOWING WAS BECAUSE THE RECALL THAT WAS PERFORMED ON THE ENGINE COOLING FAN WAS DONE WRONG AND THAT WAS WHY VEHICLE WAS OVERHEATING, DELAER THEN STATED THAT ADDITIONAL REPAIRS WOULD NOT BE COVERED DUE TO THE MILEAGE.*JB
NHTSA ODI #893427
Mileage unknown · Jul 5, 2001
Engine And Engine Cooling
AFTER RECEIVING RECAL ON 00 V 367 000/ ENGINE COOLING FAN CONSUMER TOOK VEHICLE TO DEALER FOR REPAIRS. UPON RECEIVING VEHICLE BACK FROM DEALER,. TWO DAYS LATER, VEHICLE OVERHEATED. HAD TO BE TOWED BACK TO DEALER. DEALER STATED NOTHING THEY DID WOULD HAVE CAUSED VEHICLE TO OVERHEAT. CONSUMER INSISTED HE NEVER HAD THIS PROBL…
Read full complaint
AFTER RECEIVING RECAL ON 00 V 367 000/ ENGINE COOLING FAN CONSUMER TOOK VEHICLE TO DEALER FOR REPAIRS. UPON RECEIVING VEHICLE BACK FROM DEALER,. TWO DAYS LATER, VEHICLE OVERHEATED. HAD TO BE TOWED BACK TO DEALER. DEALER STATED NOTHING THEY DID WOULD HAVE CAUSED VEHICLE TO OVERHEAT. CONSUMER INSISTED HE NEVER HAD THIS PROBLEM UNTIL IT WAS TAKEN TO DEALER FOR RECALL REPAIRS ON ENGINE COOLING FAN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #891997
Mileage unknown · Jun 27, 2001
Electrical SystemEngine And Engine Cooling
WHILE DRIVING VEHICLE OVERHEATS. CONSUMER HAS CONTACTED DEALER. DEALER REFUSED TO REPLACE BURNED WIRING UNDER WARRANTY. PLEASE PROVIDE ANY FURTHER DETAILS. *AK
NHTSA ODI #891382
Mileage unknown · Jun 27, 2001
Electrical SystemEngine And Engine CoolingFire
THE ENGINE COOLING FAN FAILED PRIOR TO RECALL NOTICE 00V-367 RESULTING IN A FIRE UNDER THE HOOD WHILE IN MOTION. NLM
NHTSA ODI #561784
Mileage unknown · Jun 22, 2001
Engine And Engine Cooling
THERMOSTAT HAS BEEN REPLACED SIX TIMES FOR OVERHEATING. DEALERSHIP INFORMED CONSUMER THAT HEAD GASKET HAD CRACKED, AND WAS LEAKING FLUID. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *AK
NHTSA ODI #891028
Mileage unknown · Jun 22, 2001
Engine And Engine Cooling
CAR HAS OVERHEATED ON NUMEROUS OCCASSIONS, ENGINE LIGHT ON CONSTANTLY, BLOWN HEAD GASKET THE LAST TIME CAR OVERHEATED, RESULTING IN ENGINE FAILURE. DEALER IS TRYING TO SAY THAT THE RECALLED COOLING FAN DIDN'T RESULT IN DESTRUCTION OF ENGINE. EXTREMELY FRUSTRATED WITH THE DEALER SERVICE AND IN FORD CUSTOMER RELATIONSHIP DEPT.
NHTSA ODI #747241
Mileage unknown · Jun 15, 2001
Engine And Engine Cooling
PLASTIC PUMP IMPELLER UNSUITABLE FOR APPLICATION. *AK
NHTSA ODI #746891
Mileage unknown · Jun 5, 2001
Engine And Engine Cooling
WHILE TRAVELING NOTICE VEHICLE RUNNING ROUGH. ALSO, NOTICE LITTLE OVERHEATING NEXT DAY VEHICLE WOULD NOT START. DEALER STATED HEAD GASKET NEEDED TO BE REPLACED.*AK CONSUMER ALSO STATES THE FLYWHEEL WAS REPLACED.*JB
NHTSA ODI #889810
Mileage unknown · Jun 1, 2001
Engine And Engine Cooling
CONSUMER EXPLAINS THAT ENGINE LIGHT STAYS ILLUMINATED AND VEHICLE BROKE DOWN, MECHANIC ORDERED PART WHICH WAS PART OF A RECALL AND REPLACED, VEHICLE BROKE DOWN ONCE AGAIN DUE TO SHORT IN THE WIRE. *JG
NHTSA ODI #561425
Mileage unknown · May 30, 2001
Engine And Engine Cooling
WATER PUMP PROPELLOR DISINTEGRATED AND CAUSED ENGINE TO EXTREMLY OVERHEAT WITH IN A MATTER OF MINUTES WITH NO WARNING AT ALL. *AK
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Consequence & remedy
Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.
CRACKS HAVE BEEN FOUND IN THE FRONT SAFETY BELT OUTBOARD ANCHOR TABS DUE TO A COMBINATION OF HYDROGEN EMBRITTLEMENT OF THE TAB AND STRESS INTRODUCED DURING ATTACHMENT OF THE ANCHOR TAB TO THE SEAT FRAME. THIS DOES NOT CONFORM WITH THE REQUIREMENTS OF FMVSS NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: A FRACTURE OR SEPARATION IN THIS AREA WOULD REDUCE THE LOAD THAT THE ANCHOR AND THE FRONT SAFETY BELT ANCHORAGES COULD SUSTAIN, INCREASING THE RISK OF INJURY IN A VEHICLE COLLISOIN.
Remedy: DEALERS WILL INSPECT AND INSTALL AN ANCHOR TAB REINFORCEMENT OR REPLACEMENT OF THE COMPLETE FRONT SEAT BELT ASSEMBLY IF AN ANCHOR TAB IS FOUND TO HAVE FRACTURED.
THE GLASS TEMPERING PROCESS ON THE RIGHT HAND REAR DOOR WINDOWS WAS NOT CORRECTLY PERFORMED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 205, "GLAZING MATERIALS."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE WINDOW BREAKS, THE GLASS FRAGMENTS OF THE REAR WINDOWS EXCEED THE SIZE SPECIFICATIONS OF FMVSS NO. 205.
Remedy: DEALERS WILL REPLACE THE RIGHT REAR DOOR GLASS.
A METAL SHIELD ON THE OUTSIDE OF THE PLASTIC FUEL FILLER PIPE CAN DEVELOP A STATIC ELECTRICAL CHARGE DURING REFUELING OF THE VEHICLE.
Consequence & remedy
Consequence: A STATIC CHARGE CAN DISCHARGE AND SERVE AS AN IGNITION SOURCE FOR FUEL VAPORS IN THE AREA OF THE FILLER PIPE, RESULTING IN A FLASH VAPOR IGNITION AND A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, MODIFY THE VEHICLES BY ADDING A GROUND STRAP BETWEEN THE FILLER PIPE SHIELD AND THE BODY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA00005 · Engine Cooling Fan Fires
Opened Feb 23, 2000 · Closed Nov 9, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
PE99052 · Engine Cooling Fan Fires
Opened Aug 18, 1999 · Closed Feb 23, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI OPENED THIS INVESTIGATION ON AUGUST 18, 1999, BASED ON FOUR REPORTS OF FIRE INVOLVING THE ENGINE COOLING FAN.THE REPORTS ALLEGE THE ELECTRONIC COOLING FAN CAUGHT FIRE WITH RESULTANT DAMAGE TO THE FAN AND WIRE HARNESS AND/OR THE HARNESS CONNECTOR.IN ITS PE RESPONSE, FORD PROVIDED INFORMATION RELEVANT TO 46 ADDITIONAL ALLEGED FIRE INCIDENTS AND 47 ALLEGED FAILURES OF THE COOLING FAN INVOLVING THERMAL DAMAGE TO THE FAN.THIS INVESTIGATION HAS BEEN UPGRADED TO FURTHER STUDY THE ISSUE.
PE98050 · Front Suspension Coil Spring Failure
Opened Sep 14, 1998 · Closed Feb 4, 1999
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
1995 Ford Contour Problems, Complaints & Recalls | Skip That Year
Illustration