IllustrationBOTH HEADLIGHTS ARE DISCOLORED, AND DO NOT PROVIDE SUFFICIENT LIGHTING,CAUSING POOR VISIBILITY. *AK
1994 Ford Aspire
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Ford Aspire do not stand out strongly from the model-year median of 54.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aspire years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 54 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports2 fire reports12 injury reports
What owners actually said
54 reportsWENT TO HAVE VEHICLE INSPECTED AND IT FAILED DUE TO THE LENS COVERING. COLOR OF THE LENS DOESN'T ALLOW VISIBLE LIGHTING. CONTACTED DEALER. *AK *ML
I AM SENDING THIS WITH GREAT CONCERN OVER A MANUFACTURING DEFECT THAT I FEEL IS VERY DANGEROUS.THE SPOT WELDS ON THE HARNESS THAT HOLDS THE BRAKE AND CLUTCH PEDALS BROKE AND CAUSED THE BRAKE PEDAL TO HANG UP ON THE STEERING COLUMN. I WAS UNABLE TO STOP SAFELY AND NEARLY PUT THE CAR INTO A DITCH. I WAS APPALLED WHEN I REALIZED …
Read full complaint
I AM SENDING THIS WITH GREAT CONCERN OVER A MANUFACTURING DEFECT THAT I FEEL IS VERY DANGEROUS.THE SPOT WELDS ON THE HARNESS THAT HOLDS THE BRAKE AND CLUTCH PEDALS BROKE AND CAUSED THE BRAKE PEDAL TO HANG UP ON THE STEERING COLUMN. I WAS UNABLE TO STOP SAFELY AND NEARLY PUT THE CAR INTO A DITCH. I WAS APPALLED WHEN I REALIZED THE CAUSE OF THE FAILURE. THE WHOLE HARNESS HAS STRESS FRACTURES AND FROM WHAT I CAN SEE HAS BROKEN ON AT LEAST TWO OF THE SPOT WELDS. HOW COULD A PART THAT WOULD OBVIOUSLY HAVE SO MUCH WEAR AND TEAR AS THE BRAKE CLUTCH PEDAL ASSEMBLY ONLY BE SPOT WELDED TOGETHER? LET ALONE BE MANUFACTURED OUT OF SUCH THIN METAL? IT WAS POORLY MANUFACTURED AND I BELIEVE THESE VEHICLES SHOULD BE INSPECTED BEFORE SOMEONE GETS SERIOUSLY HURT. HAD THIS NOT BEEN A FIVE SPEED I WOULD HAVE HAD NO WAY TO SLOW THE VEHICLE DOWN AND WOULD HAVE SURELY BEEN IN AN ACCIDENT. I AM AFRAID OF THE CAR AND I HOPE FORD WILL ACCEPT THE RESPONSIBILITY TO FIX IT BECAUSE THIS IN NO WAY IS USER ERROR. IT IS DEFINITELY A MANUFACTURER'S DEFECT/ENGINEERING DESIGN FLAW THAT NO CONSUMER SHOUD BE RESPONSIBLE FOR. IT WAS A POOR CHOICE OF COST CUTTING TO ONLY SPOT WELD THIS PART TOGETHER . IT PLAINLY IS A DANGEROUS SAFELY ISSUE FOR ANYONE OPERATING ONE OF THESE CARS. I HOPE NO ONE GETS SERIOUSLY HURT BECAUSE ANY MORE OF THESE WELDS BREAK AND CAUSE SOMEONE TO BE UNABLE TO STOP SAFELY. AS OF RIGHT NOW BOTH THE CLUTCH CABLE AND PEDAL DO NOT FUNCTION CORRECTLY AND THE BRAKE PEDAL REPEATEDLY HITS THE STEERING COLUMN PREVENTING IT FROM BEING ABLE TO DEPRESS FAR ENOUGH TO FULLY STOP THE CAR. I PRAY I AM THE ONLY ONE WHO HAS RUN INTO THIS PROBLEM, BUT I FEEL THIS NEEDS PROMPT ATTENTION AND SHOULD BE INVESTIGATED BEFORE SOMEONE IS HURT OR KILLED BY ONE OF THESE CARS DUE TO THIS MECHANICAL ERROR. THIS ASSEMBLY NEVER SHOULD HAVE BEEN "GLUED" TOGETHER WITH AN OBVIOUSLY WEAK SPOT WELD.
AIRBAGS DID NOT DEPLOY WITH A FRONT END COLLISION WITH DEER AT @40MPH. *AK
DURING HOT WEATHER AND WHEN THE CAR HAS BEEN DRIVING A LONG TIME, ENGINE WILL NOT START AFTER IT'S BEEN SHUT OFF. HAVE TO KEEP TRYING BEFORE IT FINALLY ENGAGES. HAS BEEN HAPPENING SINCE 6 MONTHS AFTER PURCHASING THE CAR. IT'S NOT A DEAD BATTERY, THE ENGINE WILL NOT ENGAGE UNTIL SEVERAL TRIES ARE MADE.
THE PLASTIC COVERING OVER THE HEADLIGHTS HAVE FADED CAUSING POOR VISIBILITY. *MJS
THE PLASTIC COVERINGS OVER THE HEADLIGHTS HAVE FADED TO THE POINT WHERE THE HEADLIGHTS SHINE VERY DIM AND MAKE IT DIFFICULT TO SEE AT NIGHT WHILE DRIVING. THIS OCCURRED APPROX 1 YEAR AFTER PURCHASING THE VEHICLE. I HAVE CONTACTED THE DEALER BUT THEY HAVE NOT HEARD OF ANY RECALLS FOR THIS SAFETY ISSUE. THE COST TO REPLACE THES…
Read full complaint
THE PLASTIC COVERINGS OVER THE HEADLIGHTS HAVE FADED TO THE POINT WHERE THE HEADLIGHTS SHINE VERY DIM AND MAKE IT DIFFICULT TO SEE AT NIGHT WHILE DRIVING. THIS OCCURRED APPROX 1 YEAR AFTER PURCHASING THE VEHICLE. I HAVE CONTACTED THE DEALER BUT THEY HAVE NOT HEARD OF ANY RECALLS FOR THIS SAFETY ISSUE. THE COST TO REPLACE THESE LAMPS ARE OUTRAGEOUS. *AK
NOTICED A LEAKAGE AT GASKET WHEN FILLING UP THE WATER RESERVOIR AND CHECKING ENGINE OIL DIP STICK. WHEN MAKING A RIGHT TURN OR GOING UP A HILL AROUND A CURVE, THE DRIVER SIDE HAS A STRANGE RATTLING NOISE ON THE FRONT TIRE. *AK
CONSUMER WAS DRIVING AT 15MPH SWERVED TO AVOID A BYCICLIST AND HIT A LIGHT POLE HEAD-ON. DURING INFLATION OF THE AIR BAGS THEY BLEW OUT ON BOTH SIDE WINDOWS, SHATTERING THE WINDOWS INTO LITTLE PIECES. DEALER HAS NOT BEEN CONTACTED. *AK
THERE IS VERY LOUD RAMBLING NOISE WHICH GETS HIGHER AS THE VEHICLE PICKS UP SPEED. ALSO, CRASH BARRIERS HAVE BEEN REPLACED THREE TIMES, AND THE DEALER IS AWARE OF THE PROBLEM. *AK
Official recalls
294V186000 · Fuel System, Gasoline:delivery
Oct 4, 1994
THE FUEL SUPPLY, RETURN AND VAPOR HOSES OR LINES CAN CONTACT OR HAVE INADEQUATE CLEARANCE WITH THE SURROUNDING COMPONENTS DUE TO IMPROPER POSITIONING DURING ASSEMBLY.
Consequence & remedy
Consequence: WEAR OF THE HOSE OR LINE CAN OCCUR, RESULTING IN FUEL LEAKAGE WITHIN THE ENGINE COMPARTMENT WHICH CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Remedy: THE FUEL LINES WILL BE REPOSITIONED. ANY DAMAGED RUBBER HOSES WILL BE REPLACED. STEEL FUEL LINES WILL HAVE THE CORROSION PROTECTION REPAIRED IF NEEDED.
94V141000 · Equipment:other:labels
Aug 1, 1994
THE DATES OF MANUFACTURE WERE OMITTED ON THE CERTIFICATION LABEL. THIS DOES NOT COMPLY WITH PART 567, "CERTIFICATION."
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: INCOMPLETE CERTIFICATION LABEL DOES NOT PROPERLY IDENTIFY THE VEHICLE.
Remedy: A COMPLETE CERTIFICATION LABEL WILL BE PROVIDED TO THE OWNER OR WILL BE INSTALLED FOR THE OWNER BY THE DEALER, IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE97037 · Steering Wheel/column Lockup
Opened Jul 28, 1997 · Closed Nov 28, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available