NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
302 reportsClear category filterMileage unknown · Feb 12, 2025
Electrical SystemFuel/propulsion SystemService Brakes
Fisker Inc has gone out of business. A mandatory recall has been issued and the bankruptcy court has assigned a trustee to ensure vehicles are updated to version 2.2 to address safety recall issues. The update to 2.2 has been extremely unpredictable and the trustee has not been able to complete this recall. I had to pay $450.00 …
Read full complaint
Fisker Inc has gone out of business. A mandatory recall has been issued and the bankruptcy court has assigned a trustee to ensure vehicles are updated to version 2.2 to address safety recall issues. The update to 2.2 has been extremely unpredictable and the trustee has not been able to complete this recall. I had to pay $450.00 to complete the software update. I will have to pay an additional $450 to have the water-pump replaced, plus drive 6 hours to closest service center to have the work done. After the software update almost immediately the estimated range has been drastically reduced. The cars were marketed as getting up to 360 miles on 100% charge. Since the recall update, they now get somewhere around 220 miles on a 100% charge. The technician that completed my update analyzed it with approved Fisker software, and he found that the rear motor is now throwing “flux error codes” and not functioning properly. This is causing an electrical issue draining the batteries much quicker than they should be. there is no fix at the moment however the trustee is still responsible for rolling out this buggy software .
NHTSA ODI #11642333
Mileage unknown · Feb 12, 2025
Forward Collision AvoidanceService BrakesUnknown Or Other
NHTSA recall campaign numbers for the software recalls are 24V865000 and 24V623000, or others can be found in this link for 2023 Fisker Oceans [XXX] . I had to pay out of pocket for the water pump recall work (receipts provided in file upload). Also, all the software updates to address software recalls have not been done and i…
Read full complaint
NHTSA recall campaign numbers for the software recalls are 24V865000 and 24V623000, or others can be found in this link for 2023 Fisker Oceans [XXX] . I had to pay out of pocket for the water pump recall work (receipts provided in file upload). Also, all the software updates to address software recalls have not been done and i've been waiting. I've been getting constant safety alerts ranging from lane departure, front collision alerts that it is not functioning, constant camera malfunctions not working causing me to risk running into things when backing up because backup camera not working, and the proximity sensors not working half the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11642321
Mileage unknown · Feb 12, 2025
Electrical SystemForward Collision AvoidanceService Brakes
Vehicle was bricked due to faulty "GATEWAY MODULE" gateway module was fried due to software version 2.2 OTA download. Vehicle was constantly giving false ADAS warnings and also had issues with driver door NFC reader. I have spent $3,869.75 to install new gateway module and manual download of version 2.2 software. What remedy d…
Read full complaint
Vehicle was bricked due to faulty "GATEWAY MODULE" gateway module was fried due to software version 2.2 OTA download. Vehicle was constantly giving false ADAS warnings and also had issues with driver door NFC reader. I have spent $3,869.75 to install new gateway module and manual download of version 2.2 software. What remedy do I have to recover all or portion of money spent to rectify problems?
NHTSA ODI #11642318
Mileage unknown · Feb 12, 2025
Service BrakesUnknown Or Other
Sometimes doors lock and can’t open it, symptom warning lights keep coming on and also various issues.
NHTSA ODI #11642315
Mileage unknown · Feb 12, 2025
EngineService Brakes
Pump recall (Recall No 24V865) work was done. I paid $340.00 out of pocket for labor to install the [ump. Subsequently, through Fisker Owners Association, I learned that the liquidating trustee decided that the maximum reimbursement is $175.00. Yet, there is no mechanism for filing for and obtaining the refund promised. The fi…
Read full complaint
Pump recall (Recall No 24V865) work was done. I paid $340.00 out of pocket for labor to install the [ump. Subsequently, through Fisker Owners Association, I learned that the liquidating trustee decided that the maximum reimbursement is $175.00. Yet, there is no mechanism for filing for and obtaining the refund promised. The fix for the sudden jerking forward of the car with it hits a bump is supposed to be fixed with 2.2 software update. As of the time of filing of this complaint, I have heard nothing from the liquidating trustee as to when this will be installed to my vehicle. I have replaced my old batter with a new one in anticipation of the update.
NHTSA ODI #11642299
Mileage unknown · Feb 12, 2025
Electrical SystemService Brakes
There has been several safety recalls for my vehicle that was supposed to be fixed by software updates I cannot drve my vehicle, i have no access to service and no access to these updates
NHTSA ODI #11642297
Mileage unknown · Feb 12, 2025
Forward Collision AvoidanceService BrakesUnknown Or Other
Braking Issue and ADAS Warning + Lack of Access Concerns I am writing to express my deep concerns regarding the ongoing issues that are being seen with the NHTSA recall campaign numbers 24V865000 and 24V623000. Specifically, the Advanced Driver Assistance System (ADAS) in my vehicle, which has become increasingly distracting and…
Read full complaint
Braking Issue and ADAS Warning + Lack of Access Concerns I am writing to express my deep concerns regarding the ongoing issues that are being seen with the NHTSA recall campaign numbers 24V865000 and 24V623000. Specifically, the Advanced Driver Assistance System (ADAS) in my vehicle, which has become increasingly distracting and, frankly, dangerous due to an incomplete or failed 2.2 Over-The-Air (OTA) update is a huge concern. As a responsible driver, I value the safety of not only myself but also those around me, and this situation and others we constantly hear about make me question the process of the recall. Every week, a number of vehicles are reported as undrivable post-OTA updates, with statistics indicating that approximately 2%-5% of owners experience this issue. With 48-hour update windows, my vehicle becomes unusable for an extended period, which is highly inconvenient and concerning. Moreover, I've noted that partial updates are expected, potentially extending this downtime by another 48 hours. I have had a partial update that has left my vehicle in worse shape than before, what could happen if the process is tried again? This inconsistent performance is not only frustrating, but also poses a serious inconvenience to scheduling and executing such a process. Owner surveys suggest that comprehensive updates, which should resolve these issues, have been successfully completed in under 30% of vehicles which were attempted. Additionally, the alarming figures shared indicate that only around 10% of the fleet has been updated in over five weeks, despite submitting over 800 Vehicle Identification Numbers (VINs). This inefficiency raises serious questions about the reliability of the process. Furthermore, the fact that there are only approximately 20 service personnel available nationwide, with a mere five traveling to assist customers whose cars are rendered undrivable, is simply unacceptable. This lack of support exacerbates an already troubling situation
NHTSA ODI #11642284
Mileage unknown · Feb 12, 2025
Lane DepartureService BrakesUnknown Or Other
I am writing to express my deep concerns regarding the ongoing issues that are being seen with the NHTSA recall campaign numbers 24V865000 and 24V623000. Specifically, the Advanced Driver Assistance System (ADAS) in my vehicle, which has become increasingly distracting and, frankly, dangerous due to an incomplete or failed 2.2 O…
Read full complaint
I am writing to express my deep concerns regarding the ongoing issues that are being seen with the NHTSA recall campaign numbers 24V865000 and 24V623000. Specifically, the Advanced Driver Assistance System (ADAS) in my vehicle, which has become increasingly distracting and, frankly, dangerous due to an incomplete or failed 2.2 Over-The-Air (OTA) update is a huge concern. As a responsible driver, I value the safety of not only myself but also those around me, and this situation and others we constantly hear about make me question the process of the recall. Every week, a number of vehicles are reported as undrivable post-OTA updates, with statistics indicating that approximately 2%-5% of owners experience this issue. With 48-hour update windows, my vehicle becomes unusable for an extended period, which is highly inconvenient and concerning. Moreover, I've noted that partial updates are expected, potentially extending this downtime by another 48 hours. I have had a partial update that has left my vehicle in worse shape than before, what could happen if the process is tried again? This inconsistent performance is not only frustrating, but also poses a serious inconvenience to scheduling and executing such a process. Owner surveys suggest that comprehensive updates, which should resolve these issues, have been successfully completed in under 30% of vehicles which were attempted. Additionally, the alarming figures shared indicate that only around 10% of the fleet has been updated in over five weeks, despite submitting over 800 Vehicle Identification Numbers (VINs). This inefficiency raises serious questions about the reliability of the process. Furthermore, the fact that there are only approximately 20 service personnel available nationwide, with a mere five traveling to assist customers whose cars are rendered undrivable, is simply unacceptable. This lack of support exacerbates an already troubling situation. Given these circumstances, I urge you to address these
NHTSA ODI #11642283
Mileage unknown · Feb 12, 2025
Lane DepartureService BrakesUnknown Or Other
Issues after applying mandated software recall: - Constant visual and audible ADAS warnings are a distracting safety issue - Loss of over 100 mile range Unavailable parts and service for water pump and door handle mandated recalls
NHTSA ODI #11642277
Mileage unknown · Feb 12, 2025
Fuel/propulsion SystemPower TrainService Brakes
I am submitting this complaint because my 2023 Fisker Ocean One has not received any of the six NHTSA-mandated recalls, and with Fisker Inc. now bankrupt and unreachable, there is no clear path to getting these critical safety repairs completed. My wife drives this vehicle daily for work, covering approximately 100–150 miles per…
Read full complaint
I am submitting this complaint because my 2023 Fisker Ocean One has not received any of the six NHTSA-mandated recalls, and with Fisker Inc. now bankrupt and unreachable, there is no clear path to getting these critical safety repairs completed. My wife drives this vehicle daily for work, covering approximately 100–150 miles per day, and the ongoing safety concerns pose a serious risk to her and others on the road. The vehicle has multiple serious safety issues that remain unaddressed due to the lack of manufacturer support: Safety features are non-functional – Several critical safety systems are either malfunctioning or have stopped working entirely. NFC Card Reader Failure – The NFC card reader on the door handle has stopped working, making entry into the vehicle unreliable. Vehicle Rolling Over Bumps – The car exhibits an uncontrolled rolling movement when driving over bumps, which creates an unpredictable driving experience and a potential loss of control. Interior Lighting Malfunctions – Various interior lights turn on randomly without user input, which may indicate electrical issues. Given Fisker’s bankruptcy, I am unable to schedule recall repairs, and no official service network exists to address these safety-critical issues. The recalls mandated by the NHTSA must be performed, yet there is no viable path for owners to ensure compliance. This situation presents an urgent safety hazard, and I am requesting immediate guidance on how these safety recalls can be fulfilled to ensure the vehicle is roadworthy and safe for daily use.
NHTSA ODI #11642272
Official recalls
6Nov 15, 2024
Fisker Group Inc (Fisker) is recalling certain 2023-2024 Ocean vehicles. The transmission may not shift into the selected gear, allowing the vehicle to roll away while in Drive or Reverse.
Consequence & remedy
Consequence: A vehicle roll away increases the risk of a crash or injury.
Remedy: Fisker released an over-the-air (OTA) software update on March 11, 2024, free of charge. Owners may contact Fisker customer service at 1-844-347-5371.
Aug 20, 2024
Fisker Group Inc (Fisker) is recalling certain 2023-2024 Ocean vehicles. The brake module software may cause an unexpected reduction in regenerative braking, decreasing the braking performance.
Consequence & remedy
Consequence: Decreased braking performance can extend the distance required to stop, increasing the risk of a crash.
Remedy: Fisker will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 26, 2024. Owners may contact Fisker customer service at 1-844-347-5371. Fisker's number for this recall is TSB10062408.
Jul 2, 2024
Fisker Group Inc (Fisker) is recalling all 2023-2024 Ocean vehicles. A communication failure with the cabin electric water pump can cause the high voltage battery management system (BMS) to enter limp mode, causing a loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Fisker will replace the pumps, free of charge. Owner notification letters were mailed August 19, 2024. Owners may contact Fisker customer service at 1-844-347-5371. Fisker's number for this recall is TSB30032401.
Jun 20, 2024
Fisker Group Inc (Fisker) is recalling all 2023-2024 Ocean vehicles. The exterior door handles can stick and fail to open.
Consequence & remedy
Consequence: A door that fails to open can prevent occupants from exiting in an emergency, increasing the risk of injury.
Remedy: Fisker will inspect and replace the door handles as necessary, free of charge. Owner notification letters were mailed August 19, 2024. Owners may contact Fisker customer service at 1-844-347-5371. Fisker's number for this recall is TSB55062401.
Jun 5, 2024
Fisker Group Inc (Fisker) is recalling all 2023 Ocean vehicles. The Motor Control Unit (MCU) and Vehicle Control Unit (VCU) software may cause the vehicle to enter a safe state protection mode unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Fisker will release an over-the-air (OTA) update to the MCU and VCU software, free of charge. Owner notification letters were mailed June 13, 2024. Owners may contact Fisker customer service at 1-844-347-5371. Fisker's number for this recall is TSB10032403.
Jun 5, 2024
Fisker Group Inc (Fisker) is recalling all 2023 Ocean vehicles. The instrument panel displays the incorrect font size of the Brake, Park, and Antilock Brake System (ABS) warning lights, and displays certain warning lights in amber instead of red. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 135, "Light Vehicle Brake Systems" and 101, "Controls and Displays." Additionally, multiple warning lights fail to illuminate during the ignition cycle bulb check, failing to comply with the requirements of FMVSS 138 and 208.
Consequence & remedy
Consequence: Warning lights that do not display correctly can fail to alert the driver to critical safety information, increasing the risk of a crash or injury.
Remedy: Fisker will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed June 11, 2024. Owners may contact Fisker customer service at 1-844-347-5371. Fisker's number for this recall is TSB70062404.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE24013 · Inadvertent Automatic Emergency Braking
Opened May 8, 2024 · Closed Jan 16, 2025
Status: closed (inferred from source dates) · Forward Collision Avoidance: Automatic Emergency Braking
On May 8, 2024, the Office of Defects Investigation (ODI) opened PE24013 to investigate reports of inadvertent activation of the automatic emergency braking (AEB) system in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. (Fisker). The complaints allege the activation of AEB without an apparent roadway obstruction in the vehicle’s forward path, resulting in sudden vehicle deceleration. This sudden deceleration occurs without adequate warning or input from the driver. The braking applications range from momentary, partial application resulting in rapid loss of speed to full application, which brings the vehicle to a complete stop in the travel lane. ODI sent Fisker an Information Request (IR) letter on May 20, 2024. On June 17 and 19, 2024, Fisker and its affiliates filed a voluntary petition for relief under chapter 11 of the Bankruptcy Code. Fisker provided an incomplete response to the IR on July 1, 2024. Limited information pertaining to system validation and failure data was provided. Fisker subsequently requested more time to provide additional responsive files due to limited available resources. Fisker sent additional responsive files on September 9, 2024, September 17, 2024, and December 16, 2024, but Fisker’s response did not contain sufficient information for ODI to fully evaluate the alleged safety defect. Further, on December 27, 2024, the Fisker employees with whom ODI had been corresponding informed ODI that all Fisker employees were being “dismissed” as of that date. ODI therefore does not anticipate receiving any further responsive submissions such that it can fully evaluate the reports that led to this investigation. ODI performed phone interviews and sent a survey to consumers to obtain more information and validate the allegations. Additionally, ODI reviewed allegations of the alleged safety defect that were submitted to various online forums. Most of these reports were similar in nature to the reports received by ODI. Some of the reports in online forums appear to be duplicative reports that were also submitted to ODI. Based on the responses received and analysis of similar online reporting, there was no clear trend in the following factors pertaining to the allegations: reoccurrence of events (i.e., single or multiple incidents), speed immediately prior to the event, whether the event concluded in a reduction of speed or a full stop, roadway conditions, and warning immediately prior to the event. To date, between the reports provided by Fisker and complaints made directly to the agency, ODI is aware of over 20 reports alleging inadvertent AEB activation. Before the employees were dismissed, Fisker’s testing done in response to the inadvertent AEB allegations reportedly did not result in any inadvertent AEB activations. The “Manufacturer” and “Total” counts in the above table have been left blank because of a pending request for confidential treatment by Fisker that could not be timely addressed given the company’s status. This information factored into ODI’s investigation and analysis. The available information does not warrant further action at this time. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. Additionally, the Agency notes that the Vehicle Safety Act states: “A manufacturer’s filing of a petition in bankruptcy under chapter 7 or chapter 11 of title 11 does not negate the manufacturer’s duty to comply with section 30112 or sections 30115 through 30120 of this title,” which include the recall provisions of the Act. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24010 · Failure To Open Door
Opened Apr 1, 2024 · Closed Aug 26, 2024
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch
On April 1, 2024, the Office of Defects Investigation (ODI) opened PE24010 to investigate instances of failure to open the door in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. Some complaints allege the inability to open the door from either the interior or exterior door handle, resulting in the need to use another door to egress. The investigation revealed that all four exterior door handles are subject to sticking in the extended/unlocked position, which may result in the inability to unlatch the door from either the interior or exterior door handle. The root cause is a dimensional interference between the exterior door handle chassis pocket and door handle, causing friction during handle deployment and retraction. The inability to open and egress from the occupant’s adjacent door presents an unreasonable risk to motor vehicle safety. On June 27, 2024, Fisker filed recall 24V-466 for certain MY 2023 Fisker Ocean vehicles. The recall remedy includes an inspection procedure for all four doors and provides replacement of the outer door handle if a “Not Okay” result is found. In view of the recall action being taken by Fisker, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24005 · Unintended Vehicle Movement
Opened Feb 14, 2024 · Closed Dec 6, 2024
Status: closed (inferred from source dates) · Power Train:automatic Transmission
On February 14, 2024, the Office of Defects Investigation (ODI) opened PE24005 to investigate reports of unintended vehicle movement in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. The complaints allege the inability to shift into the park gear and/or vehicle rollaway. The investigation found that the subject vehicles contain a logic that prevents the engagement of the park gear when the park gear request is made while the vehicle is still moving at low speeds. In the event the driver requests the park gear prior to the vehicle achieving a complete standstill status, the vehicle rejects the park gear request, displays a visual warning, and shifts into the neutral gear. Therefore, if the driver does not properly restrain the vehicle prior to exiting (i.e., allow the vehicle to come to a complete stop, then provide a second park gear request and/or engage the parking brake), the vehicle is at risk of freely rolling away in neutral. ODI found that existing strategies to deter drivers from exiting the vehicle after failing to ensure the transmission successfully engages the park gear have not stopped some from doing so. The absence of additional mechanisms to mitigate the effects of driver behavior in failing to ensure the park gear was engaged prior to exiting the vehicle constitutes a defect presenting a risk to motor vehicle safety. ODI is aware of one reported injury due to this safety defect. On November 15, 2024, Fisker filed recall 24V-865 for all MY 2023-2024 Fisker Ocean vehicles. The recall remedy is the release of software upgrade OS 2.0. This software update provides additional robustness to prevent unintended vehicle movement via two major changes. First, in the event the driver seatbelt is unlatched when the vehicle is traveling at low speeds, logic was added to initiate an automatic, controlled deceleration to bring the vehicle to a standstill. Once standstill status is achieved, the vehicle will automatically engage the park gear and the electronic parking brake. Second, OS 2.0 introduced an “Auto Vehicle Hold” feature, which holds the vehicle in standstill by maintaining friction brake pressure when the driver removes their foot from the brake pedal. This feature prevents the vehicle from rolling under gravity, which therefore helps engage both the park gear and electronic parking brake. In view of the recall action being taken by Fisker, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE24001 · Loss Of Braking Performance
Opened Jan 11, 2024 · Closed Aug 26, 2024
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Electric:software/programming
On January 11, 2024, the Office of Defects Investigation (ODI) opened PE24001 to investigate instances of loss of braking performance in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. The complaints allege an intermittent partial loss of regenerative braking over low traction surfaces, without alerting the driver. ODI is aware of six minor crashes and one injury due to this failure. The subject vehicles utilize a brake blending feature to achieve deceleration. Upon application of the brake pedal, both the service brake system (friction braking) and regenerative braking system (electric motor negative torque) are applied. Regenerative braking on low friction road surfaces may result in wheel slippage due to the high motor negative torque. The vehicle responds by reducing and/or eliminating regenerative braking torque to reduce wheel slip on drive wheels to maintain vehicle stability and steerability. This reduction in regenerative braking may cause a sensation of loss of braking force (or even vehicle accelerating) that was reported by consumers. Additionally, the driver may experience an unusual/altered brake pedal feel during loss of regenerative braking events, requiring them to press the brake pedal harder to maintain the expected braking rate. Upon exiting the low friction road surface, the regenerative braking force is restored. The initial calibration of the regenerative braking system contained aggressive interventions with a slower recovery in the event of loss of regenerative braking. In November 2023, Fisker launched an Over-the-Air update (OS1.10 SW). This update included a recalibration to reduce regenerative braking torque less aggressively and allow torque recovery to occur more quickly. Based on consumer reports and the data that Fisker provided in response to ODI’s inquiry, OS 1.10 SW reduced, but did not eliminate, the sensation of loss of braking force and resulted in stopping distance performance improvements. Friction braking is always available when the driver presses the brake pedal, and its performance is unaffected by regenerative brake loss. Fisker’s braking system is designed to reach full deceleration even with an unavailable regenerative braking system. The partial loss of braking force during moderate braking events can be overcome by applying additional pressure to the brake pedal to slow or stop the vehicle. On August 20, 2024, Fisker filed recall 24V-623 for all 2023 MY Fisker Ocean vehicles produced for the U.S.A. The recall remedy includes OS 2.2 over-the-air update, which is expected to modify the brake module to enhance the vehicle brake system’s ability to adapt to various driving scenarios. With successful implementation of OS 2.2, a road disturbance will not trigger a reduction in regenerative braking torque. In view of the recall action being taken by Fisker, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Service Brakes, Electric:software/programming
On January 11, 2024, the Office of Defects Investigation (ODI) opened PE24001 to investigate instances of loss of braking performance in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. The complaints allege an intermittent partial loss of regenerative braking over low traction surfaces, without alerting the driver. ODI is aware of six minor crashes and one injury due to this failure. The subject vehicles utilize a brake blending feature to achieve deceleration. Upon application of the brake pedal, both the service brake system (friction braking) and regenerative braking system (electric motor negative torque) are applied. Regenerative braking on low friction road surfaces may result in wheel slippage due to the high motor negative torque. The vehicle responds by reducing and/or eliminating regenerative braking torque to reduce wheel slip on drive wheels to maintain vehicle stability and steerability. This reduction in regenerative braking may cause a sensation of loss of braking force (or even vehicle accelerating) that was reported by consumers. Additionally, the driver may experience an unusual/altered brake pedal feel during loss of regenerative braking events, requiring them to press the brake pedal harder to maintain the expected braking rate. Upon exiting the low friction road surface, the regenerative braking force is restored. The initial calibration of the regenerative braking system contained aggressive interventions with a slower recovery in the event of loss of regenerative braking. In November 2023, Fisker launched an Over-the-Air update (OS1.10 SW). This update included a recalibration to reduce regenerative braking torque less aggressively and allow torque recovery to occur more quickly. Based on consumer reports and the data that Fisker provided in response to ODI’s inquiry, OS 1.10 SW reduced, but did not eliminate, the sensation of loss of braking force and resulted in stopping distance performance improvements. Friction braking is always available when the driver presses the brake pedal, and its performance is unaffected by regenerative brake loss. Fisker’s braking system is designed to reach full deceleration even with an unavailable regenerative braking system. The partial loss of braking force during moderate braking events can be overcome by applying additional pressure to the brake pedal to slow or stop the vehicle. On August 20, 2024, Fisker filed recall 24V-623 for all 2023 MY Fisker Ocean vehicles produced for the U.S.A. The recall remedy includes OS 2.2 over-the-air update, which is expected to modify the brake module to enhance the vehicle brake system’s ability to adapt to various driving scenarios. With successful implementation of OS 2.2, a road disturbance will not trigger a reduction in regenerative braking torque. In view of the recall action being taken by Fisker, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service Brakes
On January 11, 2024, the Office of Defects Investigation (ODI) opened PE24001 to investigate instances of loss of braking performance in model year (MY) 2023 Fisker Ocean vehicles manufactured by Fisker Group Inc. The complaints allege an intermittent partial loss of regenerative braking over low traction surfaces, without alerting the driver. ODI is aware of six minor crashes and one injury due to this failure. The subject vehicles utilize a brake blending feature to achieve deceleration. Upon application of the brake pedal, both the service brake system (friction braking) and regenerative braking system (electric motor negative torque) are applied. Regenerative braking on low friction road surfaces may result in wheel slippage due to the high motor negative torque. The vehicle responds by reducing and/or eliminating regenerative braking torque to reduce wheel slip on drive wheels to maintain vehicle stability and steerability. This reduction in regenerative braking may cause a sensation of loss of braking force (or even vehicle accelerating) that was reported by consumers. Additionally, the driver may experience an unusual/altered brake pedal feel during loss of regenerative braking events, requiring them to press the brake pedal harder to maintain the expected braking rate. Upon exiting the low friction road surface, the regenerative braking force is restored. The initial calibration of the regenerative braking system contained aggressive interventions with a slower recovery in the event of loss of regenerative braking. In November 2023, Fisker launched an Over-the-Air update (OS1.10 SW). This update included a recalibration to reduce regenerative braking torque less aggressively and allow torque recovery to occur more quickly. Based on consumer reports and the data that Fisker provided in response to ODI’s inquiry, OS 1.10 SW reduced, but did not eliminate, the sensation of loss of braking force and resulted in stopping distance performance improvements. Friction braking is always available when the driver presses the brake pedal, and its performance is unaffected by regenerative brake loss. Fisker’s braking system is designed to reach full deceleration even with an unavailable regenerative braking system. The partial loss of braking force during moderate braking events can be overcome by applying additional pressure to the brake pedal to slow or stop the vehicle. On August 20, 2024, Fisker filed recall 24V-623 for all 2023 MY Fisker Ocean vehicles produced for the U.S.A. The recall remedy includes OS 2.2 over-the-air update, which is expected to modify the brake module to enhance the vehicle brake system’s ability to adapt to various driving scenarios. With successful implementation of OS 2.2, a road disturbance will not trigger a reduction in regenerative braking torque. In view of the recall action being taken by Fisker, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration