I WENT THROUGH EMISSIONS AND FAILED BECAUSE THERE WAS AN OBD ERROR SAYING THAT MY CHECK ENGINE LIGHT IS ON, HOWEVER IT WAS NOT. I CALLED TO THE STATE EMISSIONS BOARD AND THEY SAID IT WAS A RECALL. I TOOK IT TO THE DEALERSHIP, AT THE END OF MAY AND IT HAS BEEN IN AND OUT EVER SINCE TRYING TO FIX THIS RECALL. IT HAS NOW BEEN IN T…
Read full complaint
I WENT THROUGH EMISSIONS AND FAILED BECAUSE THERE WAS AN OBD ERROR SAYING THAT MY CHECK ENGINE LIGHT IS ON, HOWEVER IT WAS NOT. I CALLED TO THE STATE EMISSIONS BOARD AND THEY SAID IT WAS A RECALL. I TOOK IT TO THE DEALERSHIP, AT THE END OF MAY AND IT HAS BEEN IN AND OUT EVER SINCE TRYING TO FIX THIS RECALL. IT HAS NOW BEEN IN THE DEALERSHIP CONSEQUENTLY FOR TWO MONTHS. THE DEALERSHIP HAS TOLD ME MORE THAN ONCE THAT THEY ARE GOING TO DO ONE MORE TEST AND THEN IF IT FAILS THEY WILL CALL CHRYSLER AND TELL THEM IT CAN NOT BE FIXED. BUT EVERY TIME THEY DO THE TEST AND IT FAILS THEY END UP DOING THE TESTS OVER AND OVER AGAIN. I ACTUALLY HAD TO PURCHASE A VEHICLE SO I WOULD HAVE A CAR TO DRIVE TO AND FROM HOME WORK SCHOOL AND DR'S APPOINTMENTS. I AM 8 MOTHS PREGNANT RIGHT NOW AND ON BED REST AND MY DOCTOR IS SAYING I DO NOT NEED ALL THIS EXTRA STRESS. I CALLED THE MANUFACTURER THREE TIMES WHOM TELLS ME ALL I CAN DO IS CONTINUE TO WORK WITH THE DEALERSHIP. I HAVE SPOKEN WITH THE GENERAL MANAGER OF THE DEALERSHIP AND SAME THING, NO ANSWERS. THE GENERAL MANAGER ACTUALLY TOLD ME TO GET A LAWYER. I HAVE WROTE THE BETTER BUSINESS BUREAU AND NOW I AM WRITING YOU. I DO NOT KNOW WHAT ELSE I CAN POSSIBLY DO. PLEASE HELP ME!! *JB
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
Illustration