TL*THE CONTACT OWNS A 1996 EAGLE TALON. WHILE DRIVING 60 MPH THE CONTACT HEARD A NOISE AND THE TIRES LOCKED U WITHOUT WARNING. THE VEHICLE WAS TOWED ,AND A LOCAL MECHANIC DIAGNOSED THE FAILURE AS A LEAK IN THE TRANSFER CASE. THE DEALER/MANUFACTURER DIAGNOSED THE VEHICLE AS NEEDING A NEW TRANSFER CASE. THE DEALER STATED THAT T…
Read full complaint
TL*THE CONTACT OWNS A 1996 EAGLE TALON. WHILE DRIVING 60 MPH THE CONTACT HEARD A NOISE AND THE TIRES LOCKED U WITHOUT WARNING. THE VEHICLE WAS TOWED ,AND A LOCAL MECHANIC DIAGNOSED THE FAILURE AS A LEAK IN THE TRANSFER CASE. THE DEALER/MANUFACTURER DIAGNOSED THE VEHICLE AS NEEDING A NEW TRANSFER CASE. THE DEALER STATED THAT THE VEHICLE WAS PART OF RECALL # 098V069002. RECORDS INDICATED THAT NO REPAIRS HAVE BEEN PERFORMED. THE CURRENT AND FAILURE MILEAGE WERE 112,000.*AK
NHTSA ODI #10187002
90,000 miles · Mar 8, 2006
Power Train
THE TRANSFER CASE WENT OUT OF MY TALON TSI AWD TURBO IN 06/05. I WAS DRIVING DOWN THE ROAD 75 MPH & BANG!-JERK!BANG!JERK!BANG!JERK! THE STEERING WHEEL ALSO FELT FUNNY, LIKE IT GOT LOOSE AND WASN'T HOOKED TO THE TIRES ANYMORE. I PULLED OVER THE AND HEARD A LOUD CLUNK (METAL ON METAL SORT OF SOUND) AND PUT IT INTO GEAR TO BAB…
Read full complaint
THE TRANSFER CASE WENT OUT OF MY TALON TSI AWD TURBO IN 06/05. I WAS DRIVING DOWN THE ROAD 75 MPH & BANG!-JERK!BANG!JERK!BANG!JERK! THE STEERING WHEEL ALSO FELT FUNNY, LIKE IT GOT LOOSE AND WASN'T HOOKED TO THE TIRES ANYMORE. I PULLED OVER THE AND HEARD A LOUD CLUNK (METAL ON METAL SORT OF SOUND) AND PUT IT INTO GEAR TO BABY IT INTO WORK, IT MADE MORE NOISES AND JERKS BUT SEEMED TO RUN. I COULD SMELL A BURNING SMELL SO I PARKED. THE SHOP PICKED IT UP AND COULD NOT FIND ANYTHING WRONG WITH IT. THEY ASKED IF I WAS SURE I KNEW WHAT I WAS TALKING ABOUT! I HAD DRIVEN THE CAR FOR 90000 MILES! I KNEW WHAT WASN'T NORMAL! I PICKED IT UP AND GUESS WHAT, IT RAN GREAT! I SPEEDED UP AND SLOWED DOWN AGAIN AND AGAIN AND IT JUST WOULDN'T ACT UP! I COULD FAINTLY SMELL THE BURNING SMELL BUT FIGURED I PICKED UP SOME PIECE OF SOMETHING OFF OF THE ROAD AND IT HAD BEEN STUCK BUT FELL OUT WHEN I STOPPED. I WENT FOR 50 MILES, NO PROBLEMS, THEN THE BANGING AND JERKING STARTED AGAIN MUCH WORSE THIS TIME. I KEPT GOING TO SEE IF IT WOULD STOP AND IT GOT SO LOUD THAT IT SOUNDED LIKE A SLEDGEHAMMER WAS HITTING SOME PART OF THE ENGINE OVER AND OVER. IT WOULD BANG-JERK- BANG -JERK ETC.. AND KEPT GETTING WORSE. THEN IT JUST DIED. THE SHIFTER WENT SLACK. THERE WAS A PUDDLE OF OIL UNDER THE CAR AND THE SMELL OF BURNING FLUID. THE MECHANIC PICKED IT UP AND REPLACED THE TRANSMISSION/TRANSFER WITH A USED ONE. I'M WONDERING IF THIS WAS THE TRANSFER CASE AND NOT THE TRANSMISSION AT ALL! THE MECHANIC SAID THERE WASN'T ENOUGH OIL IN THE TRANSMISSION. I DIDN'T KNOW IF THE TRANSFER CASE AND TRANSMISSION SHARE THE SAME OIL SUPPLY OR NOT. AFTER READING THIS ARTICLE ABOUT THE LOCKING UP THING IT MAKES PERFECT SENSE. ITS FELT JUST LIKE IT WANTED TO LOCK UP BUT FOR SOME REASON DIDN'T THAT FIRST TIME IT ACTED UP. THE TRANSMISSION PLACE SAID THEY HADN'T HEARD OF A TRANSMISSION BANGING AND CLANGING LIKE THAT. *JB
NHTSA ODI #10152168
Mileage unknown · May 8, 2001
Power Train
GEARS WERE HARD TO SHIFT, AND THERE WAS TRANSMISSION OIL LEAKING FROM UNDERNEATH, ALSO, TRANSFER CASE FAILED. RECEIVED MANUFACTURER'S RECALL 780. *AK
NHTSA ODI #887745
Mileage unknown · May 7, 2001
Power Train
RECALL 98V069002; INFORMED OF RECALL BY FRIEND. TOOK VEHICLE TO DEALER AND VIN WAS CHECKED, AND RECALLED. MECHANIC INSPECTED 1ST TIME AND REPAIRED PROBLEM. WAS DRIVING AND FOUND SHIFTING HARD. SLEEVE HAD CAME OFF. TOOK BACK. MECHANIC INSPECTED TRANSFER CASE AND DRIVESHAFT 2ND TIME, AND FOUND NOTHING. TAKEN VEHICLE TO TRAN…
Read full complaint
RECALL 98V069002; INFORMED OF RECALL BY FRIEND. TOOK VEHICLE TO DEALER AND VIN WAS CHECKED, AND RECALLED. MECHANIC INSPECTED 1ST TIME AND REPAIRED PROBLEM. WAS DRIVING AND FOUND SHIFTING HARD. SLEEVE HAD CAME OFF. TOOK BACK. MECHANIC INSPECTED TRANSFER CASE AND DRIVESHAFT 2ND TIME, AND FOUND NOTHING. TAKEN VEHICLE TO TRANSMISSION SHOP. INFORMED TRANSMISSION WAS SHOT AND BEARINGS GONE DUE TO A LACK OF FLUID IN TRANSFER CASE. *AK THE DEALER INDICATED THAT ALL RECALL PROBLEMS WERE FIXED. WHEN THE CONSUMER TOOK VEHICLE AGAIN, THE DEALER POINTED OUT THAT THE VEHICLE NEEDED NEW TRANSMISSION. THE CONSUMER TOOK VEHICLE TO ANOTHER DEALER WHEN IT WAS DETERMINED THAT TRANSFER CASE WAS LOW IN FLUID AND THE BEARINGS HAD FAILED. THESE WERE RECALL ITEMS (#780). THE CONSUMER WANTS THE MANUFACTURER TO REIMBURSE HIM THE COST OF REPAIR. *YH
NHTSA ODI #887629
Mileage unknown · Apr 11, 2001
Power Train
TRANSMISSION WENT OUT AT 42000 MILES. *AK
NHTSA ODI #885715
Mileage unknown · Nov 6, 1998
Power Train
WHILE DRIVING APPROXIMATELY 50 MPH,THE VEHICLE DROPPED DOWN ON THE FRAME DUE TO AXLE SHAFT FAILURE, THEN SLOWED DOWN WITHOUT ANY WARNING. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED.*AK
NHTSA ODI #830302
Mileage unknown · Mar 19, 1998
Power Train
TRANSFER CASE FLUID LEAK. *AK
NHTSA ODI #533120
Mileage unknown · Mar 17, 1998
Power Train
TRANSFER CASE FLUID LEAK.
NHTSA ODI #532943
Mileage unknown · Feb 3, 1997
Power Train
MANUAL TRANSMISSION, 5 SPEED, TRANS AXLE LOCKS UP WHILE DRIVING AT A SPEED OF 35MPH, CAUSING VEHICLE TO BECOMIE INOPERTIVE. *AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE. ALSO, MMC HAS ADDED THE POTENTIAL OF LEAKING MOISTURE, WHICH CAN CAUSE THE BALL STUD TO CORRODE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH. THIS CAMPAIGN SUPERCEDES MMC'S PREVIOUS SAFETY RECALL CAMPAIGN, SEE 99V-066.
Remedy: DEALERS WILL INSPECT THE LOWER LATERAL ARM BALL JOINT FOR WEAR. BALL JOINTS THAT EXHIBIT WEAR BEYOND THE ESTABLISHED TOLERANCE WILL BE REPLACED WITH NEWLY DESIGNED LATERAL ARM BALL JOINTS. BALL JOINTS THAT ARE WITHIN THE ESTABLISHED TOLERANCE WILL BE CLEANED AND A SPECIAL SEALANT WILL BE APPLIED TO PREVENT INTRUSION OF MOISTURE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. IF THE RUBBER BOOTS ON THE LOWER LATERAL ARM BALL JOINTS OF THE FRONT SUSPENSION WERE DAMAGED DURING ASSEMBLY, DIRT AND WATER CAN INTRUDE.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE LOWER LATERAL ARM BALL JOINT TO SEPARATE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE RUBBER BOOTS, AND IF THE BOOT IS DAMAGED, THEY WILL REPLACE THE LOWER LATERAL ARM AND BALL JOINT ON THE AFFECTED VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
Illustration