NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
42 reportsClear category filter60,000 miles · Jul 21, 2011
Electrical SystemSteering
TL* THE CONTACT OWNS A 1996 DODGE STRATUS. THE CONTACT STATED THAT THE HORN WOULD ACTIVATE WITHOUT COMMAND AT ANYTIME AND THE AIRBAG LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER REPAIRED THE FAILURE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. …
Read full complaint
TL* THE CONTACT OWNS A 1996 DODGE STRATUS. THE CONTACT STATED THAT THE HORN WOULD ACTIVATE WITHOUT COMMAND AT ANYTIME AND THE AIRBAG LIGHT WOULD ILLUMINATE ON THE INSTRUMENT PANEL. THE DEALER REPAIRED THE FAILURE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 80,000. UPDATED 08/31/11 *BF THE STEERING COLUMN WAS REPLACED TWICE. THE LAST TIME, THE DEALER PLACED A HORN BUTTON ON THE DASHBOARD. UPDATED 12/05/11
NHTSA ODI #10414004
Mileage unknown · Dec 29, 2003
Electrical SystemEngine And Engine CoolingEquipment
2ND REQUEST FAX FWD EMAIL FM BEHALF OF [XXX] (TX) RE NUMEROUS DEFECTS ON A 1996 DODGE STRATUS (VIN#[XXX]). *MR THE A/C LEAKED, ELECTRICAL CIRCUITS MALFUNCTIONED, TRANSMISSION PROBLEMS, PREMATURE BRAKE WEAR, HEAD GASKET PROBLEMS, AND POOR DRIVEABILITY. THERE WAS STEERING OSCILLATION WHEN DRIVEN ABOVE 50 MPH, ROUGH RIDE WHEN…
Read full complaint
2ND REQUEST FAX FWD EMAIL FM BEHALF OF [XXX] (TX) RE NUMEROUS DEFECTS ON A 1996 DODGE STRATUS (VIN#[XXX]). *MR THE A/C LEAKED, ELECTRICAL CIRCUITS MALFUNCTIONED, TRANSMISSION PROBLEMS, PREMATURE BRAKE WEAR, HEAD GASKET PROBLEMS, AND POOR DRIVEABILITY. THERE WAS STEERING OSCILLATION WHEN DRIVEN ABOVE 50 MPH, ROUGH RIDE WHEN THERE WAS AN IRREGULAR SURFACE, ERRATIC IDLE, PERFORMANCE LOSS, OVERHEATING IN TRAFFIC AND OR THE A/C WOULD BECOME INOPERATIVE, WARM-UP SAG, HESITATION/DIE OUT, REAR GRID DEFOGGER INDICATOR LIGHT MALFUNCTIONED, INSIDE LIGHTS WORKED IMPROPERLY, ERRATIC LATE HARSH TRANSMISSION SHIFTS, FREQUENT RUMBLE OR GEAR NOISE FROM THE FRONT BETWEEN 50 AND 70 MPH, MUSTY ODOR AND DEFOGGER FAILED TO CLEAR THE GLASS. *SCC THE VEHICLE WAS ALSO IN NEED OF AN EXHAUST MANIFOLD AND STRUTS. *JB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10052043
80,000 miles · Nov 3, 2003
Engine And Engine CoolingService Brakes, HydraulicSteering
HEAD GASKET OIL LEAK, TIE RODS BAD, TIRES REPLACED, BRAKES GOING BAD, ENGINE LIGHT ON. *LA
NHTSA ODI #10045334
Mileage unknown · Sep 16, 2003
Electrical SystemEngine And Engine CoolingPower Train
LTR FM JOVAN MATHEWS (TX) RE PROBLEMS WITH HIS 1996 DODGE STRATUS AND ASKING DAIMLER CHRYSLER TO INITIATE A RECALL. *MR THE A/C LEAKED, ELECTRIC CIRCUITS MALFUNCTIONED, TRANSMISSION PROBLEMS, PREMATURE BRAKE WEAR, HEAD GASKET, AND POOR DRIVE ABILITY. THE CONSUMER HAD REPLACED THE TIMING BELT, HYDRAULIC TENSIONER, WATER PUMP…
Read full complaint
LTR FM JOVAN MATHEWS (TX) RE PROBLEMS WITH HIS 1996 DODGE STRATUS AND ASKING DAIMLER CHRYSLER TO INITIATE A RECALL. *MR THE A/C LEAKED, ELECTRIC CIRCUITS MALFUNCTIONED, TRANSMISSION PROBLEMS, PREMATURE BRAKE WEAR, HEAD GASKET, AND POOR DRIVE ABILITY. THE CONSUMER HAD REPLACED THE TIMING BELT, HYDRAULIC TENSIONER, WATER PUMP, ALTERNATOR, ALTERNATOR BELT, ROTORS, BRAKE SHOES, REAR WHEEL CYLINDERS, PCV VALVE, DRYER, A/C COMPRESSOR, TIRES, ALL FILTERS, AND FLUIDS. THE VEHICLE WAS IN NEED OF AN EXHAUST MANIFOLD, WINDSHIELD, STRUTS, SHOCKS, STEERING WHEEL, AND A HEAD GASKET. THE VEHICLE EXPERIENCED STEERING WHEEL OSCILLATION/VIBRATION ABOVE 50 MPH, ROUGH RIDE ON ROAD WITH IRREGULAR SURFACE, ERRATIC IDLE, PERFORMANCE LOSS, OVERHEATED,WARM UP SAG, HESITATION, REAR GRID DEFOGGER INDICATOR MALFUNCTION, INSIDE LIGHTS HAD BECOME INOPERATIVE, LATE/HARSH AUTOMATIC TRANSMISSION SHIFTS, FREQUENCY RUMBLE OR GEAR NOISE FROM THE FRONT BETWEEN 50 AND 70 MPH, MUSTY ODOR, AND THE DEFROSTER FAILED TO CLEAR THE GLASS. *SCC *JB
NHTSA ODI #10040045
Mileage unknown · Mar 1, 2003
Engine And Engine CoolingService Brakes, HydraulicSteering
MY 1996 DODGE STRATUS HAS 37,000 MILES. IN FEBRUARY 2002 I TOOK IT TO SEARS FOR AN OIL CHANGE. ALSO ASKING THEM TO SEE WHERE OIL WAS LEAKING (NOTICED OIL ON CONCRETE IN GARAGE). THEY SAID VALVE COVER GASKET SO I GOT THAT FIXED FOR ABOUT $72.00 ALL ALONG THINKING THAT THERE WERE NOT THAT MANY MILES DRIVEN. AND TO BAD THE WA…
Read full complaint
MY 1996 DODGE STRATUS HAS 37,000 MILES. IN FEBRUARY 2002 I TOOK IT TO SEARS FOR AN OIL CHANGE. ALSO ASKING THEM TO SEE WHERE OIL WAS LEAKING (NOTICED OIL ON CONCRETE IN GARAGE). THEY SAID VALVE COVER GASKET SO I GOT THAT FIXED FOR ABOUT $72.00 ALL ALONG THINKING THAT THERE WERE NOT THAT MANY MILES DRIVEN. AND TO BAD THE WARRANTY HAD JUST EXPIRED. I THINK IT WAS 5 YEARS OR 25,000 MILES. WITHIN THE NEXT 2 MONTHS OIL WAS LEAKING AGAIN. TOOK IT IN AND END UP PAYING $702.00 BECAUSE THE HEAD GASKET WAS BAD. THE MECHANIC SHOWED IT TO ME AND JOKINGLY SAID ISN'T IT FUNNY HOW THIS CAN BE SO CHEAP THAT IT ALMOST WAS DETERIORATED AND THE WARRANTY 5YRS IS UP. EVEN THOUGH I HAD NOT DROVE 25,000 MILES YET. WELL THE FINAL BLOW , ON OCT 10,2002 I KEPT HEARING A CLUNK WHEN I MADE LEFT OR RIGHT TURN. TOOK IT TO THE RHODEN DODGE. WE WERE TOLD THAT RIGHT & LEFT TIE ROD ENDS WERE LOOSE & SWAY BAR LINKS WORN & LOOSE(2 TIE RODS,& 2 BALL JOINTS) I ASKED THEM TO PERFORM AN ALIGNMENT AND TRANSMISSION FLUSH ,TOTALING $779.00 BECAUSE WHAT ELSE WILL BREAK. WELL IN JAN. 2003 THE BRAKES WERE ON MEDAL ANOTHER $190.00. I'M AFRAID TO TAKE IT IN TO THE GARAGE. THERE IS ONLY 37,000 MILES DRIVEN AND I AM HEARING ANOTHER NOISE WHEN I TURN LEFT AND RIGHT. WHEN THE BRAKES WERE FIXED THEY TOLD ME THEY TEST DROVE IT AND HEARD NOTHING . SOME HOW IT SEEMS THAT 5 YRS OR 25,000 MILES IS TELLING ME THAT I SHOULD HAVE SOLD IT BEFORE THAT BECAUSE I THINK THE COMPANY KNEW THINGS WOULD START HAPPENING. IS THERE ANYTHING YOU CAN DO TO HELP ME. PLEASE, THIS CAR IS A LEMON WITH ONLY 37,000 MILES.*JB
NHTSA ODI #10008284
123,521 miles · Jan 3, 2003
SteeringFire
RUPTURE IN POWER STEERING HOSE CAUSED POWER STEERING FLUID TO TO CONTACT HOT EXHAUST MANIFOLD, RESULTING IN A FIRE THAT MELTED IGNITION WIRES, DISTRIBUTOR, AND POWER STEERING RETURN FLUID LINE. TS
NHTSA ODI #10000493
Mileage unknown · Sep 9, 2002
Steering
WHILE DRIVING FRONT TIRES LOCKED UP. CONTACTED DEALER. TIE ROD CAME UNDONE. THIS WAS COMMON PROBLEM. *AK
NHTSA ODI #8018176
Mileage unknown · Jul 21, 2002
Steering
MY WIFE CALLED ME TO REPORT THAT SHE WAS EXPERIENCING SOME BINDING IN THE STEERING AS SHE WAS LEAVING THE PARKING LOT OF A SHOPPING MALL, AND HAD DECIDED TO RETURN TO THE PARKING LOT. I WENT TO THE LOT TO INVESTIGATE THE MATTER AND DROVE THE CAR IN THE LOT, TURNING BOTH LEFT AND RIGHT FREQUENTLY, AND THE STEERING SEEMED TO BE A…
Read full complaint
MY WIFE CALLED ME TO REPORT THAT SHE WAS EXPERIENCING SOME BINDING IN THE STEERING AS SHE WAS LEAVING THE PARKING LOT OF A SHOPPING MALL, AND HAD DECIDED TO RETURN TO THE PARKING LOT. I WENT TO THE LOT TO INVESTIGATE THE MATTER AND DROVE THE CAR IN THE LOT, TURNING BOTH LEFT AND RIGHT FREQUENTLY, AND THE STEERING SEEMED TO BE ALRIGHT. I DECIDED TO DRIVE THE CAR HOME, AND THEN NOTICED THAT A SLIGHT CLUNKING NOISE COULD BE HEARD WHEN DRIVING OVER ROUGH SPOTS IN THE PAVEMENT. I DECIDED TO JACK UP THE RIGHT FRONT WHEEL TO TRY AND DETERMINE WHAT MIGHT BE LOOSE. WHILE MANUVERING THE CAR INTO POSITION IN MY GARAGE, THE RIGHT TIE ROD END BALL STUD SEPARATED FROM ITS SOCKET, WHICH OF COURSE IS THE CONNECTION TO THE RIGHT SIDE STEERING KNUCKLE. THE SOCKET AND BALL WERE VERY RUSTY AND THERE WAS NO LUBRICATION PRESENT, ALTHOUGH IT IS SUPPOSED TO BE A SEALED, LUBRICATED FOR LIFE JOINT WHICH DOES NOT HAVE A GREASE FITTING.*AK
NHTSA ODI #764514
Mileage unknown · Jul 11, 2002
Steering
WHILE PULLING INTO A PARKING LOT OUTER TIE ROD BROKE AND FELL OFF CAUSING THE CONSUMER TO LOOSE CONTROL OF THE VEHICLE, THE MANUFACTURER WAS CONTACTED BUT REFUSED TO DO ANTHING ABOUT THE PROBLEM.*AK *NLM
NHTSA ODI #8013765
Mileage unknown · Jul 9, 2002
Steering
WHILE DRIVING THE 2 OUTER TIE ROD PINS FELL OUT, ALMOST LOST CONTROL OF STEERING.*AK
NHTSA ODI #8013554
Official recalls
7Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
Jun 6, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECONDARY HOOD LATCH SPRING CAN DISENGAGE FROM ITS RETENTION HOLE IF THE HOOD IS SLAMMED SHUT.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS SIMULTANEOUSLY WITHOUT ENGAGING THE PRIMARY LATCH, THE HOOD WOULD NOT BE RESTRAINED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH SPRING WITH A LONGER END HOOK SPRING.
May 3, 1996
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
May 2, 1996
CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Consequence & remedy
Consequence: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Remedy: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
EA97016 · Lower Control Arm Ball Joint Failure
Opened Sep 29, 1997 · Closed Nov 20, 1997
Status: closed (inferred from source dates) · Suspension
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.
Illustration