NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
335 reportsClear category filter37,840 miles · Jan 26, 2005
Engine And Engine Cooling
WHILE THE VEHICLE WAS PARKED CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. IT WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE HEAD GASKET NEEDED TO BE REPLACED. *AK RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 96V006000. THE CONSUMER TOOK THE VEHICLE TO HAVE THE RECALL SERVICE DONE A…
Read full complaint
WHILE THE VEHICLE WAS PARKED CONSUMER NOTICED FLUID LEAKING FROM UNDERNEATH THE VEHICLE. IT WAS TAKEN TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE HEAD GASKET NEEDED TO BE REPLACED. *AK RECALL CAMPAIGN; NHTSA CAMPAIGN ID NUMBER : 96V006000. THE CONSUMER TOOK THE VEHICLE TO HAVE THE RECALL SERVICE DONE AND THE PROBLEM BECAME WORSE. *TC
NHTSA ODI #10103659
Mileage unknown · Dec 30, 2004
Engine And Engine Cooling
VEHICLE TENDED TO SHUTDOWN UNEXPECTEDLY AT VARIOUS SPEEDS, CAUSING CONSUMER TO LOSE CONTROL OF BRAKES AND STEERING. TOOK VEHICLE TO DEALER SEVERAL TIMES, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #10105594
75,000 miles · Jul 9, 2004
Engine And Engine Cooling
HEAD GASKET LEAKED OIL. AS A RESULT, VEHICLE CONTINUED TO OVERHEAT. *AK
NHTSA ODI #10081627
Mileage unknown · Jun 7, 2004
Engine And Engine Cooling
DRIVING THE CAR AND HEARING KNOCKING COMING FROM THE ENGINE AND VIBRATION COMING FROM THE RIGHT FRONT TIRE. *AK
NHTSA ODI #10074948
92,880 miles · May 3, 2004
Electrical SystemEngine And Engine Cooling
MY MECHANIC STATED THAT MY ENGINE IS LEAKING OIL FROM PRETTY MUCH EVERYWERE, I HAVE TO ADD A QUART OF OIL EVERY 4 - 5 DAYS. I HAVE NO INTERIOR LIGHTS, MY ODOMETER AND TACHOMETER DO NOT FUNCTION AND DISPLAY. MY RADIO DOES NOT WORK, AND NOW MY BRAKE LIGHTS AREN'T FUNCTIONING. I CHECKED AND ALL OF MY FUSES ARE FINE. I CAN'T AFFO…
Read full complaint
MY MECHANIC STATED THAT MY ENGINE IS LEAKING OIL FROM PRETTY MUCH EVERYWERE, I HAVE TO ADD A QUART OF OIL EVERY 4 - 5 DAYS. I HAVE NO INTERIOR LIGHTS, MY ODOMETER AND TACHOMETER DO NOT FUNCTION AND DISPLAY. MY RADIO DOES NOT WORK, AND NOW MY BRAKE LIGHTS AREN'T FUNCTIONING. I CHECKED AND ALL OF MY FUSES ARE FINE. I CAN'T AFFORD THE ENGINE REPAIRS FOR THE OIL. I HAVE TO GET THE ELECTRICAL PROBLEM FIXED. CHRYSLER SHOULD TAKE CARE OF THESE PROBLEMS.*AK
NHTSA ODI #10068189
Mileage unknown · Apr 27, 2004
Engine And Engine CoolingFire
VEHICLE CAUGHT FIRE WHILE PARKED WITH THE ENGINE OFF WHICH BELONGED TO THE CONSUMER'S SON. *PH (MARY FRANCIS ON BEHALF OF ALEX FRANCIS) THE FIRE MAY HAVE BEEN CAUSED BY A FAULTY ENGINE PLUG. RECALL#96V006000. OTHER CONSUMER CONTACT INFO: ALEX FRANCIS 754-235-8335 *SC *JB
NHTSA ODI #10071865
100,000 miles · Apr 5, 2004
Engine And Engine Cooling
WHILE BACKING OUT OF THE DRIVEWAY, THE DRIVER NOTICED OIL ON THE GROUND. TOOK TO A MECHANIC AND HE SAID THE GASKETS, SEALS, ETC., NEED REPLACING. PLEASE PROVIDE ANY FURTHER INFORMATION. *NM
NHTSA ODI #10065555
78,000 miles · Apr 1, 2004
Engine And Engine Cooling
CURRENTLY OWN A 1996 DODGE STRATUS 4 CYLINDER, AND IT IS SITTING IN MY DRIVEWAY AND I AM UNABLE TO USE IT, AS THE HEAD GASKET BLEW OUT OF IT, AND WILL COST OVER $1500 DO REPLACE(AND SO I HEAR EVEN IF YOU DO REPLACE IT, THE HEAD GASKET WILL BLOW AGAIN SHORTLY AFTER DUE TO THE IMPROPER DESIGN OF THE ENGINE)..THIS IS SO WELL KNOWN …
Read full complaint
CURRENTLY OWN A 1996 DODGE STRATUS 4 CYLINDER, AND IT IS SITTING IN MY DRIVEWAY AND I AM UNABLE TO USE IT, AS THE HEAD GASKET BLEW OUT OF IT, AND WILL COST OVER $1500 DO REPLACE(AND SO I HEAR EVEN IF YOU DO REPLACE IT, THE HEAD GASKET WILL BLOW AGAIN SHORTLY AFTER DUE TO THE IMPROPER DESIGN OF THE ENGINE)..THIS IS SO WELL KNOWN A PROBLEM, AND I AM DISGUSTED TO THINK THAT WITH OUR FAMILY BEING LIFETIME DODGE/CHRYSLER PEOPLE, THE COMPANY WOULD IGNORE SAFETY AND ALLOW THIS PROBLEM TO CONTINUE IN LATER MODELS. WHAT IS IT GOING TO TAKE TO GET SOME HELP HERE!!!! I AM A POOR MOM OF TWO CHILDREN, ONE DISABLED, AND THOUGHT THAT I WAS MAKNG A GOOD PURCHASE WITH THE STRATUS. I CURRENTLY CANNOT AFFORD TO HAVE THE VEHICLE FIXED, AND HAVE BEEN UNABLE TO GET MY DISABLED CHILD TO THE DOCTOR AS I DO NOT HAVE RELIABLE TRANSPORTATION......THIS IS PATHETIC! PLEASE SOMEONE HELP!*AK
NHTSA ODI #10064317
50,000 miles · Mar 30, 2004
Engine And Engine Cooling
MY DODGE STRATUS 1996 LEAKS OIL LIKE A SIVA. I BELIEVE THIS TO BE A GLOBAL ISSUE WITH THIS VEHICLE AND THE V6 ENGINE USED IN IT. I HAVE CARED FOR THIS CARE VERY WELL AND IT HAS BEEN MAINTAINED BETTER THAN RECOMMENDED BY DODGE. *AK
NHTSA ODI #10064221
58,000 miles · Jan 15, 2004
Engine And Engine CoolingPower TrainVisibility
I PURCHASED MY 1996 DODGE STRATUS IN THE SUMMER OF 1996 AND SO FAR I HAVE HAD NOTHING BUT TROUBLE WITH THIS VEHICLE, ONE HEAD GASKET REPAIR THROUGH THE DEALERSHIP AT A COST OF $1600, ONE TIMING CHAIN REPLACEMENT AT A COST OF $600 AND NOW AGAIN ANOTHER HEAD GASKET LEAK. IN THE YEAR 2000 THIS CAR SAT IN THE GARAGE FOR A TOTAL OF 1…
Read full complaint
I PURCHASED MY 1996 DODGE STRATUS IN THE SUMMER OF 1996 AND SO FAR I HAVE HAD NOTHING BUT TROUBLE WITH THIS VEHICLE, ONE HEAD GASKET REPAIR THROUGH THE DEALERSHIP AT A COST OF $1600, ONE TIMING CHAIN REPLACEMENT AT A COST OF $600 AND NOW AGAIN ANOTHER HEAD GASKET LEAK. IN THE YEAR 2000 THIS CAR SAT IN THE GARAGE FOR A TOTAL OF 11 MONTHS DUE TO NOT HAVING THE MONEY TO FIX THE HEAD GASKET PROBLEM WHICH CAUSED A SEVERE FINANCIAL AND A MENTALLY FRUSTRATING TIME DURING THOSE MONTHS WITHOUT A CAR. I WOULD LIKE TO BE INCLUDED IN THE CLASS ACTION LAWSUIT AGAINST CHRYSLER SO PLEASE FORWARD ME ANY INFORMATION NEEDED IN GOING FORWARD WITH THIS LAWSUIT.
NHTSA ODI #10070551
Official recalls
7Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH THE KEY IN THE LOCKED POSITION, CAN BREAK THE CONNECTING PIN IN THE SHIFTER.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
Nov 13, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence & remedy
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER CONTROL ARM WILL BE REPLACED.
Jun 6, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECONDARY HOOD LATCH SPRING CAN DISENGAGE FROM ITS RETENTION HOLE IF THE HOOD IS SLAMMED SHUT.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS SIMULTANEOUSLY WITHOUT ENGAGING THE PRIMARY LATCH, THE HOOD WOULD NOT BE RESTRAINED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH SPRING WITH A LONGER END HOOK SPRING.
May 3, 1996
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
May 2, 1996
CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Consequence & remedy
Consequence: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Remedy: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.
Jan 11, 1996
IN CERTAIN VEHICLES, THE ENGINE CYLINDER HEAD OIL GALLEY PLUG DOES NOT SEAL PROPERLY AND ENGINE CYLINDER HEAD OIL IS NOT ADEQUATELY RETAINED.
Consequence & remedy
Consequence: INADEQUATE SEALING AND RETENTION OF THE PLUG CAN RESULT IN OIL LEAKAGE WHICH COULD CAUSE A FIRE IN THE ENGINE COMPARTMENT.
Remedy: DEALERS WILL INSTALL AN EXPANSION PLUG AND RETAINING BRACKET OVER THE CYLINDER HEAD OIL GALLEY PLUG.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
EA97016 · Lower Control Arm Ball Joint Failure
Opened Sep 29, 1997 · Closed Nov 20, 1997
Status: closed (inferred from source dates) · Suspension
BY LETTER DATED NOVEMBER 6, 1997, THE MANUFACTURER ADVISED THIS AGENCY OF ITS DECISION TO INITIATE A SAFETY RECALL CAMPAIGN OF THE SUBJECT VEHICLES TO CORRECT THE DEFECT IDENTIFIED IN THIS EA.THE RECALL WILL ALSO COVER 1996 AND 1997 CHRYSLER CIRRUS/DODGE STRATUS VEHICLES, AS WELL AS 1995 THROUGH 1997 CHRYSLER SEBRING CONVERTIBLE AND PLYMOUTH BREEZE VEHICLES EQUIPPED WITH IDENTICAL LOWER CONTROL ARM BALL JOINTS.AN ESTIMATED TOTAL OF 599,00VEHICLES ARE AFFECTED BY THIS RECALL.THE MANUFACTURER'S INVESTIGATION DISCLOSED THAT PROCESS VARIABILITY, TOGETHER WITH THE BALL JOINT HOUSING COVER CRIMPING OPERATION, CAN RESULT IN AN INEFFECTIVE SEAL THAT PERMITS A LOSS OF LUBRICATION AND ACCELERTED WEAR OF THE BALL JOINT ASSEMBLY.THIS CONDITION CAN LEAD TO FAILURE AND SEPARTION OF THE LOWER CONTROL ARM BALL JOINT.THE RECALL IS IDENTIFIED AS NHTSA 97V-201 AND A COPY OF CHRYSLER'S LETTER TO NHTSA IS ATTACHED HERETO.
Illustration