I PURCHASED A 2003 DODGE INTREPID IN NOVEMBER OF 2005 AND THE CAR RUNS FINE UP UNTIL ABOUT A MONTH AND A HALF AGO. THE CHECK ENGINE LIGHT CAME ON AND THE CAR WOULD GET STUCK IN ONE GEAR AND MY RPM WOULD GO UP INTO THE RED LINE UNLESS I PULLED OVER AND RESTARTED THE CAR. OTHER TIMES IT WOULD GET STUCK AND THEN JERK INTO THE NEXT …
Read full complaint
I PURCHASED A 2003 DODGE INTREPID IN NOVEMBER OF 2005 AND THE CAR RUNS FINE UP UNTIL ABOUT A MONTH AND A HALF AGO. THE CHECK ENGINE LIGHT CAME ON AND THE CAR WOULD GET STUCK IN ONE GEAR AND MY RPM WOULD GO UP INTO THE RED LINE UNLESS I PULLED OVER AND RESTARTED THE CAR. OTHER TIMES IT WOULD GET STUCK AND THEN JERK INTO THE NEXT GEAR. THEN ABOUT FOUR DAYS AGO I WAS ON THE FREEWAY AND THE WHOLE CAR JUST SHUT OFF. I COULD NOT MOVE IT AND TRAFFIC WAS SPEEDING PAST ME AND A FEW HAD TO SLAM ON BREAKS TO AVOID HITTING ME AND MY TEN MONTH OLD DAUGHTER. I HAD TO HAVE SOME PEOPLE HELP ME TO PUSH IT OFF THE FREEWAY SO THAT I COULD RESTART IT TO MAKE IT BACK HOME. I AM VERY FRIGHTENED TO DRIVE NOW ESPECIALLY WITH MY DAUGHTER IN THE CAR BECAUSE I AM AFRAID THIS MAY HAPPEN AGAIN. I HAD THE CODES READ ON THE CAR AND ABOUT SEVEN CAME UP ALL POINTING TO DIFFERENT THINGS. A MECHANIC SUGGESTED THE TRANSMISSION ECM. THE ESTIMATED COST OF FIXING THIS IF IT IS THE PROBLEM IS ABOUT 750.00 DOLLARS. *TR
NHTSA ODI #10200657
8,945 miles · Aug 7, 2004
Power TrainTires
THIS STUFF IS DANGEROUS. I'VE LOST THREE TIRE VALVES IN LESS THAN 1000 MILES AND THE LAST WAS SUDDEN AND VIOLENT. HONESTLY, I THOUGHT I'D DONE SOMETHING WRONG, BUT I'VE USED ONLY MR. CLEAN WASH SYSTEM AND A VERY DILUTE DEGREASER ON THE WHEELS. IT WAS DIFFICULT TO TRY TO REMOVE THE STEMS WITHOUT FURTHER DAMAGING THE VALVES AT …
Read full complaint
THIS STUFF IS DANGEROUS. I'VE LOST THREE TIRE VALVES IN LESS THAN 1000 MILES AND THE LAST WAS SUDDEN AND VIOLENT. HONESTLY, I THOUGHT I'D DONE SOMETHING WRONG, BUT I'VE USED ONLY MR. CLEAN WASH SYSTEM AND A VERY DILUTE DEGREASER ON THE WHEELS. IT WAS DIFFICULT TO TRY TO REMOVE THE STEMS WITHOUT FURTHER DAMAGING THE VALVES AT DISCOUNT BUT WE PERFOMRED A LITTLE EXPERIMENT BEFORE DISSEMBLING THE TIRE. WE RAN THE PSI UP TO 80 OFF THE VEHICLE AND WATCHED WHERE THE AIR ESCAPED THE VALVE. THERE IS A RUBBER COLLER THAT RUNS ABOUT 1/2 UP THE METAL VALVE STEM. THE AIR LEAKS FROM THE CIRCUMFERENCE OF THE SEAL WHERE THE RUBBER ENDS AND METAL BEGINS. HOWEVER, ANY SLIGHT PRESSURE OFF-CENTER RESULTS IN AIRFLOW FROM THE JUNCTION OF THE VALVE AND RIM. FURTHER PRESSURE EMPTIES THE TIRE PRETTY QUICK. THE FIRST TWO LEAKS WERE DISCOVERED HISSING IN PARKING LOTS AFTER A TRIP INTO A STORE. THE LAST, I LEFT MY DRIVEWAY, ALL WELL AND GOT ABOUT 1/16 MILE FROM THE HOUSE. THE VAN STARTED SHUDDERING AND WAS DIFFICULT TO CONTOL. I CALLED HOKE AND ASKED MY WIFE TO LOOK IN THE DRIVEWAY. I THOUGHT THAT I'D LOST ALL THE TRANSMISSION FLUID. THE TRUCK WAS REALLY FIGHTING. I NURSED THE VAN ALONG FOR APPROXIMATELY 100 FEET AND TURNED INTO A AUTO PARTS STORE. I GOT OUT, POPPPED THE HOOD AND LOOKED UNDER THE TRUCK FOR A LEAK. I WAS ON THE WAY INTO THE STORE BEFORE I NOTICED THAT DRIVER'S SIDE TIRE WAS COMPLETELY FLAT. I LAUGHED.*AK I NOW THINK THAT THE MB TRACTION CONTROL HAS NO IDEA WHAT TO DO WITH A FLAT AND MASKS THE PROBLEM, CONVERTING IT INTO A BIZARRE TRANNY TYPE PROBLEM. IT SOUND MORONIC TO NOT RELALIZE THAT YOU HAVE A FLAT ESPECIALLY AFTER YOU JUST HAD TWO IN THE FRONT, BUT THE REAR IS TOTALLY DIFFERENT. THE ONLY EXPLANATION IS THE TRACTION CONTROL. AND NOW I FIND OUT THAT THERE ARE MANY THAT HAVE HAD THE SAME EXPERIENCE...THIS IS SCARY. HOW MANY HAVE REPLACED THE VALVES? JP PE04066_CAT
NHTSA ODI #10086373
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04066 · Tire Valve Failure
Opened Sep 21, 2004 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Tires; Tires:valve
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (2)
Tires
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
Tires:valve
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
2003 Dodge Sprinter Problems, Complaints & Recalls | Skip That Year
Illustration