NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
122 reports130,454 miles · Aug 15, 2015
Structure
THERE IS A ENTRY GRAB HANDLE MOUNTED TO THE INTERIOR DOOR POST NEAR THE WINDSHIELD INTENDED AS AN ASSIST HANDLE. MY TRUCK IS EQUIPPED WITH RUNNING BOARD TO MAKE ENTRY EASIER INTO THE TRUCK CAB. I USED THE ASSIST HANDLE WHILE GETTING INTO THE TRUCK CAB, IT PULLED LOOSE FROM THE PILLAR CAUSING ME TO NEARLY FALL FROM THE TRUCK. …
Read full complaint
THERE IS A ENTRY GRAB HANDLE MOUNTED TO THE INTERIOR DOOR POST NEAR THE WINDSHIELD INTENDED AS AN ASSIST HANDLE. MY TRUCK IS EQUIPPED WITH RUNNING BOARD TO MAKE ENTRY EASIER INTO THE TRUCK CAB. I USED THE ASSIST HANDLE WHILE GETTING INTO THE TRUCK CAB, IT PULLED LOOSE FROM THE PILLAR CAUSING ME TO NEARLY FALL FROM THE TRUCK. I WAS ABLE TO GAIN MY BALANCE AND STEP DOWN FROM THE RUNNING BOARDS WITHOUT DOING ANY INJURY. I AM OF AVERAGE HEIGHT AND WEIGHT APPROPRIATE. WHEN I EXAMINED THE HANDLE I WAS SHOCKED TO SEE THE ONLY MOUNTING INVOLVED WAS PLASTIC WITH A BOLT THROUGH IT SCREWED TO THE DOOR FRAME. THIS IN NO WAY SHOULD BE CLASSIFIED AS AN APPROPRIATE ASSIST HANDLE TO AID ONE IN THE ENTRY OF THE VEHICLE.
NHTSA ODI #10748863
100,000 miles · Aug 11, 2015
Air BagsUnknown Or OtherVisibility/wiper
THE WINDSHIELD APPEARS WEAK HAVING MANY POCK MARKS IN IT. THIS CAUSES THE WINDSHIELD WIPERS TO NEED TO BE REPLACED OFTEN. THE DASH IS SEVERELY CRACKED AND WE ARE AFRAID THAT THIS IS GOING TO CAUSE THE AIR BAG TO RUPTURE ON THE PASSENGER SIDE (BESIDES THE FACT THAT IT IS COMING APART).
NHTSA ODI #10747871
Mileage unknown · Jul 27, 2015
SteeringSuspension
I HAVE A 2003 DODGE QUAD CAB 1500 4X2 THAT I BOUGHT NEW AND HAS ONLY 71,000 ORIGINAL MILES. I HAVE NOTICED SOME NOISE AND VIBRATION COMING FROM THE STEERING AND SUSPENSION COMING FROM THE FRONT END. I'VE RESEARCHED AND FOUND THAT CHRYSLER/DODGE HAS ISSUED A RECALL (N49, N62 AND NHTSA 13-V528) THAT DOES NOT INCLUDE MY VEHICLE BUT…
Read full complaint
I HAVE A 2003 DODGE QUAD CAB 1500 4X2 THAT I BOUGHT NEW AND HAS ONLY 71,000 ORIGINAL MILES. I HAVE NOTICED SOME NOISE AND VIBRATION COMING FROM THE STEERING AND SUSPENSION COMING FROM THE FRONT END. I'VE RESEARCHED AND FOUND THAT CHRYSLER/DODGE HAS ISSUED A RECALL (N49, N62 AND NHTSA 13-V528) THAT DOES NOT INCLUDE MY VEHICLE BUT SHOULD BE INCLUDED AFTER FURTHER INSPECTIONS. THE PART IN QUESTION IS THE LEFT TIE ROD AND STEERING LINKAGE. NEW PARTS (CBUEN491AA. CBUEN492AA) APPARENTLY ARE READILY AVAILABLE PRIOR TO JANUARY 2014 BUT MY TRUCK HAS NOT BEEN INCLUDED IN THE RECALL AND REPAIR. DO I HAVE TO WAIT FOR THE PART TO SNAP OFF CAUSING INJURY AND DEATH TO ANYONE ESPECIALLY MEMBERS OF MY FAMILY BEFORE A RECALL IS ISSUED FOR THIS MODEL YEAR? WE'VE BEEN FORTUNATE FOR NOW THAT NOTHING HAS HAPPENED BUT WHY DOES THE CONSUMER HAVE TO EXPERIENCE A LOSS FIRST BEFORE THE MANUFACTURER TAKES HONORABLE RESPONSIBILITY? ANOTHER ISSUE AS PREVIOUSLY REPORTED BY OTHER TRUCK OWNERS IS THAT THE DASH BOARD DETERIORATES AND CRACKS AND MATERIALS FALL INTO THE AIR/DEFROST DUCTING. I HOPE FOR ACTION SOON RATHER THAN RE-ACTION AFTER THE FACT AND THE PREVENTION OF LOSS TO LIFE OR INJURIES.
NHTSA ODI #10743761
Mileage unknown · Jan 26, 2015
Air Bags
TL*THE CONTACT OWNS A 2003 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V354000 (AIRBAG) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE…
Read full complaint
TL*THE CONTACT OWNS A 2003 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V354000 (AIRBAG) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10678916
165,000 miles · Jan 18, 2015
StructureInjury
DRIVER WAS USING GRAB BAR TO PULL SELF UP INTO VEHICLE WHEN THE GRAB BAR BROKE SUDDENLY AND PULLED OUT OF THE VEHICLE WITHOUT WARNING. THIS CAUSED DRIVER TO FALL AND SUFFER A FRACTURED HAMATE BONE IN THE WRIST AND CHRONIC SHOULDER PAIN. INJURIES REQUIRE SURGERY AND ARE NOT YET HEALED. *TR
NHTSA ODI #10676357
168,000 miles · Nov 7, 2014
Structure
THE DASH IS FALLING APART. IT BEGAN LAST SUMMER AND PIECES ARE FALLING INTO THE AIR CONDITIONER VENTS. CHEAP MATERIAL USED FOR THE DASH BOARD. *TR
NHTSA ODI #10653518
88,563 miles · Sep 11, 2014
Electrical System
MY PASSENGER DOORS, FRONT AND REAR, WILL NOT FUNCTION WITH THE POWER LOCK AND THE WINDOWS CAN ONLY BE ROLLED DOWN FROM THE DRIVERS CONTROLS. THIS IS A SAFETY CONCERN TO ME AS IT WILL MAKE IT DIFFICULT OR IMPOSSIBLE FOR SOMEONE TO QUICKLY GET OUT OF THE VEHICLE IF THEY NEED TO BAIL OUT, OR GET OUT IN THE EVENT OF AN ACCIDENT. I…
Read full complaint
MY PASSENGER DOORS, FRONT AND REAR, WILL NOT FUNCTION WITH THE POWER LOCK AND THE WINDOWS CAN ONLY BE ROLLED DOWN FROM THE DRIVERS CONTROLS. THIS IS A SAFETY CONCERN TO ME AS IT WILL MAKE IT DIFFICULT OR IMPOSSIBLE FOR SOMEONE TO QUICKLY GET OUT OF THE VEHICLE IF THEY NEED TO BAIL OUT, OR GET OUT IN THE EVENT OF AN ACCIDENT. IF THE DRIVER BECAME ILL HAD A MEDICAL EMERGENCY, PASSENGERS WOULD BE UNABLE TO GET OUT OF THE VEHICLE. THE ELECTRICAL WIRES IN THE DOOR HARNESSES HAVE BROKEN AND CAUSED THE ISSUE TO OCCUR. *TR
NHTSA ODI #10632512
85,500 miles · Sep 11, 2014
Seat Belts
THE PLASTIC TENSION DEVICE ON THE SEAT BELTS (BUCKLE END) ARE BREAKING OFF. THIS IS OF MOST IMPORTANCE WITH MY CHILD SAFETY SEATS. IT DOES NOT ALLOW FOR THE SEATS TO STAY IN PLACE AS THEY LOOSEN UP IN JUST ONE SHORT TRIP. THIS AFFECTS THE SAFETY, SECURITY AND LIFE OF MY CHILDREN. THIS NEEDS TO BE REPAIRED RIGHT AWAY. *TR
NHTSA ODI #10632509
82,100 miles · Sep 11, 2014
Air BagsStructureVisibility/wiper
THE DASH BOARD ON THIS VEHICLE IS CRACKING ALL OVER. IT HAS CRACKED AROUND THE PASSENGER AIRBAG AND PIECES HAVE FALLEN INTO THE AIRBAG COMPARTMENT. THIS HAS NOT CAUSED INJURY YET, BUT IF INVOLVED IN AN ACCIDENT, THE BROKEN PIECES WILL DEFINITELY CAUSE INJURY AND I HOPE THAT THEY DO NOT AFFECT THE AIRBAG DEPLOYMENT. PIECES BLO…
Read full complaint
THE DASH BOARD ON THIS VEHICLE IS CRACKING ALL OVER. IT HAS CRACKED AROUND THE PASSENGER AIRBAG AND PIECES HAVE FALLEN INTO THE AIRBAG COMPARTMENT. THIS HAS NOT CAUSED INJURY YET, BUT IF INVOLVED IN AN ACCIDENT, THE BROKEN PIECES WILL DEFINITELY CAUSE INJURY AND I HOPE THAT THEY DO NOT AFFECT THE AIRBAG DEPLOYMENT. PIECES BLOW INTO YOUR FACE WHILE RUNNING THE DEFROST WHICH IF STRUCK IN THE EYE COULD CAUSE AN ACCIDENT. *TR
NHTSA ODI #10632508
100,000 miles · Sep 3, 2014
Structure
MY DASHBOARD STARTED CRACKING UP AND LARGE SHARDS OF THE PLASTIC BECAME AIRBORNE WHILE DRIVING THE VEHICLE AND STRUCK ME IN THE FACE . THIS IS DEFINITELY A SAFETY ISSUE IN MY OPINION AND I HAVE A $50000.00 DRIVEWAY ORNAMENT AS I DO NOT FEEL SAFE DRIVING THE VEHICLE ANYMORE. *TR
NHTSA ODI #10630269
NHTSA investigations
1EA04025 · False Park
Opened Aug 26, 2004 · Closed Dec 22, 2005
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Additional source detail variants (3)
Power Train:automatic Transmission
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Power Train:automatic Transmission:gear Position Indication (prndl)
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Power Train:automatic Transmission:lever And Linkage:column Shift
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE PARK POSITION.COMPLAINANTS GENERALLY REPORT THAT THE VEHICLE WAS BEING OPERATED IN A FORWARD GEAR AND BROUGHT TO A STOP THROUGH BRAKE APPLICATION ON ALEVEL SURFACE, AT WHICH TIME THE OPERATOR MOVED THE SHIFT LEVER TO ENGAGE THE PARK POSITION.THE OPERATOR THEN OPENED THE DRIVER SIDE DOOR AND, WITHOUT VERIFYING PARK ENGAGEMENT (E.G., PRNDL GEAR INDICATION), SECURING THE PARK BRAKE, OR TURNING THE ENGINE OFF, EXITED THE VEHICLE.INITIALLY, NO VEHICLE MOVEMENT WAS APPARENT, HOWEVER, A SHORT TIME LATER, TYPICALLY REPORTED AS 10 TO 30 SECONDS, THE VEHICLE MOVED REARWARD UNDER ENGINE POWER.THE INCIDENT OFTEN ENDED IN A VEHICLE CRASH, AND SOMETIMES INVOLVED SERIOUS INJURY.TWO FATALITIES ARE ALLEGED.ODI?S ANALYSIS OF TEST VEHICLES AND SOME INCIDENT VEHICLES FOUND NO EVIDENCE TO INDICATE THAT A SHIFT LEVER PROPERLY PLACED IN PARK COULD UNINTENTIONALLY (I.E., WITHOUT DRIVER INPUT) DISENGAGE FROM THAT POSITION.HOWEVER, ODI DID FIND THAT THE SHIFT LEVER COULD BE INADVERTENTLY PLACED, AND REMAIN AT REST, WITHIN AN INTERMEDIATE POSITION BETWEEN THE PARK AND REVERSE GEAR POSITIONS.WHEN PLACED IN SUCH AN INTERMEDIATE POSITION, THE VEHICLE CAN EXPERIENCE A DELAYED PRESSURIZATION OF THE REVERSE HYDRAULIC CIRCUIT THAT IS SUFFICIENT TO CAUSE THE VEHICLE TO ROLL REARWARD UNDER POWER.THE DELAY PERIOD ALLOWS SUFFICIENT TIME FOR OPERATORS TO EXIT THE STATIONARY VEHICLE WITHOUT PERCEIVING THAT THE SHIFTER IS NOT IN PARK.THE SUMMARY REPORT DISCUSSES THE TECHNICAL ANALYSIS OF THIS ISSUE IN GREATER DETAIL AND COMPARES THE FREQUENCY OF THESE INCIDENTS IN THE SUBJECT VEHICLES TO OTHER PEER VEHICLES THAT ODI EXAMINED.AS DESCRIBED IN THEIR OCTOBER 4, 2005 LETTER TO NHTSA, DAIMLERCHRYSLER CORPORATION (DCC) WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 05V-462, DCC NO. E17) TO INSTALL AN OUT-OF-PARK ALARM SYSTEM IN THE SUBJECT VEHICLES.THE ALARM WILL PROVIDE AUDIBLE AND VISUAL FEEDBACK TO ALERT THE DRIVER, AND OTHERS, IF THE DRIVER ATTEMPTS TO EXIT THE VEHICLE WHILE THE ENGINE IS RUNNING AND THE SHIFT LEVER IS NOT IN THE PARK POSITION.THE TIMING OF DCC?S ACTION HAS YET TO BE DETERMINED.
Illustration