IllustrationWHILE DRIVING AT VARIOUS SPEEDS DEFECTIVE TRANSMISSION WILL CAUSE THE VEHICLE TO JUMP/SHAKE DUE TO ERRATIC SHIFTING OF GEARS. DEALER CANNOT DETERMINE PROBLEM. *AK
1996 Dodge RAM 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Dodge RAM 3500 do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAM 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 23 of 124 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports10 fire reports3 injury reports
Power Train complaints
19 reportsTRANSMISSION MALFUNCTION: QUICK CONNECTOR ON FLUID COOLING LINE AT TRANSMISSION HOUSING.
THE AUTOMATIC TRANSMISSION LINES FAILED CAUSING FLUID TO LEAK ONTO TURBO CHARGER CAUSING VEHICLE FIRE.
TRANSMISSION AND INSTRUMENT PANEL FAILURE; INCLUDING FUEL, OIL, AND TEMPERATURE GUAGE.
WHEN APPLYING THE BRAKES THE VEHICLE WILL SEVERELY PULL TO THE RIGHT. AFTER TAKING THE VEHICLE IN FOR SERVICE FIVE TIMES THE VEHICLE NOW PULLS TO THE LEFT. DEALER HAS REPLACED THE BRAKE PADS AND THE CALIPERS WITH NO REMEDY. *AK CONSUMER STATES VEHICLE HAS BEEN BROUGHT IN 2 TIMES MORE AND STILL PROBLEM EXISTS. VEHICLE HAS A…
Read full complaint
WHEN APPLYING THE BRAKES THE VEHICLE WILL SEVERELY PULL TO THE RIGHT. AFTER TAKING THE VEHICLE IN FOR SERVICE FIVE TIMES THE VEHICLE NOW PULLS TO THE LEFT. DEALER HAS REPLACED THE BRAKE PADS AND THE CALIPERS WITH NO REMEDY. *AK CONSUMER STATES VEHICLE HAS BEEN BROUGHT IN 2 TIMES MORE AND STILL PROBLEM EXISTS. VEHICLE HAS AN INTERMITTENT TRANSMISSION, VEHICLE WON'T SHIFT THE TRANSMISSION FROM 1ST TO 2ND GEAR, RESULTING IN RED LINING THE MOTOR AND SEVERE JERKING IN TRAFFIC. *SLC
ENGINE STALLED.
THE VEHICLE DOES NOT GO INTO 5TH GEAR. WHEN 5TH GEAR IS APPLIED THE CAR JUMPS OUT OF GEAR. HAS BEEN TO DEALER 4 TIMES AND PROBLEM STILL EXISTS. *AK CONSUMER STATED THE NUT THAT HOLDS THE 5TH GEAR IS A RIGHT HAND THREAD, THE GEAR TURNS LEFT, WHICH LOOSENS THE NUT ALLOWING THE GEAR TO BACK OFF.*JB
TRANSMISSION DEFECTIVE CAUSING TORQUE CONVERTER TO LOCK UP, REPLACEMENT OF ENTIRE TRANSMISSION NECESSARY. MJS
1ST TIME FIRE OCCURRED IN TRANSMISSION WHILE TOWING TRAILER, 2ND TIME FIRE OCCURRED IN TRANSMISSION WHILE BACKING OUT OF DRIVEWAY. HAD TAKEN VEHICLE TO DEALER WHO REPLACED PLUG 1ST TIME, BUT DID NOTHING 2ND TIME. SENDING COPIES OF INVOICES. *AK
Official recalls
199V024000 · Exterior Lighting:headlights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.