IllustrationDASH IS ALL CRACKED UP ALLOWING SHARP PLASTIC PROJECTILES IN AND ABOUT THE CAB THAT CAN CUT YOU IN A WRECK SUN GETTING ON ELECTRICAL WIRES DESTROYING THEM AND NOW SHORTS AND SOMETIMES DONT WORK RIGHT
1996 Dodge RAM 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Dodge RAM 3500 do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAM 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 23 of 124 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports10 fire reports3 injury reports
Exterior Lighting complaints
9 reportsTL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP FOR A THROTTLE CABLE REPAIR MARCH 2010 BUT THE DEALER ONLY REPLACED THE THROTTLE CABLE AND NO OTHER REQUIRED PARTS THAT WOULD KEEP THE CABLE FROM FAILING. AS A RESULT, THE CABLE BECAME LOOSE TWICE AFTER THE REPAIR WHILE THE CONTAC…
Read full complaint
TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP FOR A THROTTLE CABLE REPAIR MARCH 2010 BUT THE DEALER ONLY REPLACED THE THROTTLE CABLE AND NO OTHER REQUIRED PARTS THAT WOULD KEEP THE CABLE FROM FAILING. AS A RESULT, THE CABLE BECAME LOOSE TWICE AFTER THE REPAIR WHILE THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP. THE DEALER REPLACED THE FAILED THROTTLE TWICE. THE CONTACT THEN TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AS THE DEALER WAS NOT ABLE TO CORRECT THE PROBLEM. THE MECHANIC AT THE REPAIR SHOP INFORMED HER THAT THE FAILURE WAS CAUSED BY THE THROTTLE ROD BALL, THE BALL STUD, THROTTLE CABLE STUD, THE THROTTLE ROD THREAD (LEFT AND RIGHT) AND THE THROTTLE RETURN SPRING. IN ADDITION TO THE THROTTLE FAILURE, CONTACT STATED THAT THE HEADLIGHT REPAIR PERFORMED JUNE 2009 DID NOT CORRECT THE PROBLEM; THE HEADLIGHT PLASTIC AND SWITCH MELTED EVEN AFTER THE REPAIR. SHE CALLED THE MANUFACTURER AND FILED A COMPLAINT; THE MANUFACTURER EXPLAINED THAT THE THROTTLE FAILURE WAS NOT DUE TO A MANUFACTURERS DEFECT BUT INSTEAD TO THE DEALERS POOR WORKMANSHIP. THE FAILURE MILEAGE WAS APPROXIMATELY 221,010. THE CURRENT MILEAGE WAS 221,061.
LOW BEAM HEADLIGHT FAILURE---CHECKED ON LINE FOUND RECALL # 819---WENT TO CHRYSLER DEALER---WAS ADVISED THAT THE RECALL HAD BEEN DONE ON THAT VIN# AND CHRYSLER HAD NO OBLIGATION---I PULLED THE HEADLIGHT SWITCH AND FOUND THAT IT WAS DAMAGED, THE CONNECTOR MELTED AND NO RELAY PACK SPECIFIED IN THE RECALL FIX-----IT WAS APPEARS THE…
Read full complaint
LOW BEAM HEADLIGHT FAILURE---CHECKED ON LINE FOUND RECALL # 819---WENT TO CHRYSLER DEALER---WAS ADVISED THAT THE RECALL HAD BEEN DONE ON THAT VIN# AND CHRYSLER HAD NO OBLIGATION---I PULLED THE HEADLIGHT SWITCH AND FOUND THAT IT WAS DAMAGED, THE CONNECTOR MELTED AND NO RELAY PACK SPECIFIED IN THE RECALL FIX-----IT WAS APPEARS THE RECALL WAS PENCIL WHIPPED AND THE REPAIR WAS NEVER MADE------HOW DO YOU INSURE THAT RECALLS ARE REALLY DONE AND HOW MANY MORE LIKE MINE ARE OUT THERE???????? *TR
TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE HEADLIGHTS FLICKERED ON AND OFF AND THE CONTACT NOTICED A BURNING SMELL. THE LIGHT SWITCH ALSO OVERHEATED. THE VEHICLE WAS PREVIOUSLY SERVICED AT 63,557 MILES FOR NHTSA CAMPAIGN ID NUMBER 99V024000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE MANUFACTURER WOULD NOT SERVICE THE VEH…
Read full complaint
TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE HEADLIGHTS FLICKERED ON AND OFF AND THE CONTACT NOTICED A BURNING SMELL. THE LIGHT SWITCH ALSO OVERHEATED. THE VEHICLE WAS PREVIOUSLY SERVICED AT 63,557 MILES FOR NHTSA CAMPAIGN ID NUMBER 99V024000 (EXTERIOR LIGHTING:HEADLIGHTS:SWITCH). THE MANUFACTURER WOULD NOT SERVICE THE VEHICLE AGAIN UNDER THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 201,135.
THE HEADLIGHT SWITCH FAILED.*DT *JB
PARTS WERE NOT AVAILABLE FOR RECALL 99V024000 REPAIRS FOR HEADLIGHTS. *AK
CONSUMER PULLED OVER TO SHOULDER 0FF ROAD AND LEFT VEHICLE RUNNING TO ASSIST ANOTHER MOTORIST. WHEN HE RETURNED TO VEHICLE, THERE WAS SMOKE INSIDE COMING FROM UNDERNEATH DASHBOARD. VEHICLE WAS TOWED TO DEALERSHIP. MECHANIC TOLD HIM THAT HEADLIGHT SWITCH NEEDED TO BE REPLACED. *AK
TRANSMISSION DEFECTIVE CAUSING TORQUE CONVERTER TO LOCK UP, REPLACEMENT OF ENTIRE TRANSMISSION NECESSARY. MJS
WHILE DRIVING, ALL OF THE VEHICLE LIGHTS WENTOUT. HEADLIGHTS,PARKING LIGHTSS, AND MARKER LIGHTS. PLEASE DESCRIBE. *AK
Official recalls
199V024000 · Exterior Lighting:headlights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.