IllustrationDT: CONSUMER'S VAN HEATS UP EVERY NOW AND THEN. NOTICED SMOKE COMING FROM THE FRONT OF THE CAR, INSIDE AND OUT. THE CONSUMER HAD FIRES AS WELL, HAD TO PUT THEM OUT WITH FIRE EXTINGUISHERS. TOOK VEHICLE TO A MECHANIC, AND HE CHANGED THE VEHICLE'S COMPUTER, AND THEN IT HAPPENED AGAIN.*AK UPDATED 11/29/05. *JB
1994 Dodge RAM 3500
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Dodge RAM 3500 do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all RAM 3500 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 9 of 70 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports7 fire reports1 injury reports
What owners actually said
70 reportsFAILURE OF TRAILER HITCH ON THE BACK OF THE 1994 DODGE PICKUP TRUCK.*MR THE TRUCK HITCH EXTENDED TOO FAR OUT FROM THE MOUNTS, PUTTING UNDUE LEVERAGE AND STRESS ON THE METAL WHICH RESULTED IN IT FAILING. A RECALL WAS ISSUED FOR MODEL YEAR 1998-2000 BUT NOT FOR EARLIER MODEL YEARS. THE CONSUMER HAD THE HITCHES REPLACED AT HIS E…
Read full complaint
FAILURE OF TRAILER HITCH ON THE BACK OF THE 1994 DODGE PICKUP TRUCK.*MR THE TRUCK HITCH EXTENDED TOO FAR OUT FROM THE MOUNTS, PUTTING UNDUE LEVERAGE AND STRESS ON THE METAL WHICH RESULTED IN IT FAILING. A RECALL WAS ISSUED FOR MODEL YEAR 1998-2000 BUT NOT FOR EARLIER MODEL YEARS. THE CONSUMER HAD THE HITCHES REPLACED AT HIS EXPENSE AND REQUEST REIMBURSEMENT FROM THE MANUFACTURER. *NM
WHILE DRIVING 35-40 MPH VEHICLE RAN OVER A SMALL BUMP. THIS CAUSED THE VEHICLE TO VIBRATE SEVERELY. VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED CONSUMER THAT THE STABILIZE BAR BRACKET WAS RIPPED FROM THE FRAME. *AK
PAINT BUBBLING AND PEELING ON CAB AND DISCOLORATION OF PAINT ON FENDERS. *NLM
NHTSA RECALL CAMPAIGN 99V024000 HEADLAMP SWITCH; THE HEADLIGHT SWITCH FAILED SHORTING OUT WHICH CAUSED THE HEADLIGHTS TO GO OUT WHILE IN USE. THE SWITCH FAILED AGAIN BUT THIS TIME THE WIRING HARNESS UNDER THE DASH CAUGHT FIRE WHILE BEING DRIVEN. THERE WAS A RECALL ISSUED ON THE RAM 3500 FOR THIS PROBLEM BUT THE SAME FAILURE HA…
Read full complaint
NHTSA RECALL CAMPAIGN 99V024000 HEADLAMP SWITCH; THE HEADLIGHT SWITCH FAILED SHORTING OUT WHICH CAUSED THE HEADLIGHTS TO GO OUT WHILE IN USE. THE SWITCH FAILED AGAIN BUT THIS TIME THE WIRING HARNESS UNDER THE DASH CAUGHT FIRE WHILE BEING DRIVEN. THERE WAS A RECALL ISSUED ON THE RAM 3500 FOR THIS PROBLEM BUT THE SAME FAILURE HAS OCCURED ON THIS RAM 2500 PICKUP. PLEASE DESCRIBE DETAILS TS
CONSUMER NOTICED THE A FUEL LINE FITTING CONNECTOR, AND AUXILIARY COOLER ON TRANSMISSION IS NOT WORKING PROPERLY. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS
VEHICLE IS EXHIBITING POSSIBLE SUSPENSION PROBLEMS INCLUDING EXCESSIVE MOVEMENT BETWEEN THE PICKUP WHEN TOWING A CAMPER. THE TRUCK HAS SUDDENLY ROLLED TO THE RIGHT AS THOUGH A TIRE HAD ROLLED OOT OF THE RIM, THERE ARE CRACKS IN THE FRONT OF THE PICKUP BOX AND BOTTOM OF THE CAB. ALLOWING THE BOX TO TWIST IN RELATION TO THE FRA…
Read full complaint
VEHICLE IS EXHIBITING POSSIBLE SUSPENSION PROBLEMS INCLUDING EXCESSIVE MOVEMENT BETWEEN THE PICKUP WHEN TOWING A CAMPER. THE TRUCK HAS SUDDENLY ROLLED TO THE RIGHT AS THOUGH A TIRE HAD ROLLED OOT OF THE RIM, THERE ARE CRACKS IN THE FRONT OF THE PICKUP BOX AND BOTTOM OF THE CAB. ALLOWING THE BOX TO TWIST IN RELATION TO THE FRAME AND THE HEIGHT OF THE CAMPER. THE MOTION IS EXTREME AND IS ACCOMPANIED BY CLICKS AND POPS OF THE SHEET METAL FROM THE AREA OF THE CRACKS. IT IS ALSO POSSIBLE THAT THE SUSPENSION PROBLEMS CAUSED THE DRIVER SIDE U BOLTS TO BE LOOSE. *TT
DRIVER SIDE AIRBAG DEPLOYED WITHOUT VEHICLE BEING IN AN ACCIDENT.*AK
VEHICLE OF WILL STALL INTERMITTENTLY. PROBLEM IS MORE FREQUENT DURING WARM WEATHER. DEALERSHIP HAS EXAMINED VEHICLE NUMEROUS TIMES, BUT COULD NOT DETERMINE CAUSE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / ATTACHMENTS.*AK
TIRE HAS SEPARATED IN THE MIDDLE OF TREAD. STEEL BELTS HAVE COMPLETELY SEPARATED AND THE TREAD IS COMPLETELY OPENED UP. *AK (DOT NUMBER: VD1L1XA TIRESIZE: 225 75R16)
Official recalls
199V024000 · Exterior Lighting:headlights:switch
Feb 5, 1999
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.
PE99026 · Front Suspension Spring/shock Absorber
Opened Apr 16, 1999 · Closed Aug 31, 1999
Status: closed (inferred from source dates) · Suspension
ALLEGE FAILURE OF THE COIL SPRING/SHOCK ABSORBER BRACKET AT ITS ATTACHMENT TO THE VEHICLE FRAME MAY ALLOW COLLAPSE OF THE FRONT SUSPENSION, AND POTENTIALLY AFFECT STEERING OR BRAKING SYSTEM PERFORMANCE
EA98010 · Headlight Circuit
Opened May 8, 1998 · Closed Dec 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.
PE98002 · Headlight Circuit Failure
Opened Jan 14, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE94072 · Trans Hose Separation
Opened Oct 3, 1994 · Closed Mar 22, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available