NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
236 reportsMileage unknown · Aug 21, 2014
Electrical System
MY 2007 DODGE NITRO WOULDN'T CRANK. SO I TOOK IT TO THE DODGE DEALERSHIP THEY TOLD ME THAT IT WAS THE GPS, WELL I PAID TO GET THAT FIXED AND IT STARTED DOING THE SAME THING.. SO I TOOK IT TO ANOTHER SHOP WHOM TOLD ME IT WAS THE BATTERY.. OK I GOT THAT FIXED AND WAS STILL HAVING THE SAME PROBLEM. IN THE MIDDLE OF DRIVING, THE HOR…
Read full complaint
MY 2007 DODGE NITRO WOULDN'T CRANK. SO I TOOK IT TO THE DODGE DEALERSHIP THEY TOLD ME THAT IT WAS THE GPS, WELL I PAID TO GET THAT FIXED AND IT STARTED DOING THE SAME THING.. SO I TOOK IT TO ANOTHER SHOP WHOM TOLD ME IT WAS THE BATTERY.. OK I GOT THAT FIXED AND WAS STILL HAVING THE SAME PROBLEM. IN THE MIDDLE OF DRIVING, THE HORN CONTINUOUSLY GOES OFF, SO DOES THE WINDSHIELD WIPERS, THE DOORS BEGAN LOCKING AND UNLOCKING. SO I TOOK IT TO ONE FINAL SHOP AND THAT'S WHEN THEY TOLD ME ITS A PROBLEM WITH THE TOTAL INTEGRATED POWER MODULE. I ASKED COULD THIS BE FIXED AND WAS TOLD ITS BEEN ON BACK ORDER. SO NOW I HAVE TO DRIVE AROUND WITH MY VEHICLE MALFUNCTIONING.. *TR
NHTSA ODI #10627274
187,000 miles · Aug 9, 2014
Electrical SystemFire
FIRST THE DRIVERS WINDOW FELL A LITTLE THEN THE DRIVERS DOOR MASTER POWER SWITCH STARTED SMOKING AND SMOLDERED SO MUCH THAT I HAD TO DRIVE TO THE SIDE OF THE ROAD. I TURNED OFF THE DODGE AND ATTEMPTED TO REMOVE THE SWITCH. THE CONNECTOR WAS MELTED AND WAS UNABLE TO REMOVE. RESTARTED VEHICLE TO GO TO DEALERSHIP AND THE SWITCH CAU…
Read full complaint
FIRST THE DRIVERS WINDOW FELL A LITTLE THEN THE DRIVERS DOOR MASTER POWER SWITCH STARTED SMOKING AND SMOLDERED SO MUCH THAT I HAD TO DRIVE TO THE SIDE OF THE ROAD. I TURNED OFF THE DODGE AND ATTEMPTED TO REMOVE THE SWITCH. THE CONNECTOR WAS MELTED AND WAS UNABLE TO REMOVE. RESTARTED VEHICLE TO GO TO DEALERSHIP AND THE SWITCH CAUGHT FIRE. AGAIN TURNED OFF THE VEHICLE AND PULLED THE SWITCH, IT WAS MELTED AND FELL APART. THERE WERE NO INJURIES. THE WIRES WERE BADLY MELTED FROM THE HEAT. TOOK TO THE LOCAL DEALERSHIP. *TR
NHTSA ODI #10621138
88,000 miles · Jul 21, 2014
Electrical SystemExterior Lighting
MY VEHICLE COMPLETELY SHUT DOWN TWICE WHILE I WAS DRIVING. ANOTHER PROBLEM I HAVE WITH THIS VEHICLE IS THAT THE CAR UNLOCKS BY ITSELF, TURNING ON THE HEADLIGHTS AND DRAINING THE BATTERY. THIS HAS HAPPENED SEVERAL TIMES RECENTLY AND IS VERY FRUSTRATING. *TR
NHTSA ODI #10615182
79,000 miles · May 14, 2014
Structure
I AM ORIGINAL OWNER OF THIS VEHICLE. IT IS GARAGED , WELL MAINTAINED, AND SERVICED BY DEALERSHIP. THERE IS NO HISTORY OF ABUSE, OR AUTO ACCIDENTS ASSOCIATED WITH THIS VEHICLE. THE INTERIOR DRIVERS DOOR HANDLE SNAPPED OFF IN MY HANDS YESTERDAY, WHILE ATTEMPTING TO EXIT THE PARKED VEHICLE. THIS IS A CONSIDERABLE SAFETY CONCER…
Read full complaint
I AM ORIGINAL OWNER OF THIS VEHICLE. IT IS GARAGED , WELL MAINTAINED, AND SERVICED BY DEALERSHIP. THERE IS NO HISTORY OF ABUSE, OR AUTO ACCIDENTS ASSOCIATED WITH THIS VEHICLE. THE INTERIOR DRIVERS DOOR HANDLE SNAPPED OFF IN MY HANDS YESTERDAY, WHILE ATTEMPTING TO EXIT THE PARKED VEHICLE. THIS IS A CONSIDERABLE SAFETY CONCERN. ONLY EXIT IS THROUGH AN ELECTRIC WINDOW, DUE TO LARGE CONSOLE BETWEEN SEATS. I HAVE CONTACTED DODGE, AND DUE TO MILEAGE (79K) AND AGE (2007), THEY OFFER NO ASSISTANCE IN FIXING, SO I WILL HAVE TO PAY AT DEALERSHIP. I HAVE SEEN ENOUGH COMPLAINTS IN VARIOUS FORUMS OF THIS SAME ISSUE, TO WARRANT CONTACTING YOU. THIS IS NOT COSMETIC, BUT OF VITAL CONCERN TO DRIVER SAFETY. PLEASE CONSIDER FURTHER ACTION WITH A VIEW TO RECALL , SO THAT MANUFACTURER WILL PROCEED RECTIFY THIS DANGEROUS FLAW. THANK YOU FOR YOUR CONSIDERATION. *TR
NHTSA ODI #10588324
Mileage unknown · May 7, 2014
Electrical SystemFuel/propulsion SystemVisibility/wiper
BACK DRIVER SIDE WINDOW HAS CAME OFF THE TRACK TWICE IN ABOUT 12 MONTHS, REPLACED MOTOR, STILL DID IT. EVERY TIME I FILL UP WITH GAS IT SPILLS OUT ALL OVER THE CAR AND GROUND. THE WINDSHIELD WIPERS ONLY WORK ON HIGH SOME OF THE TIME. DRIVER SIDE DOOR HANDLE BROKE OFF, VERY EXPENSIVE TO FIX! *TR
NHTSA ODI #10587068
75,497 miles · Mar 19, 2014
Structure
PULLED ON DRIVER'S SIDE DOOR HANDLE AND IT SNAPPED OFF. HAVE TO ROLL DOWN WINDOW AND OPEN FROM THE OUTSIDE TO GET OUT OF THE VEHICLE. NOT A VERY SAFE OPTION. I HAVE READ MANY OTHERS ARE HAVING THIS SAME PROBLEM, PERHAPS A RECALL SHOULD BE PUT OUT. IT IS A PRICEY FIX AT THE DEALER. MY CAR IS IN EXCELLENT CONDITION AND I TAKE…
Read full complaint
PULLED ON DRIVER'S SIDE DOOR HANDLE AND IT SNAPPED OFF. HAVE TO ROLL DOWN WINDOW AND OPEN FROM THE OUTSIDE TO GET OUT OF THE VEHICLE. NOT A VERY SAFE OPTION. I HAVE READ MANY OTHERS ARE HAVING THIS SAME PROBLEM, PERHAPS A RECALL SHOULD BE PUT OUT. IT IS A PRICEY FIX AT THE DEALER. MY CAR IS IN EXCELLENT CONDITION AND I TAKE GOOD CARE OF IT. NOT HAPPY ABOUT SPENDING UPWARDS OF $250.00 TO HAVE A PLASTIC DOOR HANDLE FIXED. I PURCHASED THIS VEHICLE NEW IN 2007. *TR
NHTSA ODI #10573368
60,000 miles · Mar 13, 2014
Electrical SystemService BrakesStructure
THE EMERGENCY BRAKE NEVER WORKED LIKE IT SHOULD, EVEN WHEN NEW, THE ELECTRIC WINDOW SWITCHES AND POWER DOOR LOCKS WORK WHEN THEY FEEL LIKE IT, AND THE INSIDE DOOR HANDLES BREAK FOR NO REASON OTHER THAN POOR WORKMANSHIP AND POOR CHOICE OF MATERIALS (PLASTIC) RENDERING THEM USELESS. THESE ARE ALL KNOWN PROBLEMS FOR YEARS WITH DODG…
Read full complaint
THE EMERGENCY BRAKE NEVER WORKED LIKE IT SHOULD, EVEN WHEN NEW, THE ELECTRIC WINDOW SWITCHES AND POWER DOOR LOCKS WORK WHEN THEY FEEL LIKE IT, AND THE INSIDE DOOR HANDLES BREAK FOR NO REASON OTHER THAN POOR WORKMANSHIP AND POOR CHOICE OF MATERIALS (PLASTIC) RENDERING THEM USELESS. THESE ARE ALL KNOWN PROBLEMS FOR YEARS WITH DODGE NITROS . THEY SHOULD BE FORCED TO RECALL THEM FOR THESE REASONS, ESPECIALLY BECAUSE THEY ARE ALL DANGEROUS. IT'S LIKE THE MONEY PIT. DODGE WANTS $150.00 PER DOOR JUST TO REPAIR THE HANDLE ASSEMBLIES. ARE THEY KIDDING ME? WHO MAKES A DOOR HANDLE OUT OF CHEAP PLASTIC? WE TAKE CARE OF THIS VEHICLE LIKE ITS A NEW CAR, AND NEVER ABUSE IT. IT HAS ONLY 60,000 MILES ON IT. THE FIRST DOOR HANDLE BROKE WITH 30,000 MILES. DODGE HAD BETTER DO SOMETHING BEFORE I NO LONGER OWN THIS VEHICLE OR I WILL CROSS THEM OFF MY LIST FOR GOOD. I HAVE NO PROBLEM GOING BACK TO FORD AND STAYING THERE.(OR HYUNDAI FOR THAT MATTER). *TR
NHTSA ODI #10569100
79,000 miles · Feb 21, 2014
Service Brakes
ESP CAN NOT BE SHUT DOWN COMPLETELY. THE PROBLEM I AM HAVING IS WHEN I NEED TO PULL THE BOAT OFF A SLIP, IT ACTIVATES WHEN WHEELS SPIN OR BEGINS TO SLIDE APPLYING THE REAR BRAKES AGGRESSIVELY. ALSO WHEN I AM IN 4X4 AND SPINNING IN THE MUD IT ALSO DOES THE SAME RESULTING IN ALMOST GETTING STUCK OR GETTING STUCK, WHICH MAKES ME US…
Read full complaint
ESP CAN NOT BE SHUT DOWN COMPLETELY. THE PROBLEM I AM HAVING IS WHEN I NEED TO PULL THE BOAT OFF A SLIP, IT ACTIVATES WHEN WHEELS SPIN OR BEGINS TO SLIDE APPLYING THE REAR BRAKES AGGRESSIVELY. ALSO WHEN I AM IN 4X4 AND SPINNING IN THE MUD IT ALSO DOES THE SAME RESULTING IN ALMOST GETTING STUCK OR GETTING STUCK, WHICH MAKES ME USE 4X4 MORE OFTEN THEN NOT. I HAVE CONTACTED DEALERS AND DODGE ABOUT THIS ISSUE BUT THEY SAY ITS INTEGRATED INTO THE ABS SYSTEM AND CAN DO NOTHING ABOUT IT. I HAVE GONE THROUGH SEVERAL REAR BRAKES AND ROTORS DUE TO THIS ISSUE. ALL I ASK IS TO CHANGE THE MODES ON THE DEACTIVATION FROM 70 PERCENT TO 0 PERCENT. *TR
NHTSA ODI #10565255
55,000 miles · Feb 20, 2014
Structure
TL-THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED, THAT THE FRONT AND BACK DOME LIGHT COMES ON RANDOMLY. THE VEHICLE WAS PARKED WHEN THE INCIDENT OCCURS AND WHEN HE IS DRIVING THE VEHICLE. HE HAS TO DETACH THE BATTERY TO TURN OFF THE LIGHTS. THE ALARM GOES OFF WITHOUT WARNING AND THE BATTERY ALSO HAS TO BE DISCONNECTED.…
Read full complaint
TL-THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED, THAT THE FRONT AND BACK DOME LIGHT COMES ON RANDOMLY. THE VEHICLE WAS PARKED WHEN THE INCIDENT OCCURS AND WHEN HE IS DRIVING THE VEHICLE. HE HAS TO DETACH THE BATTERY TO TURN OFF THE LIGHTS. THE ALARM GOES OFF WITHOUT WARNING AND THE BATTERY ALSO HAS TO BE DISCONNECTED. THE AUTHORIZED DEALER DIAGNOSED THE PROBLEM AND STATED THAT HE NEEDS A NEW TAIL GATE SWITCH. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 55000. DYD
NHTSA ODI #10565089
77,780 miles · Jan 27, 2014
Electrical SystemLatches/locks/linkages
DOOR LOCKS BECAME INOPERABLE FROM DOOR PANELS AND KEY FOB. POWER LOCKS COULD NO LONGER BE USED FROM EITHER. WAS TOLD IT WAS AN ISSUE WITH THE TIPM, WOULD HAVE TO BE FIXED WITH DEALERSHIP. IN READING COMPLAINTS HERE, AS WELL AS MANY FORUMS ONLINE IT SEEMS TO BE A VERY COMMON ISSUE. RECOMMEND A RECALL. SOUNDS AS THOUGH THIS IS…
Read full complaint
DOOR LOCKS BECAME INOPERABLE FROM DOOR PANELS AND KEY FOB. POWER LOCKS COULD NO LONGER BE USED FROM EITHER. WAS TOLD IT WAS AN ISSUE WITH THE TIPM, WOULD HAVE TO BE FIXED WITH DEALERSHIP. IN READING COMPLAINTS HERE, AS WELL AS MANY FORUMS ONLINE IT SEEMS TO BE A VERY COMMON ISSUE. RECOMMEND A RECALL. SOUNDS AS THOUGH THIS IS NOT AN ISOLATED INCIDENT AND SHOULD BE ADDRESSED. *TR
NHTSA ODI #10561701
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Illustration