IllustrationWINDSHIELD WIPERS WENT OUT UNEXPECTEDLY, CV AXEL BOOT TORE, TRANSMISSION SHIFTS HARD
2007 Dodge Nitro 4X4
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Nitro 4X4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
4325–50K
4050–75K
3075–100K
22100–150K
8150K+
190 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports5 fire reports2 injury reports
Power Train complaints
19 reportsFAILURE OF DRIVE TRAIN AND TRANSMISSION AT 94,000 MILES. AUTHORIZED DODGE DEALER SHOP IS SAYING $13,000 TO FIX.
VEHICLE HAS A NEW TRANSMISSIO NOW.FUEL BACKFIRES OUT THE TANK EVERYTIME I GO TO FILL UP THE TANK.THEN,MY INSURANCE GAVE ME A RECALL LIST TO HAVE IT TAKEN IN.TOOK IT TO THE DODGE DEALERSHIP NUMEROUS OF TIMES AND SAME PROBLEM OCCURS AND THEY SAY IN THEY'RE DATABASE ITS NOT SHOWING ANYTHING ON MY VIN NUMBER.AIR BAG LIGHT GOES ON AN…
Read full complaint
VEHICLE HAS A NEW TRANSMISSIO NOW.FUEL BACKFIRES OUT THE TANK EVERYTIME I GO TO FILL UP THE TANK.THEN,MY INSURANCE GAVE ME A RECALL LIST TO HAVE IT TAKEN IN.TOOK IT TO THE DODGE DEALERSHIP NUMEROUS OF TIMES AND SAME PROBLEM OCCURS AND THEY SAY IN THEY'RE DATABASE ITS NOT SHOWING ANYTHING ON MY VIN NUMBER.AIR BAG LIGHT GOES ON AND OFF ALLDAY.CAR BEATS AND AIRBAG LIGHT BLINKS ON AND OFF AND IS VERY ANNOYING.A/C COMPRESSOR IS NOW OUT AND WORKING ON GETTING IT REPLACED BUT OTHER THAN THAT EVERYTHING IS GOING PERFECT.
TAKATA RECALL I LEASED MY DODGE NITRO IN 2007 AND DECIDED TO BUY IT OUT DUE TO OVER MILEAGE ALLOWANCE. ISSUES WITH THIS CAR STARTED SLOWLY AND ESCALATED OVER TIME. MY TIRES LOST AIR CONSTANTLY. NEW TIRES DIDN'T HELP. WINTER I HAVE TO PUT AIR IN ALL TIRES ONCE A WEEK. POSSIBLY DUE TO RIMS. WHEN BACKING UP THIS VEHICLE WOULD…
Read full complaint
TAKATA RECALL I LEASED MY DODGE NITRO IN 2007 AND DECIDED TO BUY IT OUT DUE TO OVER MILEAGE ALLOWANCE. ISSUES WITH THIS CAR STARTED SLOWLY AND ESCALATED OVER TIME. MY TIRES LOST AIR CONSTANTLY. NEW TIRES DIDN'T HELP. WINTER I HAVE TO PUT AIR IN ALL TIRES ONCE A WEEK. POSSIBLY DUE TO RIMS. WHEN BACKING UP THIS VEHICLE WOULD JOLT OUT ON ITS OWN NOT GIVING ME ENOUGH TIME TO REACT TO HITTING SOMETHING OR SOMEONE. THE ENGINE WAS SPORADIC WITH THE WAY IT HANDLED POWER AND ADMINISTERING IT THROUGHOUT FUNCTIONS. CONSTANT LEAKING OF FLUIDS. MY FIRST EXPERIENCE WITH POWER LOSS WAS GETTING ONTO HIGHWAY, SPED UP LOSING POWER AND LUCKILY ABLE TO REACH THE BREAK DOWN LANE SAFELY.AFTER SEVERAL TIMES THE DEALER TOOK IT IN AND SAID THEY FIXED IT. THEN TRUCK STARTED TO OVER HEAT AND ANTI FREEZE WOULD NOT STAY IN ENGINE AND OUT OF NO WHERE IT WOULD JUMP TO HOT,LOSE CONTROL OF THE VEHICLE AND PULL OVER ANYWHERE I COULD. AFTER 5 TIMES OR MORE HERB CHAMBERS COULD NOT FIGURE OUT WHAT WAS WRONG WITH IT. THEY KEPT MY TRUCK FOR SEVERAL WEEKS FIXING MY HEAD GASKET , WATER PUMP AND 5 OTHER PARTS, THEY TOLD ME I WAS ALL SET TO GO. I DROVE OFF LOT 10 MINUTES UP THE HIGHWAY TO HAVE IT OVER HEAT LEAVING ME STRANDED ON THE SIDE OF THE HIGHWAY AGAIN WITHOUT POWER BACK IT GOES TO REPLACE THE HEATING CORE ELEMENT. SIX MONTHS LATER I LOSE POWER AROUND A ROTARY, ON HIGHWAY AND IN A FEW PARKING LOTS.I DECIDE TO INVESTIGATE MY OPTIONS TO DISCOVER THERE IS A RECALL AND PURSUE THE DEALER ABOUT HOW UNSAFE THIS VEHICLE IS AND NO ONE EVER TOLD ME IT HAD A RECALL AND DID NOT FEEL SAFE GOING ANY FURTHER. I WAS TOLD TO SETTLE WITH THE MANUFACTURER AND DIDN'T SEEM WORRIED SENDING ME &MY KIDS BACK INTO AN UNSAFE VEHICLE. I BECAME SICK DURING THE LAST FEW YRS OF THIS AND AM STILL BATTLING WITH MY HEALTH. SOME OF THIS PROLONGED TIME HAS BEEN A RESULT OF NOT HAVING THE MENTAL OR PHYSICAL CAPABILITY. *TR
CONFUSED WITH DIFFERENT INFORMATION REGARDING REPLACEMENT / REPAIR OF THE DRIVESHAFT OR BOOT. WHICH OF THE FOLLOWING IS CORRECT... REPLACE THE WHOLE DRIVESHAFT REPLACE JUST THE BOOT ONE MECHANIC SAYS THE SHAFT THAT NEEDS TO BE REPLACED IS FROM THE TRANSFER CASE TO THE FRONT DIFFERENTIAL IS THIS A AFTER MARKET PART OR DEALER…
Read full complaint
CONFUSED WITH DIFFERENT INFORMATION REGARDING REPLACEMENT / REPAIR OF THE DRIVESHAFT OR BOOT. WHICH OF THE FOLLOWING IS CORRECT... REPLACE THE WHOLE DRIVESHAFT REPLACE JUST THE BOOT ONE MECHANIC SAYS THE SHAFT THAT NEEDS TO BE REPLACED IS FROM THE TRANSFER CASE TO THE FRONT DIFFERENTIAL IS THIS A AFTER MARKET PART OR DEALERSHIP PART? CONCERNED - RECALL DRIVESHAFT ISSUES WITH 4X2 2007 NITRO - WHY WOULD 4X4 AND 4X2 HAVE DRIVESHAFT ISSUES BUT RECALL ON THE 4X2 ONLY. *TR
THIS PROBLEM HAS HAPPENED TO ME 3 DIFFERENT TIMES. AND THE LAST TIME WAS BACK IN NOVEMBER 2014. WHILE I AM DRIVING MY VEHICLE STALLS, MY BRAKES LOCK UP AND MY STEERING WHEEL LOOSES POWER WITH THE REST OF MY CAR EXCEPT MY RADIO. THIS IS EXTREMELY SCARY BECAUSE I AM PUTTING MY LIFE AND OTHERS IN DANGER. AND CHRYSLER SAYS THERE IS …
Read full complaint
THIS PROBLEM HAS HAPPENED TO ME 3 DIFFERENT TIMES. AND THE LAST TIME WAS BACK IN NOVEMBER 2014. WHILE I AM DRIVING MY VEHICLE STALLS, MY BRAKES LOCK UP AND MY STEERING WHEEL LOOSES POWER WITH THE REST OF MY CAR EXCEPT MY RADIO. THIS IS EXTREMELY SCARY BECAUSE I AM PUTTING MY LIFE AND OTHERS IN DANGER. AND CHRYSLER SAYS THERE IS NO PROBLEM BECAUSE IT DOESN'T SHOW UP ON DIAGNOSTIC. BUT WHEN YOU PULL UP RECALLS AND DEFECTS. THE PROBLEM IS RIGHT THERE. WHEN THIS PROBLEM HAPPENS. I HAVE TO TURN OFF MY KEYS AND RESTART THE VEHICLE FOR IT TO WORK AGAIN. BUT YOU NEVER KNOW WHEN THIS IS GOING TO HAPPEN THERE ARE NO WARNING SIGNS. *TR
I STARTED THE CAR TO MOVE IT IN THE DRIVEWAY. AFTER BACKING UP, I PUT IT IN PARK. I THEN TRIED TO PLACE IT IN DRIVE, AND THE SHIFTER LOCK WOULDN'T RELEASE. (IT NORMALLY RELEASES WHEN THE BRAKE PEDAL IS DEPRESSED.) AFTER A FEW TRIES, I ATTEMPTED TO TURN OFF AND RESTART THE CAR. WHEN I TURNED THE IGNITION TO RESTART THE CAR, ALL T…
Read full complaint
I STARTED THE CAR TO MOVE IT IN THE DRIVEWAY. AFTER BACKING UP, I PUT IT IN PARK. I THEN TRIED TO PLACE IT IN DRIVE, AND THE SHIFTER LOCK WOULDN'T RELEASE. (IT NORMALLY RELEASES WHEN THE BRAKE PEDAL IS DEPRESSED.) AFTER A FEW TRIES, I ATTEMPTED TO TURN OFF AND RESTART THE CAR. WHEN I TURNED THE IGNITION TO RESTART THE CAR, ALL THE ELECTRONICS ACTIVATED, THE HEADLIGHTS WERE FLASHING, THE HORN WAS CYCLING, THE WIPERS AND SPRAYERS WERE RUNNING, ETC. I TURNED OFF THE IGNITION AND POPPED THE HOOD RELEASE. WHEN I GOT OUT AND WALKED TO THE FRONT OF THE VEHICLE, I NOTICED LIGHT COMING FROM THE HOOD GAP. WHEN I OPENED THE HOOD, FLAMES WERE SURROUNDING ALL SIDES OF THE TIPM UNIT, AND THE HOOD INSULATION LINER WAS ON FIRE. I DISCONNECTED THE BATTERY AND WAS ABLE TO EXTINGUISH THE FIRE. *TR
A MONTH AGO STARTED HEARING A HIGH PITCH WHISTLING SOUND. GOT LOUDER AS I ACCELERATED, NOW A CONSTANT SOUND. DRIVING AT 2,000 RPM IT WOULDN'T SHIFT INTO 2ND GEAR. WENT INTO "LIMP MODE" TOOK TO TRANSMISSION SHOP SAID THAT TORQUE CONVERTER WAS FALLING APART AND DEBRIS GOT INTO THE FLUID AND UP INTO PUMP AND.TRANSMISSION. TOLD I …
Read full complaint
A MONTH AGO STARTED HEARING A HIGH PITCH WHISTLING SOUND. GOT LOUDER AS I ACCELERATED, NOW A CONSTANT SOUND. DRIVING AT 2,000 RPM IT WOULDN'T SHIFT INTO 2ND GEAR. WENT INTO "LIMP MODE" TOOK TO TRANSMISSION SHOP SAID THAT TORQUE CONVERTER WAS FALLING APART AND DEBRIS GOT INTO THE FLUID AND UP INTO PUMP AND.TRANSMISSION. TOLD I NEED A NEW TRANSMISSION. 7YR OLD VEHICLE NEEDING A TRANSMISSION? HAD CHEVY'S THAT LASTED WELL OVER 210,000 MI. FILLING GAS TANK WAITING FOR AUTOMATIC SHUT OFF. NEVER HAPPENED. GASOLINE SPEWED OUT ONTO GROUND AND ME. THIS IS CONSTANT. TRIED A DIFFERENT PUMP AND STATION, STILL GAS NOT SHUTTING OFF. I NO LONGER FILL UP THE GAS TANK. HAVING TO FIGURE OUT WHAT SIZE TANK AND HOW MUCH GAS IS LEFT IN TANK BEFORE ADDING MORE GAS. THIS STARTED 2 YRS AGO. CHRYSLER STEP UP AND TAKE RESPONSIBILITY FOR THE SUBSTANDARD PARTS THAT ARE USED TO BUILD THESE VEHICLES THAT THE PUBLIC PUT TRUST IN!!!!!!! I WILL NO LONGER BUY A DODGE / CHRYSLER PRODUCT. *TR
2007 DODGE NITRO-AUTOMATIC TRANSMISSION-PARKING BRAKE FAILURE: VEHICLE AT DEALER FOR PARKING BRAKE FAILING TO ENGAGE. DEALER FINDS THAT ALL PARKING BRAKE COMPONENTS ARE RUSTED AND FROZEN. DEALER STATES APPEARS PARKING BRAKE HAS NEVER ENGAGED. DEALER STATES ISSUE HAS CAUSED RUST TO FORM ON INSIDE OF REAR WHEEL ROTORS CAUSIN…
Read full complaint
2007 DODGE NITRO-AUTOMATIC TRANSMISSION-PARKING BRAKE FAILURE: VEHICLE AT DEALER FOR PARKING BRAKE FAILING TO ENGAGE. DEALER FINDS THAT ALL PARKING BRAKE COMPONENTS ARE RUSTED AND FROZEN. DEALER STATES APPEARS PARKING BRAKE HAS NEVER ENGAGED. DEALER STATES ISSUE HAS CAUSED RUST TO FORM ON INSIDE OF REAR WHEEL ROTORS CAUSING PREMATURE NEED FOR REPLACEMENT. HAVE NOTICED SIMILAR ISSUES ON WEB SEARCHES. ITEM IS NOT UNDER WARRANTY. ALTHOUGH LATER MODELS HAVE RECALL, NONE FOR THIS YEAR MODEL. VEHICLE HAS 54000 MILES ON IT AND IS WELL TAKEN CARE OF. *TR
TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE DRIVING 65 MPH THE VEHICLE LOST POWER AND WOULD NOT ACCELERATE OVER 25 MPH. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC TEST THAT INDICATED THE FAILURE IN THE TRANSMISSION SPEED SENSOR. THE MANUFACTURER FILED REPO…
Read full complaint
TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE DRIVING 65 MPH THE VEHICLE LOST POWER AND WOULD NOT ACCELERATE OVER 25 MPH. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC TEST THAT INDICATED THE FAILURE IN THE TRANSMISSION SPEED SENSOR. THE MANUFACTURER FILED REPORT 20696273, AND ADVISED HER TO HAVE THE DEALERSHIP DIAGNOSE THE FAILURE. THE DEALERS DIAGNOSTIC TEST INDICATED THAT THE TRANSMISSION SPEED SENSOR HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 58,000.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.