IllustrationFUEL TANK OVERFLOWS EVERY TIME THAT WE FILL THE TANK. WHEN THE GAS IS FILLED, THE NOZZLE IS FULLY INSERTED IN THE TANK AND WILL NOT AUTOMATICALLY SHUT-OFF SPILLING GAS EVERYWHERE UNTIL I MANUALLY STOP THE NOZZLE.
2007 Dodge Nitro 4X4
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Nitro 4X4 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
4325–50K
4050–75K
3075–100K
22100–150K
8150K+
190 reports with mileage · 46 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports5 fire reports2 injury reports
Fuel/propulsion System complaints
17 reportsREFUELING SPILLAGE DODGE NITRO R/T WHEN FUELING THE VEHICLE, FUEL OVERFLOWS UP THRU THE FILLER NECK AND ONTO THE PERSON WHO IS REFUELING THE SUV, THUS CAUSING IT TO SPILL OVER THE PAINT OF THE CAR WITH APPROXIMATELY 30 - 50OZ OF GAS. UNFORTUNATELY THIS OCCURS ABOUT 70% OF THE TIME THE NITRO IS FUELED UP. THIS IS VERY SIMILAR …
Read full complaint
REFUELING SPILLAGE DODGE NITRO R/T WHEN FUELING THE VEHICLE, FUEL OVERFLOWS UP THRU THE FILLER NECK AND ONTO THE PERSON WHO IS REFUELING THE SUV, THUS CAUSING IT TO SPILL OVER THE PAINT OF THE CAR WITH APPROXIMATELY 30 - 50OZ OF GAS. UNFORTUNATELY THIS OCCURS ABOUT 70% OF THE TIME THE NITRO IS FUELED UP. THIS IS VERY SIMILAR TO A RECALL I HAD ON MY 2005 DODGE DURANGO. BELOW ARE THE ISSUES NOTED BY OTHER DODGE NITRO OWNERS ON THE NITRO FORUMS WEBSITE. HTTPS://WWW.NITROFORUMZ.COM/THREADS/GAS-OVERFLOW-FIXED.700/PAGE-6#POST-159638 HTTPS://WWW.NITROFORUMZ.COM/THREADS/X46-WARRANTY-FUEL-SPIT-BACK-DURING-REFUELING.38708/
VEHICLE HAS A NEW TRANSMISSIO NOW.FUEL BACKFIRES OUT THE TANK EVERYTIME I GO TO FILL UP THE TANK.THEN,MY INSURANCE GAVE ME A RECALL LIST TO HAVE IT TAKEN IN.TOOK IT TO THE DODGE DEALERSHIP NUMEROUS OF TIMES AND SAME PROBLEM OCCURS AND THEY SAY IN THEY'RE DATABASE ITS NOT SHOWING ANYTHING ON MY VIN NUMBER.AIR BAG LIGHT GOES ON AN…
Read full complaint
VEHICLE HAS A NEW TRANSMISSIO NOW.FUEL BACKFIRES OUT THE TANK EVERYTIME I GO TO FILL UP THE TANK.THEN,MY INSURANCE GAVE ME A RECALL LIST TO HAVE IT TAKEN IN.TOOK IT TO THE DODGE DEALERSHIP NUMEROUS OF TIMES AND SAME PROBLEM OCCURS AND THEY SAY IN THEY'RE DATABASE ITS NOT SHOWING ANYTHING ON MY VIN NUMBER.AIR BAG LIGHT GOES ON AND OFF ALLDAY.CAR BEATS AND AIRBAG LIGHT BLINKS ON AND OFF AND IS VERY ANNOYING.A/C COMPRESSOR IS NOW OUT AND WORKING ON GETTING IT REPLACED BUT OTHER THAN THAT EVERYTHING IS GOING PERFECT.
EVERY TIME I FILL THE TANK THE PUMP AT THE GAS STATION SHUTS OFF BUT I HAVE FUEL THAT BURPS BACK OUT. FROM WHAT I UNDERSTAND ABOUT THESE CARS IS THAT THERE IS A FUEL SHUTOFF VALVE ON THE GAS TANK TO PREVENT FIRES/EXPLOSIONS IN THE EVENT OF A ROLLOVER ACCIDENT THAT IS DEFECTIVE. MY VEHICLE IS OUT OF WARRANTY AND THIS CAUSES ME CO…
Read full complaint
EVERY TIME I FILL THE TANK THE PUMP AT THE GAS STATION SHUTS OFF BUT I HAVE FUEL THAT BURPS BACK OUT. FROM WHAT I UNDERSTAND ABOUT THESE CARS IS THAT THERE IS A FUEL SHUTOFF VALVE ON THE GAS TANK TO PREVENT FIRES/EXPLOSIONS IN THE EVENT OF A ROLLOVER ACCIDENT THAT IS DEFECTIVE. MY VEHICLE IS OUT OF WARRANTY AND THIS CAUSES ME CONCERN FOR MY AND OTHERS SAFTEY. I WOULD LIKE CHRYSLER TO FIX THIS PROBLEM AS I DON'T BELIEVE I SHOULD HAVE TO PAY FOR THIS OUT OF POCKET AS THEY KNOW THAT THIS IS A COMMON PROBLEM WITH THESE CARS.
2007 DODGE NITRO SLT - CAR SITTING IN DRIVEWAY OVERNIGHT THE VEHICLE LISTED, ON MULTIPLE OCCASIONS, WILL GO INTO A STATE WHERE ATTEMPTING TO START THE VEHICLE CAUSES MULTIPLE ODD THINGS TO SIMULTANEOUSLY HAPPEN: LOUD CLICKING NOISES CAN BE HEARD FROM ENGINE COMPARTMENT HEADLIGHTS / TAIL LIGHTS FLASH WIPERS START AND STOP R…
Read full complaint
2007 DODGE NITRO SLT - CAR SITTING IN DRIVEWAY OVERNIGHT THE VEHICLE LISTED, ON MULTIPLE OCCASIONS, WILL GO INTO A STATE WHERE ATTEMPTING TO START THE VEHICLE CAUSES MULTIPLE ODD THINGS TO SIMULTANEOUSLY HAPPEN: LOUD CLICKING NOISES CAN BE HEARD FROM ENGINE COMPARTMENT HEADLIGHTS / TAIL LIGHTS FLASH WIPERS START AND STOP RANDOMLY ALL DASH LIGHTS RANDOMLY TURN ON AND OFF RADIO CLOCK IS RESET TO 12:00 AS IF THE BATTERY WAS DISCONNECTED RADIO SOMETIMES RANDOMLY TURNS ON/OFF FUEL PUMP CAN BE HEARD STARTING AND STOPPING, SOMETIMES WILL NOT STOP SOMETIMES PUTTING A BATTERY CHARGER ON THE CAR'S BATTERY WILL MAKE IT START. SOMETIMES IT ONLY MAKES THE CLICKING LOUDER, ALONG WITH RANDOM OTHER EVENTS LISTED ABOVE. SOMETIMES THE ONLY THING THAT FIXES THE PROBLEM IS A THUMP WITH A SMALL RUBBER MALLET TO THE BLACK BOX JUST TO THE REAR OF THE MAIN 12 VOLT BATTERY. THIS SEEMS TO BE MORE LIKELY TO HAPPEN IN COLDER WEATHER, BUT IS NOT LIMITED TO HAPPENING DURING COLD WEATHER. SOMETIMES, JUST UNLOCKING THE CAR DOORS WITH THE DODGE KEY FOB WILL CAUSE SOME ISSUES TO HAPPEN. SOMETIMES THE ISSUES ARE FOLLOWED UP WITH CHECK ENGINE LIGHT COMING ON, BUT WHEN CODES ARE PULLED THEY ARE INVALID CODES (CODES CHECKED AT DEALER).
I JUST PURCHASED A 2007 DODGE NITRO WITH 57334 KMS. ON MY FIRST REFUELING I WAS ALMOST SOAKED IN GASOLINE BECAUSE OF WHAT I DETERMINED LATER AS A FACTORY FAULTY ROLLOVER VALVE IN THE GAS TANK. THE HOSE CLICKS OFF AS THE TANK IS FULL BUT THEN THE GASOLINE GUSHES OUT ALL OVER THE VEHICLE & GROUND. THE AMOUNT IS CONSIDERABLE. THIS …
Read full complaint
I JUST PURCHASED A 2007 DODGE NITRO WITH 57334 KMS. ON MY FIRST REFUELING I WAS ALMOST SOAKED IN GASOLINE BECAUSE OF WHAT I DETERMINED LATER AS A FACTORY FAULTY ROLLOVER VALVE IN THE GAS TANK. THE HOSE CLICKS OFF AS THE TANK IS FULL BUT THEN THE GASOLINE GUSHES OUT ALL OVER THE VEHICLE & GROUND. THE AMOUNT IS CONSIDERABLE. THIS IS A VERY DANGEROUS FIRE ISSUE. ON MY 2ND REFUELING WAS THE SAME THING & EACH ADDITIONAL FILL. HASN'T THERE BEEN ANY RECALLS OR FORCIBLE FIX TO GET THE MANUFACTURE TO CORRECT THIS ISSUE? *TR
BACK DRIVER SIDE WINDOW HAS CAME OFF THE TRACK TWICE IN ABOUT 12 MONTHS, REPLACED MOTOR, STILL DID IT. EVERY TIME I FILL UP WITH GAS IT SPILLS OUT ALL OVER THE CAR AND GROUND. THE WINDSHIELD WIPERS ONLY WORK ON HIGH SOME OF THE TIME. DRIVER SIDE DOOR HANDLE BROKE OFF, VERY EXPENSIVE TO FIX! *TR
WHEN FILLING UP GAS TANK, GAS SPITS OUT. *TR
I JUST BOUGHT MY NITRO BUT EVERY TIME I FILL UP THE GAS TANK IT WILL CLICK OFF AT THE NOZZLE BUT THEN I GET GAS SPEWING BACK OUT! IT HAS HAPPENED TO ME TWICE NOW AT TWO DIFFERENT PUMPS AT TWO DIFFERENT GAS STATIONS. IT SCARED ME VERY MUCH AND IS A HUGE SAFETY HAZARD! MY NITRO IS NO LONGER UNDER WARRANTY BUT I KNOW I AM NOT ALONE…
Read full complaint
I JUST BOUGHT MY NITRO BUT EVERY TIME I FILL UP THE GAS TANK IT WILL CLICK OFF AT THE NOZZLE BUT THEN I GET GAS SPEWING BACK OUT! IT HAS HAPPENED TO ME TWICE NOW AT TWO DIFFERENT PUMPS AT TWO DIFFERENT GAS STATIONS. IT SCARED ME VERY MUCH AND IS A HUGE SAFETY HAZARD! MY NITRO IS NO LONGER UNDER WARRANTY BUT I KNOW I AM NOT ALONE WITH HAVING THIS ISSUE. THE ONLY FIX I KNOW OF IS REPLACING THE GAS TANK AT MY EXPENSE. I FEEL AS THIS IS A WELL KNOWN AND PREVALENT ISSUE DODGE SHOULD ADDRESS IT ASAP! *TR
EVERY TIME I FILL UP THE VEHICLE THE GAS OVERFLOWS ONTO THE CAR AND GAS STATION GROUND. THIS IS A HUGE SAFETY HAZARD FOR A FIRE TO START. I AM WORRIED THAT IT WILL EAT THE PAINT OFF BY THE FILL UP AS WELL. *TR
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.