NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
95 reportsMileage unknown · Sep 23, 2013
Air BagsPower TrainStructure
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10545010
Mileage unknown · Aug 20, 2013
Power TrainStructure
I AM LIVING IN PUERTO RICO AND I HAVE A 2007 DODGE NITRO, WHICH HAS A RECALL, UNDER BODY TRANSMISSION TUNNEL SHIELD 05/24/2013 INCOMPLETE I WENT TO CABRERA MOTORS WHERE I PURCHASED THE CAR SO I CAN GET THE RECALL FIXED. I WENT ON JULY 11, 2013, AND WAS TOLD THE PART WOULD BE IN 2 WEEKS. HERE WE ARE AUGUST 20, 2013 AND STI…
Read full complaint
I AM LIVING IN PUERTO RICO AND I HAVE A 2007 DODGE NITRO, WHICH HAS A RECALL, UNDER BODY TRANSMISSION TUNNEL SHIELD 05/24/2013 INCOMPLETE I WENT TO CABRERA MOTORS WHERE I PURCHASED THE CAR SO I CAN GET THE RECALL FIXED. I WENT ON JULY 11, 2013, AND WAS TOLD THE PART WOULD BE IN 2 WEEKS. HERE WE ARE AUGUST 20, 2013 AND STILL NO PART. I'VE CALLED MANY TIMES AND EVERY TIME I CALL I'M TOLD THE PART IS NOT IN. I NEED MY VEHICLE TO MOVE AND I HAVE MY FAMILY IN IT. IF A CAR IS RECALLED IT IS DUE TO A SAFETY CONCERN. PLEASE HELP. *TR
NHTSA ODI #10536251
2,500 miles · Jul 2, 2013
Fuel/propulsion System
EACH TIME I FILL WITH FUEL IT SPITS OUT ABOUT A GALLON. VERY BAD................. *TR
NHTSA ODI #10522889
78,500 miles · Jan 1, 2013
Electrical SystemFuel/propulsion System
WHEN FILLING UP THE GAS TANK, AFTER PUMP AUTOMATICALLY SHUTS OFF, APPROXIMATELY 1/2 GALLON OF GAS OVERFLOWS. THIS HAS HAPPENED 3 TIMES. THE LAST TIME, GAS WAS PROPELLED INTO MY FACE AND ALL OVER MY CLOTHES. RESEARCH INDICATES THAT THIS IS DUE TO A DEFECT IN THE VALVE THAT PREVENTS GAS LEAKAGE DURING/AFTER A ROLLOVER CRASH. THIS …
Read full complaint
WHEN FILLING UP THE GAS TANK, AFTER PUMP AUTOMATICALLY SHUTS OFF, APPROXIMATELY 1/2 GALLON OF GAS OVERFLOWS. THIS HAS HAPPENED 3 TIMES. THE LAST TIME, GAS WAS PROPELLED INTO MY FACE AND ALL OVER MY CLOTHES. RESEARCH INDICATES THAT THIS IS DUE TO A DEFECT IN THE VALVE THAT PREVENTS GAS LEAKAGE DURING/AFTER A ROLLOVER CRASH. THIS IS WORRISOME IN AND OF ITSELF, BUT ESPECIALLY WHEN COMBINED WITH THE OTHER 2 PROBLEMS I'VE HAD WITH THIS VEHICLE. ABOUT 2 YEARS AGO, I WAS GOING TO EXIT THE DRIVER'S SEAT WHEN THE INTERIOR DOOR HANDLE BROKE OFF IN MY HAND. THE MASTER SWITCH FOR THE POWER WINDOWS STOPPED WORKING WITHIN A FEW DAYS OF THAT. I AM WORRIED THAT I CAN BE IN AN ACCIDENT IN WHICH THE CAR CATCHES FIRE DUE TO THE DEFECTIVE VALVE, AND I WILL NOT BE ABLE TO EXIT MY CAR IF THE DOOR HANDLE BREAKS OFF AGAIN AND THE WINDOWS WON'T ROLL DOWN. I HAVE BEEN TOLD THAT THE FIX FOR THIS VALVE IS TO GET THE GAS TANK REPLACED, AT MY OWN EXPENSE. ALSO, WHEN I WENT TO THE DEALER TO ORDER MY DOOR HANDLE, THEY ALREADY HAD SOME IN STOCK, WHICH INDICATES, TO ME, THAT THIS IS A COMMON PROBLEM AND YET CHRYSLER HAS NOT RECALLED IT. THE SHODDY CONSTRUCTION OF THIS VEHICLE COMBINED WITH THE LACK OF ASSISTANCE FROM CHRYSLER HAS ENSURED THAT I WILL NEVER PURCHASE ANOTHER ONE OF THEIR PRODUCTS AGAIN. *TR
NHTSA ODI #10490646
60,000 miles · Dec 22, 2012
Fuel/propulsion System
OCCASIONALLY, WHEN I AM FILLING UP MY TANK WITH GAS (REGARDLESS OF THE GAS STATION) THE AUTO SHUTOFF MECHANISM WILL NOT WORK AND A MODERATE AMOUNT OF GASOLINE WILL OVERFLOW OUT OF THE TANK AND ONTO THE CAR/STREET. *TR
NHTSA ODI #10489521
81,700 miles · Dec 7, 2012
EnginePower Train
ON DECEMBER 06, 2012 WAS STOPPED AT A RED LIGHT. LIGHT TURNED GREEN AND I PROCEEDED TO ACCELERATE, I THEN HEAR A LOUD THUMP AND VEH SHUT DOWN. I LOOKED UNDER THE VEH ONLY TO FIND THAT MY DRIVE SHAFT HAD EXPLODED AND BROKE IN TWO, FALLING TO THE ROADWAY. LOOKED LIKE A BOMB WENT OFF UNDER MY VEH. SEE THAT THIS IS S RECURRING PROB…
Read full complaint
ON DECEMBER 06, 2012 WAS STOPPED AT A RED LIGHT. LIGHT TURNED GREEN AND I PROCEEDED TO ACCELERATE, I THEN HEAR A LOUD THUMP AND VEH SHUT DOWN. I LOOKED UNDER THE VEH ONLY TO FIND THAT MY DRIVE SHAFT HAD EXPLODED AND BROKE IN TWO, FALLING TO THE ROADWAY. LOOKED LIKE A BOMB WENT OFF UNDER MY VEH. SEE THAT THIS IS S RECURRING PROBLEM WITH THIS MODEL. WHY IS THEIR NO RECALL??? IF I WERE GOING AT ST HIGHER RATE OF SPEED COULD OF RESULTED IN INJURY OR LOST OF LIFE. WHY IS DODGE NOT TAKING RESPONSIBILITY?? *TR
NHTSA ODI #10487728
81,700 miles · Dec 6, 2012
Electrical SystemPower Train
WAS STOPPED AT A RED LIGHT AND WHEN TURNED GREEN PRESSED GAS AND THE DRIVE TRAIN EXPLODED UPWARDS. DRIVE TRAIN COMPLETELY MANGLED. IF WERE GOING DOWN ROAD LIKELY COULD OF GOT KILLED ALONG WITH MY DAUGHTER. DODGE NOT TAKING RESPONSIBILITY. BROUGHT TO ACADIANA DODGE IN LAFAYETTE, LA. *TR
NHTSA ODI #10487575
60,000 miles · Jul 17, 2012
Power Train
I WAS DRIVING AT 45PH AND ALL OF A SUDDEN MY CARS WHEELED LOCKED UP AND I CAME TO A SUDDEN STOP WITH MY WHEELS LAYING DOWN RUBBER BUT I DID NOT CRASH. WHEN MY CAR WAS TOWED TO THE GARAGE THE CONCLUSION WAS THAT THE REAREND SEAL WAS LEAKING AND ALL THE FLUID CAME OUT OF THE REAREND AND THE GEARS LOCKED UP. *TR
NHTSA ODI #10465923
30,000 miles · Jun 14, 2012
Electrical System
I WAS RIDING DOWN THE HIGHWAY AND THE DASHBOARD LIGHTS ALL CAME ON AND THE VEHICLE POWERED DOWN AND THEN STARTED UP. THERE HAVE BEEN MULTIPLE TIMES THAT THIS HAS HAPPENED. THE LAST TIME IT HAPPENED WAS TODAY 06/14/2012 AND THE SUV STALLED AND ALMOST CAUSED A WRECK IN HEAVY TRAFFIC. SPEED WAS AROUND 30 MILES PER HOUR. I WENT …
Read full complaint
I WAS RIDING DOWN THE HIGHWAY AND THE DASHBOARD LIGHTS ALL CAME ON AND THE VEHICLE POWERED DOWN AND THEN STARTED UP. THERE HAVE BEEN MULTIPLE TIMES THAT THIS HAS HAPPENED. THE LAST TIME IT HAPPENED WAS TODAY 06/14/2012 AND THE SUV STALLED AND ALMOST CAUSED A WRECK IN HEAVY TRAFFIC. SPEED WAS AROUND 30 MILES PER HOUR. I WENT ONLINE AND DISCOVERED THAT THERE HAD BEEN A RECALL FOR THE 2007 DODGE NITRO WITH THE VERY SAME PROBLEM BUT I HAVE BEEN TOLD MINE WAS NOT COVERED UNDER THE RECALL BY MY LOCAL CHRYSLER DODGE DEALERSHIP. DO I HAVE ANY RECOURSE? I WAS TOLD THERE WERE TWO OTHER RECALLS RELATED TO MY VEHICLE AFTER I PROVIDED MY VIN AND THEN DURING ANOTHER CONVERSATION I WAS TOLD THERE WAS ONLY ONE. A TRIP TO MY MECHANIC INDICATED THAT THERE WERE NO CODES SHOWING UP WHEN HE CHECKED IT WITH HIS METER. I PURCHASED MY NITRO FROM ANOTHER INDIVIDUAL AND THE WARRANTY WAS STILL ON IT AS IT ONLY HAD 16,000 MILES ON IT. IT CURRENTLY HAS ABOUT 57,000 MILES ON IT. *JB
NHTSA ODI #10461815
50,000 miles · May 22, 2012
Fuel/propulsion System
WHEN FUELING THE CAR, THE AUTO SHUTOFF DOES NOT WORK AND FUEL SPEWS OUT OF THE TANK. THIS IS MOST LIKELY CAUSED BY A VALVE IN THE GAS TANK THAT IS THERE TO PREVENT AN EXPLOSION IN THE EVENT OF A ROLLOVER ACCIDENT. THE VALVE IS DEFECTIVE, AND THUS THE GAS SPILLS OUT, AND THE CAR COULD POSSIBLY EXPLODE IN A ROLLOVER ACCIDENT. I …
Read full complaint
WHEN FUELING THE CAR, THE AUTO SHUTOFF DOES NOT WORK AND FUEL SPEWS OUT OF THE TANK. THIS IS MOST LIKELY CAUSED BY A VALVE IN THE GAS TANK THAT IS THERE TO PREVENT AN EXPLOSION IN THE EVENT OF A ROLLOVER ACCIDENT. THE VALVE IS DEFECTIVE, AND THUS THE GAS SPILLS OUT, AND THE CAR COULD POSSIBLY EXPLODE IN A ROLLOVER ACCIDENT. I HAD TAKEN IT TO A DEALERSHIP ABOUT A YEAR AGO AND ALL THEY WOULD DO IS CLEAN OUT THE FILTER. THAT DID NOT RESOLVE THE PROBLEM. *TT
NHTSA ODI #10459255
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Illustration