NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
21 reportsClear category filter288,000 miles · Oct 10, 2017
Air BagsPower TrainWheels
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. WHILE DRIVING 35 MPH, ALL FOUR WHEELS LOCKED UP AND THE VEHICLE STALLED. THE CONTACT ALSO STATED THAT THE DRIVER SIDE, PASSENGER SIDE, REAR DRIVER SIDE, AND REAR PASSENGER SIDE AIR BAGS DEPLOYED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. T…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. WHILE DRIVING 35 MPH, ALL FOUR WHEELS LOCKED UP AND THE VEHICLE STALLED. THE CONTACT ALSO STATED THAT THE DRIVER SIDE, PASSENGER SIDE, REAR DRIVER SIDE, AND REAR PASSENGER SIDE AIR BAGS DEPLOYED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DID NOT RECEIVE NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 13V121000 (POWER TRAIN, AIR BAGS, STRUCTURE). THE CONTACT BELIEVED THAT THE RECALL NOTIFICATION WAS SENT TO THE OWNER FROM WHOM HE BOUGHT THE VEHICLE. THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS CONTACTED AT 800-247-9753 AND STATED THAT THEY WOULD NOT REPAIR THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 288,000. *LN CONSUMER STATED AIR BAGS, POWER TRAIN BROKE, 4 WHEELS LOCKED UP. UPDATED 7/25/18*JB
NHTSA ODI #11032647
2,350,000 miles · Sep 17, 2017
Air BagsPower TrainUnknown Or OtherInjury
WE WERE DRIVING LIKE EVERY MORNING TO OUR WORK AND WHEN WE TRY TO PASS THE INTERSECTION WE HAVE TO STOP ON A YIELD SIGN TO LET THE OTHER TRAFFIC PASS. WHEN I TRY TO HIT THE ACCELERATE ALL THE LATERAL AIR BAGS EXPLODED WITHOUT REASON AND THE1ST THING WE THOUGHT WAS THAT SOMEONE HIT US. I TRY TO MOVE THE CAR AND THE CAR WASN'T RUN…
Read full complaint
WE WERE DRIVING LIKE EVERY MORNING TO OUR WORK AND WHEN WE TRY TO PASS THE INTERSECTION WE HAVE TO STOP ON A YIELD SIGN TO LET THE OTHER TRAFFIC PASS. WHEN I TRY TO HIT THE ACCELERATE ALL THE LATERAL AIR BAGS EXPLODED WITHOUT REASON AND THE1ST THING WE THOUGHT WAS THAT SOMEONE HIT US. I TRY TO MOVE THE CAR AND THE CAR WASN'T RUNNING AT ALL ALSO I CANNOT STOP IT SO I HAVE TO TURN IN OFF. WE GO OUT OF THE CAR TO SEE IF WE GOT HIT BUT THE CAR DIDN'T HAVE ANYTHING SO WE TRY TO SEE UNDER THE CAR AND ALL THE DRIVE SHAFT WAS CRACKED IN HALF! THE SHERIFFS COME TO THE SCENE AND THEY CAN'T BELIEVE THAT THE CAR WAS IN THAT CONDITION IF WE DIDN'T HAVE A WRECK OR ANYTHING! THEY SAY THAT EVERYTHING LOOKS LIKE A SAFETY RECALL, WE DID A RESEARCH ONLINE AND WAS RIGHT MY CAR HAS A SAFETY RECALL SINCE 2013 AND THEY NEVER SEND ME A LETTER OR CALL ME TO LET ME KNOW ABOUT IT! I DROVE THAT CAR EVERYDAY TO WORK,TO PICK UP MY KIDS FROM SCHOOL ETC..ETC.. AND I CAN'T BELIEVE WHAT HAPPENED I COULD DIE IF MY CAR WASN'T STOP! I WAS VERY LUCKY THAT I WAS ON A YIELD SIGN WHEN EVERYTHING HAPPEN. NOW MY CAR INSURANCE DIDN'T WANT TO PAY ANYTHING BECAUSE THEY FOUND OUT ABOUT THE RECALL AND TOLD ME THAT THE AGENCY HAS TO PAY FOR EVERYTHING BECAUSE THAT WAS A MANUFACTURER PROBLEM! BUT THE DODGE DON'T WANT TO PAY OR FIX ANYTHING THEY ALSO HAVE THE NERVE TO TOLD ME THAT MY CAR DIDN'T HAD A SAFETY RECALL AT ALL EVEN WHEN THE MOPAR PAGE SAY THAT MY CAR DID HAD A RECALL! NOW I'M WITHOUT CAR AND DEALING WITH THE EXPENSES OF TOWING MY CAR ETC..ETC..
NHTSA ODI #11023862
66,685 miles · Feb 3, 2015
EnginePower TrainService Brakes
WHEN BACKING UP VEHICLE HESITATES . WHEN SPEEDING UP ON THE HIGHWAY VEHICLE BUMPS LIKE TRANSMISSION IS COMING OUT OF CASE LIKE IT IS PUSHING CAR FORWARD. WHEN STOPPING AT HIGH SPEEDS VEHICLE STEERING WHEEL SHAKES AND CAR SQUEALS COMING FROM LEFT FRONT BRAKES. WHILE DRIVING DOWN THE ROAD VEHICLE PULLS TO THE RIGHT. WHEN AT A STOP…
Read full complaint
WHEN BACKING UP VEHICLE HESITATES . WHEN SPEEDING UP ON THE HIGHWAY VEHICLE BUMPS LIKE TRANSMISSION IS COMING OUT OF CASE LIKE IT IS PUSHING CAR FORWARD. WHEN STOPPING AT HIGH SPEEDS VEHICLE STEERING WHEEL SHAKES AND CAR SQUEALS COMING FROM LEFT FRONT BRAKES. WHILE DRIVING DOWN THE ROAD VEHICLE PULLS TO THE RIGHT. WHEN AT A STOP LIGHT RPMS GO ALL THE WAY DOWN LIKE VEHICLE IS READY TO STALL. *TR
NHTSA ODI #10680760
100,000 miles · Oct 23, 2013
Power TrainFire
OUR 2007 DODGE NITRO HAS A RECALL ON IT (N10) I HAVE BEEN TRYING TO GET IT FIXED SINCE LATE JUNE/2013 TO EARLY JULY/2013 WITH NO PREVAIL IT IS MAKING A HORRIBLE NOISE AND GET WORSE AS TIME GOES ON. I HAVE CALLED CHRYSLER RECALL DEPARTMENT ASKING TO GET A LOANER UNTIL THE PARTS ARE AVAILABLE TO FIX THIS PROBLEM BECAUSE I HAVE BE…
Read full complaint
OUR 2007 DODGE NITRO HAS A RECALL ON IT (N10) I HAVE BEEN TRYING TO GET IT FIXED SINCE LATE JUNE/2013 TO EARLY JULY/2013 WITH NO PREVAIL IT IS MAKING A HORRIBLE NOISE AND GET WORSE AS TIME GOES ON. I HAVE CALLED CHRYSLER RECALL DEPARTMENT ASKING TO GET A LOANER UNTIL THE PARTS ARE AVAILABLE TO FIX THIS PROBLEM BECAUSE I HAVE BEEN ADVISED THAT IT IS VERY DANGEROUS TO DRIVE.THIS IS MY ONLY MEANS OF TRANSPORTATION. EVERYTIME I CALL THE DEALERSHIP THEY SAY THEY ARE STILL WAITING ON THE PARTS TO REPAIR IT.ANY SUGGESTIONS ON WHAT TO DO NEXT WOULD BE GREATLY APPRECIATED. KIND REGARD [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10549294
Mileage unknown · Sep 23, 2013
Air BagsPower TrainStructure
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF T…
Read full complaint
TL* THE CONTACT OWNS A 2007 DODGE NITRO 4X2. THE CONTACT STATED THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 13V121000 (AIR BAGS , POWER TRAIN , STRUCTURE) AND THE PART WAS UNAVAILABLE. THE DEALER WAS UNABLE TO PROVIDE AN EXPECTED DATE FOR THE REMEDY PART TO BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE CONTACT HAD NOT EXPERIENCED ANY FAILURES. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10545010
Mileage unknown · Aug 20, 2013
Power TrainStructure
I AM LIVING IN PUERTO RICO AND I HAVE A 2007 DODGE NITRO, WHICH HAS A RECALL, UNDER BODY TRANSMISSION TUNNEL SHIELD 05/24/2013 INCOMPLETE I WENT TO CABRERA MOTORS WHERE I PURCHASED THE CAR SO I CAN GET THE RECALL FIXED. I WENT ON JULY 11, 2013, AND WAS TOLD THE PART WOULD BE IN 2 WEEKS. HERE WE ARE AUGUST 20, 2013 AND STI…
Read full complaint
I AM LIVING IN PUERTO RICO AND I HAVE A 2007 DODGE NITRO, WHICH HAS A RECALL, UNDER BODY TRANSMISSION TUNNEL SHIELD 05/24/2013 INCOMPLETE I WENT TO CABRERA MOTORS WHERE I PURCHASED THE CAR SO I CAN GET THE RECALL FIXED. I WENT ON JULY 11, 2013, AND WAS TOLD THE PART WOULD BE IN 2 WEEKS. HERE WE ARE AUGUST 20, 2013 AND STILL NO PART. I'VE CALLED MANY TIMES AND EVERY TIME I CALL I'M TOLD THE PART IS NOT IN. I NEED MY VEHICLE TO MOVE AND I HAVE MY FAMILY IN IT. IF A CAR IS RECALLED IT IS DUE TO A SAFETY CONCERN. PLEASE HELP. *TR
NHTSA ODI #10536251
81,700 miles · Dec 7, 2012
EnginePower Train
ON DECEMBER 06, 2012 WAS STOPPED AT A RED LIGHT. LIGHT TURNED GREEN AND I PROCEEDED TO ACCELERATE, I THEN HEAR A LOUD THUMP AND VEH SHUT DOWN. I LOOKED UNDER THE VEH ONLY TO FIND THAT MY DRIVE SHAFT HAD EXPLODED AND BROKE IN TWO, FALLING TO THE ROADWAY. LOOKED LIKE A BOMB WENT OFF UNDER MY VEH. SEE THAT THIS IS S RECURRING PROB…
Read full complaint
ON DECEMBER 06, 2012 WAS STOPPED AT A RED LIGHT. LIGHT TURNED GREEN AND I PROCEEDED TO ACCELERATE, I THEN HEAR A LOUD THUMP AND VEH SHUT DOWN. I LOOKED UNDER THE VEH ONLY TO FIND THAT MY DRIVE SHAFT HAD EXPLODED AND BROKE IN TWO, FALLING TO THE ROADWAY. LOOKED LIKE A BOMB WENT OFF UNDER MY VEH. SEE THAT THIS IS S RECURRING PROBLEM WITH THIS MODEL. WHY IS THEIR NO RECALL??? IF I WERE GOING AT ST HIGHER RATE OF SPEED COULD OF RESULTED IN INJURY OR LOST OF LIFE. WHY IS DODGE NOT TAKING RESPONSIBILITY?? *TR
NHTSA ODI #10487728
81,700 miles · Dec 6, 2012
Electrical SystemPower Train
WAS STOPPED AT A RED LIGHT AND WHEN TURNED GREEN PRESSED GAS AND THE DRIVE TRAIN EXPLODED UPWARDS. DRIVE TRAIN COMPLETELY MANGLED. IF WERE GOING DOWN ROAD LIKELY COULD OF GOT KILLED ALONG WITH MY DAUGHTER. DODGE NOT TAKING RESPONSIBILITY. BROUGHT TO ACADIANA DODGE IN LAFAYETTE, LA. *TR
NHTSA ODI #10487575
60,000 miles · Jul 17, 2012
Power Train
I WAS DRIVING AT 45PH AND ALL OF A SUDDEN MY CARS WHEELED LOCKED UP AND I CAME TO A SUDDEN STOP WITH MY WHEELS LAYING DOWN RUBBER BUT I DID NOT CRASH. WHEN MY CAR WAS TOWED TO THE GARAGE THE CONCLUSION WAS THAT THE REAREND SEAL WAS LEAKING AND ALL THE FLUID CAME OUT OF THE REAREND AND THE GEARS LOCKED UP. *TR
NHTSA ODI #10465923
86,000 miles · Dec 29, 2011
Power Train
ABOUT THREE WEEKS AGO ON 05 DECEMBER 2011, I WAS DRIVING MY 2007 DODGE NITRO 4X2 UNTIL I CAME TO A STOP AT A RED TRAFFIC LIGHT. I HAD MY BLINKER ON AND WAS READY TO MAKE A RIGHT TURN AS SOON AS THE LIGHT TURNED GREEN. WHEN THE LIGHT TURNED GREEN I LIGHTLY STEPPED ON THE ACCELERATOR WHEN A LOUD EXPLOSION WAS HEARD AND FELT IN T…
Read full complaint
ABOUT THREE WEEKS AGO ON 05 DECEMBER 2011, I WAS DRIVING MY 2007 DODGE NITRO 4X2 UNTIL I CAME TO A STOP AT A RED TRAFFIC LIGHT. I HAD MY BLINKER ON AND WAS READY TO MAKE A RIGHT TURN AS SOON AS THE LIGHT TURNED GREEN. WHEN THE LIGHT TURNED GREEN I LIGHTLY STEPPED ON THE ACCELERATOR WHEN A LOUD EXPLOSION WAS HEARD AND FELT IN THE VEHICLE UNDERCARRIAGE. THE VEHICLE'S DRIVE SHAFT HAD EXPLODED UPWARDS, HITTING THE UNDERCARRIAGE AND THEN DROPPING TO THE FLOOR. THE VEHICLE LOST COMPLETE POWER AND STOPPED IMMEDIATELY AFTER THE DRIVELINE FELL OFF. MY DAUGHTER AND NIECE FELT THE HIT IN GREATER MAGNITUDE AS THEY WERE SITTING IN THE BACK SEAT. MY INSURANCE COVERED THE WRECKER AND TRANSPORTED THE VEHICLE TO THE NEAREST DODGE DEALERSHIP. THE DEALERSHIP DIAGNOSED THE PROBLEM AS A FAULTY HEATSHIELD THAT FELL OFF THE UNDERCARRIAGE AND WAS RUBBING AGAINST THE ALUMINUM DRIVESHAFT. SINCE THE HEATSHIELD IS MADE OF ALUMINUM AND FIBERGLASS, THE RUBBING OF ALUMINUM AGAINST ALUMINUM HAS A CUTTING EFFECT THAT CAUSED THE DRIVESHAFT TO CUT OPEN AND THEN EXPLODE CUTTING IT IN HALF. LUCKILY, I WAS MAKING A TURN GOING NO MORE THAN 10 TO 15 MILES AN HOUR. HAD I BEEN DRIVING ON A HIGHWAY THIS ISSUE WOULD HAVE LIKELY CAUSED A FATAL AND CATASTROPHIC ACCIDENT. THERE IS NO RECALL THAT I KNOW OF. MY EXTENDED WARRANTY DOES NOT COVER THE REPAIR AS IT IS NOT COVERED UNDER THE POLICY. MY CAR INSURANCE DOES NOT COVER THE REPAIRS AS IT IS CONSIDERED A MECHANICAL FAILURE AND NOT A COLLISION. DODGE SHOULD CONDUCT AN INVESTIGATION ON THE CAUSE OF THE HEATSHIELD COMING OFF FROM THE UNDERCARRIAGE, AND RECALL VEHICLES TO PREVENT ANY FUTURE CATASTROPHIC EVENTS. *KB
NHTSA ODI #10441649
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
PE07027 · Engine Stalling & Electric Power Loss
Opened May 29, 2007 · Closed Aug 2, 2007
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling; Power Train:automatic Transmission; Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Additional source detail variants (4)
Electrical System
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Engine And Engine Cooling
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:automatic Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Power Train:manual Transmission
ON JULY 3, 2007, DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA DESCRIBING A DEFECT THAT COULD RESULT IN ENGINE STALL WHILE DRIVING IN APPROXIMATELY 80,894 MODEL YEAR (MY) 2007 JEEP WRANGLER AND DODGE NITRO VEHICLES MANUFACTURED BETWEEN JANUARY 30, 2006 AND JANUARY 22, 2007 (NHTSA RECALL 07V-291, DCC RECALL G25).ACCORDING TO DCC, THE TOTALLY INTEGRATED POWER MODULE (TIPM) IN THESE VEHICLES WAS PROGRAMMED WITH SOFTWARE THAT MAY ALLOW THE ENGINE TO STALL UNDER CERTAIN CONDITIONS.DCC WILL REPROGRAM THE TIPM IN THE RECALLED VEHICLES WITH REVISED SOFTWARE. ODI OPENED PE07-027 ON MAY 29, 2007, BASED ON 53 COMPLAINTS ALLEGING ENGINE STALL AND/OR LOSS OF ELECTRICAL POWER IN MY 2007 JEEP WRANGLER VEHICLES.ODI WAS ALSO MONITORING SIMILAR COMPLAINTS IN MY 2007 DODGE NITRO VEHICLES.DCC'S ANALYSIS OF COMPLAINTS TO DCC AND NHTSA FOUND THAT MANY DESCRIBED EVENTS WITH A MOMENTARY LOSS OF ELECTRICAL POWER INSIDE THE VEHICLE AND A CORRESPONDING LOSS OF ENGINE POWER.MANY OF THE REPORTS ALSO INDICATED THAT THE INSTRUMENT CLUSTER TELLTALE LAMPS MOMENTARILY ILLUMINATED DURING THE EVENT. DCC'S ENGINEERING ANALYSIS DETERMINED THAT THE TIPM COULD INITIATE AN INTERNAL RESET CYCLE LASTING APPROXIMATELY 75 MS IN RESPONSE TO ERROR MESSAGES ON THE COMMUNICATION BUS.THE KEY ON SIGNAL FROM THE TIPM TO THE POWERTRAIN CONTROL MODULE (PCM) IS LOST DURING A TIPM RESET.IF THE PCM LOSES THE KEY ON SIGNAL FOR LONGER THAN 40 MS, IT INTERPRETS IT AS THE VEHICLE IGNITION BEING TURNED OFF AND BEGINS A POWER DOWN ROUTINE.AFTER THE TIPM RESET, THE KEY ON SIGNAL IS RESTORED AND THE PCM POWERS BACK UP.IF THE ROTATING COMPONENTS OF THE ENGINE CONTAIN SUFFICIENT INERTIA, THE VEHICLE MAY RESTART WITH NO INPUT FROM THE OPERATOR AS REPORTED IN SOME OF THE COMPLAINTS.IF THE ENGINE DOES NOT RESTART IN THIS MANNER, IT CAN BE RESTARTED BY THE OPERATOR.A REVISION TO THE TIPM SOFTWARE ON JANUARY 22, 2007 CHANGED THE TIPM RESET TIME TO 17 MS, REMOVING THE POTENTIAL FOR PCM POWER DOWN AND ENGINE STALL. ODI HAS RECEIVED 178 COMPLAINTS POTENTIALLY RELATED TO THE ALLEGED DEFECT IN MY 2007 JEEP WRANGLER VEHICLES AND 52 COMPLAINTS INVOLVING MY 2007 DODGE NITRO VEHICLES.TWO OF THE NITRO COMPLAINTS ALLEGE THAT A CRASH RESULTED FROM AN ENGINE STALL INCIDENT, ONE OF WHICH CAUSED MINOR INJURIES TO A PASSENGER.AS OF JUNE 1, 2007, DCC IDENTIFIED 151 WRANGLER COMPLAINTS AND 128 NITRO COMPLAINTS. THIS INVESTIGATION HAS BEEN CLOSED WITH DCC'S RECALL.
Illustration