NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
173 reports76,328 miles · Jan 17, 2007
Power Train
VEHICLE HAS CONTINUED TO IDLE HARD AFTER TRANSMISSION REPLACEMENT IN NOV OF 2004. VEHICLE HAS STARTED TO STALL WHEN STOPPED. ON DATE OF INCIDENT, OWNER WAS DRIVING VEHICLE HOME IN A 55 MPH ZONE. VEHICLE MADE A SCREECHING NOISE, CHECK ENGINE LIGHT CAME ON, AND VEHICLE STARTED TO SPUTTER. TRANSAXLE HAD TO BE REPLACED TWICE (FI…
Read full complaint
VEHICLE HAS CONTINUED TO IDLE HARD AFTER TRANSMISSION REPLACEMENT IN NOV OF 2004. VEHICLE HAS STARTED TO STALL WHEN STOPPED. ON DATE OF INCIDENT, OWNER WAS DRIVING VEHICLE HOME IN A 55 MPH ZONE. VEHICLE MADE A SCREECHING NOISE, CHECK ENGINE LIGHT CAME ON, AND VEHICLE STARTED TO SPUTTER. TRANSAXLE HAD TO BE REPLACED TWICE (FIRST ONE SHIPPED FROM MANU WAS DEFECTIVE). *NM
NHTSA ODI #10178928
34,000 miles · Jan 17, 2007
Power Train
VEHICLE HAD IDLED HARD SINCE PURCHASE. TAKEN TO LOCAL DEALERSHIP NUMEROUS TIMES FOR KNOCKING SOUND ON START UP OF VEHICLE EVERY MORNING. OWNER WAS TOLD THAT SOUND COULD NOT BE DUPLICATED. ON DATE OF INCIDENT, VEHICLE STARTED JERKING IN AND OUT OF GEAR ON HIGHWAY. LOUD WHINE STARTED AND INCREASED WITH ACCELERATION. OWNER PUL…
Read full complaint
VEHICLE HAD IDLED HARD SINCE PURCHASE. TAKEN TO LOCAL DEALERSHIP NUMEROUS TIMES FOR KNOCKING SOUND ON START UP OF VEHICLE EVERY MORNING. OWNER WAS TOLD THAT SOUND COULD NOT BE DUPLICATED. ON DATE OF INCIDENT, VEHICLE STARTED JERKING IN AND OUT OF GEAR ON HIGHWAY. LOUD WHINE STARTED AND INCREASED WITH ACCELERATION. OWNER PULLED VEHICLE TO THE SHOULDER AND GOT OUT TO TRY TO LOCATE SOURCE OF SOUND. WHEN OWNER TRIED TO PUT CAR BACK INTO GEAR, GEAR SHIFT MOVED BUT DID NOT ENGAGE. TRANSMISSION HAD TO BE REPLACED. *NM
NHTSA ODI #10178924
49,824 miles · Dec 21, 2006
Power Train
DRIVING AT 49.9K MILES ON THE ODOMETER. THIS BEING 19.9K MILES AFTER WARRANTY EXPIRES (30K MILE WARRANTY). JUST MADE A LONG TRIP FROM HAMPTON, VA TO APPLETON, WI. ABOUT A WEEK AFTER ARRIVING IN WI, I AM HEADING TO WORK AND START TO HEAR A HIGH-PITCHED WHINE. WITHIN ABOUT 10 MINUTES OF HEARING THIS WHINE, I WAS ABLE TO PULL I…
Read full complaint
DRIVING AT 49.9K MILES ON THE ODOMETER. THIS BEING 19.9K MILES AFTER WARRANTY EXPIRES (30K MILE WARRANTY). JUST MADE A LONG TRIP FROM HAMPTON, VA TO APPLETON, WI. ABOUT A WEEK AFTER ARRIVING IN WI, I AM HEADING TO WORK AND START TO HEAR A HIGH-PITCHED WHINE. WITHIN ABOUT 10 MINUTES OF HEARING THIS WHINE, I WAS ABLE TO PULL INTO A PARK AND RIDE JUST AS THE CAR STOPPED MOVING. I WAS STILL ABLE TO REV THE ENGINE, BUT NO ACCELERATION. I PLACED THE CAR INTO PARK AND TURNED IT OFF. I STARTED IT BACK UP, AND STILL COULD NOT GET THE CAR TO MOVE. PLACED THE CAR INTO NEUTRAL, AND THE CAR STILL WOULD NOT MOVE WHEN I TRIED TO PUSH IT. FOUND OUT, AFTER CAR WAS TOWED TO AN AUTO SHOP, THAT A PINION BOLT INSIDE THE TRANSMISSION (2002 MODEL) HAD BROKEN OFF AND WAS THE CAUSE TO THE SEIZURE OF THE VEHICLE. IF I HAD BEEN DRIVING DOWN THE HIGHWAY, AND THIS HAD HAPPENED, THE CAR WOULD HAVE STOPPED IN THE MIDDLE OF THE HIGHWAY AND BEEN THE CAUSE OF A SERIOUS ACCIDENT THAT, THANKFULLY, WAS AVOIDED IN THIS INSTANCE. NEW TRANSMISSION (2006 MODEL) INSTALLED. THE NEW SAFETY FEATURE FOR THIS MODEL IS THAT IT HAS METAL PLATES (BRACKETS) AROUND THE OFFENDING BOLT SO THAT THIS DOES NOT HAPPEN. SEMI-OFF TOPIC: IF THEY (THE MANUFACTURES OF THE TRANSMISSION, AND SUBSEQUENTLY THE DEALERSHIPS THAT SELL THE VEHICLE) KNEW THIS WAS AN ISSUE (APPARENT FROM THE INTRODUCTION OF THE METAL PLATES FOR THE BOLT) WHY WAS IT NOT ANNOUNCED AND CORRECTED WHILE UNDER WARRANTY FOR THOSE THAT HAVE BOUGHT THE VEHICLE IN 2002? *JB
NHTSA ODI #10176776
50,000 miles · Dec 12, 2006
StructureUnknown Or Other
TRUNK LEAKS WITH WATER COLLECTING IN THE SPARE TIRE WELL. *JB
NHTSA ODI #10175908
9,800 miles · Dec 6, 2006
Structure
DT*: THE CONTACT STATED THE PLASTIC ADJUSTING VENT FOR THE HEAT APPEARED TO HAVE BEEN GNAWED ON, AND THE AIR COMING OUT SMELLED LIKE FECES. THE CONTACT ASCERTAINED THAT A MOUSE HAD GOTTEN IN TO THE VENTILATION SYSTEM OF THE VEHICLE THROUGH THE SPACE WHERE THE WIPER POST PROTRUDED THROUGH THE TOP OF THE HOOD. THE CONTACT EXPRES…
Read full complaint
DT*: THE CONTACT STATED THE PLASTIC ADJUSTING VENT FOR THE HEAT APPEARED TO HAVE BEEN GNAWED ON, AND THE AIR COMING OUT SMELLED LIKE FECES. THE CONTACT ASCERTAINED THAT A MOUSE HAD GOTTEN IN TO THE VENTILATION SYSTEM OF THE VEHICLE THROUGH THE SPACE WHERE THE WIPER POST PROTRUDED THROUGH THE TOP OF THE HOOD. THE CONTACT EXPRESSED A CONCERN THAT THE MOUSE COULD HAVE CHEWED THROUGH THE WIRES IF GIVEN THE CHANCE. THE MAIN CONCERN WAS THAT THE VEHICLE WAS NOT SECURED FROM THE FORCES OF NATURE. THE VEHICLE WAS NOT SEEN BY A DEALER, HOWEVER THE MANUFACTURER WAS NOTIFIED.
NHTSA ODI #10175333
66,640 miles · Nov 17, 2006
SuspensionWheelsCrash
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH ON NORMAL RURAL ROADS, THE VEHICLE UNEXPECTEDLY VEERED TO THE LEFT HITTING A SCHOOL BUS AND BANKING OFF THE ROAD. THE DRIVER SIDE WHEEL SNAPPED OFF THE AXEL CAUSING A LOSS OF STEERING CONTROL. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR THE INCIDENT. THERE WAS A POLICE REPORT TA…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 45 MPH ON NORMAL RURAL ROADS, THE VEHICLE UNEXPECTEDLY VEERED TO THE LEFT HITTING A SCHOOL BUS AND BANKING OFF THE ROAD. THE DRIVER SIDE WHEEL SNAPPED OFF THE AXEL CAUSING A LOSS OF STEERING CONTROL. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR THE INCIDENT. THERE WAS A POLICE REPORT TAKEN AND NO INJURIES WERE SUSTAINED. PRIOR TO THE ACCIDENT, THE CONTACT NOTICED SHAKING ON THE FRONT END OF THE VEHICLE. IT WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO PERFORMED TIRE BALANCING AND ROTATION. AS THE SHAKING PERSISTED, THE MANUFACTURER WAS CONTACTED, WHO REFERRED THE CONTACT TO A DEALERSHIP. THE DEALERSHIP RECOMMENDED A COMPLETE WHEEL ALIGNMENT. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHO PERFORMED THE ALIGNMENT AND THE SHAKING DISAPPEARED. THE ACCIDENT OCCURRED A FEW MILES AFTER THE VEHICLE HAD THE ALIGNMENT PERFORMED.
NHTSA ODI #10173740
Mileage unknown · Nov 9, 2006
Engine And Engine CoolingPower Train
DT*: THE CONTACT STATED THAT WHILE TRAVELING 60 MPH ON NORMAL ROAD CONDITIONS AND MAKING A RIGHT TURN A LOUD POPPING SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE AXLE WAS BROKEN. THIS MANUFACTURES DEFECT CAUSED PROBLEMS WITH THE CB UNIT AND THE ENGINE COMPUTER UNIT. THE VEHICLE WAS …
Read full complaint
DT*: THE CONTACT STATED THAT WHILE TRAVELING 60 MPH ON NORMAL ROAD CONDITIONS AND MAKING A RIGHT TURN A LOUD POPPING SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE AXLE WAS BROKEN. THIS MANUFACTURES DEFECT CAUSED PROBLEMS WITH THE CB UNIT AND THE ENGINE COMPUTER UNIT. THE VEHICLE WAS TAKEN TO A DEALER PRIOR TO THIS INCIDENT WHERE THE CB UNIT WAS REPLACED. THE PROBLEMS STILL PERSISTS. THE VEHICLE WAS AWAITING A PART TO ARRIVE FOR THE INDEPENDENT MECHANIC TO PERFORM A REPLACEMENT. THERE WERE NO RECALL NOR COMPLAINT FOUND ON THIS PROBLEM. UPDATED 12/05/06. *JB
NHTSA ODI #10173021
48,000 miles · Oct 31, 2006
Power Train
DT*: THE CONTACT STATED WHILE DRIVING 60 MPH ON NORMAL ROAD CONDITIONS, THE FRONT PASSENGER AXLE FRACTURED. THERE WAS A NOISE PRIOR TO THE FAILURE. THE NATURE OF THE FAILURE WAS GRADUALLY WORSENING. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO CHANGED THE AXLE, BUT AFTER A YEAR THE AXLE FRACTURED AGAIN. *AK
NHTSA ODI #10172267
22,351 miles · Aug 24, 2006
Service Brakes, Hydraulic
VEHICLE 2002 DODGE NEON 22,351 MILES ON VEHICLE. WHILE MY WIFE WAS BACKING OUT OF GARAGE THE BRAKES FAILED. THREE PIECES OF FRONT DISK BRAKE PADS WERE FOUND LYING ON THE GARAGE FLOOR (STILL IN MY POSSESSION). BOTH FRONT INSIDE DISK PADS APPEARED TO HAVE BROKEN IN HALF. UPON CHECKING THE FRONT BRAKES I FOUND NO PADS IN PLACE …
Read full complaint
VEHICLE 2002 DODGE NEON 22,351 MILES ON VEHICLE. WHILE MY WIFE WAS BACKING OUT OF GARAGE THE BRAKES FAILED. THREE PIECES OF FRONT DISK BRAKE PADS WERE FOUND LYING ON THE GARAGE FLOOR (STILL IN MY POSSESSION). BOTH FRONT INSIDE DISK PADS APPEARED TO HAVE BROKEN IN HALF. UPON CHECKING THE FRONT BRAKES I FOUND NO PADS IN PLACE ON THE LEFT INSIDE OF THE BRAKE AND ONLY ONE HALF OF THE BRAKE PAD ON THE INSIDE OF THE RIGHT BRAKE WHICH WAS STILL WITH THE VEHICLE, OBVIOUSLY THE REST OF THE PADS WERE ON THE FLOOR OF MY GARAGE. MY WIFE WAS SHAKEN BUT THANKFUL THAT SHE WASN'T DRIVING IN TRAFFIC WHEN THE BRAKE PADS FELL OFF THE CAR. THE VEHICLE HAD TO BE TOWED TO JOE CECCONI"S CHRYSLER TO HAVE NEW FRONT BRAKES PUT ON THE VEHICLE. I FEEL THAT THIS WAS EITHER A DEFECT IN THE BRAKE PADS OR A FAULTY ENGINEERING DESIGN AND BECAUSE OF THE SERIOUSNESS OF THE CONSEQUENCES THAT COULD HAVE RESULTED I FELT THAT THIS INCIDENT SHOULD BE REPORTED. I'M ALSO SENDING A LETTER TO CHRYSLER IN REGARDS TO THIS MATTER. *JB
NHTSA ODI #10166464
Mileage unknown · Aug 18, 2006
Service Brakes, Hydraulic
2002 DODGE NEON CALIPERS ARE TILTED ON TOP OF THE ROTOR CAUSING WEAR. MECHANIC REPLACED ROTORS. *KB THE DEALER TOLD THE CONSUMER THE PROBLEM WAS DUE TO THE VEHICLE NOT BEING DRIVEN ENOUGH.*JB
NHTSA ODI #10166893
NHTSA investigations
3EA06019 · Headlight Failure
Opened Nov 22, 2006 · Closed Nov 7, 2007
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (4)
Exterior Lighting:fog Lights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:fog Lights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Exterior Lighting:headlights:switch
THIS EA WAS OPENED AFTER RECEIVING REPORTS THAT THE MULTIFUNCTION SWITCH ON THESE VEHICLES WOULD FAIL, CAUSING A LOSS OF HEADLIGHT ILLUMINATION.SOME COMPLAINANTS REPORT LOSS OF HEADLIGHT FUNCTION WHILE FOR OTHERS TEMPORARY LIGHTING WAS AVAILABLE BY PULLING ON THE MULTIFUNCTION SWITCH STALK TO ILLUMINATE HIGH BEAM LIGHTING.ANALYSIS OF THE COMPLAINT AND WARRANTY DATA SHOW A LOW AND DECLINING FAILURE TREND.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE06028 · Headlight Failure
Opened Jul 28, 2006 · Closed Nov 22, 2006
Status: closed (inferred from source dates) · Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Additional source detail variants (4)
Exterior Lighting:fog Lights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:fog Lights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
Exterior Lighting:headlights:switch
ODI HAS REVIEWED COMPLAINTS FROM CONSUMERS STATING THAT THEY DO NOT HAVE HEADLIGHT FUNCTION WHILE OPERATING THEIR VEHICLE.THE REPORTS INDICATE THAT A LOSS OF BOTH HIGH AND LOW BEAM HEADLIGHTS IS THE RESULT OF PROBLEMS WITH THE VEHICLES MULTIFUNCTION SWITCH AND CONNECTING WIRING HARNESS.CONSUMERSNOTICED THAT THE STEERING COLUMN AREA (WHERE THESE PARTS ARE LOCATED) IS HEATING UP.IN SOME CASES, SMOKE WOULD COME OUT OF THE STEERING COLUMN AREA AND THE PLASTIC TRIM WOULD BEGIN TO MELT.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-019) TO FURTHER STUDY THIS ISSUE.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
Illustration