Electrical SystemEngine And Engine CoolingPower Train
INSTRUMENT CLUSTER LOSES POWER UNEXPLICABLY DURING NORMAL CAR USAGE. POWER IS IMMEDIATLY RESTORED AFTER THE LOSS, HOWEVER IT MAKES VEHICLE DIFFICULT TO DRIVE AT TIMES WHEN ODEMTER IS BEING RESET. EXCESSIVE LEAKAGE IN VEHICLE'S TRUNK AND DRIVER'S SIDE BACK SEAT HAS OCCURED. BOSAK TO FIX AFTER CAR WAS RECENTLY BOUGHT, HOWEVER, …
Read full complaint
INSTRUMENT CLUSTER LOSES POWER UNEXPLICABLY DURING NORMAL CAR USAGE. POWER IS IMMEDIATLY RESTORED AFTER THE LOSS, HOWEVER IT MAKES VEHICLE DIFFICULT TO DRIVE AT TIMES WHEN ODEMTER IS BEING RESET. EXCESSIVE LEAKAGE IN VEHICLE'S TRUNK AND DRIVER'S SIDE BACK SEAT HAS OCCURED. BOSAK TO FIX AFTER CAR WAS RECENTLY BOUGHT, HOWEVER, LEAK NOT COMPLETELY FIXED AND RE-DISCOVERED 1 YEAR LATER. A HOLE WAS DISCOVERED IN THE DRIVERE'S SIDE REAR WHEEL WELL AS A RESULT OF UNEXPLICABLE EXCESSIVE CORROSION. IT WAS ALSO DISCOVERED THAT SEALS WERE BROKED ON DRIVERE'S SIDE DOOR AND WINDOW TRACK WAS GLUED IMPROPERLY CAUSING THE WINDOW AND TRACK TO COME LOOSE. OUT OF POCKET EXPENCES NOT REVOVERED BY DEALERSHIP. ALSO DISCOVERED WAS A SEVERE LEAKE FROM HEAD GASKET. CALLED SEVERAL REPAIR PLACES AND FOUND THE NEON'S HAVE HAD MUCH TROUBLE IN THE PAST.. EXCESSIVE OIL LOSS, AND REPAIRS ARE COSTLY. FRONT ENGINE MOUNT OFF; CAUSING PRESSURE IN TRANSMISSION LINES AND TRANS FLUID LEAKAGE. PLEASE CONTACT ME ASAP ABOUT THE CAR; NEED TO RECOVER COSTS.
NHTSA ODI #720478
Mileage unknown · Mar 18, 2000
Engine And Engine Cooling
THE PAINT ON THIS VEH AND MANY OTHERS IS DEFECTIVE! CHIPPING AND PEELING ALL OVER THE CAR. NO SAFETY DEFECT LISTED WITHIN VEHICLE. *AK
NHTSA ODI #720287
Mileage unknown · Mar 18, 2000
Engine And Engine Cooling
HEAD GASKET LEAKING OIL EVERYWHERE/DEALERSHIP CHARGED ME $600 FOR REPLACING THE DEFECTIVE GASKET. WHY SHOULD I HAVE TO PAY FOR THEIR DEFECTS. *AK
NHTSA ODI #720286
Mileage unknown · Mar 16, 2000
Engine And Engine Cooling
THE ENGINE PART HAS NOT FAILED YET - I'VE BEEN TOLD THE HEAD GASKET IS LEAKING AND CAN GO AT ANY TIME. THAT WAS TOLD TO ME ON THE DATE I WROTE AS 'FAILURE' CHRYLSE SHOULD REPLACE THIS PART WITH THEIR UPDATED PARTS FOR FREE FOR THE CONSUMER. I WANT TO SEE SOMETHING DONE ABOUT THIS AS I HAVE HEARD TOO MANY ACCOUNTS OF THE GASKET G…
Read full complaint
THE ENGINE PART HAS NOT FAILED YET - I'VE BEEN TOLD THE HEAD GASKET IS LEAKING AND CAN GO AT ANY TIME. THAT WAS TOLD TO ME ON THE DATE I WROTE AS 'FAILURE' CHRYLSE SHOULD REPLACE THIS PART WITH THEIR UPDATED PARTS FOR FREE FOR THE CONSUMER. I WANT TO SEE SOMETHING DONE ABOUT THIS AS I HAVE HEARD TOO MANY ACCOUNTS OF THE GASKET GOING AND CHRYLSER NOT DOING ANYTHING FOR THE CONSUMER. *AK
NHTSA ODI #720195
Mileage unknown · Mar 6, 2000
Engine And Engine Cooling
NOTICED LOW ON OIL. OIL WAS LEAKING OUT ON THE ENGINE. TOOK IT TO THE MECHANIC WHO SAID THAT IT WAS AN ENGINE HEAD GASKET PROBLEM. *AK
NHTSA ODI #857994
Mileage unknown · Mar 5, 2000
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
HEAD GASKET FAILED. NLM
NHTSA ODI #551211
Mileage unknown · Mar 3, 2000
Engine And Engine Cooling
ENGINE HEAD GASKET LEAKS AND NEEDS REPAIRS ON MOST IF NOT ALL NEONS FROM WHAT I HEAR. *AK
NHTSA ODI #719612
Mileage unknown · Mar 3, 2000
Engine And Engine Cooling
ENGINE HEAD GASKET OF THE FIRST FEW YEARS OF NEONS ARE KNOWN TO FAIL OFTEN. THIS FAILURE CAN CAUSE ENGINE HEAD TO LEAK OIL AND ANTI-FREEZE. THIS COULD LEAD TO ENGINE FAILURE IF NOT REPAIRED. THE HEAD GASKET FOR NEON'S WAS REDESIGNED AT LEAST ONCE TO FIX THIS DESIGN PROBLEM. IN MY OPINION, THE EARLY NEON HEAD GASKETS SHOULD …
Read full complaint
ENGINE HEAD GASKET OF THE FIRST FEW YEARS OF NEONS ARE KNOWN TO FAIL OFTEN. THIS FAILURE CAN CAUSE ENGINE HEAD TO LEAK OIL AND ANTI-FREEZE. THIS COULD LEAD TO ENGINE FAILURE IF NOT REPAIRED. THE HEAD GASKET FOR NEON'S WAS REDESIGNED AT LEAST ONCE TO FIX THIS DESIGN PROBLEM. IN MY OPINION, THE EARLY NEON HEAD GASKETS SHOULD BE RECALLED TO FIX THIS DEFECT. *AK
NHTSA ODI #719605
Mileage unknown · Mar 2, 2000
Engine And Engine Cooling
THE HEAD GASKET IS A KNOWN PROBLEM THAT DEVELOPS A LEAK AT CYL#4. IT WAS DETECTED WHEN THE ENGINE BEGAN OVERHEATING. A NEW HEAD GASKET WAS DEVELOPED MID 1998 DUE TO THE NUMBER OF PROBLEMS AND WAS USED SUBSEQUENTLY FOR ALL NEW ENGINES AND REPAIRS. *AK
NHTSA ODI #719594
Mileage unknown · Feb 29, 2000
Engine And Engine Cooling
VEHICLE WAS OVERHEATING. LOOKED UNDER THE VEHICLE AND IT WAS BUBBLING. CONSUMER THOUGHT IT WAS SOME COOLANT. VEHICLE WAS TAKEN TO JIFFY LUBE AND COOLANT/OIL CHANGE WAS DONE. TWO DAYS LATER, VEHICLE STARTED RUNNING HOT AND WAS TAKEN TO FIRESTONE. THEY CHECKED THE THERMOSTAT AND NOTICED THAT COOLANT HAD LEAKED ONTO THE SPAR…
Read full complaint
VEHICLE WAS OVERHEATING. LOOKED UNDER THE VEHICLE AND IT WAS BUBBLING. CONSUMER THOUGHT IT WAS SOME COOLANT. VEHICLE WAS TAKEN TO JIFFY LUBE AND COOLANT/OIL CHANGE WAS DONE. TWO DAYS LATER, VEHICLE STARTED RUNNING HOT AND WAS TAKEN TO FIRESTONE. THEY CHECKED THE THERMOSTAT AND NOTICED THAT COOLANT HAD LEAKED ONTO THE SPARK PLUGS. IT WAS TAKEN TO FAST TO JIFF LUBE, PROBLEM IS STILL HAPPPENING. *AK
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence & remedy
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
THE FUEL AND REAR BRAKE TUBES CAN EXPERIENCE ACCELERATED CORROSION BETWEEN THE TUBES AND A RUBBER ISOLATOR.
Consequence: CORROSION OF THE TUBES CAN LEAD TO BRAKE FLUID OR FUEL LEAKAGE. THIS CAN CAUSE A LOSS OF BRAKES OR RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE BRAKE, FUEL SUPPLY AND FUEL VAPOR TUBES FOR THE PRESENCE OF CORROSION. ANY TUBES SHOWING CORROSION WILL BE REPLACED. ALL VEHICLES WILL HAVE THE RUBBER ISOLATOR REPLACED WITH A PLASTIC CLIP.
THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
THE REAR BRAKE HOSE MOUNTING BRACKET SCREWS CAN FAIL ALLOWING THE BRAKE HOSES TO MOVE OUT OF POSITION. THE UNRESTRAINED HOSES ARE THEN SUSCEPTIBLE TO DAMAGE WHICH COULD RESULT IN BRAKE FLUID LEAKAGE.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE WILL REDUCE THE BRAKING PERFORMANCEOF THE VEHICLE, EXTEND STOPPING DISTANCES, AND COULD RESULT IN AN ACCIDENT.
Remedy: THE REAR BRAKE LINE HOSE BRACKET SCREWS ON THESE VEHICLES WILL BE REPLACED.
THE ABS BRAKE MASTER CYLINDER REAR SEAL ALLOWS AIR TO ENTER THE BRAKE SYSTEM, CAUSING SPONGY BRAKES OR PARTIAL BRAKE SYSTEM LOSS.
Consequence & remedy
Consequence: AIR ENTERING THE BRAKE SYSTEM CAUSED EXTENDED STOPPING DISTANCE OR PARTIAL LOSS OF BRAKES WHICH MAY RESULT IN AN ACCIDENT.
Remedy: MASTER CYLINDERS WILL BE INSPECTED FOR THE SUSPECT BUILD DATE CODE RANGE AND WILL BE REPLACED IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE02082 · Safety Belt Cinching Latch Plate
Opened Nov 6, 2002 · Closed Apr 23, 2003
Status: closed (inferred from source dates) · Seat Belts
THERE ARE NO INJURIES OR FATALITIES ASSOCIATED WITH THIS ALLEGED DEFECT.WHILE CONDUCTING THIS INVESTIGATION, ODI FOUND THAT THE SUBJECT CINCHES MEET THE LOAD BEARING REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 208, AND THAT MANY OF THE REPORTED FAILURES WERE DUE TO INCORRECT CHILD SAFETY SEAT INSTALLATIONS. ADDITIONALLY, THE REPORT RATE IS LOW (1.60/100K).THE INFORMATION AVAILABLE FAILS TO ESTABLISH THE EXISTENCE OF A DEFECT TREND AT THIS TIME.FURTHER ALLOCATION OF AGENCY RESOURCES TO THIS ISSUE IS UNWARRANTED AND THE PRELIMINARY EVALUATION IS BEING CLOSED.
PE98012 · Underhood Fires
Opened Feb 26, 1998 · Closed Jun 23, 1998
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
EA98003 · Oversensitive Air Bag Deployments
Opened Jan 30, 1998 · Closed Jan 5, 2000
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
PE97042 · Oversensitive Air Bag Deployment
Opened Sep 21, 1997 · Closed Jan 30, 1998
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available
EA97009 · Loss Of Steering Control
Opened Apr 30, 1997 · Closed Oct 8, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE97007 · Alleged Fires In Steering Column Area
Opened Jan 31, 1997 · Closed Apr 7, 1997
Status: closed (inferred from source dates) · Electrical System
THE APPARENT CAUSE OF THE PROBLEM IS THE ACCUMULATION OF BRASS POWDER, THAT WEARS OFF THE ELECTRICAL CONTACTS INSIDE THE TURN SIGNAL SWITCH.THIS POWDER COLLECTS IN SMALL TRAILS OF GREASE THAT TRACK FROM ONE CONTACT TO ANOTHER.WHEN THE CONCENTRATION OF BRASS IN THE GREASE GETS HIGH ENOUGH, IT CAN CAUSE A HIGH RESISTANCE SHORT.THIS SHORT, IN TURN CAN IGNITE THE GREASE AND CAUSE SMOKE TO BE EMITTED FROM THE STEERING COLUMN.THE GREASE USED INSIDE THE SWITCH, AS WELL AS THE VARIOUS PLASTIC COMPONENTS IN THE COLUMN, ARE FIRE RETARDANT AND WILL NOT BURN WITHOUT A SUSTAINED HEAT SOURCE.THERE HAS BEEN ONLY A SINGLE VERIFIED INCIDENT THAT RESULTED IN A VEHICLE FIRE AND THIS REPORTED FIRE WAS SMALL, INVOLVING SOME CHARRING OF THE STEERING WHEEL.ALL OTHER VERIFIED INCIDENTS WERE LIMITED TO SMOKE FROM THE COLUMN AND MINOR INTERNAL DAMAGE TO THE STEERING COLUMN.
PE96069 · Loss Of Steering Control
Opened Nov 26, 1996 · Closed Apr 30, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94095 · Loss Of Steering Control
Opened Dec 28, 1994 · Closed Apr 25, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1995 Dodge Neon Problems, Complaints & Recalls | Skip That Year
Illustration