IllustrationMY CRANKSHAFT IS GOING OUT WE GOT THE VEHICLE CHECKED DUE TO THE ENGINE LIGHT TURNING ON. WE NOTICED THERE WAS A RECALL THE CRANKSHAFT FOR THE 2016 DODGE JOURNEY
2016 Dodge Journey
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2016 Dodge Journey do not stand out strongly from the model-year median of 293.
About this comparison →How this year compares
Owner complaints by model year
Compare all Journey years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
5825–50K
6050–75K
3775–100K
32100–150K
2150K+
240 reports with mileage · 146 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 113 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 84 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports4 fire reports10 injury reports
What owners actually said
386 reportsTL* THE CONTACT OWNS A 2016 DODGE JOURNEY. THE CONTACT STATED THAT THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO TURNERSVILLE JEEP CHRYSLER DODGE RAM (3100 NJ-42, ERIAL, NJ 08081, (856) 316-7956) WHERE THEY REPLACED THE FRONT SENSOR AND HUB BEARING. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEA…
Read full complaint
TL* THE CONTACT OWNS A 2016 DODGE JOURNEY. THE CONTACT STATED THAT THE ABS WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO TURNERSVILLE JEEP CHRYSLER DODGE RAM (3100 NJ-42, ERIAL, NJ 08081, (856) 316-7956) WHERE THEY REPLACED THE FRONT SENSOR AND HUB BEARING. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THEY DID NOT HAVE THE UNSPECIFIED PART AVAILABLE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS SAFE TO DRIVE IN THE INTERIM. WHILE DRIVING, THE CONTACT'S VEHICLE FAILED TO STOP AND REAR ENDED ANOTHER VEHICLE. THE GRILL OF THE CONTACT'S VEHICLE WAS DAMAGED. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DRIVEN BACK TO THE DEALER AND THEY REPLACED THE ABS PART AFTER THE CRASH. THE MANUFACTURER WAS CONTACTED AND STATED THAT THEY WANTED TO EXAMINE THE VEHICLE. THE MANUFACTURER CONCLUDED THAT THERE WAS NO MALFUNCTION WITH THE BRAKES AFTER THE REPAIRS FROM THE CRASH WERE ALREADY COMPLETED. THE MANUFACTURER STATED THAT THE BEARINGS WERE THE CAUSE OF THE FAILURE. THE CONTACT FELT THAT THE DEALER WAS RESPONSIBLE FOR THE CRASH. THE FAILURE MILEAGE WAS 19,960. *BF CONSUMER STATED REPAIRS WERE DONE BUT ADJUSTOR ASKED CONSUMER TO BRING IN THE CAR.*JB
ABS SYSTEM LIGHT COMES ON AND OFF AT WILL AND THIS WOULD BE THE 2ND TIME IN ABOUT A YEAR LAST TIME THE ABS LIGHT HAS DONE THIS LAST TIME IT CAUSED THE BRAKES TO LOCK DOWN RESULTING IT AN NON-INJURY ACCIDENT ALSO IT WOULD NOT CLEAR AFTER REPAIRS AND COMPUTER RESET
POWER DISTRIBUTION CENTER WENT OUT IN VEHICLE AND REPAIRED FOR THE SECOND TIME. I DONT TRUST THE VEHICLE. STALLED ON THE HIGHWAY, WITH CHILDREN IN THE CAR. THIS WAS VERY SCARY AND DANGEROUS. THIS VEHICLE HAD A RECALL THAT TRIGGERED ALOT OF ISSUES WITH THE TRUCK, TO BE QUIET HONEST WHEN IT GETS FIXED I DON'T FEEL SAFE DRIVING THE…
Read full complaint
POWER DISTRIBUTION CENTER WENT OUT IN VEHICLE AND REPAIRED FOR THE SECOND TIME. I DONT TRUST THE VEHICLE. STALLED ON THE HIGHWAY, WITH CHILDREN IN THE CAR. THIS WAS VERY SCARY AND DANGEROUS. THIS VEHICLE HAD A RECALL THAT TRIGGERED ALOT OF ISSUES WITH THE TRUCK, TO BE QUIET HONEST WHEN IT GETS FIXED I DON'T FEEL SAFE DRIVING THE VEHICLE.
'TAKATA RECALL' IN LESS THAN A YEAR THE ABS LIGHT HAVE COME ON. THE FIRST TIME IT EVER CAME ON WAS STOPPING FOR A RED LIGHT ON THE HIGHWAY THE VEHICLE KEPT GOING. SECOND TIME LESS THAN A YEAR LATER THE LIGHT HAS COME BACK ON AND YOU HAVE TO PRESS THE BRAKES THEN RELEASE AND AND PRESS THE BRAKES AGAIN FOR THE VEHICLE TO STOP ADEQ…
Read full complaint
'TAKATA RECALL' IN LESS THAN A YEAR THE ABS LIGHT HAVE COME ON. THE FIRST TIME IT EVER CAME ON WAS STOPPING FOR A RED LIGHT ON THE HIGHWAY THE VEHICLE KEPT GOING. SECOND TIME LESS THAN A YEAR LATER THE LIGHT HAS COME BACK ON AND YOU HAVE TO PRESS THE BRAKES THEN RELEASE AND AND PRESS THE BRAKES AGAIN FOR THE VEHICLE TO STOP ADEQUATELY.
THE ISSUES STARTED AFTER THE RECALL FOR THE SPEED CONTROL COMPUTER FLASH WAS DONE, ABOUT 2 WEEKS AFTER I NOTICED THAT MY REAR WIPER WOULD ONLY TURN ON WHEN THE CAR WAS IN REVERSE. IF I WOULD PUT THE REAR WIPER SWITCH IN THE ON POSITION NOTHING WOULD HAPPEN. SO IN ORDER TO STOP THE REAR WIPER FROM MOVING WHILE IN REVERSE, I HAV…
Read full complaint
THE ISSUES STARTED AFTER THE RECALL FOR THE SPEED CONTROL COMPUTER FLASH WAS DONE, ABOUT 2 WEEKS AFTER I NOTICED THAT MY REAR WIPER WOULD ONLY TURN ON WHEN THE CAR WAS IN REVERSE. IF I WOULD PUT THE REAR WIPER SWITCH IN THE ON POSITION NOTHING WOULD HAPPEN. SO IN ORDER TO STOP THE REAR WIPER FROM MOVING WHILE IN REVERSE, I HAVE TO LEAVE THE SWITCH ON THE ON POSITION, MY REAR WIPER ALSO MOVES WHEN I UNLOCK MY CAR.. FOLLOWING THAT MY REVERSE LIGHTS DO NOT COME ON. THEN MY LEFT TAIL GATE LIGHT DOES NOT COME ON WHEN LIGHTS ARE TURNED ON BUT IT DOES COME ON WHEN I UNLOCKED THE CAR. WHEN I OPEN THE REAR HATCH DOOR NONE OF THE INTERIOR LIGHTS TURN ON. SO I AM FORCED TO OPEN ANOTHER DOOR IF I WANT THE LIGHTS TO TURN ON. ALSO WHEN I GO TO REVERSE MY BACK UP CAMERA SCREEN GOES BLACK AND ALSO STARTS TO GLITCH. THIS HAPPENS OCCASIONALLY.
THE AIRBAG SIGN SHOW UP
VEHICLE STALLS RANDOMLY. MOSTLY AT LOW SPEEDS OR SLOWING DOWN.
TL* THE CONTACT OWNS A 2016 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD ABNORMAL NOISES UNDERNEATH THE HOOD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSFER CASE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MA…
Read full complaint
TL* THE CONTACT OWNS A 2016 DODGE JOURNEY. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD ABNORMAL NOISES UNDERNEATH THE HOOD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSFER CASE NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 59,000.
VEHICLE WAS IN REVERSE. AS SOON AS THE GAS WAS PRESSED THE ENGINE STALLED OUT. WE WERE PULLING OUT FROM A PARKING SPOT WHEN IT HAPPENED. THIS IS NOW THE FOURTH INSTANCE IN 4 WEEKS THIS HAS HAPPENED. CLEARLY CHRYSLER HASN'T FOUND ALL ITS VEHICLES PRODUCED WITH THIS PROBLEM SIMPLY BECAUSE THE VIN# SAYS IT SHOULD BE FINE
Official recalls
418V332000 · Electrical System:software; Electrical System:wiring; Vehicle Speed Control:cruise Control
May 17, 2018
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence & remedy
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Additional source detail variants (3)
Electrical System:software
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Vehicle Speed Control:cruise Control
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
Electrical System:wiring
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Consequence: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will inspect the software, and perform a software flash on the engine or powertrain control module, free of charge. The recall began June 4, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Note: Owners are advised to stop using cruise control until the software update has been performed. In the event that cruise control cannot be disengaged while driving, owners should firmly and steadily apply the brakes and shift the transmission to neutral, placing the vehicle in park once it has stopped.
16V907000 · Engine And Engine Cooling:engine
Dec 16, 2016
Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Journey, Jeep Compass, and Jeep Patriot vehicles manufactured May 9, 2016, to July 15, 2016. The crankshaft or camshaft sensor may only work intermittently, causing the engine to stall.
Consequence & remedy
Consequence: If the engine stalls, there is an increased the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the crankshaft or camshaft sensor connector, free of charge. The recall began February 8, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S89.
16V461000 · Power Train:automatic Transmission
Jun 24, 2016
Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Chrysler Town & Country, Dodge Grand Caravan vehicles manufactured July 31, 2015, to April 18, 2016, 2016 Dodge Journey vehicles manufactured August 17, 2015, to January 29, 2016, and 2016 RAM ProMaster vehicles manufactured August 15, 2016, to April 15, 2016. The transmission pump may seize causing a loss of hydraulic pressure.
Consequence & remedy
Consequence: If the transmission loses hydraulic pressure, the vehicle may lose motive power, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the transmission pump, free of charge. The recall began on August 18, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S44.
16V273000 · Steering:hydraulic Power Assist:hose, Piping, And Connections
May 6, 2016
Chrysler (FCA US LLC) is recalling certain model year 2009-2016 Dodge Journey vehicles manufactured July 31, 2007, to November 12, 2016. After exposure to cold temperatures, the power steering return hose may rupture at engine start-up causing a loss of power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist may require extra steering effort, especially at lower speeds, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the power steering return hoses, steel tubes, and power steering oil cooler, free of charge. The recall began on May 24, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S08.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ22002 · Stall From Crankshaft\camshaft Failure
Opened Jul 22, 2022 · Closed Jun 16, 2025
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:crank/camshaft Position Sensor
On December 13, 2016, the National Highway Traffic Safety Administration (NHTSA) received recall 16V-907 from Fiat Chrysler Automobiles (FCA) that identified a safety defect involving crankshaft or camshaft sensor failures on certain 2016 Model Year Dodge Journey, Jeep Compass, and Jeep Patriot vehicles. The failure of the crankshaft or camshaft sensor may lead to a loss of motive power (LOMP) in the recalled vehicles. Following the receipt of recall 16V-907, the Office of Defects Investigation (ODI) received 127 vehicle owner’s questionnaires (VOQ), in which consumers allege experiencing crankshaft or camshaft failures on similar vehicles not included in the recall. On July 22, 2022, this Recall Query was opened to further assess the scope, frequency, and safety consequences of the alleged defect described in the recall. During this investigation, ODI sent two information request (IR) letters to FCA. The first letter was sent on August 15, 2022, and the second on July 12, 2024. Responses to these IR letters, that included manufacturer claim data related to the alleged defect, were received on September 26, 2022, and September 6, 2024, respectively. Analysis of ODI and FCA claim data identified two failure modes relating to intermittent crankshaft and camshaft sensor loss of signal. The first failure mode involves a faulty crankshaft or camshaft electrical connector, as identified in recall 16V-907. The second failure mode involves a faulty crankshaft and/or camshaft position sensor. Both failure modes exhibit intermittent operation of the crankshaft and/or camshaft position sensor that can result in a malfunction indicator lamp (MIL), engine stall while driving, or a no start condition. For the first failure mode, the claim data indicates that the majority of failures resulted in a LOMP and occurred on vehicles covered by recall 16V-907. For the second failure mode, the claim data indicates that the majority of failures resulted in a MIL or no start condition and occurred on vehicles manufactured prior to the vehicles covered by recall 16V-907. VOQ and claim data submitted to NHTSA, involving vehicles built outside the scope of recall 16V-907, commonly do not describe a LOMP. These claims typically describe experiencing symptoms such as a MIL, Diagnostic Trouble Code (DTC) associated with crank/camshaft position sensor, and subsequent visits to a dealership. A substantially smaller percentage of the complaints allege an actual LOMP ( During production, FCA implemented multiple corrective actions to address the camshaft/camshaft sensor signal issue. The last of which was a software update that occurred in February 2016 and based on the claim data, addressed the crankshaft and/or camshaft position sensor issues that were leading to MIL or no start. For vehicles built prior to the software update, the sensor failures were normally covered under warranty. FCA’s assessment of the alleged defect is that the subject vehicles (not included in recall 16V-907) are not typically experiencing a LOMP when they have trouble with their crankshaft and/or camshaft position sensor and for that reason it does not represent a safety defect. FCA states consumers experience multiple warning signs including MIL illumination, drive quality changes, or no start conditions when a crankshaft and/or camshaft position sensor is failing. Based on ODI's analysis of the failure modes, the failure mode for vehicles not included in recall 16V-907 is unlikely to result in LOMP. The data indicates that vehicles not included in the recall experience LOMP at much lower rates than the recalled population. In addition, ODI is not aware of any related vehicle crashes or injuries in that time. Given these facts, a safety-related defect trend has not been identified at this time. Accordingly, this investigation is closed without action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.