NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
600 reportsClear category filter50,000 miles · Apr 20, 2015
Electrical System
SINCE PURCHASE HORN BEEPS INTERMITTENTLY WHEN DOORS ARE OPENED AND SHUT. DEALER COULD NEVER FIND ISSUE. WINDOWS WOULD NOT GO UP IN FRONT BUT CORRECTED SELF. NOW BATTERY DIES AND NO DEALER CAN FIND THE REASON. PUT IN BRAND NEW BATTERY AND LASTED A WEEK UNTIL DOING IT AGAIN. DASH LIGHTS DIM TO ALMOST DARK WHEN WIPERS ARE TURNED ON…
Read full complaint
SINCE PURCHASE HORN BEEPS INTERMITTENTLY WHEN DOORS ARE OPENED AND SHUT. DEALER COULD NEVER FIND ISSUE. WINDOWS WOULD NOT GO UP IN FRONT BUT CORRECTED SELF. NOW BATTERY DIES AND NO DEALER CAN FIND THE REASON. PUT IN BRAND NEW BATTERY AND LASTED A WEEK UNTIL DOING IT AGAIN. DASH LIGHTS DIM TO ALMOST DARK WHEN WIPERS ARE TURNED ON. SOMETIMES DASH LIGHTS STAY ON WHEN DOOR CLOSED AND MUST STAY UNTIL DELAY TO BE SURE THEY ARE ALL OFF . VERY ANNOYING. THERE ARE MANY ASPECTS THAT WE LIKED WITH THE JOURNEY BUT THIS IS A REAL PROBLEM. *TR
NHTSA ODI #10711810
120,000 miles · Apr 17, 2015
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING AT 50 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
NHTSA ODI #10706365
128,000 miles · Apr 2, 2015
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE WIN MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE FAILED TO START INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE WIN MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 11V139000 (ELECTRICAL SYSTEM) AND 14V373000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10703372
54,000 miles · Apr 1, 2015
Electrical SystemPower TrainSteering
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE STEERING WHEEL STARTED TO SHAKE EXCESSIVELY. THE CONTACT MENTIONED THAT THE ESC AND TRACTION CONTROL LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. ALSO, THE CONTACT MENTIONED THAT THE SHIFT LEVER BECAME STUCK IN THE PARK POSITION…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND THE STEERING WHEEL STARTED TO SHAKE EXCESSIVELY. THE CONTACT MENTIONED THAT THE ESC AND TRACTION CONTROL LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. ALSO, THE CONTACT MENTIONED THAT THE SHIFT LEVER BECAME STUCK IN THE PARK POSITION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 54,000.
NHTSA ODI #10703221
114,000 miles · Mar 27, 2015
Air BagsElectrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING AT 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE HORN INDEPENDENTLY ACTIVATED. THE VEHICLE FAILED TO START AND THE DOORS LOCKED INDEPENDENTLY. AS A RESULT, THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE CONTACT HAD TO USE THE EMER…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING AT 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE HORN INDEPENDENTLY ACTIVATED. THE VEHICLE FAILED TO START AND THE DOORS LOCKED INDEPENDENTLY. AS A RESULT, THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE CONTACT HAD TO USE THE EMERGENCY KEY TO EXIT THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.
NHTSA ODI #10702266
550,000 miles · Mar 23, 2015
Electrical System
AFTER DRIVING APPROXIMATELY 10 - 20 MILES, I SHUT THE VEHICLE OFF AND WHEN I WENT BACK TO START IT ABOUT 1 HOUR LATER, IT WOULD NOT START. THERE WAS A CLICK AND NOTHING. AFTER SEVERAL ATTEMPTS AND MAYBE 5 MINUTES LATER, THE VEHICLE STARTED. I HAD NO FURTHER ISSUES UNTIL MARCH 17, 2015 WHEN I WENT TO START MY VEHICLE AND AGAIN…
Read full complaint
AFTER DRIVING APPROXIMATELY 10 - 20 MILES, I SHUT THE VEHICLE OFF AND WHEN I WENT BACK TO START IT ABOUT 1 HOUR LATER, IT WOULD NOT START. THERE WAS A CLICK AND NOTHING. AFTER SEVERAL ATTEMPTS AND MAYBE 5 MINUTES LATER, THE VEHICLE STARTED. I HAD NO FURTHER ISSUES UNTIL MARCH 17, 2015 WHEN I WENT TO START MY VEHICLE AND AGAIN NOTHING HAPPENED. THINKING IT WAS A BATTERY, I HAD IT CHECKED OUT AND WAS TOLD AT THAT TIME THAT THERE WAS A RECALL ON 2010 JOURNEY IGNITION SWITCHES. THE RECALL STATES THAT IT IS ON VEHICLES THAT WERE BUILT PRIOR TO JUNE 2010. EVEN THOUGH MY VEHICLE WAS BUILT IN MAY 2010, IT IS NOT INCLUDED IN THE RECALL. I DON'T THINK I SHOULD HAVE TO PAY $700 OUT OF POCKET TO FIX AN OBVIOUS DEFECTIVE PART. PLEASE, I WOULD LIKE TO KNOW WHY MY VEHICLE WAS NOT INCLUDED IN THE RECALL. *TR
NHTSA ODI #10701060
45,000 miles · Mar 19, 2015
Electrical SystemEquipment Adaptive/mobility
IN JUNE OF 2013 MY CAR ALARM STARTED TO COME ON RANDOMLY. FIRST WHILE CAR WAS IN PARKED POSITION. DAYS AFTER IT THEN STARTED SOUNDING WHILE DRIVING, LEAVING MY THEN 6 YEAR OLDS HYSTERICAL. IT WAS HAPPENING SO MUCH THAT WE TOOK OUT THE FUSES. IN NOV 2014, WHILE ENTERING THE INTERSTATE EXIT MY CAR SHUT OFF GOING 35MPH AROUND A D…
Read full complaint
IN JUNE OF 2013 MY CAR ALARM STARTED TO COME ON RANDOMLY. FIRST WHILE CAR WAS IN PARKED POSITION. DAYS AFTER IT THEN STARTED SOUNDING WHILE DRIVING, LEAVING MY THEN 6 YEAR OLDS HYSTERICAL. IT WAS HAPPENING SO MUCH THAT WE TOOK OUT THE FUSES. IN NOV 2014, WHILE ENTERING THE INTERSTATE EXIT MY CAR SHUT OFF GOING 35MPH AROUND A DEEP CURVE. I LOST ALL CONTROL OF STEERING AND ACCELERATION, BRAKES LOCKED UP. I WAS ABLE TO FORCE STEER TO SHOULDER AND TURN CAR OFF AND BACK ON. IT RAN OK UNTIL A COUPLE WEEKS LATER IT DID IT AGAIN. COMING HOME OFF INTERSTATE W/ KIDS IN CAR, CAR SHUT OFF WHILE GOING 40 MPH IN MID CURVE! NOW BEGINNING FEB 2015, MY BATTERY GOES DEAD REPEATEDLY. I'VE HAD TO HAVE IT JUMPED OFF ALMOST EVERY MORNING FOR LAST MONTH. I TOOK IT TO AUTO STORE AND BATTERY TESTED GOOD. MARCH 2015, BATTERY GOING DEAD AGAIN. I'VE HAD ACCREDITED MECHANIC LOOK AT IT WHO TESTED EVERYTHING ALONG W/ RELAYS. HE STATED BATTERY WAS GOOD BUT BASICALLY ALARM, ALTHOUGH IT'S NOT HEARD, ITS STILL WAKING UP AND DRAIN BATTERY. HE COULDN'T GO BEYOND THIS POINT TO FIX BECAUSE HE BELIEVED IT'S SOMETHING IN COMPUTER SYSTEM? I TOOK TO DEALER AND AFTER I EXPLAINED EVERYTHING TO THEM & BEEN WITHOUT A CAR FOR WEEK, THEY INSISTED IT BATTERY WAS BAD. SO WE HAVE REPLACED BATTERY, YET THEY DID NOT ADDRESS RANDOM ALARM/HORN. SO I TOOK BACK SAME DAY TO ADDRESS THIS ISSUE B/C IT WILL CONTINUE. THEY NOW ARE SUGGESTING TO REPLACE HORN SWITCH OF WHICH AFTER LOOKING AT OTHER CONSUMERS I DON'T THINK WILL FIX THE PROBLEM. THERE IS SOMETHING IN THE CARS COMPUTER TRIGGERING THE ALARM BUT FOR SOME REASON THEY REFUSE TO CHECK THAT. I'M NOT SURE IF IT'S JUST BECAUSE THEY CAN'T GET AS MUCH MONEY FROM RESETTING COMPUTER OR NOT. I KNOW I DON'T HAVE MONEY TO THROW AWAY ON TRAIL & ERROR. WITH ALL THE COMPLAINTS ON THIS I CAN'T FIGURE OUT HOW THE DEALERS/COMPANY CHRYSLER DODGE JEEP DOESN'T HAVE A SOLUTION. *TR
NHTSA ODI #10695381
37,424 miles · Mar 11, 2015
Electrical SystemService Brakes
I WENT TO THE STORE GOT WHAT I NEEDED CAME OUT AND THE JOURNEY WOULD NOT START. I HAD IT TOWED TO THE DODGE DEALERSHIP AND THEY TOLD ME THE TIPM WAS BAD.THEY REPLACED IT AND HAS BEEN WORKING SO FAR. IT COST 900.00 DOLLARS TO FIX WITH ONLY 37424 MILES ON IT.THE OTHER PROBLEM WAS THE BRAKES ALL HAD TO BE REPLACED WITH JUST OVER 20…
Read full complaint
I WENT TO THE STORE GOT WHAT I NEEDED CAME OUT AND THE JOURNEY WOULD NOT START. I HAD IT TOWED TO THE DODGE DEALERSHIP AND THEY TOLD ME THE TIPM WAS BAD.THEY REPLACED IT AND HAS BEEN WORKING SO FAR. IT COST 900.00 DOLLARS TO FIX WITH ONLY 37424 MILES ON IT.THE OTHER PROBLEM WAS THE BRAKES ALL HAD TO BE REPLACED WITH JUST OVER 20000 MILES ON THE CAR. THE DEALERSHIP COVERED THE FRONT BRAKES BUT WITH A DEDUCTIBLE OF 100.00 DOLLARS BUT I HAD TO PAY FOR THE BACK BRAKES. *TR
NHTSA ODI #10693635
24,575 miles · Mar 10, 2015
Electrical SystemEngineSteering
ENGINE STALLED WHILE DRIVING CAUSING LOSS OF POWER STEERING & POWER BRAKES. DIAGNOSIS REVEALED THAT ENGINE WOULD STALL IF KEY WAS MOVED SLIGHTLY. COULD HAVE CAUSED A SERIOUS ACCIDENT. SUPERSTITION SPRINGS CHRYSLER REPLACED THE WIN MODULE AT A COST OF $492.46. HOW MANY PEOPLE HAVE TO DIE OR BE INJURED BEFORE THE MANUFACTURER ACC…
Read full complaint
ENGINE STALLED WHILE DRIVING CAUSING LOSS OF POWER STEERING & POWER BRAKES. DIAGNOSIS REVEALED THAT ENGINE WOULD STALL IF KEY WAS MOVED SLIGHTLY. COULD HAVE CAUSED A SERIOUS ACCIDENT. SUPERSTITION SPRINGS CHRYSLER REPLACED THE WIN MODULE AT A COST OF $492.46. HOW MANY PEOPLE HAVE TO DIE OR BE INJURED BEFORE THE MANUFACTURER ACCEPTS RESPONSIBILITY, INITIATES A RECALL AND TAKES CARE OF THE PROBLEM AT NO COST TO THE VEHICLE OWNER?? I BELIEVE THAT CHRYSLER CORP SHOULD REIMBURSE ME FOR THE COST OF THIS REPAIR. *TR
NHTSA ODI #10693298
44,787 miles · Mar 10, 2015
Air BagsElectrical SystemSteering
WHILE DRIVING INTO WORK THIS MORNING MY HORN BEGAN TO GO OFF ON ITS ON AND RANDOMLY. NOTHING I DID WOULD STOP THE HORN FROM GOING OFF. I CALLED BOTH MY DEALER AND CHRYSLER DIRECTLY NEITHER SAID THEY HAVE HEARD OF ANY ISSUES REGARDING THIS. SOME OF THE WARNING LIGHTS ON MY DASH ALSO CAME UP AND THEN WENT OFF. THIS SEEMS TO BE A S…
Read full complaint
WHILE DRIVING INTO WORK THIS MORNING MY HORN BEGAN TO GO OFF ON ITS ON AND RANDOMLY. NOTHING I DID WOULD STOP THE HORN FROM GOING OFF. I CALLED BOTH MY DEALER AND CHRYSLER DIRECTLY NEITHER SAID THEY HAVE HEARD OF ANY ISSUES REGARDING THIS. SOME OF THE WARNING LIGHTS ON MY DASH ALSO CAME UP AND THEN WENT OFF. THIS SEEMS TO BE A SAFETY ISSUE AND I AM CONCERNED. *TR
NHTSA ODI #10693213
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration