NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
600 reportsClear category filter30,000 miles · Oct 11, 2018
Air BagsElectrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE OPERATING THE VEHICLE, THE HORN RANDOMLY SOUNDED. THE FAILURE ALSO OCCURRED WHILE THE VEHICLE WAS SHUT OFF AND THE KEY WAS REMOVED FROM THE IGNITION SWITCH. IN ADDITION, WHILE DRIVING, THE PASSENGER SIDE AIR BAG INDICATOR REMAINED ILLUMINATED. THE FAILURES WERE NOT DIAGNOSED OR RE…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE OPERATING THE VEHICLE, THE HORN RANDOMLY SOUNDED. THE FAILURE ALSO OCCURRED WHILE THE VEHICLE WAS SHUT OFF AND THE KEY WAS REMOVED FROM THE IGNITION SWITCH. IN ADDITION, WHILE DRIVING, THE PASSENGER SIDE AIR BAG INDICATOR REMAINED ILLUMINATED. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER (DUNES AUTO, 2502 LOCUST STREET, STERLING, IL) WAS NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #11139741
64,000 miles · Oct 10, 2018
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING AT ANY SPEED, THE HORN SOUNDED INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO MEMORIAL HIGHWAY CHEVROLET, INC. (814-467-4596, LOCATED AT 1 CHEVY DR, WINDBER, PA 15963) WHERE THE TECHNICIAN STATED THAT THE WARRANTY DID NOT COVER THE HORN. THE MANUFACTURER WAS MADE…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING AT ANY SPEED, THE HORN SOUNDED INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO MEMORIAL HIGHWAY CHEVROLET, INC. (814-467-4596, LOCATED AT 1 CHEVY DR, WINDBER, PA 15963) WHERE THE TECHNICIAN STATED THAT THE WARRANTY DID NOT COVER THE HORN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE WARRANTY WAS EXPIRED. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.
NHTSA ODI #11139539
65,803 miles · Oct 9, 2018
Electrical SystemEngine
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOSS POWER. THE VEHICLE WAS ABLE TO RESTART. IN ADDITION, THE VEHICLE WOULD NOT START WHEN PROMPTED. THE CONTACT STATED THAT LIVONIA CHRYSLER JEEP (30777 PLYMOUTH RD, LIVONIA, MICHIGAN 48150) REPLACED THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE JOURNEY. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOSS POWER. THE VEHICLE WAS ABLE TO RESTART. IN ADDITION, THE VEHICLE WOULD NOT START WHEN PROMPTED. THE CONTACT STATED THAT LIVONIA CHRYSLER JEEP (30777 PLYMOUTH RD, LIVONIA, MICHIGAN 48150) REPLACED THE VEHICLE BATTERY THREE TIMES AND THE STARTER WAS REPLACED TWICE. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER; HOWEVER, THEY COULD NOT DUPLICATE THE FAILURES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 65,803.
NHTSA ODI #11139339
Mileage unknown · Oct 9, 2018
Electrical System
STARTING ISSUES
NHTSA ODI #11139232
140,000 miles · Oct 3, 2018
Electrical System
MY DODGE IS DOING THIS, DEALERSHIP WON'T FIX IT, MY VIN SHOWS NO RECALL. MY JOURNEY DOES THIS EXACTLY LIKE BELOW. NOW HAVE TO PULL OUT FUEL PUMP FUSE, DISCONNECT BATTERY JUST TO GET THE CAR TO SHUT OFF.......... 2010 JOURNEY IGNITION SWITCH MAY TURN OFF POSTED 2015-05-26 NHTSA HAS ASSIGNED THIS RECALL ID #14V373000. THER…
Read full complaint
MY DODGE IS DOING THIS, DEALERSHIP WON'T FIX IT, MY VIN SHOWS NO RECALL. MY JOURNEY DOES THIS EXACTLY LIKE BELOW. NOW HAVE TO PULL OUT FUEL PUMP FUSE, DISCONNECT BATTERY JUST TO GET THE CAR TO SHUT OFF.......... 2010 JOURNEY IGNITION SWITCH MAY TURN OFF POSTED 2015-05-26 NHTSA HAS ASSIGNED THIS RECALL ID #14V373000. THERE ARE 722,705 VEHICLES AFFECTED. RECALL SUMMARY THIS DEFECT CAN AFFECT THE SAFE OPERATION OF THE AIRBAG SYSTEM. UNTIL THIS RECALL IS PERFORMED, CUSTOMERS SHOULD REMOVE ALL ITEMS FROM THEIR KEY RINGS, LEAVING ONLY THE IGNITION KEY. THE KEY FOB (IF APPLICABLE), SHOULD ALSO BE REMOVED FROM THE KEY RING. CHRYSLER GROUP LLC (CHRYSLER) IS RECALLING CERTAIN MODEL YEAR 2009-2010 DODGE JOURNEY VEHICLES MANUFACTURED JUNE 29, 2007, TO JUNE 17, 2010, AND 2008-2010 DODGE GRAND CARAVAN AND CHRYSLER TOWN AND COUNTRY VEHICLES MANUFACTURED JANUARY 26, 2007, TO JUNE 17, 2010. ROAD CONDITIONS OR SOME OTHER JARRING EVENT MAY CAUSE THE IGNITION SWITCH TO MOVE OUT OF THE RUN POSITION, TURNING OFF THE ENGINE. THE PROBLEM IF THE IGNITION KEY INADVERTENTLY MOVES INTO THE OFF OR ACCESSORY POSITION, THE ENGINE WILL TURN OFF, WHICH WILL THEN DEPOWER VARIOUS KEY SAFETY SYSTEMS INCLUDING BUT NOT LIMITED TO AIR BAGS, POWER STEERING, AND POWER BRAKING. LOSS OF FUNCTIONALITY OF THESE SYSTEMS MAY INCREASE THE RISK OF CRASH AND/OR INCREASE THE RISK OF INJURY IN THE EVENT OF A CRASH.
NHTSA ODI #11133093
87,150 miles · Oct 1, 2018
Electrical SystemUnknown Or Other
MY CAR HAS AN INTERMITTENT PROBLEM WITH STARTING. I HAVE ONLY HAD THIS VEHICLE FOR 6 WEEKS AND IT HAS FAILED TO START ON MANY DIFFERENT OCCASSIONS. I HAVE HAD IT TOWED TO THE DEALERSHIP TWO SEPARATE TIMES AND THEY TELL ME THEY DON'T KNOW WHAT'S WRONG WITH IT. I FIGURED OUT THAT WHEN MY CAR WON'T START, WHILE IN PARK, I CAN TU…
Read full complaint
MY CAR HAS AN INTERMITTENT PROBLEM WITH STARTING. I HAVE ONLY HAD THIS VEHICLE FOR 6 WEEKS AND IT HAS FAILED TO START ON MANY DIFFERENT OCCASSIONS. I HAVE HAD IT TOWED TO THE DEALERSHIP TWO SEPARATE TIMES AND THEY TELL ME THEY DON'T KNOW WHAT'S WRONG WITH IT. I FIGURED OUT THAT WHEN MY CAR WON'T START, WHILE IN PARK, I CAN TURN THE KEY TO THE ON POSITION AND MOVE THE SHIFTER INTO NEUTRAL. IT STARTS AT THIS POINT. EACH TIME THAT MY VEHICLE HAS FAILED TO START, IT HAS BEEN IN PARK IN MY DRIVEWAY, ON A SLIGHT INCLINE.
NHTSA ODI #11132661
170,000 miles · Sep 30, 2018
Electrical SystemExterior LightingUnknown Or Other
IT STARTED WITH A WINDOW NOT GOING UP, THEN THE ELECTRICAL WIRES TO THE FRONT LEFT HEADLIGGT BURNED OUT AND MELTED THE BULB CONNECTOR. BULB CONNECTOR WAS REPLACED AND IT HAPPENED AGAIN. KEYLESS ENTRY FOBS STOPPED WORKING, BATTERIES WERE CHANGED AND FOBS WERE TESTED BUT THEY STILL DON'T WORK. ALARM GOES OFF AT RANDOM TIMES AND T…
Read full complaint
IT STARTED WITH A WINDOW NOT GOING UP, THEN THE ELECTRICAL WIRES TO THE FRONT LEFT HEADLIGGT BURNED OUT AND MELTED THE BULB CONNECTOR. BULB CONNECTOR WAS REPLACED AND IT HAPPENED AGAIN. KEYLESS ENTRY FOBS STOPPED WORKING, BATTERIES WERE CHANGED AND FOBS WERE TESTED BUT THEY STILL DON'T WORK. ALARM GOES OFF AT RANDOM TIMES AND TAKES US STARTING AND MOVING THE CAR 50 FEET TO TURN IT OFF. THE OTHER NIGHT THE CAR HORN WENT OFF IN THE MIDDLE OF THE NIGHT RANDOMLY, ABOUT 12 TIMES. NOW THE HORNNIS GOING OFF AS WE DRIVE FOR NO REASON. THIS CAR CKEARLY HAS ELECTRICAL ISSUES. ELECTRICAL PARTS KEEP BURNING OUT CAUSING ME TO CHANGE THEM FOR REINSPECTION TIME BY THE STATE.
NHTSA ODI #11132381
110,000 miles · Sep 29, 2018
Electrical System
IT STARTED WITH CAR ALARM GOING OFF AT RANDOM TIMES, THEN WINDOWS NOT WORKING CORRECTLY AND EVENTUALLY LANDED ON RELAYS FIRING ALL NIGHT LONG AND DEAD BATTERY EVERY DAY. THE CAR HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES WITH NO FIX, SO I REPLACED THE BATTERY, ECM, KEYS, TIPM TO NO AVAIL. THERE ARE SO MANY PEOPLE ON THE INTERNET …
Read full complaint
IT STARTED WITH CAR ALARM GOING OFF AT RANDOM TIMES, THEN WINDOWS NOT WORKING CORRECTLY AND EVENTUALLY LANDED ON RELAYS FIRING ALL NIGHT LONG AND DEAD BATTERY EVERY DAY. THE CAR HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES WITH NO FIX, SO I REPLACED THE BATTERY, ECM, KEYS, TIPM TO NO AVAIL. THERE ARE SO MANY PEOPLE ON THE INTERNET WITH THIS SAME ISSUE, BUT NO CLEAR FIXES OUT THERE. IT HAS RENDERED THE CAR COMPLETELY UNUSEABLE AND UNSAFE.
NHTSA ODI #11132250
135,000 miles · Sep 26, 2018
Electrical System
ABOUT A WEEK AGO MY HORN STARTED GOING OFF WHILE I WAS DRIVING TO WORK IN THE MORNING IT WAS SO OUT OF THE BLUE THAT I DIDN'T EVEN REALIZE IT WAS ME RIGHT AWAY, I WAS ABLE TO PULL OF THE ROAD, TAPPED THE HORN A COUPLE OF TIMES THINKING IT MIGHT HAVE JUST GOT STUCK AFTER A COUPLE MINUTES IT JUST STOPPED I THOUGHT IT WAS JUST A ON…
Read full complaint
ABOUT A WEEK AGO MY HORN STARTED GOING OFF WHILE I WAS DRIVING TO WORK IN THE MORNING IT WAS SO OUT OF THE BLUE THAT I DIDN'T EVEN REALIZE IT WAS ME RIGHT AWAY, I WAS ABLE TO PULL OF THE ROAD, TAPPED THE HORN A COUPLE OF TIMES THINKING IT MIGHT HAVE JUST GOT STUCK AFTER A COUPLE MINUTES IT JUST STOPPED I THOUGHT IT WAS JUST A ONE TIME FREAK INCIDENT SO I PAID IT NO MIND UNTIL 4AM THIS MORNING WHILE IT WAS PARKED IN THE DRIVEWAY ONCE AGAIN MY HORN JUST START GOING AGAIN FOR LIKE 3 OR 4 MINUTES THEN IT WOULD STOPPED AND START AGAIN IT DID THIS ABOUT 4 TIMES WAKING MY NEIGHBORS. WHEN THE SUN CAME UP I WAS FINALLY ABLE TO FIGURE OUT WHICH FUSES TO PULL TO DISCONNECT THE HORN AND WHILE SEARCHING TO FIND THIS OUT I SAW THAT MANY OTHER DODGE JOURNEY OWNERS HAVE HAD THE SAME PROBLEM. THERE NEED TO BE SOME KIND OF RECALL I CAN'T DRIVE WITHOUT A HORN THATS A SAFETY HAZARD BUT WITH THE WORLD WE LIVE IN NOW I ALSO CAN'T HAVE A HORN JUST GOING OFF AT ANY TIME IN TRAFFIC SOME PEOPLE MIGHT THINK YOU ARE BLOWING AT THEM. THIS IS A ISSUE DODGE NEEDS TO ADDRESS AND FIX.
NHTSA ODI #11131838
104,000 miles · Sep 22, 2018
Electrical System
WHILE DRIVING ON INTERSTATE 5 AND SOME CITY STREETS THE IGNITION WILL TURN OFF AFTER HITTING SMALL BUMPS. IGNITION DOES RESTART BY ITSELF WHILE DRIVING DOWN THE ROAD.
NHTSA ODI #11130794
NHTSA investigations
4EA24003 · Vehicle Entrapment
Opened Aug 1, 2024 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages
The Office of Defects Investigation (ODI) opened PE23-008 on May 1, 2023 to investigate an incident involving a 2009 Dodge Journey alleging occupant entrapment during a vehicle fire that resulted in a fatality. During the investigation, ODI collected information from the manufacturer and involved parties to confirm or refute the defect allegation. ODI has determined that additional reports of vehicle entrapment exist for other model year Dodge Journey vehicles. ODI continues to explore the cause of the thermal event and its potential effect on the actuation of the door locks. ODI also continues to explore other potential causes for door lock malfunction. ODI has determined that an upgrade to an Engineering Analysis (EA) is necessary to continue the review of the investigative material and to assess the risk to motor vehicle safety . To review the ODI report cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration