NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
698 reportsClear category filterMileage unknown · Aug 27, 2001
Electrical SystemEngine And Engine CoolingStructure
REAR PASSENGER'S SIDE POWER WINDOW IS DEAD AND HAS FAILED. WHEN ELECTRONIC COOLING FANS FOR ENGINE TURN ON AUTOMATICALLY AS THEY SHOULD DURING CERTAIN ENGINE TEMPERATURES FRONT HEADLIGHTS NOTICEABLY DIM ALMOST LOOKING LIKE THEY ARE BEING FLASHED FOR A SECOND OR WHAT SOMEONE COULD INTEROPERATE AS THE DRIVER FLASHING HIS LIGHTS. H…
Read full complaint
REAR PASSENGER'S SIDE POWER WINDOW IS DEAD AND HAS FAILED. WHEN ELECTRONIC COOLING FANS FOR ENGINE TURN ON AUTOMATICALLY AS THEY SHOULD DURING CERTAIN ENGINE TEMPERATURES FRONT HEADLIGHTS NOTICEABLY DIM ALMOST LOOKING LIKE THEY ARE BEING FLASHED FOR A SECOND OR WHAT SOMEONE COULD INTEROPERATE AS THE DRIVER FLASHING HIS LIGHTS. HEADLIGHTS ALSO SEEM TO DIM SLIGHTLY WHEN ROLLING DOWN TWO WINDOWS AT THE SAME TIME. I PURCHASED A PROFESSIONAL BATTERY AND ALTERNATOR TESTER HAS SHOWN THAT THE VEHICLES BATTERY AND ALTERNATOR ARE WORKING AS NORMAL. THIS MAKES ME WONDER ABOUT THE VEHICLE'S ELECTRICAL SYSTEM.*AK
NHTSA ODI #751170
Mileage unknown · Aug 23, 2001
Engine And Engine Cooling
CONSUMER TOOK VEHICLE FOR A ROUTINE CHECK UP. MECHANIC STATED THAT WATER PUMP NEEDED TO BE CHANGED BECAUSE IT WAS LEAKING ANTIFREEZE, PART NUMBER 501718388AA. TUBE AND GASKET, PART NUMBER 5277928, WERE REPLACED. DEALERSHIP IWAS AWARE OF PROBLEM. *AK
NHTSA ODI #895068
Mileage unknown · Jul 28, 2001
Engine And Engine CoolingEquipmentPower Train
A/CEVAPORATOR HAS GONE OUT IN MY CAR. ADDITIONALLY, THE SENSOR ON TRANSMISSION WENT OUT 4 MONTHS AGO. MY MECHANIC SAYS THE EXHAUST SYSTEM HAS RUST SPOTS. ALL PEOPLE WHO HAVE LOOKED AT THE CAR SAY THESE PROBLEMS SHOUND NOT BE HAPPENING ON A CAR WITH ONLY 48,000 MILES. *AK
NHTSA ODI #749358
Mileage unknown · Jul 3, 2001
Electrical SystemEngine And Engine CoolingEquipment
CAR WAS 4 MONTHS OLD - DRIVING DOWN I-70 AND HAD A BLOWOUT. THE TIRE SPLIT CLEAN IN TO. WAS TOLD THAT I MUST OF HIT A POT HOLE. ON 9/13/99 I HAD TAKEN THE CAR INTO THE DEALERSHIP AND TOLD THEM THE TIRE WAS LOSING AIR. THEY SAID THEY COULDN'T FIND A PROBLEM, AIRED UP THE TIRE AND I LEFT. LITTLE OVER A MONTH LATER I HAD A B…
Read full complaint
CAR WAS 4 MONTHS OLD - DRIVING DOWN I-70 AND HAD A BLOWOUT. THE TIRE SPLIT CLEAN IN TO. WAS TOLD THAT I MUST OF HIT A POT HOLE. ON 9/13/99 I HAD TAKEN THE CAR INTO THE DEALERSHIP AND TOLD THEM THE TIRE WAS LOSING AIR. THEY SAID THEY COULDN'T FIND A PROBLEM, AIRED UP THE TIRE AND I LEFT. LITTLE OVER A MONTH LATER I HAD A BLOW OUT. I DID NOT HIT A POT HOLE. THE TIRE WAS DEFECTIVE. I HAD TO REPLACE THE TIRE WITH MY OWN MONEY.*AK (TIRESIZE: P205/70R15)
NHTSA ODI #747734
Mileage unknown · Jun 26, 2001
Engine And Engine Cooling
PLEASE SEE THE LETTER WE HAVE SENT TO THE MANUFACTURER: JUNE 18, 2000. NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #747436
Mileage unknown · May 30, 2001
Electrical SystemEngine And Engine CoolingSteering
WHILE DRIVING EXCESSIVE MOVEMENTS OCCUR WITHIN STEERING WHEEL AND COLUMN. ALSO, AFTER VEHICLE IS PARKED STEERING WHEEL DOES NOT LOCK UP. *AK WITHIN FIRST 2 MONTHS OF OWNERSHIP, ENGINE LIGHT ILLUMINATED. EVERY HOSE AND WIRE UNDER THE HOOD HAD TAPE ON THEM, DEALER STATED THAT EVERY VEHICLE CAME FROM THE MANUFACTURER LIKE TH…
Read full complaint
WHILE DRIVING EXCESSIVE MOVEMENTS OCCUR WITHIN STEERING WHEEL AND COLUMN. ALSO, AFTER VEHICLE IS PARKED STEERING WHEEL DOES NOT LOCK UP. *AK WITHIN FIRST 2 MONTHS OF OWNERSHIP, ENGINE LIGHT ILLUMINATED. EVERY HOSE AND WIRE UNDER THE HOOD HAD TAPE ON THEM, DEALER STATED THAT EVERY VEHICLE CAME FROM THE MANUFACTURER LIKE THAT. CONSUMER QUESTIONED WHY THE STEERING WHEEL PANEL WOULD NOT SNAP OR STAY IN PLACE, DEALER COULD NOT ANSWER THAT QUESTION. *SLC
NHTSA ODI #889418
Mileage unknown · May 29, 2001
Engine And Engine Cooling
WHILE TRAVELING AT APPROXIMATELY 65 MPH WAS A LIGHT "TICKING" NOISE COMING FROM FRONT OF VEHICLE. NOISE STARTED INCREASING IN VOLUME, AND CONSUMER PARKED VEHICLE. DEALERSHIP HAS EXAMINED VEHICLE, AND DETERMINED THAT OIL WAS LEAKING FROM HEAD GASKET AND OIL PAN WHICH CAUSED HEAD GASKET TO BLOW. CONSUMER WAS INFORMED…
Read full complaint
WHILE TRAVELING AT APPROXIMATELY 65 MPH WAS A LIGHT "TICKING" NOISE COMING FROM FRONT OF VEHICLE. NOISE STARTED INCREASING IN VOLUME, AND CONSUMER PARKED VEHICLE. DEALERSHIP HAS EXAMINED VEHICLE, AND DETERMINED THAT OIL WAS LEAKING FROM HEAD GASKET AND OIL PAN WHICH CAUSED HEAD GASKET TO BLOW. CONSUMER WAS INFORMED THAT ENGINE CAME OUT OF FACTORY WITH THIS PROBLEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #889265
Mileage unknown · Apr 19, 2001
Engine And Engine Cooling
DROVE VEHICLE TO CLOSEST DEALERSHIP AT TIME OF ENGINE NOISE. VEHICLE WAS RUNNING WHEN TAKEN TO DEALERSHIP. DEALERSHIP LOOKED AT ENGINE, SAID THERE WAS SLUDGE IN ENGINE, SAID THEY COULD CLEAN THE SLUDGE OUT OF ENGINE FOR $360.00 AND THAT WOULD PROBABLY SOLVE NOISE PROBLEM IN ENGINE. DEALERSHIP SUPPOSEDLY CLEANED SLUDGE OUT OF …
Read full complaint
DROVE VEHICLE TO CLOSEST DEALERSHIP AT TIME OF ENGINE NOISE. VEHICLE WAS RUNNING WHEN TAKEN TO DEALERSHIP. DEALERSHIP LOOKED AT ENGINE, SAID THERE WAS SLUDGE IN ENGINE, SAID THEY COULD CLEAN THE SLUDGE OUT OF ENGINE FOR $360.00 AND THAT WOULD PROBABLY SOLVE NOISE PROBLEM IN ENGINE. DEALERSHIP SUPPOSEDLY CLEANED SLUDGE OUT OF ENGINE, ENGINE THEN SEIZED. DEALERSHIP ASKED FOR RECEIPTS OF ENGINE OIL CHANGES WHICH WERE PROVIDED. DEALERSHIP SUPPOSEDLY CLEANED OUT SLUDGE FROM ENGINE. ENGINE THEN SEIZED UPON BEING STARTED. DAIMLERCHRYSLER REFUSES TO FIX ENGINE.*AK
NHTSA ODI #744274
Mileage unknown · Mar 29, 2001
Electrical SystemEngine And Engine CoolingPower Train
IN AND OUT OF MORLANS, INC (DODGE DEALER) SEVERAL TIMES BECAUSE OF THE ELECTRICAL SYTEM CAUSING THE CHECK ENGINE LIGHT TO COME ON WITH MANY DIFFERENT CODES SUCH AS ROUGH IDLE-TRANSMISSION NOT SHIFTING /DOWN SHIFTING-TRANSMISSION CONTROL MODULE REPLACED-CAMSHAFT SENSOR REPLACED-IGNITION COIL PACK REPLACED-THESE WERE DONE WHILE ST…
Read full complaint
IN AND OUT OF MORLANS, INC (DODGE DEALER) SEVERAL TIMES BECAUSE OF THE ELECTRICAL SYTEM CAUSING THE CHECK ENGINE LIGHT TO COME ON WITH MANY DIFFERENT CODES SUCH AS ROUGH IDLE-TRANSMISSION NOT SHIFTING /DOWN SHIFTING-TRANSMISSION CONTROL MODULE REPLACED-CAMSHAFT SENSOR REPLACED-IGNITION COIL PACK REPLACED-THESE WERE DONE WHILE STILL UNDER WARRANTY AT DIFFERENT DATES. JUST RECENTLY 3/25/01 MY TRANSMISSION WENT INTO A LIMP MODE AGAIN AT 40,000 MILES-THIS TIME IT WAS A TRANSMISSION INPUT SPEED SENSOR (MY COST $92.00), WHEN I GOT MY CAR BACK NOW MY HEATER- A/C AND REAR DEFROST CONTROL / VENTS DON'T WORK ? DIAGNOSED PROBLEM ELECTRICAL (CHARGED $50.00) AGAIN WITH THE CONTROL HEAD / BOARD CONTROL MODULE. I'VE MADE SEVERAL CALLS TO THE CHRYSLER CORP. WITHOUT AVAIL FOR ASSISTANCE. PLEASE GIVE ANY HELP POSSIBLE TO CORRECT THESE ELECTRICAL DEFECTS. THANK YOU. *AK
NHTSA ODI #743229
Mileage unknown · Feb 28, 2001
Engine And Engine Cooling
CONSUMER WAS TRAVELING ALONG AND VEHICLE JUST STOPPED. IT WOULD NOT MOVE OR START BACK UP. A SPRING BROKE AND CAUSED ENGINE VALVES TO COME DOWN AND PUT HOLES IN PISTONS. VEHICLE HAS A 2.7 ENGINE THAT NEEDED REPLACEMENT. DEALER KNEW THIS WAS A COMMON PROBLEM. WARRANTY EXPIRED. *AK *JB
NHTSA ODI #881723
Official recalls
4Jan 13, 2004
ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 5, 2003
ON CERTAIN PASSENGER VEHICLES, SEAT BACK RECLINER BOLT BREAKAGE CAN OCCUR RESULTING IN THE SEAT BACK RECLINING UNEXPECTEDLY.
Consequence & remedy
Consequence: IF THE SEAT BACK UNEXPECTEDLY RECLINES WHILE THE CAR IS BEING DRIVEN, IT COULD RESULT IN LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE RECLINER BOLTS. OWNER NOTIFICATION BEGAN ON APRIL 23, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Apr 11, 2001
VEHICLE DESCRIPTION: CERTAIN VAN, WAGON, PICKUP TRUCKS, PASSENGER AND SPORT UTILITY VEHICLES, FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE FRONT SEAT BELT RETRACTOR MAY NOT COMPLY WITH THE REQUIREMENTS OF THE STANDARD.
Consequence & remedy
Consequence: IF THE RETRACTOR DOES NOT WORK PROPERLY, IT WILL NOT ADEQUATELY PROTECT OCCUPANTS IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SEAT BELT RETRACTOR. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 4, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT SHOULDER HEIGHT ADJUSTABLE TURNING LOOP (ATL) TOP MOUNTING BOLT WAS INADEQUATELY MANUFACTURED.
Consequence & remedy
Consequence: THE AFFECTED MOUNTING BOLTS MAY NOT WITHSTAND SUFFICIENT FORCE TO FUNCTION PROPERLY IN CERTAIN IMPACT SITUATIONS, INCREASING THE RISK OF INJURY TO A BELTED OCCUPANT.
Remedy: DEALERS WILL REPLACE THE SHOULDER BELT HEIGHT ADJUSTER MOUNTING BOLTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
PE03010 · Throttle Control Failure
Opened Feb 27, 2003 · Closed Sep 2, 2003
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal; Vehicle Speed Control:cables; Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Additional source detail variants (4)
Vehicle Speed Control:accelerator Pedal
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:cables
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Vehicle Speed Control:linkages
BASED ON THE LOW FAILURE RATE, THE ABSENCE OF FAILURES OVER THE PAST YEAR, THE ABSENCE OF INJURIES, AND ODI'S FIELD INVESTIGATION OF INCIDENT VEHICLES, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ATTACHED REPORT FOR ADDITIONAL INFORMATION.
Illustration