IllustrationTHE REAR SLIDING DOORS OPENED, I LOADED MY CHILD AND GEAR INTO THE VAN. WHEN WE REACHED OUR DESTINATION, THE DIES WOULD NOT UNLOCK OR OPEN, TRAPPING HER IN THE CAR. WE HAD TO HAVE HER CLIMB INTO THE PASSENGER SEAT AND EXIT THAT WAY. THE VAN WAS PARKED, ENGINE OFF.
2017 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2017 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
3425–50K
7450–75K
4475–100K
16100–150K
2150K+
178 reports with mileage · 235 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 144 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports4 injury reports
Unknown Or Other complaints
98 reportsI'VE HAD THE VEHICLE SINCE LITERALLY 1 YEAR 6 MONTHS AGO THE PASSENGER REAR DOOR STOPPED LOCKING/UNLOCKING I SEARCHED FOR ANSWERS ONLINE AND FOUND FORUMS WITH THIS DOOR ACTUATOR ISSUE I SEE IT AS A HAZARD BECAUSE DUE BELOW AVERAGE USE IT WENT OUT WHAT IF THE OTHER 1 GOES OUT THEN I LOSE ACCESS TO THE REAR OF MY VEHICLE IN AN EME…
Read full complaint
I'VE HAD THE VEHICLE SINCE LITERALLY 1 YEAR 6 MONTHS AGO THE PASSENGER REAR DOOR STOPPED LOCKING/UNLOCKING I SEARCHED FOR ANSWERS ONLINE AND FOUND FORUMS WITH THIS DOOR ACTUATOR ISSUE I SEE IT AS A HAZARD BECAUSE DUE BELOW AVERAGE USE IT WENT OUT WHAT IF THE OTHER 1 GOES OUT THEN I LOSE ACCESS TO THE REAR OF MY VEHICLE IN AN EMERGENCY OR ANYTHING MOST PEOPLE SAYS IT'S AT LEAST $650 FIX WHICH IS 2 MONTHS WORTH OF CAR PAYMENTS I CAN'T AFFORD
OIL HOUSING UNIT FAILED AT 72,000 MILES. DODGE STATED IT SHOULD BE A RECALL, THEY CAN'T EVEN KEEP UP WITH THE PARTS TO REPLACE IT WHEN IT FAILS. THEY TOLD ME TO USE AN AFTER MARKET PART THAT WOULD FAIL BUT IT WOULD AT LEAST GET THE CAR BACK IN MY POSSESSION.
THE DRIVER'S SIDE SLIDING DOOR BECAME STUCK IN THE LOCK POSITION. IT WILL NOT UNLOCK MANUALLY OR ELECTRICALLY WITH THE POWER LOCK BUTTON OR KEY FOB. THE DOOR WILL NOT OPEN AT ALL.
2017 DODGE GRAND CARAVAN DRIVER SIDE DOOR JUST STOPPED OPERATING. CANNOT OPEN WITH KEY FOB OR MANUALLY INSIDE OR OUT. THIS POSES A SAFETY CONCERN AS YOU CANNOT GET IN OR OUR OF VEHICLE ON THAT SIDE IN THE BACK SEATS. THIS HAPPENED ALL OF A SUDDEN. JUST STOPPED WORKING AS SITTING IN DRIVEWAY.
THERE NEEDS TO BE A RECALL ON MY CAR'S FRONT SEAT ACTIVE HEAD RESTRAINTS. I RECEIVED A LETTER FROM FIAT CHRYSLER AUTOMOBILES (FAC) STATING THAT MY FRONT SEAT ACTIVE HEAD RESTRAINTS MAY INADVERTENTLY DEPLOY. FAC OFFERED ME AN EXTENDED 10 YEAR WARRANTY. I CONSIDER THEIR OFFER OF A 10 YEAR WARRANTY TO BE NEGLIGENT. THIS NEEDS T…
Read full complaint
THERE NEEDS TO BE A RECALL ON MY CAR'S FRONT SEAT ACTIVE HEAD RESTRAINTS. I RECEIVED A LETTER FROM FIAT CHRYSLER AUTOMOBILES (FAC) STATING THAT MY FRONT SEAT ACTIVE HEAD RESTRAINTS MAY INADVERTENTLY DEPLOY. FAC OFFERED ME AN EXTENDED 10 YEAR WARRANTY. I CONSIDER THEIR OFFER OF A 10 YEAR WARRANTY TO BE NEGLIGENT. THIS NEEDS TO BE A RECALL. I CONSIDER IT SERIOUS THAT I COULD BE DRIVING DOWN THE ROAD AND GET BUMPED IN THE HEAD BY MY ACTIVE HEAD RESTRAINT.
I HAVE A 2017 DODGE CARAVAN ABOUT A YEAR AFTER I BOUGHT IT MY HAZARD LIGHTS STARTED ACTIVATING WHEN MY MIDDLE SLIDING DOORS WOULD OPEN. I THOUGHT IT WAS A GREAT SAFETY FEATURE, WHILE BEING CONFUSED WHY IT HAD JUST STARTED HAPPENING 1 DAY. THEN A FEW MONTHS LATER MY LOCKS WOULD AND STILL MAKE A DISTRACTING BUZZING SOUND WHEN THE …
Read full complaint
I HAVE A 2017 DODGE CARAVAN ABOUT A YEAR AFTER I BOUGHT IT MY HAZARD LIGHTS STARTED ACTIVATING WHEN MY MIDDLE SLIDING DOORS WOULD OPEN. I THOUGHT IT WAS A GREAT SAFETY FEATURE, WHILE BEING CONFUSED WHY IT HAD JUST STARTED HAPPENING 1 DAY. THEN A FEW MONTHS LATER MY LOCKS WOULD AND STILL MAKE A DISTRACTING BUZZING SOUND WHEN THE DOORS GET LOCKED OR UNLOCKED. IS THERE A SAFETY RECALL ON ANY OF THESE ISSUES?
I RECENTLY PURCHASED A USED 2017 DODGE GRAND CARAVAN IN NOV 2020. I WENT IN FOR AN OIL CHANGE AND WAS INFORMED OF A SMALL OIL LEAK. THE DEALERSHIP SAID THAT THE OIL FILTER ADAPTER HOUSING NEEDED TO BE REPLACED. THEY ARE UNABLE TO GET THE PART AT THIS TIME SAID THEY ARE NOT SURE WHEN IT WILL COME IN. MEANWHILE I AM DRIVING IN A V…
Read full complaint
I RECENTLY PURCHASED A USED 2017 DODGE GRAND CARAVAN IN NOV 2020. I WENT IN FOR AN OIL CHANGE AND WAS INFORMED OF A SMALL OIL LEAK. THE DEALERSHIP SAID THAT THE OIL FILTER ADAPTER HOUSING NEEDED TO BE REPLACED. THEY ARE UNABLE TO GET THE PART AT THIS TIME SAID THEY ARE NOT SURE WHEN IT WILL COME IN. MEANWHILE I AM DRIVING IN A VAN THAT IS STILL LEAKING AND TOLD JUST TO CHECK IT WEEKLY AND TO IT OFF IN THE MEANTIME. I'M NOT SURE IF YOU CAN HELP OUT IF I SHOULD DIRECT THIS TO YOU OR SOMEONE ELSE. I SAW THIS INFO ON NHTSA.GOV. ANY GUIDANCE HOW TO REPORT THIS ISSUE WOULD HELP. I HAVE SEEN VIDEOS THAT SAY THIS USUALLY OCCURS IF SOMEONE TORQUES THE FILTER TO TIGHT. THIS IS THE FIRST OIL CHANGE SINCE I PURCHASED THIS VEHICLE AND THE LAST PAGE THAT DID THE OIL CHANGE WAS THE DEALERSHIP IN OCT 2020. I'M SO FRUSTRATED RIGHT NOW BECAUSE THE WARRANTY THE DEALERSHIP SOLD ME DOESN'T COVER THIS ISSUE. I DON'T KNOW WHEN IT WILL EVEN BE RESOLVED. I DON'T WANT TO RISK THE LEAK GETTING WORSE AND I DON'T CATCH IT OR MY VAN CATCHING ON FIRE. PLEASE HELP IF YOU CAN.
COULD MEAN THE DIFFERENCE BETWEEN LIFE AND DEATH. 2017 DODGE GRAND CARAVAN DRIVER'S SIDE SLIDING DOOR WILL NOT UNLOCK. THIS A SAFETY ISSUE BECAUSE IT PREVENTS THE PASSENGERS IN THE BACK FROM EXITING QUICKLY IN CASE OF EMERGENCY. IN THE CASE OF PARENTS WITH CHILDREN IN CAR SEATS THEY ARE UNABLE TO GET THE CHILD OUT SAFELY.
DRIVER SIDE DOOR DOES NOT LOCK OR UNLOCK WITH BUTTON INSIDE OR BUTTON ON KEY FOB
Official recalls
325V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
20V278000 · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:storage:tank Assembly
May 15, 2020
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Additional source detail variants (2)
Fuel System, Gasoline:delivery:fuel Pump
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
Fuel System, Gasoline:storage:tank Assembly
Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.
18V524000 · Electrical System:wiring:front Underhood
Aug 9, 2018
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Consequence & remedy
Consequence: A vehicle stall can increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the powertrain control module, free of charge. The recall began October 2, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U87.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.