← New search

2016 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2016 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

601 reports with mileage · 399 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 314 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 227 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 220 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

14 crash reports7 fire reports11 injury reports

What owners actually said

1,000 reports
36,133 miles · Feb 10, 2020
Electrical System

DOORS BUZZING NOISE WHEN LOCK OR UNLOCK

NHTSA ODI #11308245

66,718 miles · Feb 9, 2020
Electrical System

DRIVER'S SIDE BACK SLIDING DOOR IS STUCK SHUT AND IN LOCKED POSITION. WILL NOT OPEN WITH REMOTE OR MANUALLY. CAN'T GET IT OPENED AT ALL. PASSENGERS SIDE SLIDING DOOR MAKES LOUD BUZZING NOISE WHEN UNLOCKING IT.

NHTSA ODI #11308082

22,000 miles · Feb 7, 2020
Structure

TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR DRIVER SIDE SLIDING DOOR FAILED TO OPEN AND CLOSE. IN ADDITION, WHILE ATTEMPTING TO OPEN OR CLOSE THE SLIDING DOOR AN ABNORMAL BUZZING SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO ARRIGO DODGE CHRYSLER JEEP RAM DEALER, (5901 MADISON AVE, TAMARAC, FL 3…

Read full complaint

TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE REAR DRIVER SIDE SLIDING DOOR FAILED TO OPEN AND CLOSE. IN ADDITION, WHILE ATTEMPTING TO OPEN OR CLOSE THE SLIDING DOOR AN ABNORMAL BUZZING SOUND WAS HEARD. THE VEHICLE WAS TAKEN TO ARRIGO DODGE CHRYSLER JEEP RAM DEALER, (5901 MADISON AVE, TAMARAC, FL 33321) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THE VEHICLE WARRANTY WAS EXPIRED. THERE WAS NO ADDITIONAL ASSISTANCE PROVIDED. THE FAILURE MILEAGE WAS 22,000.

NHTSA ODI #11307754

55,000 miles · Feb 7, 2020
StructureUnknown Or Other

AUTOMATIC SECOND ROW PASSENGER DOORS AND OR LOCKS ARE SEALED SHUT. THE DOORS CANNOT BE OPENED OR CLOSED AND ARE SEALED COMPLETELY AND TOTALLY SHUT. THERE IS NO MANUAL OVER RIDE SYSTEM TO MANUALLY OPEN AND CLOSE THE DOORS OR TO MANUALLY UNLOCK THE DOORS TO OPEN THEM. THESE ARE THE DOORS THAT CHILDREN USE TO GET IN AND OUT OF TH…

Read full complaint

AUTOMATIC SECOND ROW PASSENGER DOORS AND OR LOCKS ARE SEALED SHUT. THE DOORS CANNOT BE OPENED OR CLOSED AND ARE SEALED COMPLETELY AND TOTALLY SHUT. THERE IS NO MANUAL OVER RIDE SYSTEM TO MANUALLY OPEN AND CLOSE THE DOORS OR TO MANUALLY UNLOCK THE DOORS TO OPEN THEM. THESE ARE THE DOORS THAT CHILDREN USE TO GET IN AND OUT OF THE VEHICLE AS THESE ARE THE SEATS THAT CHILDREN, TODDLERS, AND BABIES RIDE IN. THESE DOORS ARE COMPLETELY AND TOTALLY SEALED SHUT AND CANNOT BE OPENED MANUALLY. THEY MAY OR MAY NOT BE LOCKED AND CANNOT BE UNLOCKED MANUALLY EITHER. THE AUTO MECHANIC CANNOT GET INSIDE OF THESE DOOR PANELS TO FIND OUT WHAT IS WRONG EVEN AFTER STOWING THE SEATS AS THERE IS ALSO NO WAY TO GET THE DOOR PANELS OFF FROM THE INSIDE OF THE CAR WHILE THE DOORS ARE SEALED SHUT. YOU HAVE TO OPEN THE DOORS TO GET THE DOOR PANELS OFF TO LOOK INSIDE OF THE DOORS TO SEE WHAT IS WRONG. BUT, YOU CANNOT DO THIS BECAUSE THE DOORS ARE SEALED SHUT. FAULTY AND DEFECTIVE DESIGN AND ENGINEERING! SERIOUS SAFETY ISSUE FOR CHILDREN! MECHANIC CANNOT GET ANY INFORMATION FROM DODGE ABOUT HOW TO FIX PROBLEM. DOORS HAVE BEEN SEALED SHUT FOR 6 MONTHS. CANNOT GET IN OR OUT OF EITHER DOOR IN SECOND ROW. NO MANUAL OVERRIDE OF ANY KIND TO USE DOORS AS MANUAL DOORS. AUTOMATIC DOOR DESIGN AND AUTOMATIC LOCK DESIGN ARE DEFECTIVE AND PRESENT A SERIOUS SAFETY ISSUE. DODGE NOT TELLING DEALERS OR MECHANICS HOW TO FIX THIS EITHER. IT IS A MYSTERY AND DODGE IS NOT SHARING INFORMATION TO GET IT FIXED.

NHTSA ODI #11307676

37,000 miles · Feb 6, 2020
Electrical System

WE HAVE PROBLEMS WITH BOTH THE REAR PASSENGER AND REAR DRIVER SIDE SLIDING DOORS ON OUR 2016 DODGE GRAND CARAVAN R/T. THE VAN HAD ABOUT 37,000 MILES ON IT AT THE TIME OF THE FIRST INCIDENT. THE REAR SLIDING DOORS WERE NOT UNLOCKING TO OPEN THEM WHILE WE WERE STOPED, AND IN PARK. THIS HAPPENED IN A PUBLIC PARKING LOT. THE ISSUE W…

Read full complaint

WE HAVE PROBLEMS WITH BOTH THE REAR PASSENGER AND REAR DRIVER SIDE SLIDING DOORS ON OUR 2016 DODGE GRAND CARAVAN R/T. THE VAN HAD ABOUT 37,000 MILES ON IT AT THE TIME OF THE FIRST INCIDENT. THE REAR SLIDING DOORS WERE NOT UNLOCKING TO OPEN THEM WHILE WE WERE STOPED, AND IN PARK. THIS HAPPENED IN A PUBLIC PARKING LOT. THE ISSUE WITH THIS IS, WE COULDN'T OPEN THE DOORS TO LET OUR KIDS OUT OF THE VAN. THE OPEN/CLOSE SLIDING DOOR SWITCH IN THE VAN WOULD NOT OPEN THEM, NEITHER WOULD THE KEY FOB. WE TRIED TO UNLOCK IT MANUALLY ON THE DOOR ITSELF, BUT THE LOCK WAS STUCK IN THE LOCKED POSITION. I USED A LOT OF FORCE TO UNLOCK IT MANUALLY WITH NO LUCK. THE ACTUATORS THAT POWER THE MECHANICAL LOCKS FELT LIKE THEY WERE JAMMED AND WOULDN'T LET US UNLOCK THE DOORS MANUALLY. I FINALLY WAS ABLE TO GET IT UNLOCKED BY FORCING AND HOLDING THE MANUAL LOCK IN THE UNLOCK POSITION WHILE HITTING THE KEY FOB UNLOCK/LOCK FEATURE OVER AND OVER AGAIN. IT TOOK ME 10 MINUTES TO TROUBLESHOOT THIS IN ORDER TO GET THE KIDS OUT. IT NOW WORKS FOR AWHILE JUST FINE, AND THEN GETS STUCK AGAIN WHEN YOU LEAST EXPECT IT. I THOUGHT AFTER I HAD IT WORKING THAT IT WOULDN'T HAPPEN AGAIN. THIS HAS NOW HAPPENED FIVE MORE TIMES AFTER THE FIRST INCIDENT. THIS IS WHY I'M REPORTING IT. IF WE HAVE A EMERGENCY AND NEED TO GET OUT OF THE VEHICLE FAST, THESE DEFECTIVE DOORS COULD POTENTIALLY CAUSE INJURIES OR DEATH. THE SCARIEST PART ABOUT THIS IS, I NEVER KNOW WHEN THEY WILL ACT UP. I WOULD LEAVE THE DOORS UNLOCKED WHILE DRIVING, BUT THEY AUTOMATICALLY LOCK WHEN YOU REACH A CERTAIN SPEED. I SHOULDN'T HAVE TO DISABLE A SAFETY FEATURE TO FEEL SAFE DRIVING THIS VEHICLE WITH PASSENGERS IN THE BACK.

NHTSA ODI #11307619

46,361 miles · Feb 6, 2020
Structure

THE DRIVER'S SIDE SLIDING DOOR IS NOT UNLOCKING. THE DOOR WON'T OPEN, SO I AM UNABLE TO PUT MY BABY IN AND OUT OF HIS CAR SEAT THROUGH THAT DOOR. THE DOOR WON'T OPEN MANUALLY OR THROUGH THE USE OF THE AUTOMATIC LOCK BUTTONS. THE VEHICLE'S LOCKS WERE WORKING IN THE MORNING, BUT THE ONE LOCK STOPPED WORKING THAT EVENING. THE CAR W…

Read full complaint

THE DRIVER'S SIDE SLIDING DOOR IS NOT UNLOCKING. THE DOOR WON'T OPEN, SO I AM UNABLE TO PUT MY BABY IN AND OUT OF HIS CAR SEAT THROUGH THAT DOOR. THE DOOR WON'T OPEN MANUALLY OR THROUGH THE USE OF THE AUTOMATIC LOCK BUTTONS. THE VEHICLE'S LOCKS WERE WORKING IN THE MORNING, BUT THE ONE LOCK STOPPED WORKING THAT EVENING. THE CAR WAS STATIONARY AND IN A PARKING LOT WHEN THE LOCK WAS CHECKED AND FOUND TO BE MALFUNCTIONING. THIS IS DEFINITELY A SAFETY RISK BECAUSE I NEED TO BE ABLE TO GET MY BABY IN AND OUT OF HIS CAR SEAT IN CASE OF AN ACCIDENT. ALSO, THE SAFETY OF THE VEHICLE ISN'T GUARANTEED WITH THE FAULTY LOCK.

NHTSA ODI #11307476

45,000 miles · Feb 6, 2020
Structure

SLIDING DOOR BEHIND DRIVER IS CLOSED AND LOCKED. THE DOOR WILL NOT UNLOCK OR OPEN. I FEEL THIS IS A SAFETY ISSUE FOR THE REAR PASSENGERS. IN ANOTHER VAN I RAN OVER A PIECE OF STEEL ON THE HIGHWAY AND PUT A HOLE IN THE GAS TANK. AFTER PULLING OVER TO THE SIDE OF THE HIGHWAY AND SMELLING GAS ALL REAR PASSENGERS WAS ABLE TO GET …

Read full complaint

SLIDING DOOR BEHIND DRIVER IS CLOSED AND LOCKED. THE DOOR WILL NOT UNLOCK OR OPEN. I FEEL THIS IS A SAFETY ISSUE FOR THE REAR PASSENGERS. IN ANOTHER VAN I RAN OVER A PIECE OF STEEL ON THE HIGHWAY AND PUT A HOLE IN THE GAS TANK. AFTER PULLING OVER TO THE SIDE OF THE HIGHWAY AND SMELLING GAS ALL REAR PASSENGERS WAS ABLE TO GET OUT ON BOTH SIDES. I HAVE HEARD OF OTHER DODGE VANS HAVING THE SAME PROBLEM.

NHTSA ODI #11307475

68,000 miles · Feb 4, 2020
Electrical SystemStructure

WE STOPPED TO GET GAY GAS WHILE ON VACATION, EVERYONE EXITED THE VAN AND SHUT ALL THE DOORS. WHEN WE CAME BACK AND I PUSHED THE BUTTON ON THE KEY FOB TO OPEN THE SLIDER DOORS OPEN O LY THE PASSENGER SIDE DOOR OPENED. I WENT TO OPEN IT FROM THE INSIDE AND IT WOULDN'T BUDGE. I UNLOCKED ALL DOORS AND STILL WON'T OPEN. IT FEELS …

Read full complaint

WE STOPPED TO GET GAY GAS WHILE ON VACATION, EVERYONE EXITED THE VAN AND SHUT ALL THE DOORS. WHEN WE CAME BACK AND I PUSHED THE BUTTON ON THE KEY FOB TO OPEN THE SLIDER DOORS OPEN O LY THE PASSENGER SIDE DOOR OPENED. I WENT TO OPEN IT FROM THE INSIDE AND IT WOULDN'T BUDGE. I UNLOCKED ALL DOORS AND STILL WON'T OPEN. IT FEELS AS THOUGH THE MANUAL LOCK IS JAMMED ON LOCK POSITION!. I FEEL THIS IS A SAFETY ISSUE. IF THERE WERE A NEED TO OPEN THAT DOOR IN AN EMERGENCY IT WOULD NOT WORK! I HAVE ALSO READ ON MULTIPLE CHAT SITES OF OTHER PEOPLE WITH THIS PROBLEM. I FEEL IT NEEDS A RECALL SO IT GETS FIXED.

NHTSA ODI #11307122

75,500 miles · Jan 29, 2020
Electrical System

SLIDING DOOR LOCK ACTUATOR IS MAKING A GRINDING OR BUZZING NOISE.

NHTSA ODI #11302828

118,000 miles · Jan 29, 2020
Power Train

TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING AT 45 MPH, THERE WAS AN ABNORMAL SOUND AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT PULLED THE VEHICLE OFF OF THE ROADWAY AND CONTACTED AND TOW TRUCK COMPANY TO HAVE THE VEHICLE TOWED. THE VEHICLE WAS TOWED TO (STEVE WHITE MOTORS LOC…

Read full complaint

TL* THE CONTACT OWNS A 2016 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING AT 45 MPH, THERE WAS AN ABNORMAL SOUND AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT PULLED THE VEHICLE OFF OF THE ROADWAY AND CONTACTED AND TOW TRUCK COMPANY TO HAVE THE VEHICLE TOWED. THE VEHICLE WAS TOWED TO (STEVE WHITE MOTORS LOCATED AT 3470 HIGHWAY 70 SE, NEWTON, NC 28658), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRANSMISSION TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. UPON INVESTIGATION THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 16V461000 (POWER TRAIN). THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 118,000. *BF*JB

NHTSA ODI #11302761

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

20V278000 · Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:storage:tank Assembly

May 15, 2020

Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.

Additional source detail variants (2)

Fuel System, Gasoline:delivery:fuel Pump

Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.

Fuel System, Gasoline:storage:tank Assembly

Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1-800-488-9082.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

16V461000 · Power Train:automatic Transmission

Jun 24, 2016

Chrysler (FCA US LLC) is recalling certain model year 2015-2016 Chrysler Town & Country, Dodge Grand Caravan vehicles manufactured July 31, 2015, to April 18, 2016, 2016 Dodge Journey vehicles manufactured August 17, 2015, to January 29, 2016, and 2016 RAM ProMaster vehicles manufactured August 15, 2016, to April 15, 2016. The transmission pump may seize causing a loss of hydraulic pressure.

Consequence & remedy

Consequence: If the transmission loses hydraulic pressure, the vehicle may lose motive power, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace the transmission pump, free of charge. The recall began on August 18, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S44.

16V300000 · Seats:mid/rear Assembly

May 16, 2016

Chrysler (FCA US LLC) is recalling certain model year 2016 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured March 16, 2016, to March 17, 2016. The nuts on the third row seatbacks were incorrectly torqued and may become loose.

Consequence & remedy

Consequence: If the third row seatback becomes loose, it may separate from the seat frame, increasing the risk of injury.

Remedy: Chrysler will notify owners, and dealers will re-torque the third row seatback nuts, free of charge. The recall began on July 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S37.

15V595000 · Latches/locks/linkages:hood:latch

Sep 24, 2015

Chrysler Group LLC (Chrysler) is recalling certain model year 2016 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 19, 2015 to August 27, 2015. In the affected vehicles, the bolts that attach the hood striker may loosen and, as a result, the hood may open unexpectedly while driving.

Consequence & remedy

Consequence: If the hood opens while driving, the driver's vision may be obstructed, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will install new hood striker bolts with the proper torque, free of charge. The recall began on October 22, 2015. Owners may contact Chrysler's customer service at 1-800-853-1403. Chrysler's recall number is R53.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE21016 · Sliding Doors Inoperative

Opened Jul 9, 2021 · Closed Jul 22, 2022

Status: closed (inferred from source dates) · Latches/locks/linkages:doors:lock

The Office of Defects Investigation (ODI) opened PE21-016 on July 7, 2021, to investigate 364 complaints alleging that one or both sliding doors on 2016 Model Year (MY) Grand Caravan or Town and Country vehicles could not be opened. The door(s) could not be opened using the mechanical handle or electronic remote switches. Many of the complaints described having to remove passengers seated in the rear of vehicles through the front doors, the second sliding door (if it was operational), the window, or the car?s rear hatch. The complainants have expressed concerns that if the sliding door(s) cannot be opened in the event of an emergency or crash, it could trap passengers or delay their egress.On June 4, FCA published TSB# 23-017-20 instructing dealers to replace the door lock actuator instead of the entire door latch assembly on the subject vehicles when consumers complained about either one or both of the sliding door locks not functioning and/or emitting a loud buzzing noise during lock/unlock operation. On June 16, 2021, FCA approved a Quality Warranty Extension for fifteen years/150,000 miles from the vehicle's in-service date for sliding door lock actuators on vehicles built between May 1, 2015, through January 9, 2017. FCA has started notifying owners about the new program. FCA will provide reimbursement for owners who previously paid for sliding door repairs.Consumers whose sliding doors are inoperative will have the opportunity to have their vehicle diagnosed, and if a fault is identified, have the sliding door actuator repaired at no charge.Analysis of the FCA IR response and ODI complaint data found that the majority (96%) of sliding door failures occurred prior to the calendar year 2020 when the subject vehicles had approximately 4 years in service. At the time of the closing of this investigation, 99% of the subject vehicles are passed the age where failures typically occur. The number of new reports has been decreasing since 2020 and further reduced following the FCA Warranty Extension program. ODI found that prior to a failure of the sliding door(s) there is normally a loud buzzing noise/sound generated that alerts the operator to the actuator starting to wear out.ODI has not identified any crashes or injury allegations due to the sliding door being inoperable on the subject vehicles following nearly six years of exposure. ODI will continue to monitor complaints received for the incidence of sliding doors becoming inoperative.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.For a complete summary of this investigation and related consumer complaints, please see attached closing resume document.

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.