Electrical System. Review the 128 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

11 crash reports13 fire reports18 injury reports

Engine complaints

80 reports

Clear category filter

Mileage unknown · Jan 16, 2017

Engine

OIL FILTER HOUSING HAS A MAJOR OIL LEAK. PART # 68105583AE IS ON NATIONAL BACK ORDER BECAUSE SO MANY OF THESE HAVE FAILED. I HAVE CALLED DEALERSHIPS ACROSS THE COUNTRY AND NO ONE WILL SELL ONE DUE TO THE AMOUNT OF FAILURES AND THE ONLY WAY TO GET THE PART REPLACED IS TO HAVE THE DEALERSHIP'S SERVICE DEPARTMENT REPLACE ONE.

NHTSA ODI #10945466

57,000 miles · Nov 2, 2016

EnginePower Train

Read full complaint

WHILE DRIVING THE VAN JUST CUT OFF IN THE MIDDLE OF THE ROAD. IT MANAGED TO ROLL TO THE SHOULDER AND STARTED. THE VAN WAS DRIVEN A LITTLE FURTHER AND THE SAME THING HAPPENED AGAIN. THE NEXT DAY THE SAME THING HAPPENED. IT WAS TAKEN TO A DEALERSHIP AND THEY SAID IT WAS THE WRONG SIZE TIRES ON THE REAR CAUSED THE ABS TO COME ON AND STOPPED THE VEHICLE. THEY REPLACED THE TIRES AND RETURNED THE VAN. TWO DAYS LATER IT DID THE SAME THING. TOOK THE VAN BACK AND THEY KEPT IT FOR OVER A MONTH. THEY REPLACED THE TRANSMISSION & RETURNED IT. THE SAME PROBLEM OCCURRED AGAIN AND WAS TAKEN BACK. THE DEALERSHIP COULD RECREATE THE PROBLEM BUT DIDN'T KNOW WHAT WAS WRONG WITH IT. ANOTHER MONTH OR MORE GOES BY AND THEY DECIDED THAT THE PUMP THAT THEY REPLACED WAS DEFECTIVE. THEY REPLACED THE PUMP AND RETURNED THE VAN. A COUPLE OF WEEKS GO BY AND THE VAN IS CUTTING OFF AGAIN. IT IS CURRENTLY AT THE DEALERSHIP AGAIN. EACH TIME THAT THIS HAPPENED THE VEHICLE WAS BEING DRIVEN ON A ROADWAY IN TRAFFIC. THIS REALLY COULD CAUSE AN ACCIDENT. I BELIEVE THIS VEHICLE IS JUST A LEMON AND CANNOT BE REPAIRED TO THE POINT THAT ANYONE FEELS SAFE DRIVING IT. *TR

NHTSA ODI #10923876

5 miles · Aug 30, 2016

Electrical SystemElectronic Stability Control (esc)Engine

Read full complaint

I WAS DRIVING AT NIGHT AND ALL OF A SUDDEN THE CAR DIED WHILE IN MOTION; THE ENGINE STOP WORKING, THE LIGHTS WENT VERY DIM AND IT WAS DIFFICULT TO DRIVE IT AT THAT MOMENT, I ALMOST GOT HIT FROM THE CAR BEHIND ME AND I WAS CLOSE TO HIT THE CAR IN FRONT OF ME. I DIDN'T GET ANY WARNING LIGHTS FOR THE ENGINE OR THE BATTERY. I TRIED TO TURN IT ON AGAIN AND IT CRANKED BUT DIDN'T START. A LITTLE LATTER I TRIED AGAIN AND THE CAR STARTED. WHILE DRIVING BACK HOME I NOTICE THAT THE LIGHTS WERE DIM, BUT I DIDN'T GET ANY WARNING LIGHTS FROM THE ENGINE OR THE BATTERY AGAIN. I ALSO NOTICED THAT THE STEREO RESET ALL THE STATIONS AND THE CLOCK. IT WAS VERY DANGEROUS. I AM VERY UPSET BECAUSE THAT'S THE CAR MY KIDS RIDE EVERYDAY.

NHTSA ODI #10899523

38,000 miles · Jul 15, 2016

EngineFuel/propulsion SystemVehicle Speed Control

Read full complaint

FUEL LINE FAILURE WHILE MERGING ONTO MAJOR HIGHWAY. THIS RESULTED IN LOSS OF ACCELERATION AND POWER STEERING ON THE HIGHWAY. VEHICLE COASTED / ROLLED TO THE NEXT AVAILABLE HIGHWAY EXIT. UPON INSPECTION OF THE ENGINE COMPARTMENT, I OBSERVED BOILING LIQUID; VEHICLE WAS NON-FUNCTIONAL AND HAD TO BE TOWED TO DEALER. ODB SCANNER REPORTED IT AS A #2 CYLINDER FAILURE. PRIOR TO HIGHWAY FAILURE, VAN HAD PROBLEMS WITH THE CHECK ENGINE LIGHT RESULTING FROM A #2 CYLINDER MISFIRE. TOOK THE VAN TO DEALER AND THEY DID NOT FIND THE CORRECT PROBLEM, SO PAID TWICE FOR SERVICE. THE FIRST PAYMENT TO FIX RESULTED FROM THE CHARGE FOR INSPECTION FROM THE CHECK ENGINE LIGHT. SECOND CHARGE RESULTED AFTER NEEDING TO HAVE THE VEHICLE TOWED TO THE DEALERSHIP, AND AFTER THE DEALER FIXED THE FUEL LINE ISSUE.

NHTSA ODI #10885187

112,000 miles · Mar 28, 2016

Engine

Read full complaint

OUR 2014 DODGE GRAND CARAVAN HAS THE SAME EXACT ISSUES AS 2011-2013 MODELS WITH THE MISFIRE ON CYLINDER 2 OR MULTIPLE CYLINDERS, AS WELL AS THE ENGINE TICKING. WE HAVE TRIED TO PURSUE THIS PROBLEM WITH CHRYSLER VIA OUR LOCAL DODGE DEALERSHIP. THEY SAY IT IS A MERE COINCIDENCE. WE FEEL THAT IT IS A CONTINUATION OF THE SAME PROBLEM INTO THE NEW MODEL YEAR, AND THAT THEIR SUPPOSED FIX FOR THIS PROBLEM IS NOT WHAT THEY THOUGHT IT WOULD BE. THE ENGINE LIGHT CAME ON WITHIN HOURS OF PURCHASING IT FROM A REPUTABLE USED CAR DEALERSHIP. RETURNED TO DEALER, THEY READ THE CODE, SAID IT WAS PROBABLY JUST A FLUKE, AND RESET IT. A COUPLE HOURS LATER IT CAME BACK ON. BROUGHT IT BACK TO THE DEALERSHIP. THEY TRIED THE "EASY" FIXES (SPARK PLUGS, WIRES, COIL) AND THE ENGINE CONTINUED TO THROW THE SAME CODE. THEY BROUGHT IT TO A REGULAR DODGE DEALERSHIP, WHERE THEY CLEANED THE INJECTORS, SAID THE PROBLEM WAS SOLVED AND SENT US ON OUR WAY. WITHIN HOURS IT THREW THE SAME CODE. CALLED THE DEALERSHIP, BUT THEY DID NOT RESPOND. WE LIVED 8 HOURS AWAY, AND WERE HALFWAY HOME AT THAT POINT. SO WE TRIED TO PURSUE IT WITH OUR LOCAL DEALERSHIP, AND THEY ARE SAYING IT IS JUST A COINCIDENCE. WE HAVE DONE EXTENSIVE RESEARCH, BOTH BEFORE AND AFTER PURCHASING THE VEHICLE, AND INTENTIONALLY AVOIDED THE 11-13 MODELS BECAUSE OF THIS EXACT PROBLEM. NOW WE REALIZE WE SHOULD HAVE BOUGHT ONE OF THOSE MODEL YEARS BECAUSE DODGE WILL CORRECT THEIR PROBLEM. HOWEVER, NOT ENOUGH COMPLAINTS HAVE BEEN MADE ABOUT THE 14S TO GET THEM TO OWN UP TO THE CONTINUED PROBLEM AND OFFER A REPAIR. ALL WE GOT FROM THE LOCAL DEALERSHIP WAS A QUOTE FOR $2500 TO FIX THIS PROBLEM. OUR RESEARCH HAS TURNED UP SEVERAL OTHER 2014 VEHICLES WITH THE SAME PENTASTAR ENGINE (NOT NECESSARILY GRAND CARAVANS) THAT ARE HAVING THE SAME ISSUE. DODGE EXTENDED THE WARRANTY FOR 11-13 TO 150,000 DUE TO THIS EXACT SAME PROBLEM. THEY SHOULD INCLUDE 2014.

NHTSA ODI #10852104

16,981 miles · Jan 30, 2016

Electrical SystemElectronic Stability Control (esc)Engine

Read full complaint

MIL LIGHT CAME ON. HAD OIL CHANGED & CHECKED. MIL DID NOT TURN OFF. TPMS LIGHT CAME ON. CHECKED TIRES. TPMS LIGHT DID NOT TURN OFF. ESC LIGHT CAME ON. VEHICLE GOT STUCK IN PARK SEVERAL TIMES. GOT VEHICLE OUT OF PARK AND DROVE HOME. VEHICLE WAS PARKED FOR A FEW DAYS. TRIED TO START. DEAD BATTERY. CHARGED BATTERY AND STARTED VEHICLE. VEHICLE WOULD NOT TURN OFF EVEN WITH IGNITION KEY REMOVED. VEHICLE OVERHEATED TO MAX TEMPERATURE ON GAUGE, BEGAN TO STEAM AND SPILLED A LOT OF COOLANT. VERY AFRAID VEHICLE WOULD CATCH FIRE. CALLED AAA AND TOW TRUCK DRIVER LOCATED AND REMOVED FUSE TO SHUT DOWN RUNNING VEHICLE. HAD VEHICLE TOWED TO CHRYSLER DODGE DEALERSHIP. AFTER A WEEK STILL HAVE NOT HEARD FROM DEALERSHIP SERVICE DEPARTMENT OR CHRYSLER. THE VEHICLE BEING STUCK WITH THE ENGINE RUNNING EVEN WITH IGNITION KEY REMOVED AND SUBSEQUENT RAPID OVERHEATING AND LOSS OF COOLANT PRESENTED AN EXTREMELY DANGEROUS SITUATION WITH THE STRONG POTENTIAL FOR A VEHICLE FIRE. THE TPMS LIGHT MALFUNCTION LEAVES THE DRIVER UNABLE TO DETERMINE IF THERE REALLY IS AN UNDERINFLATED TIRE AND/OR TIRES. THE ESC LIGHT MALFUNCTION LEAVES THE DRIVER UNABLE TO USE THIS FUNCTION FOR IMPROVED THE VEHICLE'S TRACTION IN VATIOUS SITUATIONS.

NHTSA ODI #10823250

10,000 miles · Sep 21, 2015

Electrical SystemEngineVehicle Speed Control

Read full complaint

MY 2014 GRAND CARAVAN HAS BEEN HAVING ISSUES WITH NOT STARTING. I MAY HAVE TO TRY 4 TIMES BEFORE IT WILL START. THIS WAS BAD ENOUGH, BUT IT HAS ALSO LEFT ME SITTING IN VERY BUSY TRAFFIC 3 TIMES IN THE LAST TWO WEEKS. THE FIRST TIME HAPPENED AS I WAS EXITING OFF THE INTERSTATE. THE CAR JUST WENT DEAD WITH NO WARNING. I WAS ABLE TO RESTART AND KEEP GOING. THE SECOND AND THIRD INCIDENTS HAPPENED YESTERDAY. THE FIRST TIME IT WENT DEAD YESTERDAY WAS AS I WAS PULLING OUT OF MY DRIVEWAY. I WAS COMPLETELY ON THE ROAD AND WAS IN THE PROCESS OF TRYING TO ACCELERATE. MY CAR BEGAN TO SHAKE, ALL LIGHTS CAME ON THE PANEL, AND THE CAR WAS DEAD. THE SECOND TIME THIS HAPPENED YESTERDAY, I WAS SLOWING DOWN TO STOP AT A RED LIGHT ON A VERY BUSY 4 LANE HIGHWAY. THE CAR WENT DEAD WITH NO WARNING. WE TOOK THIS CAR TO THE DEALERSHIP TO HAVE IT CHECKED. THEY SAID THERE WAS NOTHING THEY COULD DO BECAUSE THERE WAS NO CODE. I REFUSE TO DRIVE THIS CAR, THAT WE'VE HAD LESS THAN A YEAR, BECAUSE I FEAR FOR MY LIFE AND EVEN MORE FOR MY CHILD'S LIFE. THIS NEEDS TO BE FIXED IMMEDIATELY.

NHTSA ODI #10766299

5,000 miles · Jun 7, 2015

EngineService BrakesSteering

WHILE SLOWING DOWN TO ENTER A PARKING LOT, THE CAR ENGINE STOPPED. THE POWER STEERING WENT AS DID THE BRAKES. I PUT IT INTO NEUTRAL AND STARTED THE CAR. SINCE THEN IT HAS RANDOMLY STOPPED AT LOW SPEED DOZENS OF TIMES, SLOWING FOR A RED LIGHT OR ENTERING A PARK LOT. THE CAR HAS BEEN TO THE SHOP 6 TIMES. 3 DIFFERENT ELECTRONI…

Read full complaint

NHTSA ODI #10723828

100 miles · May 13, 2015

Electrical SystemEngine

WE PURCHASED THE VEHICLE ON 9/27/15. ON 10/3/14 WHILE DRIVING 70 MPH ON THE INTERSTATE THE VEHICLE DIED AND SHOOK VIOLENTLY. ALL SYSTEM INDICATOR LIGHTS FLASHED RANDOMLY. 10/4/14 THE VEHICLE DIED WHILE AT A STOP SIGN. 5/6/15 THE VEHICLE DIED WHILE AT A STOP SIGN. 5/10/15 THE BATTERY LIGHT APPEARED FOR 2 HOURS.

NHTSA ODI #10716146

17,000 miles · May 4, 2015

Engine

AS I WAS AT A STOP MY CAR STALLED. THEN STARTED BOGGING REAL BAD AS IF IT WAS RUNNING ON 4 CYLINDERS. HAD IT TOWED TO THE DEALER AND THE CHECK ENGINE LIGHT WAS FLASHING. THEY PUT IT ON THE MACHINE AND SAID IT WAS FINE. 2 WEEKS LATER THE SAME THING HAS HAPPENED AND THEY ARE TELLING ME THEY CAN NOT DIAGNOSE THE PROBLEM. *TR

NHTSA ODI #10714515

Official recalls

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V824000 · Equipment

Dec 21, 2017

Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence & remedy

Consequence: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.

Remedy: Chrysler will notify owners instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began February 14, 2018. Owners may contact Chrysler customer service at 1-800-853-1403 or Kidde customer service service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Chrysler's number for this recall is T82.

16V044000 · Visibility:windshield

Jan 28, 2016

FCA US LLC (Chrysler) is recalling certain model year 2015-2016 Chrysler Town and Country, and 2014-2015 Dodge Grand Caravan vehicles manufactured August 16, 2014, to December 5, 2015. The windshield on the affected vehicles may have been installed using expired urethane primer, allowing the windshield to become displaced in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."

Consequence & remedy

Consequence: If the windshield dislodges during a crash, there is an increased risk of occupant injury.

Remedy: Chrysler will notify owners, and dealers will replace the windshield, free of charge. The recall began March 4, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S02.

14V632000 · Tires:pressure Monitoring And Regulating Systems

Oct 8, 2014

Chrysler Group LLC (Chrysler) is recalling certain model year 2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured March 20, 2014, to April 22, 2014, and 2014 Jeep Wrangler vehicles manufactured March 21, 2014, to April 22, 2014. Due to a software error, the Tire Pressure Monitoring System (TPMS) may fail to learn the locations of the individual sensors while the vehicle is being driven. As a result, the low tire pressure warning light will illuminate, despite the the tire pressures being within specification. Should one of the tires lose air pressure, the driver would not be notified of the change in air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 138, "Tire Pressure Monitoring Systems."

Consequence & remedy

Consequence: If the TPMS light illuminates because the sensors cannot be located, it could mask an actual low tire pressure condition, possibly resulting in tire failure, increasing the risk of a crash.

Remedy: Chrysler has notified owners, and dealers will reprogram the TPMS module, free of charge. The recall began on October 23, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P63.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

Seats:front Assembly:head Restraint

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den