← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

What owners actually said

583 reports
36,000 miles · Jun 25, 2014
Service BrakesSteering

VEHICLE HAS ROUGHLY 36000 MILES, WHEN BRAKING THE STEERING SHAKES HARD, VIBRATING. WORRIED ONE DAY ONE OF MY TIRES IS GOING TO FALL OFF OR THE STEERING STOP WORKING AND LOOSE CONTROL OF THE VEHICLE. EVEN DODGE HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THIS EXACT PROBLEM, THE DEALERSHIP WON'T DO ANYTHING ABOUT IT BECAUSE THEY …

Read full complaint

VEHICLE HAS ROUGHLY 36000 MILES, WHEN BRAKING THE STEERING SHAKES HARD, VIBRATING. WORRIED ONE DAY ONE OF MY TIRES IS GOING TO FALL OFF OR THE STEERING STOP WORKING AND LOOSE CONTROL OF THE VEHICLE. EVEN DODGE HAS ISSUED A TECHNICAL SERVICE BULLETIN FOR THIS EXACT PROBLEM, THE DEALERSHIP WON'T DO ANYTHING ABOUT IT BECAUSE THEY SAY IT IS NOT COVERED UNDER WARRANTY BUT ADMITS THAT IT IS A DESIGN FLAW WITH THE VEHICLE BEING BUILT WITH SUBSTANDARD PARTS. *TR

NHTSA ODI #10605919

8,500 miles · Jun 10, 2014
Service Brakes

SINCE WE BOUGHT THE VEHICLE, WITHIN 6 MONTHS OF PURCHASE BRAKES STARTED MAKING SQUEAKING NOISE, BRAKES GOT CLEANED AT A LOCAL SHOP; AND STARTED MAKING NOISE AGAIN IN ABOUT 6 MONTHS, TOOK TO THE DODGE DEALERSHIP AT ABOUT APX. 8,000, DON'T REMEMBER EXACT DATE; THEY DID A COMPLETE BRAKE JOB NEW PADS ROTORS AND ALIGNMENT, AT 6 MONTH…

Read full complaint

SINCE WE BOUGHT THE VEHICLE, WITHIN 6 MONTHS OF PURCHASE BRAKES STARTED MAKING SQUEAKING NOISE, BRAKES GOT CLEANED AT A LOCAL SHOP; AND STARTED MAKING NOISE AGAIN IN ABOUT 6 MONTHS, TOOK TO THE DODGE DEALERSHIP AT ABOUT APX. 8,000, DON'T REMEMBER EXACT DATE; THEY DID A COMPLETE BRAKE JOB NEW PADS ROTORS AND ALIGNMENT, AT 6 MONTHS BREAKS STARTED SQUEAKING AGAIN. HAD BRAKES CLEANED AT A MECHANIC SHOP, NOISE STOPPED. THEN AGAIN AT 23,340 MILES, IN AT THE SHOP AGAIN, THEY TELL ME BRAKE PADS ARE NORMAL WEAR AND TEAR AND ARE NOT COVERED; BUT NOW THE FRONT AXLES ARE MAKING NOISES WHEN THE WHEEL TURNS AND REGULAR DRIVING WITHOUT BREAKING, LIKE A CLICK, CLICK, CLICK SOUND AS THE FRONT WHEELS TURN. WHEN APPLYING BRAKES THE VEHICLE SEEMS TO SHAKE A BIT AND MAKES SQUEAKING NOISES WHEN BRAKING. I BOUGHT THE VEHICLE BRAND NEW AND DO NOT TOW ANYTHING WITH IT, JUST NORMAL DRIVING TO AND FROM WORK; BUT THE BRAKES ISSUE SEEMS TO BE A CONSTANT ISSUE EVERY 6 MONTHS TO A YEAR. IT WILL BE REQUIRING ANOTHER BRAKE CHANGE AND PROBABLE AXLE REPAIR; AM WAITING FOR RESOLUTION UNDER FILE NO. 25141204 WITH DODGE, AM WAITING TO HEAR BACK. BUT IT SEEMS TO BE A BRAKES DEFECT IN THE 2012 DODGE GRAND CARAVAN VAN. I DO NOT FEEL SAFE DRIVING THIS VEHICLE BECAUSE OF THE BRAKES ISSUE. THEY TOLD ME AT THE DEALERSHIP THAT IT'S BECAUSE THEY ARE MOPAD PADS, AND THAT THEY ONLY LAST ABOUT 12,000 MILES AND WEAR OUT ARE NOT COVERED UNDER WARRANTY. I BOUGHT THE EXTENDED WARRANTY ON THE VEHICLE AT THE TIME OF PURCHASE, BUT THE BRAKES PROBLEM IS A RECURRING THING; THEY SEEM TO START MAKING NOISE AT ABOUT 6 MONTHS AFTER EACH FIX AND BRAKE PADS BEING WORN OUT WITHIN A YEAR. DON'T KNOW WHAT ELSE TO DO. *TR

NHTSA ODI #10597461

53,000 miles · Jun 7, 2014
SeatsInjury

ON SEVERAL OCCASIONS, THE LATEST BEING TODAY, THE SEATS HAVE ATTACKED PASSENGERS BY SPRINGING FORWARD IN A VERY UNSAVORY MANNER. ON THE REAR BENCH SEAT, THE HEADREST WHEN IN LOCKED MODE WILL RELEASE WITH A FURY ONLY KNOWN TO THE MOST VICIOUS OF CREATION SMASHING INTO THE HEAD OF THE GUEST. THE MIDDLE SEAT HAS AN EQUALLY NASTY VE…

Read full complaint

ON SEVERAL OCCASIONS, THE LATEST BEING TODAY, THE SEATS HAVE ATTACKED PASSENGERS BY SPRINGING FORWARD IN A VERY UNSAVORY MANNER. ON THE REAR BENCH SEAT, THE HEADREST WHEN IN LOCKED MODE WILL RELEASE WITH A FURY ONLY KNOWN TO THE MOST VICIOUS OF CREATION SMASHING INTO THE HEAD OF THE GUEST. THE MIDDLE SEAT HAS AN EQUALLY NASTY VERTICAL EFFECT THAT ALMOST BROKE MY TWEEN'S NOSE TODAY AS SHE WAS ADJUSTING THE SEAT. DODGE NEEDS TO LOOK AT THE SPRING ACTION ON ALL OF THE SEAT COMPONENTS AND RECALL ALL VEHICLES WITH STOW AND GO SEATS AND LESSON THE STRENGTH OF THE SEAT RECLINING SPRINGS. *TR

NHTSA ODI #10596788

55,000 miles · May 20, 2014
Service Brakes

DODGE GRAND CARAVAN 2012; NOTICED ABOUT 3 MONTHS AGO THAT THE REAR ROTORS WERE BECOMING SO HOT THAT YOU COULD MELT A STICK OF BUTTER BY JUST HOLDING IT NEAR AFTER DRIVING (30 MINUTES NON-INTENSE DRIVING). ONE TIME THE ROTORS WERE EVEN SMOKING AFTER. I HAVE ALREADY REPLACED BOTH REAR ROTORS/BRAKES TWICE AND JUST BOUGHT THE…

Read full complaint

DODGE GRAND CARAVAN 2012; NOTICED ABOUT 3 MONTHS AGO THAT THE REAR ROTORS WERE BECOMING SO HOT THAT YOU COULD MELT A STICK OF BUTTER BY JUST HOLDING IT NEAR AFTER DRIVING (30 MINUTES NON-INTENSE DRIVING). ONE TIME THE ROTORS WERE EVEN SMOKING AFTER. I HAVE ALREADY REPLACED BOTH REAR ROTORS/BRAKES TWICE AND JUST BOUGHT THE CAR (USED) IN DEC 2012. I DO NOT DO ANY DISTANCE DRIVING, AND MOST IS NOT CITY. I BROUGHT THE CAR TO A MECHANIC WHO RECOMMENDED A COMPLETE CALIPER/ROTOR/PAD REPLACEMENT AT AROUND $600. SEEMED LIKE A GENERIC FIX. I DECLINED, AS I CAN DO THIS WITH A FREE WEEKEND, AND HAD NO GUARANTEE OF FIXING THE PROBLEM LOOKING AT OTHER REPORTED ISSUES. THE ROTORS CONTINUE TO GET HOT (USUALLY NOT BOTH AT THE SAME TIME, BUT RATHER ONE MORE THAN THE OTHER EACH TIME), AND AM AFRAID TO DRIVE ANY FARTHER THAN THE 30 MIN COMMUTE TO WORK. I HAVE READ SO MANY STORIES OF THE SAME ISSUE OCCURRING TO DODGE/CHRYSLER OWNERS, AND ONES GOING ALL THE WAY BACK TO 2008 MODELS. I CAN'T FATHOM HOW THIS WOULD STILL BE AN ISSUE IN A 2012 MODEL, AND THAT NOTHING HAS BEEN DONE TO HELP THE CONSUMER AND CORRECT THE MISTAKE. EVEN THE DEALERSHIP MECHANIC TOLD ME THAT THE ROTORS ARE TOO SMALL TO HANDLE THE HEAT. I HAVE NIGHTMARES OF THE DAY THAT IT GETS SO HOT THAT SOMETHING IN THE ASSEMBLY OR TIRE GOES AND SENDS MY FAMILY OF 4 AND 2 UNBORN CHILDREN INTO ONCOMING TRAFFIC. *TR

NHTSA ODI #10592928

Mileage unknown · May 13, 2014
Equipment

CPCS: I1440342A. CAR CHARGER. CONSUMER STATED SHE HAD THE CHARGER PLUGGED INTO THE OUTLET IN HER 2012 DODGE GRAND CARAVAN, AN IT STARTED SMOKING WITH NO DEVICE PLUGGED INTO IT. *LN

NHTSA ODI #10589008

43,500 miles · May 12, 2014
Wheels

HUMMING NOISE COMING FROM THE REAR OF THE VEHICLE. TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT BOTH REAR WHEEL BEARINGS NEED TO BE REPLACED. I HAVE NEVER HAD TO REPLACE WHEEL BEARING ON A CAR MUCH LESS AFTER ONLY 43,500 MILES. *TR

NHTSA ODI #10587783

500 miles · May 5, 2014
Structure

IT SHAKES RATTLES , RIDES LIKE FREIGHT TRUCK NOT SMOOTH RIDING AT ALL AIR COMES AROUND ALL DOORS DUST ALSO , DOORS RATTLE LIKE THEY WERE NOT SHUT PROPERLY THE VAN WHISTLES AT VARIOUS TIMES SOUNDS LIKE COMING FROM MOTOR OR FRONT OF VAN UNDER HOOD SOMEWHERE MIDDLE SEATS DO NOT FOLD DOWN INTO THE COMPARTMENT AS SHOWS TO BE ST…

Read full complaint

IT SHAKES RATTLES , RIDES LIKE FREIGHT TRUCK NOT SMOOTH RIDING AT ALL AIR COMES AROUND ALL DOORS DUST ALSO , DOORS RATTLE LIKE THEY WERE NOT SHUT PROPERLY THE VAN WHISTLES AT VARIOUS TIMES SOUNDS LIKE COMING FROM MOTOR OR FRONT OF VAN UNDER HOOD SOMEWHERE MIDDLE SEATS DO NOT FOLD DOWN INTO THE COMPARTMENT AS SHOWS TO BE STOW A WAY SEATS IT REAL SHAKES BOUNCES LIKE NO SHOCKS ON IT NOT SMOOTH RIDING LIKE THE DEMO VANS I TEST DROVE AND IS REALLY LOAD ON INSIDE FROM OUT SIDE VAN FROM OTHER NOISES AND WIND I HAVE HAD IT INTO THE DEALER 2 TIMES FOR THIS I HAD LESS THAN 10,000 MILES FIRST TIME AND IT RODE AS IF THE VAN WAS 200,000 MILES AND OVER 10 YEARS OLD THEY STATED THEY FIXED IT BUT IT WAS NOT. IT HAS BEEN THIS WAY SINCE THE DAY WE BOUGHT IT DEALER SAYS IT GETS BETTER AFTER 2 OR 3 THOUSAND MILES OR FIRST OIL CHANGE BUT IT HAS NOT NOW IT HAS THE WHISTLE THING GOING ON BOUGHT THE VAN MAY 22 2012 PAID ALMOST $30,000. FOR IT EXPECT FOR THIS KIND OF MONEY IT WOULD RIDE SMOOTHER LIKE THE DEMOS I TEST DROVE I AM VERY DISAPPOINTED IN IT . A FRIEND ASKED ABOUT BUYING A NEW ONE LIKE MINE (SHE HAS HANDICAP CHILD) I TOLD HER TO BUY KIA INSTEAD IT WOULD RIDE BETTER . IT WOULD BE BETTER IF DEALERSHIP HAD NOT LIED ALSO THEY WERE SUPPOSE TO REFUND THE $900. EXCISE TAX IF I BOUGHT IT THAT DAY AND STILL HAD TO WAIT OVER A WEEK FOR THE DELIVERY TO DEALER BEFORE I GOT MY VAN. *TR

NHTSA ODI #10586707

22,300 miles · May 3, 2014
Visibility

MY VEHICLE WAS PARKED IN MY DRIVEWAY ABOUT 50 FEET AWAY FROM THE ROAD AT APPRX 11:00 AM 5/3/2014 WHEN ME AND MY HUSBAND HEARD A POP LOOKED OUTSIDE TO SEE THAT MY REAR WINDSHIELD EXPLODED. MY SIDE VENTS WHERE BOTH OPEN ON THE VEHICLE AND IT WAS NOT DRIVEN SINCE 5/2/2014 AT 12:30 PM. THEN WAS PARKED FROM THERE ON. POLICE CAME BY A…

Read full complaint

MY VEHICLE WAS PARKED IN MY DRIVEWAY ABOUT 50 FEET AWAY FROM THE ROAD AT APPRX 11:00 AM 5/3/2014 WHEN ME AND MY HUSBAND HEARD A POP LOOKED OUTSIDE TO SEE THAT MY REAR WINDSHIELD EXPLODED. MY SIDE VENTS WHERE BOTH OPEN ON THE VEHICLE AND IT WAS NOT DRIVEN SINCE 5/2/2014 AT 12:30 PM. THEN WAS PARKED FROM THERE ON. POLICE CAME BY AND SAW NO FOUL PLAY. *TR

NHTSA ODI #10586328

55,000 miles · Apr 28, 2014
EnginePower TrainVehicle Speed Control

ENGINE RUNS VERY ROUGH, IDLES LOW ALMOST DIES AT INTERSECTIONS. DOES NOT HAVE POWER WHEN GAS PEDAL IS PUSHED DOWN, LOOSES POWER WHILE DRIVING AS WELL. THESE VANS HAVE SOMETHING MAJORLY WRONG WITH THE ENGINES AND TRANSMISSIONS. DODGE NEEDS TO INVESTIGATE AND RECALL/REPAIR THESE VANS. THEY ARE HAZARDOUS. I CANNOT WAIT TO BE…

Read full complaint

ENGINE RUNS VERY ROUGH, IDLES LOW ALMOST DIES AT INTERSECTIONS. DOES NOT HAVE POWER WHEN GAS PEDAL IS PUSHED DOWN, LOOSES POWER WHILE DRIVING AS WELL. THESE VANS HAVE SOMETHING MAJORLY WRONG WITH THE ENGINES AND TRANSMISSIONS. DODGE NEEDS TO INVESTIGATE AND RECALL/REPAIR THESE VANS. THEY ARE HAZARDOUS. I CANNOT WAIT TO BE RID OF MINE BEFORE SOMETHING HAPPENS TO ME AND MY FOUR CHILDREN. DOESN'T SOUND LIKE I'M THE ONLY ONE WITH THE PROBLEMS EITHER. MAYBE DODGE/CHRYSLER IS GOING TO BE LIKE GM AND LET PEOPLE DIE BEFORE REPAIR A MINOR PART. VERY DISAPPOINTED IN THIS VEHICLE. IT WILL BE MY LAST DODGE PURCHASE. *JS

NHTSA ODI #10585201

21,100 miles · Apr 20, 2014
Electrical SystemVehicle Speed Control

NO ACCELERATION WHEN GAS PEDAL PUSHED, RPMS RACED BUT NOT ABLE TO PROCEED. WARNING LIGHT INDICATING ELECTRONIC THROTTLE PROBLEM. PULLED OFF THE HIGHWAY, TURNED OFF THE IGNITION, SAT FOR 5 MINUTES. RESTARTED THE VEHICLE AND DROVE IMMEDIATELY TO THE DEALERSHIP. TOLD THEM TO CALL ME WHEN IT WAS CORRECTED. FORTUNATELY, I HAD P…

Read full complaint

NO ACCELERATION WHEN GAS PEDAL PUSHED, RPMS RACED BUT NOT ABLE TO PROCEED. WARNING LIGHT INDICATING ELECTRONIC THROTTLE PROBLEM. PULLED OFF THE HIGHWAY, TURNED OFF THE IGNITION, SAT FOR 5 MINUTES. RESTARTED THE VEHICLE AND DROVE IMMEDIATELY TO THE DEALERSHIP. TOLD THEM TO CALL ME WHEN IT WAS CORRECTED. FORTUNATELY, I HAD PURCHASED THE EXTENDED WARRANTY ON THIS MINIVAN DUE TO HAVING HUGE TRANSMISSION PROBLEMS WITH A 2002 HONDA ODYSSEY. THE SERVICE MANAGER SAID THE TECHNICIAN WHO TORE THE ELECTRONIC THROTTLE APART FOUND FIBER IN IT. THE RADIO WAS ALSO NOT WORKING BUT THEY SAID THAT THERE WAS A WIRE THAT CAME LOOSE. RADIO NOW WORKING AS WELL AS THE ELECTRONIC THROTTLE. NO CHARGE BECAUSE I PURCHASED THE EXTENDED WARRANTY. UPON READING OTHER ELECTRONIC THROTTLE PROBLEMS AT THIS SITE I FELT COMPELLED TO JOT DOWN MY EXPERIENCE. *TR

NHTSA ODI #10583766

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den