← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

Fuel/propulsion System complaints

68 reports
Clear category filter
106,000 miles · Jan 4, 2019
Electrical SystemEngineFuel/propulsion System

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. KINGS DODGE CHRYSLER JEEP RAM (4486 KINGS WATER DR, CINCINNATI, OH 45249, (513) 683-3000) WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE CONTACT STATED THAT THERE WAS A CONSTANT LOSS OF POWER AND REDUCTION IN SPEE…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. KINGS DODGE CHRYSLER JEEP RAM (4486 KINGS WATER DR, CINCINNATI, OH 45249, (513) 683-3000) WAS UNABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE CONTACT STATED THAT THERE WAS A CONSTANT LOSS OF POWER AND REDUCTION IN SPEED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA ACTION NUMBER: DP14004 (ELECTRICAL SYSTEM). IN ADDITION, PERTAINING TO THE NHTSA INVESTIGATION, THE CONTACT WAS UNCERTAIN IF THE FAILURE WAS RELATED TO THE TIPM, FUEL SYSTEM, AND/OR ENGINE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.

NHTSA ODI #11165847

89,500 miles · Dec 18, 2018
Electrical SystemEngineFuel/propulsion System

SATURDAY 15, 2018 MY FAMILY AND I WERE DRIVING BACK FROM THE MALL, I WAS DRIVING AT ABOUT 55 MILES AN HOUR WHEN THE VEHICLE STALLED AND JUST DIED IN THE MIDDLE OF THE HIGHWAY WITHOUT ANY WARNINGS OR SIGNALS ON THE DASH. I MANAGED TO USE THE MOMENTUM AND PULLED OVER TO THE SHOULDER, IT RESTARTED AFTER 9 TIMES TRY. THANKFULLY WE W…

Read full complaint

SATURDAY 15, 2018 MY FAMILY AND I WERE DRIVING BACK FROM THE MALL, I WAS DRIVING AT ABOUT 55 MILES AN HOUR WHEN THE VEHICLE STALLED AND JUST DIED IN THE MIDDLE OF THE HIGHWAY WITHOUT ANY WARNINGS OR SIGNALS ON THE DASH. I MANAGED TO USE THE MOMENTUM AND PULLED OVER TO THE SHOULDER, IT RESTARTED AFTER 9 TIMES TRY. THANKFULLY WE WERE ABLE TO MAKE IT HOME. A MONTH BEFORE VEHICLE WAS PARKED IN DRIVEWAY AND IT WOULDN'T START, TOWED IT TO MECHANIC AND REPLACED ALTERNATOR. TILL NOW VEHICLE ALWAYS STALLS WHEN SLOWING DOWN OR COMING TO STOP. THIS VEHICLE ACTS LIKE IT HAVE BEEN TAKEN OVER BY SUPERNATURAL FORCES AND WHAT HAPPENED LAST SATURDAY WAS VERY SCARY TO MY FAMILY. I HAVE READ A LOT OF THE SAME COMPLAINTS ON THIS SITE ABOUT THIS VEHICLE AND IT IS VERY UPSETTING THAT THE MAKER HAVE NOT TAKEN RESPONSIBILITY IN ADDRESSING THIS SAFETY ISSUE. I WONDER HOW MANY PEOPLE WILL HAVE TO DIE FIRST BEFORE THEY ADDRESS THIS SAFETY ISSUE. LET IT BE CLEAR I WILL SUE, GOD FORBID ANY HAPPEN.

NHTSA ODI #11162230

32,500 miles · Oct 26, 2018
EngineFuel/propulsion System

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE PULLING INTO A HANDICAP PARKING SPACE. THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE VEHICLE IN LARGE QUANTITIES AND THE FIRE DEPARTMENT WAS CONTACTED TO PU…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE PULLING INTO A HANDICAP PARKING SPACE. THE CONTACT NOTICED FUEL LEAKING FROM UNDERNEATH THE VEHICLE IN LARGE QUANTITIES AND THE FIRE DEPARTMENT WAS CONTACTED TO PUSH THE VEHICLE INTO THE PARKING SPACE. IN ADDITION, THE CONTACT STATED THAT A FUEL ODOR ENTERED THE CABIN OF THE VEHICLE DIRECTLY AFTER THE FUEL TANK WAS FILLED. THE CONTACT SUFFERED FROM CHEMICAL SENSITIVITY AND WAS ILL DUE TO THE STRONG ODOR OF FUEL. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT STATED THAT A VEHICLE MODIFICATION COMPANY MODIFIED THE VEHICLE PRIOR TO THE FAILURE. THE CONTACT STATED THAT A MOBILITY CENTER WAS ALSO MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 32,500. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #11143030

90,000 miles · Sep 6, 2018
Fuel/propulsion System

WHILE IN MOTION AT LOW SPEED THE ENGINE SUDDENLY STOPPED RUNNING AND COULD NOT BE IMMEDIATELY RESTARTED, UNABLE TO GET OUT OF THE LANE OR OFF TO THE SHOULDER. AFTER SEVERAL ATTEMPTS OF CYCLING THE KEY FOB OFF AND ON THE VAN STARTED AGAIN. IT IS FORTUNATE THAT THIS OCCURRED IN A VERY RURAL AREA WITH NO TRAFFIC. THIS IS A 2012 G…

Read full complaint

WHILE IN MOTION AT LOW SPEED THE ENGINE SUDDENLY STOPPED RUNNING AND COULD NOT BE IMMEDIATELY RESTARTED, UNABLE TO GET OUT OF THE LANE OR OFF TO THE SHOULDER. AFTER SEVERAL ATTEMPTS OF CYCLING THE KEY FOB OFF AND ON THE VAN STARTED AGAIN. IT IS FORTUNATE THAT THIS OCCURRED IN A VERY RURAL AREA WITH NO TRAFFIC. THIS IS A 2012 GRAND CARAVAN WITH APPROX. 90K MILES. MY HUSBAND RESEARCHED SIMILAR FAILURES OTHER DRIVERS HAVE EXPERIENCED WITH THE GRAND CARAVAN, HE BELIEVES IT IS LIKELY A FAILING FUEL PUMP RELAY. HE READ THAT MANY OTHER CHRYSLER VEHICLES HAVING THE SAME RELAY SYSTEM HAVE BEEN RECALLED BUT APPARENTLY NOT THE GRAND CARAVAN AS WE HAVE NOT RECEIVED A RECALL NOTICE IN THE MAIL.

NHTSA ODI #11127956

125,000 miles · Feb 28, 2018
Electrical SystemFuel/propulsion SystemVisibility/wiper

FAULTY TIPM , CAUSING ALL ELECTRICAL DEVICES TO QUIT WORKING OR OPERATE INTERMITTENTLY ON THERE OWN . DOOR SAFETY LOCKS TO NOT OPEN AND TRAP OCCUPANTS INSIDE OR NOT LOCK WHEN VEHICAL REACHES SPEED. VEHICLE NO START AND LEAVE STRANDED AND WRECKER CHARGES!

NHTSA ODI #11075536

246 miles · Jan 12, 2018
Electrical SystemFuel/propulsion System

I GOING DRIVING AT 70 MPH IN I-75 TAMPA FLORIDA AND THE VEHICLE TURN OFF. CHECKING IN INTERNET THE POSIBLE PROBLEM IS OVERHEAD IN THE TIPM. I AM IN THIS MOMENT IN A HIGHWAY FOR 3 HOURS WAITING FOR TOWNING. THE VEHICLE NOT START.

NHTSA ODI #11062529

71,923 miles · Jan 3, 2018
Fuel/propulsion System

THE VEHICLE DIDN'T START IN THE MORNING WHEN SWITCH ON I HAVE TO CALL TO THE BODY SHOP AND THEY FOUND OUT IT WAS THE FUEL PUMP THEY HAD TO CHANGE IT. I THING THAT FOR A CAR THAT IS ONLY 5 YEARS AND 71963 MILES IT IS TO SOON TO HAVE THAT KIND OF PROBLEMS .THE VEHICLE WAS STATIONARY ON A DRIVEWAY I DO HAVE A REPAIR INVOICE

NHTSA ODI #11058352

137,000 miles · Dec 27, 2017
Electrical SystemFuel/propulsion SystemService Brakes

DRIVER REAR BRAKES LOCKED UP ON ME TODAY. HAD FUEL RELAY SWITCH GO OUT BUT HAD IT REPLACED, FUEL PUMP WENT OUT HAD IT REPLACED. SOMEONE TOLD ME THE BRAKES SYSTEM IS UNDER RECALL.

NHTSA ODI #11057003

119,910 miles · Aug 31, 2017
Electrical SystemEngineFuel/propulsion System

THREE DIFFERENT TIMES, I TOOK MY 2012 DODGE GRAN CARAVAN TO HAVE THE ENGINE CHECK BECAUSE IT STALLS OUT. THIS HAPPENS AT ANY SPEED. EVERY TIME ALL CHECK OUT OK PER THE DODGE REPAIR CENTER. TWICE THE CHECK ENGINE LIGHT WAS ON AT THE TIME OF THE ENGINE STALLING. TWICE NO INDICATION. ENGINE JUST QUIT. IT HAPPENED AGAIN LAST N…

Read full complaint

THREE DIFFERENT TIMES, I TOOK MY 2012 DODGE GRAN CARAVAN TO HAVE THE ENGINE CHECK BECAUSE IT STALLS OUT. THIS HAPPENS AT ANY SPEED. EVERY TIME ALL CHECK OUT OK PER THE DODGE REPAIR CENTER. TWICE THE CHECK ENGINE LIGHT WAS ON AT THE TIME OF THE ENGINE STALLING. TWICE NO INDICATION. ENGINE JUST QUIT. IT HAPPENED AGAIN LAST NIGHT (08/30/2017) WHEN MY WIFE WAS COMING HOME ON THE INTERSTATE. SHE WAS IN TRAFFIC AND THE ENGINE JUST QUIT. BIG SAFETY ISSUE. THANK GOD THAT SHE WAS NOT IN AN ACCIDENT. SOME THING IS WRONG WITH MY GRAN CARAVAN. THIS PROBLEM STARTED EARLY THIS YEAR (2017). FIRST TIME TO A DODGE FACILITY WAS ON 05/23/17, NEXT ON 06/05/17 AND ON 07/07/17.

NHTSA ODI #11020874

106,000 miles · Jul 17, 2017
Electrical SystemFuel/propulsion System

MULTIPLE ATTEMPTS TO START, PERHAPS OCCURING MOST OFTEN IN THE MORNING WHEN THE VEHICLE IS COLD. THE PROBLEM GETS WORSE OVER TIME AND EVENTUALLY WON'T START AT ALL. UNEXPLAINED BATTERY DRAINAGE DUE TO A RELAY THAT IS STUCK IN THE CLOSED/ON POSITION. YOU CAN LIKELY HEAR THE FUEL PUMP RUNNING IF LISTENING FROM THE REAR OF THE VEHI…

Read full complaint

MULTIPLE ATTEMPTS TO START, PERHAPS OCCURING MOST OFTEN IN THE MORNING WHEN THE VEHICLE IS COLD. THE PROBLEM GETS WORSE OVER TIME AND EVENTUALLY WON'T START AT ALL. UNEXPLAINED BATTERY DRAINAGE DUE TO A RELAY THAT IS STUCK IN THE CLOSED/ON POSITION. YOU CAN LIKELY HEAR THE FUEL PUMP RUNNING IF LISTENING FROM THE REAR OF THE VEHICLE AFTER IT'S TURNED OFF. BATTERY DRAINAGE MAY STILL OCCUR EVEN AFTER A NEW BATTERY IS INSTALLED. THE VEHICLE STALLS WHILE DRIVING AND YOU COAST TO A STOP. THE VEHICLE WON'T START AND APPEARS TO BE OUT OF GAS

NHTSA ODI #11006005

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den