← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

Fuel/propulsion System complaints

68 reports
Clear category filter
99,000 miles · Oct 30, 2019
Electrical SystemFuel/propulsion System

FUEL RELAY BYPASS. WHEN I TRIED TO START MY DODGE GRAND CARAVAN WHICH WAS PARKED DRIVEWAY IN MY DRIVEWAY IT WOULD NOT START. IT WAS NOT GETTING FUEL. EVENTUALLY IT DID START. WHEN I TRIED TO START MY VAN IN MY DRIVEWAY IT WOULD NOT GET FIEL TO START.THIS HAPPENED SEVERAL TIMES AFTER THIS. I FOUND A YOUTUBE VIDEO THAT EXPLAINED T…

Read full complaint

FUEL RELAY BYPASS. WHEN I TRIED TO START MY DODGE GRAND CARAVAN WHICH WAS PARKED DRIVEWAY IN MY DRIVEWAY IT WOULD NOT START. IT WAS NOT GETTING FUEL. EVENTUALLY IT DID START. WHEN I TRIED TO START MY VAN IN MY DRIVEWAY IT WOULD NOT GET FIEL TO START.THIS HAPPENED SEVERAL TIMES AFTER THIS. I FOUND A YOUTUBE VIDEO THAT EXPLAINED THE PROBLEM. I HAD TO BYPASS THE FUEL RELAY. THIS IS A COMMON PROBLEM ON THE CARAVAN. IF I HAD TO REPLACE THE ICBM IT WOULD COST $1200. THIS ITEM IS RECALLED ON OTHER DODGE PRODUCTS AND SHOULD BE ON THE CARAVAN.

NHTSA ODI #11277174

89,865 miles · Oct 21, 2019
Electrical SystemFuel/propulsion System

PROBLEM STARTING FROM FAULTY TIPM CAUSING FUEL RELAY TO WORK INTERMITTENTLY. FUEL PUMP WORKS BY TESTING. THE PROBLEM IS FAULTY POWER IN TIPM.

NHTSA ODI #11269845

Mileage unknown · Sep 16, 2019
Fuel/propulsion System

TAMARA RECALL CAR WAS WORKING FINE ALL OF A SUDDEN IT WOULDN'T CRANK JUST MAKING CONSTANT CLICKING NOISE THE NOISE STOP WHEN I TURN THE KEY BACK SO I WENT TO GET IT CHECKED THEY TOLD ME IT WAS THE FUEL PUMP SO I CHECKED ON YOUTUBE FOR THE YEAR MAKE AND MODEL OF THE PROBLEM THE CLICKING NOISE SO COMES TO FIND OUT THE MAN ON YOU…

Read full complaint

TAMARA RECALL CAR WAS WORKING FINE ALL OF A SUDDEN IT WOULDN'T CRANK JUST MAKING CONSTANT CLICKING NOISE THE NOISE STOP WHEN I TURN THE KEY BACK SO I WENT TO GET IT CHECKED THEY TOLD ME IT WAS THE FUEL PUMP SO I CHECKED ON YOUTUBE FOR THE YEAR MAKE AND MODEL OF THE PROBLEM THE CLICKING NOISE SO COMES TO FIND OUT THE MAN ON YOUTUBE SET THAT A LOT OF GOOD CARS THE CARAVANS ACT LIKE THAT BUT PEOPLE ALWAYS THINK IT'S THE FUEL PUMP BUT IT DON'T BE THE FUEL PUMP IT IS THE RELAY AND IT SHOWED ME HOW TO DO A RELAY BYPASS WITH A WIRE SOON AS I PERFORM THE RELAY BYPASS MY CAR CRANK RIGHT UP BUT I KNOW THAT'S NOT GOING TO LAST AND TO ME THAT IS AN EXPENSIVE PART TO TRY TO FIX ON MY OWN

NHTSA ODI #11255544

109,000 miles · Jul 30, 2019
Fuel/propulsion System

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND HAD TO BE JUMPSTARTED. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT REPLACED THE BATTERY. IN ADDITION, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHA…

Read full complaint

TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND HAD TO BE JUMPSTARTED. THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT REPLACED THE BATTERY. IN ADDITION, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS DRAINING THE BATTERY. THE MECHANIC DIAGNOSED THAT THE RELAY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT THE VEHICLE WAS UNABLE TO START AND WOULD HESITATE IN THE PROCESS. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

NHTSA ODI #11240630

55,000 miles · Jul 23, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

THE TOTALLY INTEGRATED POWER MODULE (TIPM) ON MY DODGE CARAVAN VEHICLE CONTAINS AN INTERNAL FUEL PUMP RELAY THAT OPERATES INTERMITTENTLY AND FAILS WITHOUT WARNING CAUSED AND STILL CAUSES THE ENGINE TO STALL WHILE DRIVING WHICH COULD CAUSE A CRASH. THERE IS NO WARNING WHEN THE FUEL PUMP IS GOING TO FAIL. THIS IS A KNOWN ISSUE …

Read full complaint

THE TOTALLY INTEGRATED POWER MODULE (TIPM) ON MY DODGE CARAVAN VEHICLE CONTAINS AN INTERNAL FUEL PUMP RELAY THAT OPERATES INTERMITTENTLY AND FAILS WITHOUT WARNING CAUSED AND STILL CAUSES THE ENGINE TO STALL WHILE DRIVING WHICH COULD CAUSE A CRASH. THERE IS NO WARNING WHEN THE FUEL PUMP IS GOING TO FAIL. THIS IS A KNOWN ISSUE ON THE 2012 DODGE CARAVAN, BUT NO RECALL TO DATE.

NHTSA ODI #11234315

102,000 miles · May 20, 2019
Fuel/propulsion System

THE FUEL PUMP STAYS ON AFTER THE VAN IS TURNED OFF AND THE KEYS ARE REMOVED, SOMETIMES IT WILL KICK OFF IF YOU REINSERT THE KEYS AND TURN IT OFF OTHER TIMES WE HAVE TO PULL THE FUSE TO MAKE IT KICK OFF. THIS HAS HAPPENED ON NUMEROUS OCCASIONS OTHER THAN TODAY. AFTER DOING RESEARCH I HAVE FOUND OUT IT'S A VERY COMMON OCCURRENCE I…

Read full complaint

THE FUEL PUMP STAYS ON AFTER THE VAN IS TURNED OFF AND THE KEYS ARE REMOVED, SOMETIMES IT WILL KICK OFF IF YOU REINSERT THE KEYS AND TURN IT OFF OTHER TIMES WE HAVE TO PULL THE FUSE TO MAKE IT KICK OFF. THIS HAS HAPPENED ON NUMEROUS OCCASIONS OTHER THAN TODAY. AFTER DOING RESEARCH I HAVE FOUND OUT IT'S A VERY COMMON OCCURRENCE IN DODGE CARAVAN AND ALSO THE TOWN AND COUNTRY.

NHTSA ODI #11208797

135,000 miles · Apr 23, 2019
Electrical SystemEngineFuel/propulsion System

MY FUEL PUMP KEPT RUNNING WHEN THE CAR WAS OFF AND THE KEY WAS OUT IT WAS THE TIPM COMPUTER THAT WAS BAD I BYPASSED THE TIPM WHEN THIS WAS FIXED AT DODGE NOW MY BATTERY LIGHT IS COMING ON ITS A BRAND NEW BATTERY AND ALTERNATOR AND IM BEING TOLD ITS THE TIPM. IT ALSO WAS EFFECTING ACCELERATION IT WOULD RAMP UP RPM BUT SPEED WOULD…

Read full complaint

MY FUEL PUMP KEPT RUNNING WHEN THE CAR WAS OFF AND THE KEY WAS OUT IT WAS THE TIPM COMPUTER THAT WAS BAD I BYPASSED THE TIPM WHEN THIS WAS FIXED AT DODGE NOW MY BATTERY LIGHT IS COMING ON ITS A BRAND NEW BATTERY AND ALTERNATOR AND IM BEING TOLD ITS THE TIPM. IT ALSO WAS EFFECTING ACCELERATION IT WOULD RAMP UP RPM BUT SPEED WOULD NOT CHANGE THIS ISSUE OCCURED WHILE IN MOTION DRIVING ON A FREEWAY

NHTSA ODI #11203260

125,000 miles · Feb 6, 2019
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System

THE TIPM IS JUST SHOT AND I'VE HAD THE ALTNATOR REPLACED THE STARTER AND IT'S DEFINITELY TIPM RELATED. I DON'T UNDERSTAND WHY THE RECALL ON THIS EXCLUDED MY VAN, IT'S BEEN DOING THIS FOR SEVERAL MONTHS AND IT'S MAKING THE VEHICLE UNSAFE. PLEASE INVESTIGATE THIS SITUATION. (I HAVE 4 KIDS AND TWO OF THEM HAVE SPECIAL NEEDS AND I N…

Read full complaint

THE TIPM IS JUST SHOT AND I'VE HAD THE ALTNATOR REPLACED THE STARTER AND IT'S DEFINITELY TIPM RELATED. I DON'T UNDERSTAND WHY THE RECALL ON THIS EXCLUDED MY VAN, IT'S BEEN DOING THIS FOR SEVERAL MONTHS AND IT'S MAKING THE VEHICLE UNSAFE. PLEASE INVESTIGATE THIS SITUATION. (I HAVE 4 KIDS AND TWO OF THEM HAVE SPECIAL NEEDS AND I NEED MY VEHICLE TO BE SAFE FOR MY KIDS, AND RIGHT NOW IT'S JUST A JOKE AND I'M TELLING YOU THIS VAN IS POSSESSED) IT'S COMPLETELY UNREASONABLE FOR THE MY DODGE TO KEEP BURNING THROUGH EVERYTHING I'VE PUT IT IN IT. PLEASE INVESTIGATE THIS, THE ISSUE ISN'T GONNA GO AWAY AND I CAN'T KEEP BURNING THROUGH PARTS AND FURTHER DESTROYING THE VEHICLE. THE RECALL THAT WAS ISSUED EXCLUDED MY VAN BUT EVERYTHING FROM THAT RECALL IS HAPPENING TO MY VAN AND HAS BEEN FOR SEVERAL MONTHS AND DODGE KEEPS GIVING ME THE RUN AROUND. I'VE BEEN A DODGE OWNER MY WHOLE LIFE. BUT DODGE IS ABOUT TO LOSE A [XXX] GOOD LOYAL CUSTOMER BECAUSE THIS IS BEYOND RIDICULOUS. IVE BEEN GETTING THE RUN AROUND FROM DODGE SINCE THE BEGINNING OF NOVEMBER OF 2018. PLEASE INVESTIGATE THIS. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI #11174687

125,000 miles · Jan 28, 2019
Electrical SystemFuel/propulsion System

ON MY 2012 GRAND CARAVAN ABOUT TWO MONTHS AGO STARTED AN ISSUE OF INTERMITTENT STARTING OR HAVING TO DEPRESS THE ACCELERATOR TO GT THE VEHICLE TO START. THEN ABOUT A WEEK AGO THE VAN COMPLETELY STOP STARTING AND WOULD JUST TURN OVER UNLESS IT WAS JUMP STARTED. I HAVE NOT HAD THE VEHICLE INTO A DEALER BUT WITH READING SEVERAL ONL…

Read full complaint

ON MY 2012 GRAND CARAVAN ABOUT TWO MONTHS AGO STARTED AN ISSUE OF INTERMITTENT STARTING OR HAVING TO DEPRESS THE ACCELERATOR TO GT THE VEHICLE TO START. THEN ABOUT A WEEK AGO THE VAN COMPLETELY STOP STARTING AND WOULD JUST TURN OVER UNLESS IT WAS JUMP STARTED. I HAVE NOT HAD THE VEHICLE INTO A DEALER BUT WITH READING SEVERAL ONLINE FORUMS ON THIS ISSUE AND USED A TEXT LIGHT TO VERIFY POWER TO THE M25 20A FUSE. I READ TO USE A FUSE TAP TO LINK AN ACC FUSE TO THIS FUSE SO WHEN THE KEY IS IN THE ON POSITION THE PUMP WILL RUN AND THAT IS MY CURRENT SETUP TO HAVE VEHICLE RUN.

NHTSA ODI #11172462

162,000 miles · Jan 11, 2019
Electrical SystemFuel/propulsion System

THE INTEGRATED CONTROL MODEL IS MAKING THE FUEL RELAY RUN ALL NIGHT AND MAKE THE BATTERY DIE. I HAVE LOOKED ONLINE FOR RECALLS AND THERE IS NONE. THIS PROBLEM IS HAPPENING ON MORE GRAND CARAVAN. I HAVE HAD THIS PROBLEM FOR ALL MOST A YEAR. I CAN'T FIND THE TIPM OR IT COST TO MOST. THIS NEED TO BE RECALLED

NHTSA ODI #11166474

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den