← New search

2012 Dodge Grand Caravan

Owner reports · Recalls · Investigations

More warning signs than most Grand Caravan years

Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

374 reports with mileage · 209 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports14 fire reports8 injury reports

Electrical System complaints

336 reports
Clear category filter
Mileage unknown · Jun 29, 2021
Electrical System

Bought the van and with in 2 Days just driving an it cuts off, No warning Nothing, Can click back on at any time...Engine reeves up sounds like it's gonna blow up.. You have to either put it in Neutral or pull off the road and turn it off and it will crank right back up... It does this at any given time.. This is VERY DANGEROUS …

Read full complaint

Bought the van and with in 2 Days just driving an it cuts off, No warning Nothing, Can click back on at any time...Engine reeves up sounds like it's gonna blow up.. You have to either put it in Neutral or pull off the road and turn it off and it will crank right back up... It does this at any given time.. This is VERY DANGEROUS WHEN YOUR DRIVING AT HIGH RATES OR LOW RATES OF SPEED. IT'S GONNA CUSS A BAD WRECK ONE DAY..

NHTSA ODI #11422836

139,000 miles · May 8, 2021
Electrical SystemFuel/propulsion System

WHEN TURNING THE KEY OVER TO START THE VEHICLE IT WILL KEEP TURNING OVER BUT NOT CRANK AND IT WILL NOT STOP TURNING OVER UNTIL YOU SWITCH THE KEY IN OFF POSITION. ALSO, AT TIMES THE VAN WILL STALL WHILE RUNING AND SHUT OFF. SO FAR IN PARKED POSITION BUT I AM AFRAID IT COULD HAPPEN WHILE DRIVING. THE FUEL PUMP WILL KEEP RUNING A…

Read full complaint

WHEN TURNING THE KEY OVER TO START THE VEHICLE IT WILL KEEP TURNING OVER BUT NOT CRANK AND IT WILL NOT STOP TURNING OVER UNTIL YOU SWITCH THE KEY IN OFF POSITION. ALSO, AT TIMES THE VAN WILL STALL WHILE RUNING AND SHUT OFF. SO FAR IN PARKED POSITION BUT I AM AFRAID IT COULD HAPPEN WHILE DRIVING. THE FUEL PUMP WILL KEEP RUNING AFTER THE IGNITION HAS BEEN SHUT OFF AND THE KEY TAKEN OUT. THIS RUNS THE BATTERY DEAD AND WILL LEAVE YOU SITTING.

NHTSA ODI #11415692

100,000 miles · May 4, 2021
Electrical SystemSeat Belts

MY DOORS ARE UNLOCKING BY THEMSELVES AFTER I LOCKED THEM. SEAT BELT WARNING GOING OFF WHEN SEAT BELT IS ENGAGED.VEHICLE IS STATIONARY WITH DOOR LOCKS AND IN MMOTION FOR SEAT BELT WARNING GOING OFF.

NHTSA ODI #11415172

110,000 miles · May 1, 2021
Electrical System

MY 2012 DODGE GRAND CARAVAN 3.6L SHUTS OFF RANDOMLY WHILE DRIVING. IT HAS HAPPENED AT HIGHWAY SPEED ON THE INTERSTATE IN TRAFFIC AND ON LOCAL ROADS. THERE IS NO WARNING. IT WILL RESTART. THERE IS A RECALL FOR THIS ISSUE FOR 2008-2010 CARAVAN, BUT OBVIOUSLY IT NEEDS TO BE EXTENDED. THIS IS A DANGEROUS ISSUE

NHTSA ODI #11414735

111,000 miles · Apr 9, 2021
Electrical SystemEngineUnknown Or Other

MY VAN CUT OFF IN THE DRIVEWAY, THANKFULLY I WAS PARKED AND WILL NOT TURN OVER OR CRANK BACK UP. WE HAD JUST GOTTEN HOME,, WE COULD HAVE BEEN ON THE INTERSTATE!!! THERE IS A RED LIGHT BLINKING LIGHT UNDER THE NEUTRAL. I AM READING HUNDREDS OF COMPLAINTS OF THE SAME PROBLEM AND THIS SHOULD BE RECALLED. MY VAN IS A HANDICAP ACCESS…

Read full complaint

MY VAN CUT OFF IN THE DRIVEWAY, THANKFULLY I WAS PARKED AND WILL NOT TURN OVER OR CRANK BACK UP. WE HAD JUST GOTTEN HOME,, WE COULD HAVE BEEN ON THE INTERSTATE!!! THERE IS A RED LIGHT BLINKING LIGHT UNDER THE NEUTRAL. I AM READING HUNDREDS OF COMPLAINTS OF THE SAME PROBLEM AND THIS SHOULD BE RECALLED. MY VAN IS A HANDICAP ACCESSIBLE VAN FOR MY DAUGHTER AND THANKFULLY WE WERE NOT DRIVING DOWN THE HIGHWAY WHEN THIS HAPPENED. WE HAD JUST GOTTEN HOME FROM CELEBRATING HER BIRTHDAY AND HAD HER, MY 82 YEAR OLD GRANNY, MY WIFE AND MYSELF. WE COULD HAVE BEEN KILLED. THIS IS DANGEROUS. I HAD IT LOOKED AT AND IT IS GIVING A CODE U1197 THAT'S A SECURITY CODE. THIS NEEDS TO BE RECALLED IMMEDIATELY!!! THERE ARE TOO MANY COMPLAINTS

NHTSA ODI #11407313

Mileage unknown · Mar 29, 2021
Air BagsElectrical SystemVehicle Speed Control

SEAT BELT WARNING CHIME IS PERIODICAL ACTIVATED WHILE VEHICLE IS IN MOTION AND SEAT BUCKLE IS ENGAGED.

NHTSA ODI #11405490

120,000 miles · Mar 19, 2021
Electrical SystemSteeringUnknown Or Other

WHILE DRIVING MY VAN, I ATTEMPTED TO TURN LEFT ON A CITY STREET, WHEN EVERYTHING SHUT DOWN ON ME. ALL OF MY DASHBOARD LIT UP LIKE A CHRISTMAS TREE. I HAD NO STEERING, NO BRAKES, IT WAS FRIGHTENING! I DID HAVE HEADLIGHTS, FLASHERS, I COULDN'T ACCESS THE SIDE DOORS TO GE MY CANE OUT. MY BACK GATE WOULDN'T OPEN EITHER SO I COULD GE…

Read full complaint

WHILE DRIVING MY VAN, I ATTEMPTED TO TURN LEFT ON A CITY STREET, WHEN EVERYTHING SHUT DOWN ON ME. ALL OF MY DASHBOARD LIT UP LIKE A CHRISTMAS TREE. I HAD NO STEERING, NO BRAKES, IT WAS FRIGHTENING! I DID HAVE HEADLIGHTS, FLASHERS, I COULDN'T ACCESS THE SIDE DOORS TO GE MY CANE OUT. MY BACK GATE WOULDN'T OPEN EITHER SO I COULD GET MY ROLLERATOR AND WALK TO THE BUSINESS I WAS ATTEMPTING TO GET TO. I HAD TO HAVE MY VAN TOWED AND WAS TOLD IT'S MY ELECTRICAL SYSTEM AND THAT MANY PEOPLE HAVE HAD THE SAME ISSUE. I WOULD LIKE TO BRING MY AWARENESS TO THIS ISSUE, FOR IF I WAS ON 95, MY MAIN HIGHWAY AND THIS HAPPENED, I WOULD BE DEAD ALONG WITH MY SON. ATTACHED IS THE DASHBOARD, BUT THE CENTER BOTTOM RED LIGHT WAS FLASHING ON AND OFF. I'M TOLD IT'S MY SECURITY SYSTEM LIGHT

NHTSA ODI #11403945

133,689 miles · Mar 14, 2021
Electrical SystemFuel/propulsion System

OUR DODGE GRAND CARAVAN WAS STATIONARY AND EXPERIENCED INTERMITTENT STARTING PROBLEMS OVER A PERIOD OF MONTHS AND SOMETIMES WHEN IT DID START, IT WOULD STALL SHORTLY AFTER STARTING WHILE IN MOTION. FINALLY, IT WOULD NOT START AFTER REPEATED ATTEMPTS, WAITING ARE TRYING AGAIN. WE HAD IT TOWED TO OUR MECHANIC WHO TESTED IT AND F…

Read full complaint

OUR DODGE GRAND CARAVAN WAS STATIONARY AND EXPERIENCED INTERMITTENT STARTING PROBLEMS OVER A PERIOD OF MONTHS AND SOMETIMES WHEN IT DID START, IT WOULD STALL SHORTLY AFTER STARTING WHILE IN MOTION. FINALLY, IT WOULD NOT START AFTER REPEATED ATTEMPTS, WAITING ARE TRYING AGAIN. WE HAD IT TOWED TO OUR MECHANIC WHO TESTED IT AND FOUND THAT IT WAS THE FUEL PUMP RELAY. HE SAID IT WAS COMMON TO MAY DODGE AND JEEP MODELS. THEY ALL HAVE THE SAME CIRCUIT BOARD. HE RECOMMENDED TAKING IT TO A DEALER FOR REPAIRS EVEN THOUGH IT HAD NOT YET BEEN RECALLED. THE DEALER CONFIRMED THAT THEY HAD THE PARTS FOR THE FIX AND FIXED THE FUEL PUMP RELAY PROBLEM. THE REPAIR HAS A 2 YEAR WARRANTY. AN EMPLOYEE OF DEALER EXPRESSED THAT IT MAY BE 3 MONTHS FROM THE OCTOBER 8, 2020 REPAIR, BUT EVENTUALLY CHRYSLER WOULD ISSUE A RECALL SINCE SO MANY MODELS WITH THIS PART HAVE BEEN RECALLED. WE WERE ADVISED TO KEEP THE RECEIPT FOR LATER REIMBURSEMENT. IT IS NOW MARCH 14, 2021 AND NO RECALL HAS BEEN MADE FOR OUR VEHICLE. PLEASE TRY TO EXPEDITE THIS RECALL. THE NHTSA PROBABLY IS NOT GETTING MANY COMPLAINTS BECAUSE EVERYONE WITH THE PROBLEM EXPECTS IT TO BE HANDLED SOON. THANK YOU FOR YOUR HELP.

NHTSA ODI #11402885

215,000 miles · Mar 8, 2021
Electrical System

KEY FOBS NO LONGER WORK EVEN AFTER BATTERIES HAVE BEEN CHANGED

NHTSA ODI #11399827

168,388 miles · Feb 16, 2021
Electrical System

WHILE DRIVING THIS VEHICLE WILL SHUT OFF ON ITS OWN AND THEN RESTART.THIS HAS HAPPENED SEVERAL TIMES. I WAS GOING 65MPH ON THE HIGHWAY AND IT JUST SHUT OFF AND RESTARTED. THANKFULLY NO ONE WAS BEHIND ME WHEN THIS HAPPENED BECAUSE IT COULD HAVE COST US OUR LIFE. I ALSO AM HAVING ISSUES WITH MY SLIDING DOORS. NEITHER ONE WILL LOCK…

Read full complaint

WHILE DRIVING THIS VEHICLE WILL SHUT OFF ON ITS OWN AND THEN RESTART.THIS HAS HAPPENED SEVERAL TIMES. I WAS GOING 65MPH ON THE HIGHWAY AND IT JUST SHUT OFF AND RESTARTED. THANKFULLY NO ONE WAS BEHIND ME WHEN THIS HAPPENED BECAUSE IT COULD HAVE COST US OUR LIFE. I ALSO AM HAVING ISSUES WITH MY SLIDING DOORS. NEITHER ONE WILL LOCK, NOT WITH DOOR LOCK SWITCH, NOT WITH KEY FOB, NOT MANUALLY. UPON RESEARCHING, I HAVE SEEN AT LEAST 200 COMPLAINTS FOR THE SAME ISSUE.

NHTSA ODI #11396562

Official recalls

6

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

12V191000 · Equipment

May 2, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.

Consequence & remedy

Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

12V141000 · Suspension:rear

Apr 3, 2012

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.

Consequence & remedy

Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

11V487000 · Engine And Engine Cooling

Sep 29, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.

Consequence & remedy

Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den