IllustrationFAULTY TIPM , CAUSING ALL ELECTRICAL DEVICES TO QUIT WORKING OR OPERATE INTERMITTENTLY ON THERE OWN . DOOR SAFETY LOCKS TO NOT OPEN AND TRAP OCCUPANTS INSIDE OR NOT LOCK WHEN VEHICAL REACHES SPEED. VEHICLE NO START AND LEAVE STRANDED AND WRECKER CHARGES!
2012 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 2012 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
380–25K
4725–50K
6350–75K
5475–100K
141100–150K
31150K+
374 reports with mileage · 209 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 336 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports14 fire reports8 injury reports
Electrical System complaints
336 reportsTL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH, THE VEHICLE WOULD NOT START WHEN PROMPTED AND INDEPENDENTLY LOCKED ALL OF THE DOORS IN THE VEHICLE. THE FAILURE PREVENTED THE CONTACT FROM EXITING THE VEHICLE. APPROXIMATELY FIVE MINUTES LATER, THE CONTACT WAS ABLE TO USE THE KEY FOBIK TO OPEN THE DRIVER'S DO…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH, THE VEHICLE WOULD NOT START WHEN PROMPTED AND INDEPENDENTLY LOCKED ALL OF THE DOORS IN THE VEHICLE. THE FAILURE PREVENTED THE CONTACT FROM EXITING THE VEHICLE. APPROXIMATELY FIVE MINUTES LATER, THE CONTACT WAS ABLE TO USE THE KEY FOBIK TO OPEN THE DRIVER'S DOOR. THE CONTACT STATED THAT THE ANTI-THEFT WARNING INDICATOR ILLUMINATED. IN ADDITION, WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE LOST POWER COMPLETELY. THE CONTACT COASTED THE VEHICLE TO A NEARBY PARKING LOT USING MANUAL STEERING. THE CONTACT REMOVED THE BATTERY CABLES AND RE-ATTACHED THEM TO RESTART THE VEHICLE. CUTTER DODGE IN HONOLULU, HAWAII WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REQUESTED THAT THE VEHICLE BE BROUGHT IN UNDER AN EXTENDED WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING 30 MPH, THE VEHICLE SPONTANEOUSLY DOWNSHIFTED AND STALLED. ALSO, THE ALTERNATOR WARNING INDICATOR ILLUMINATED. A TOWING COMPANY JUMPSTARTED THE BATTERY AND THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE V…
Read full complaint
TL* THE CONTACT OWNS A 2012 DODGE GRAND CARAVAN. WHILE DRIVING 30 MPH, THE VEHICLE SPONTANEOUSLY DOWNSHIFTED AND STALLED. ALSO, THE ALTERNATOR WARNING INDICATOR ILLUMINATED. A TOWING COMPANY JUMPSTARTED THE BATTERY AND THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
I GOING DRIVING AT 70 MPH IN I-75 TAMPA FLORIDA AND THE VEHICLE TURN OFF. CHECKING IN INTERNET THE POSIBLE PROBLEM IS OVERHEAD IN THE TIPM. I AM IN THIS MOMENT IN A HIGHWAY FOR 3 HOURS WAITING FOR TOWNING. THE VEHICLE NOT START.
DRIVER REAR BRAKES LOCKED UP ON ME TODAY. HAD FUEL RELAY SWITCH GO OUT BUT HAD IT REPLACED, FUEL PUMP WENT OUT HAD IT REPLACED. SOMEONE TOLD ME THE BRAKES SYSTEM IS UNDER RECALL.
THE VEHICLE HAS 92,000 MILES AND WHEN TRAVELING LAST MONTH THE ALTERNATOR WENT OUT. WAS TOLD AT THE DEALERSHIP THAT FIXED IT THERE HAVE BEEN SOME ALTERNATORS RECALLED. WITH PARTS AND LABOR THE BILL WAS $797.77. THEY SAID OURS WAS NOT ON RECALL LIST. HOW DO I GET REIMBURSED FOR SURPRISE EXPENSE.
IT APPEARS THAT I AM ONE OF MANY DODGE OWNERS WITH TIPM ISSUES. AT LEAST ONCE A DAY WHEN GOING TO START THE ENGINE, IT JUST CRANKS AND CRANKS BUT WON'T START. AFTER TURNING OFF THE KEY AND TRYING ONE OR TWO OR THREE MORE TIMES, IT WILL START. THE BATTERY IS BRAND NEW, AND THE STARTER IS GETTING PLENTY OF POWER. COMPARING MY EXPE…
Read full complaint
IT APPEARS THAT I AM ONE OF MANY DODGE OWNERS WITH TIPM ISSUES. AT LEAST ONCE A DAY WHEN GOING TO START THE ENGINE, IT JUST CRANKS AND CRANKS BUT WON'T START. AFTER TURNING OFF THE KEY AND TRYING ONE OR TWO OR THREE MORE TIMES, IT WILL START. THE BATTERY IS BRAND NEW, AND THE STARTER IS GETTING PLENTY OF POWER. COMPARING MY EXPERIENCE WITH WHAT I'VE READ ONLINE, I FIRMLY BELIEVE THE ISSUE IS THE FUEL PUMP RELAY SWITCH IN THE TIPM. IT STARTED MONTHS AGO, AND HAS GOTTEN WORSE. MY WIFE DRIVES THIS VEHICLE THE MOST, VERY OFTEN WITH OUR KIDS INSIDE. WE JUST HAVE TO HOPE AND PRAY THAT IT WILL START AND NOT STRAND THEM SOMEWHERE. SO FAR, WE HAVE ONLY HAD ISSUES WHILE STATIONARY. THANK GOODNESS IT HASN'T SHUT OFF WHILE DRIVING AS MANY OTHER OWNERS HAVE STATED. THIS IS WHY I FEEL IT IS AN IMPORTANT SAFETY ISSUE. WHAT IF IT WERE TO SHUT OFF IN THE MIDDLE OF A FREEWAY OR WHILE CROSSING AN INTERSECTION? I FIND IT ABSURD THAT DODGE (OR FIAT CHRYSLER WHATEVER) WOULD LET THIS ISSUE GO WHILE HAVING KNOWLEDGE OF SO MANY TIPM ISSUES, EVEN WITH A CLASS ACTION LAWSUIT FILED AGAINST THEM.
WHEN WE FIST GOT THE VAN WE EXPERIENCED SOME ISSUES WITH THE BRAKES. THE DEALERSHIP WAS SUPPOSED TO TAKE CARE OF IT BUT THE PROBLEM PERSISTED AND WE WENT TO A RECOMMENDED MECHANIC. THEN THE FOLLOWING MONTHS WE HAD SOME ISSUES WITH THE MOTOR MOUNTS. ONCE AGAIN WE HAD TO REPLACE THEM AND THEN WE HAD SOME PROBLEMS WITH THE ELECTRON…
Read full complaint
WHEN WE FIST GOT THE VAN WE EXPERIENCED SOME ISSUES WITH THE BRAKES. THE DEALERSHIP WAS SUPPOSED TO TAKE CARE OF IT BUT THE PROBLEM PERSISTED AND WE WENT TO A RECOMMENDED MECHANIC. THEN THE FOLLOWING MONTHS WE HAD SOME ISSUES WITH THE MOTOR MOUNTS. ONCE AGAIN WE HAD TO REPLACE THEM AND THEN WE HAD SOME PROBLEMS WITH THE ELECTRONIC COMPUTER AND WE HAD TO RE-LEARN SOME OF THE ALREADY INSTALLED PROGRAMS. I WOULD LIKE FOR WHOEVER APPROVES THE RECALLS TO GO AHEAD AND APPROVE THE OTHER ISSUES BECAUSE FOR IT BEING A SIX YEAR OLD CAR IT DEFINITELY HAS MORE ISSUES THAN IT SHOULD.
THE DRIVERS SIDE WINDOW SWITCH DOESN'T MAKE THE WINDOW GO UP. YOU HAVE TO PLAY WITH IT FOR AWHILE BEFORE IT DOES . IT DOES THIS ANY TIME YOU TRY TO MAKE THE WINDOW GO UP
WITH KEY IN IGNITION SWITCH, JARRING OR NATURAL MOVEMENT AFTER STARTING CAUSES SYSTEM SHUTDOWN AT ANY SPEED. FIRST INCIDENT OCCURRED AT 55 MPH AND WAS LEFT WITHOUT POWER STEERING, BRAKES OR ANY OTHER ELECTRICALLY CONTROLLED SYSTEM FUNCTIONAL.
Official recalls
625V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
17V376000 · Air Bags:frontal
Jun 13, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.
Consequence & remedy
Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.
Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.
14V234000 · Electrical System
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
12V191000 · Equipment
May 2, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES, MANUFACTURED FROM MARCH 9, 2012 THROUGH MARCH 12, 2012. SOME VEHICLES MAY BE EQUIPPED WITH A RIGHT SIDE LIFTGATE PINCH SENSOR THAT DOES NOT FUNCTION PROPERLY. AS A RESULT, INCREASED FORCE MAY BE REQUIRED IN ORDER TO STOP THE POWER LIFTGATE DURING FINAL CLOSING STAGES.
Consequence & remedy
Consequence: THE POWER LIFTGATE DOOR MAY CLOSE ON AN APPENDAGE, INCREASING THE RISK OF INJURY.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE RIGHT SIDE LIFTGATE PINCH SENSORS, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
12V141000 · Suspension:rear
Apr 3, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM NOVEMBER 15, 2011, THROUGH NOVEMBER 21, 2011. SOME VEHICLES MAY BE EQUIPPED WITH RIGHT REAR HUB AND BEARING ASSEMBLIES THAT WERE NOT FULLY MACHINED.
Consequence & remedy
Consequence: THIS COULD RESULT IN A DECREASE IN DURABILITY, WHICH MAY LEAD TO WHEEL SEPARATION, INCREASING THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE RIGHT REAR HUB AND BEARING ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
11V487000 · Engine And Engine Cooling
Sep 29, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 CHRYSLER VEHICLES, INCLUDING 200 AND TOWN AND COUNTRY MODELS, DODGE VEHICLES, INCLUDING CHARGER, DURANGO, GRAND CARAVAN AND JOURNEY MODELS AND JEEP GRAND CHEROKEE VEHICLES MANUFACTURED FROM AUGUST 31, 2011, THROUGH SEPTEMBER 13, 2011, THAT ARE EQUIPPED WITH 3.6L ENGINES. THESE ENGINES MAY EXPERIENCE CONNECTING ROD BEARING FAILURE DUE TO DEBRIS INSIDE THE ENGINE BLOCK.
Consequence & remedy
Consequence: CONNECTING ROD FAILURE MAY LEAD TO ENGINE SEIZURE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE ENGINE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT NOVEMBER 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den