← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

What owners actually said

530 reports
Mileage unknown · Aug 17, 2022
SeatsInjury

While driving my vehicle at highway speed (75mph), the driver's seat headrest, for lack of a more descriptive term, exploded and struck me in the back of my head. After the incident I stopped the vehicle and looked at the headrest. It appears to be spring loaded and something in the headrest failed causing it to spring forward f…

Read full complaint

While driving my vehicle at highway speed (75mph), the driver's seat headrest, for lack of a more descriptive term, exploded and struck me in the back of my head. After the incident I stopped the vehicle and looked at the headrest. It appears to be spring loaded and something in the headrest failed causing it to spring forward for no reason. The headrest is now compressed and held in place with zip ties until I can find a replacement. I feel this is a safety issue due to the disorientation and headache that immediately followed the incident.

NHTSA ODI #11479815

Mileage unknown · Jun 21, 2022
Electrical System

Vehicle windows intermittently would roll down on there own and car horn would beep, than vehicle intermittently would not start engine would just shut off. Vehicle, stalls when in gear and wouldn't restart. Replaced, TIPM vehicle seemed to go back into normal operation for few minutes than TIPM faulted again. I understand, NHTS…

Read full complaint

Vehicle windows intermittently would roll down on there own and car horn would beep, than vehicle intermittently would not start engine would just shut off. Vehicle, stalls when in gear and wouldn't restart. Replaced, TIPM vehicle seemed to go back into normal operation for few minutes than TIPM faulted again. I understand, NHTSA has investigated this issue with Dodge Caravan and needing to recall faulty TIPM.

NHTSA ODI #11470200

Mileage unknown · May 3, 2022
Fuel/propulsion System

The tipm fuel pump relay is stuck causing the fuel pump to stay on even when the vehicle is turned off and the key is not in the ignition switch. This problem is, its dangerous if I was ever to be in an accident and fuel pump will stay on according to the mechanic. Also my car battery is drained after an hour making it undrivabl…

Read full complaint

The tipm fuel pump relay is stuck causing the fuel pump to stay on even when the vehicle is turned off and the key is not in the ignition switch. This problem is, its dangerous if I was ever to be in an accident and fuel pump will stay on according to the mechanic. Also my car battery is drained after an hour making it undrivable until I call a tow or get a jump start. It was inspected by a mechanic and the vehicle is available for inspection. No warning lamps were on or previous symptoms before 4/30/21. Only the sound of a running fuel pump when the car is completely off. Mechanic states car is known to have this issue. Recalls were made for other dodge vehicles with same part number but they failed to include the this model.

NHTSA ODI #11463235

200,000 miles · Apr 14, 2022
EngineFuel System, Gasoline

The contact owns a 2011 Dodge Grand Caravan. The contact stated that while driving at 35 MPH, the vehicle stalled inadvertently. There were several unknown warning lights illuminated on the instrument panel. The contact was able to veer to the side of the road, where he successfully restarted the vehicle. The vehicle was taken t…

Read full complaint

The contact owns a 2011 Dodge Grand Caravan. The contact stated that while driving at 35 MPH, the vehicle stalled inadvertently. There were several unknown warning lights illuminated on the instrument panel. The contact was able to veer to the side of the road, where he successfully restarted the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel pump needed to be replaced. The contact stated that after the vehicle had been repaired, the vehicle would fail to start intermittently, and would only start after several attempts. An unknown dealer was notified of the failure and informed the contact that there were no open recalls on the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 200,000. THE CONSUMER STATED THE VEHICLE WAS REPAIRED BY REPLACING THE INGNITION SWITCH. THE CONSUMER DISCOVERED AN IGNITION SWITCH RECALL THAT THE VEHICLE WAS NOT INCLUDED IN DUE TO THE MODEL YEAR. THE CONSUMER REQUESTED THAT THE VEHICLE BE INCLUDED IN THE RECALL, AS IT DISPLAYED THE SAME FAILURE DETAILED IN THE RECALL NOTICE.

NHTSA ODI #11460756

Mileage unknown · Feb 12, 2022
Electrical SystemFuel/propulsion System

Car starts intermittently especially when In colder conditions takes 3 to 4 starts , hard to start , put in neutral and starts right away ,car feels like it’s going to stall out when accelerating at times

NHTSA ODI #11451642

Mileage unknown · Jan 13, 2022
Fuel/propulsion SystemVehicle Speed Control

The accelerator pedal sticks in full throttle and forces the car to speed forward. Brakes barely overcome the acceleration and the engine will accelerate from a complete stop. Super dangerous and there are a number of threads on vehicle forums that describe the situation

NHTSA ODI #11447331

Mileage unknown · Nov 19, 2021
Electrical SystemEngineService Brakes

My car was fine until one day in rain the whole dash and radio shut off and came back on repeatedly, spedometer bouncing each time. Took it to dealer/JDByrider and "they dont know prob/happens all the time" w a very "oh well" attitude. They did nothing. I called again when car ALSO started shutting completely off at long red lig…

Read full complaint

My car was fine until one day in rain the whole dash and radio shut off and came back on repeatedly, spedometer bouncing each time. Took it to dealer/JDByrider and "they dont know prob/happens all the time" w a very "oh well" attitude. They did nothing. I called again when car ALSO started shutting completely off at long red lights. I was told next appt available would be 23 days! Thats still 4 days away. NOW in addition to dash/radio/spedometer problem the van doesnt just die at LONG lights, it dies if I have to stop for drive thrus, stop signs, short lights. The headlights have also started flickering very very badly. Im upset that repairs are supposed to be covered by JDByrider and theyve had me driving this dangerous car for almost a month before trying to fix it. Im not allowed to get work done on it elsewhere or else it makes future repairs on parts not covered by JDByrider. I have 4 kids and this car is not safe on road and Im literally not allowed to get someone else to fix it if I want it to continue to be covered by JDB. JDB blames Dodge. My car purchase was supposed to cover repairs and instead Im being forced to drive 4 kids around in car dealer cant fix and they claim Dodge dont know how to either. I should have never been expected to wait almost a month for this to be addressed.

NHTSA ODI #11441091

Mileage unknown · Sep 14, 2021
Electrical SystemSteering

DRIVING AT ABOUT15 M.P.H. I HAD TROUBLE STEERING AND NOISE WAS COMING FOR UNDER THE HOOD, I PULLED OVER AND I LOOK UNDER THE CAR IT WAS LEAKING LOTS OF OIL. I HAD IT TOWED TO THE DEALER,THE PROBLEM WAS A HOLE IN THE TUBING ON THE RACKEN PINEN STEERING .IF IT WAS ON A HIGHWAY OR ON A FASTER ROAD IT WOULD HAVE BEEN A VERY BAD ACCI…

Read full complaint

DRIVING AT ABOUT15 M.P.H. I HAD TROUBLE STEERING AND NOISE WAS COMING FOR UNDER THE HOOD, I PULLED OVER AND I LOOK UNDER THE CAR IT WAS LEAKING LOTS OF OIL. I HAD IT TOWED TO THE DEALER,THE PROBLEM WAS A HOLE IN THE TUBING ON THE RACKEN PINEN STEERING .IF IT WAS ON A HIGHWAY OR ON A FASTER ROAD IT WOULD HAVE BEEN A VERY BAD ACCIDENT WITH OIL LEAKING AND COULD NOT STEER THE VAN. I WAS VERY VERY LUCKY.THERE WAS NO WARNING LIGHT. I HAVE A PICTURE OF THE HOLE. I REPORTED TO CHRYSLER. Consumer stated metal that was replaced rusted.

NHTSA ODI #11432932

Mileage unknown · Sep 6, 2021
Electrical SystemEngine

Battery light turned on and vehicle immediately shut off. Got car jump to make it home and all electrical components went hay wire - all dash lights blinking - transmission wouldn’t not shit and accelerated by itself, headlights wouldn’t go on, windows wouldn’t go down. Dodge recalled every other car model in their line for a …

Read full complaint

Battery light turned on and vehicle immediately shut off. Got car jump to make it home and all electrical components went hay wire - all dash lights blinking - transmission wouldn’t not shit and accelerated by itself, headlights wouldn’t go on, windows wouldn’t go down. Dodge recalled every other car model in their line for a bad ALTERNATOR rapid failure, except Caravan, which should absolutely be included. It’s a know issue - car shouldn’t be dying while driving with under 100k miles.

NHTSA ODI #11431864

Mileage unknown · Aug 31, 2021
Electrical System

It started a few months ago with my van not starting properly. After being stranded multiple times & it stalling once while driving, I had my mechanic check multiple issues we assumed the fuel pump was going bad. Nearly $600 later and a new fuel pump the issues continued until today when it is now dead! After searching I foun…

Read full complaint

It started a few months ago with my van not starting properly. After being stranded multiple times & it stalling once while driving, I had my mechanic check multiple issues we assumed the fuel pump was going bad. Nearly $600 later and a new fuel pump the issues continued until today when it is now dead! After searching I found 2010 and older models of my van were recalled for this EXACT issue, just not 2011! I don’t have the money to fix it and am pissed that while it’s the same problem it is not covered in the recall.

NHTSA ODI #11431155

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den