← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

What owners actually said

530 reports
100,700 miles · Aug 18, 2017
Electrical System

FOR THE LAST MONTH I HAVE BEEN HAVING TROUBLE STARTING THE VAN. TURN THE KEY, RADIO AND DASH LIGHTS COMES ON BUT THE VEHICLE WILL NOT START. TRY SEVERAL TIMES AND EVENTUALLY IT WILL START. TOOK VAN INTO REPAIR SHOP AND THEY REPLACED THE BATTERY; HOWEVER, STILL HAVING THE UNRELIABLE STARTING ISSUE. TOOK INTO A DODGE DEALER A…

Read full complaint

FOR THE LAST MONTH I HAVE BEEN HAVING TROUBLE STARTING THE VAN. TURN THE KEY, RADIO AND DASH LIGHTS COMES ON BUT THE VEHICLE WILL NOT START. TRY SEVERAL TIMES AND EVENTUALLY IT WILL START. TOOK VAN INTO REPAIR SHOP AND THEY REPLACED THE BATTERY; HOWEVER, STILL HAVING THE UNRELIABLE STARTING ISSUE. TOOK INTO A DODGE DEALER AND THEY SAID COULDN'T FIND ANYTHING. STARTING TO QUESTION IF IT IS AN ISSUE WITH THE TIPM - THIS IS THE VAN I USE TO TRANSPORT MY CHILDREN AROUND, CONCERNED WHEN YOU READ THE ADDITIONAL ISSUES IF IT IS A DEFECTIVE TIPM.

NHTSA ODI #11016235

100,300 miles · Aug 3, 2017
Air BagsElectrical System

MY AIRBAG LIGHT WOULD COME ON AND GO OFF RANDOMLY. I TOOK IT BACK TO MY DEALER AND IT WAS STATED THAT IT WAS AN ISSUE WITH IN THE WIRING BUT NOT AN ISSUE WITH THE AIRBAG. NOW MY AIRBAG LIGHT HAS BEEN ON FOR OVER A MONTH. I CHECKED RECALLS AND SEE THERE IS A RECALL ON 2011-2012 DODGE GRAND CARAVANS FOR THE DRIVER SIDE AIRBAG RAND…

Read full complaint

MY AIRBAG LIGHT WOULD COME ON AND GO OFF RANDOMLY. I TOOK IT BACK TO MY DEALER AND IT WAS STATED THAT IT WAS AN ISSUE WITH IN THE WIRING BUT NOT AN ISSUE WITH THE AIRBAG. NOW MY AIRBAG LIGHT HAS BEEN ON FOR OVER A MONTH. I CHECKED RECALLS AND SEE THERE IS A RECALL ON 2011-2012 DODGE GRAND CARAVANS FOR THE DRIVER SIDE AIRBAG RANDOMLY DEPLOYING YET NOTHING FOR MY VIN. I DRIVE MY CHILDREN AROUND IN THIS VEHICLE AND IF THE DRIVER SIDE OR EITHER SIDE WAS TO RANDOMLY DEPLOY....THIS IS A CATASTROPHE WAITING TO HAPPEN!!!

NHTSA ODI #11012569

80,000 miles · Jul 15, 2017
Air BagsElectrical System

CAR WAS NOT ABLE TO START WITH CLICKING NOISE. ALSO FUEL PUMP WAS STILL RUNNING LONG AFTER CAR WAS TURNED OFF AND EXITED. PROBLEM WAS THE TIPM. THIS IS A RECALL FOR OTHER DODGE MODELS THAT ARE 2011 YET IT IS NOT FOR MY VAN. THIS IS OVER A $1000 PROBLEM TO HAVE DEALERSHIP CHANGE THE TIPM. NOW MY AIRBAG LIGHT IS ON. I'M FINDING MA…

Read full complaint

CAR WAS NOT ABLE TO START WITH CLICKING NOISE. ALSO FUEL PUMP WAS STILL RUNNING LONG AFTER CAR WAS TURNED OFF AND EXITED. PROBLEM WAS THE TIPM. THIS IS A RECALL FOR OTHER DODGE MODELS THAT ARE 2011 YET IT IS NOT FOR MY VAN. THIS IS OVER A $1000 PROBLEM TO HAVE DEALERSHIP CHANGE THE TIPM. NOW MY AIRBAG LIGHT IS ON. I'M FINDING MASS OF PEOPLE HAD THIS PROBLEM BECAUSE OF WATER INTRUSION IN CONNECTION IN ENGINE COMPARTMENT. HOW IS THIS NOT A RECALL? THAT SHOULD BE A WATER SEALED CONNECTION TO PREVENT AIRBAG SYSTEM SHUTTING OFF. WE WERE STATIONARY, CAR RUNNING, LIGHT CAME ON.

NHTSA ODI #11005452

84,000 miles · Jul 12, 2017
Electrical System

CAR SHUT OFF WHILE DRIVING, WILL NOT CRANK OR TURN OVER. POWER TRANS MODULE ISSUE AFTER A RECALL THAT REPROGRAMMED THE POWER TRANS MODULE.

NHTSA ODI #11004752

66,550 miles · Jun 12, 2017
Electrical SystemFire

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V234000 (ELECTRICAL SYSTEM). WHILE THE CONTACT'S WIFE WAS DRIVING 35 MPH, SHE HEARD CLICKING AND POPPING NOISES COMING FROM THE FRONT DRIVER'S SIDE DOOR AND NOTICED SMOKE. THE FRONT DRIVER'S SIDE DOOR CAUGHT FIRE. THE FIRE DEPA…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V234000 (ELECTRICAL SYSTEM). WHILE THE CONTACT'S WIFE WAS DRIVING 35 MPH, SHE HEARD CLICKING AND POPPING NOISES COMING FROM THE FRONT DRIVER'S SIDE DOOR AND NOTICED SMOKE. THE FRONT DRIVER'S SIDE DOOR CAUGHT FIRE. THE FIRE DEPARTMENT WAS CALLED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED. THE MANUFACTURER SENT AN INDEPENDENT INSPECTOR TO INVESTIGATE THE INCIDENT AND ULTIMATELY STATED THAT CHRYSLER HAD NO RESPONSIBILITY FOR THE FIRE. THE CAUSE OF THE FIRE WAS NOT DIAGNOSED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THE CONTACT'S INSURANCE COMPANY STATED THAT THEY WOULD ATTEMPT TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 66,550. *TT *JS

NHTSA ODI #10994447

51,515 miles · Jun 8, 2017
Electrical SystemPower TrainService Brakes

A LOS POCOS DAS DE COMPRAR LA GUAGUA EN UN DEALER, CUANDO ESTABA DANDO REVERSA SENT QUE DA UNOS BRINCOS Y TIEMBLA. TARDA UN POCO EN MOVERSE. FUIMOS EL DA 2 DE MARZO Y NOS DIJERON QUE ERA NORMAL, AL COMPARARLA CON OTRA PARECIDA, SEGN NOS DIJERON, AN CONTINA HACINDOLO. NO LE HICIERON NADA A LA GUAGUA. AL MES SALIMOS A UNA CITA MD…

Read full complaint

A LOS POCOS DAS DE COMPRAR LA GUAGUA EN UN DEALER, CUANDO ESTABA DANDO REVERSA SENT QUE DA UNOS BRINCOS Y TIEMBLA. TARDA UN POCO EN MOVERSE. FUIMOS EL DA 2 DE MARZO Y NOS DIJERON QUE ERA NORMAL, AL COMPARARLA CON OTRA PARECIDA, SEGN NOS DIJERON, AN CONTINA HACINDOLO. NO LE HICIERON NADA A LA GUAGUA. AL MES SALIMOS A UNA CITA MDICA Y NO COGI FRENO, BAJAMOS UNA CUESTA Y NO QUERA PARAR, PARAMOS CON LA EMERGENCIA FRENTE A UNA CASA,CUANDO LA CHEQUEARON NO TENA PATTS EN NINGUNA GOMA. LOS COMPRAMOS Y CUANDO LE RECLAM AL DEALER SOLO NOS DIJERON QUE TENAMOS QUE LLEVRSELO DAADO QUE AHORA NO PODAN HACER NADA, MI ESPOSO EST ENFERMO Y NO NOS HAN AYUDADO. TAMBIN TIENE PROBLEMAS CON LOS SEGUROS YA HEMOS COMPRADO 3 BATERAS Y SE AGOTA MUY RPIDO,(DEL CONTROL).'

NHTSA ODI #10994047

Mileage unknown · May 30, 2017
Electrical SystemFuel/propulsion System

CAR WILL NOT START, WILL CRANK BUT NO TURN OVER. IT WILL ONLY START IF I BYPASS THE FUEL PUMP RELAY. THIS IS AN ONGOING ISSUE WITH DODGE/CHRYSLER AND SOME VEHICLES HAVE BEEN RECALLED FOR THIS FAULT TIPM BUT THE CARAVAN HASN'T. THIS IS A SAFETY ISSUE AS THE CAR WILL STALL AT ANY MOMENT WHILE DRIVING IF DOES START TO BEGIN WITH…

Read full complaint

CAR WILL NOT START, WILL CRANK BUT NO TURN OVER. IT WILL ONLY START IF I BYPASS THE FUEL PUMP RELAY. THIS IS AN ONGOING ISSUE WITH DODGE/CHRYSLER AND SOME VEHICLES HAVE BEEN RECALLED FOR THIS FAULT TIPM BUT THE CARAVAN HASN'T. THIS IS A SAFETY ISSUE AS THE CAR WILL STALL AT ANY MOMENT WHILE DRIVING IF DOES START TO BEGIN WITH.

NHTSA ODI #10992268

128,000 miles · May 25, 2017
Engine

AS I AM DRIVING THE CAR JUST SHUTS OFF WITH NO WARNING. IT HAS HAPPENED MULTIPLE TIMES BOTH ON THE HIGHWAY AND IN TOWN. I LOSE INSTRUMENTATION, POWER STEERING, AND POWER BRAKES. I HAVE HAD TO GLIED TO A STOP AND TRY AND RESTART THE VEHICLE.

NHTSA ODI #10991611

86,000 miles · May 24, 2017
Electrical SystemEngineFuel/propulsion System

MY VAN IS CRANKING BUT NOT TURNING OVER. THERE ARE SEVERAL RECALLS FOR THE SAME ISSUE FOR OTHER DODGE AND CHRYSLER VEHICLES BUT NOT MINE. IT STATES WHEN RESEARCHING IT'S A TIPM ISSUE.

NHTSA ODI #10991340

85,000 miles · May 20, 2017
Fuel/propulsion System

WHILE TRAVELING ON FREEWAY 65 MPH VEHICE COMPLETELY STALLED OUT AFTER SEVERAL ATTEMPS TO RESTART IN RESTARTED HAS STALLED MULTIPLE TIMES MECHANIC SAYS IT IS FUELL PUMP RELAY IN TIPM.

NHTSA ODI #10990726

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den