← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Engine complaints

92 reports
Clear category filter
65,000 miles · Nov 20, 2015
Electrical SystemElectronic Stability Control (esc)Engine

MY VEHICLE HAD A DEFECTIVE TIPM MODULE IN IT. I FIRST HAD TO REPLACE THE BATTERY THEN THE ALTENATOR THEN THE KEY FOB AND FINALLY THE TIPM MODULE. LOOKING BACK THAT ALL OF THE FIRST REPAIRS TURNED OUT NOT TO BE THE PROBLEM. WE HAD ALWAYS NOTICED THAT AT TIMES THE WINDOWS WOULD AUTOMATICALLY ROLL DOWN AND THAT THE ELECTRIC DOORS W…

Read full complaint

MY VEHICLE HAD A DEFECTIVE TIPM MODULE IN IT. I FIRST HAD TO REPLACE THE BATTERY THEN THE ALTENATOR THEN THE KEY FOB AND FINALLY THE TIPM MODULE. LOOKING BACK THAT ALL OF THE FIRST REPAIRS TURNED OUT NOT TO BE THE PROBLEM. WE HAD ALWAYS NOTICED THAT AT TIMES THE WINDOWS WOULD AUTOMATICALLY ROLL DOWN AND THAT THE ELECTRIC DOORS WOULD SUDDENLY OPEN UP. WE NEVER QUITE KNEW WHAT IT WAS UNTIL NOW. WE REPLACED THE TIPM AND IT WORKED FINE. AFTER SPENDING 800 DOLLARS THAT I DIDN'T REAL NEED TO THE TIPM WAS ANOTHER 1000 DOLLARS. I'VE SEEN THE LAWSUIT THAT IS ON GOING RELATED TO THE VERY SAME PROBLEM I HAD IN THE GRAND CHEROKEES AND THE DODGE DURANGOS. MY VEHICLE IS LIST IN THE ADDENDUM TO THE LAWSUIT. I'M VERY FRUSTRATED I HAD TO SPEND FIRST 800 DOLLARS THAT DIDN'T FIX THE PROBLEM THEN THE1000 DOLLARS KNOWING THEY HAVEN'T HAD A RECALL YET AFTER SO MANY COMPLAINTS REGARDING THE SAME ISSUES.

NHTSA ODI #10795055

66,447 miles · Nov 10, 2015
EngineUnknown Or Other

I HAVE BEEN HAVING PROBLEMS WITH MY VAN CRANKING. SO I TOOK IT TO MY DEALER.THEY CHANGED THE FUEL PUMP AND IT CONTINUED TO DO THE SAME THING. SO THEY REPLACED RELAYS. THEY KEPT MY VAN FOR OVER THREE WEEKS, BUT CLAIMED THEY NEVER COULD GET IT TO DO ANYTHING. BUT EVERY TIME I GET IN IT IN THE MORNING IT STILL DOES THE SAME THING. …

Read full complaint

I HAVE BEEN HAVING PROBLEMS WITH MY VAN CRANKING. SO I TOOK IT TO MY DEALER.THEY CHANGED THE FUEL PUMP AND IT CONTINUED TO DO THE SAME THING. SO THEY REPLACED RELAYS. THEY KEPT MY VAN FOR OVER THREE WEEKS, BUT CLAIMED THEY NEVER COULD GET IT TO DO ANYTHING. BUT EVERY TIME I GET IN IT IN THE MORNING IT STILL DOES THE SAME THING. WHEN YOU TURN THE KEY TO CRANK IT, IT CONTINUES TO TRY TO CRANK. BUT IF YOU TURN THE KEY OFF THEN TO RIGHT BEFORE IT CRANKS, DO THIS A COUPLE OF TIMES THEN IT WILL CRANK. I ASKED IF ANYONE EVER DROVE IT TO SEE IF IT DID THE SAME THING WITH THEM AND THEY SAID NO. NEEDLESS TO SAY IT IS STILL DOING THE SAME THING AND NO ONE HAS BOTHER TO CONTACT ME TO FIX THE PROBLEM. AND MY VAN HAS ALWAYS HAD SERVICE AT THE DEALERSHIP. I WANT MY VAN BACK THE WAY IT WAS!!!!!!!!!!

NHTSA ODI #10789533

65,000 miles · Nov 7, 2015
Electrical SystemElectronic Stability Control (esc)Engine

FIRST I WAS TOLD IT WAS THE BATTERY THEN IT WAS THE ALTERNATOR THEN IT WAS THE KEY FOB. AFTER ALL THESE REPAIRS THE DODGE DEALERSHIP SAYS NOW IT'S THE TIMP MODULE. THIS VAN ONLY HAS 65000 MILES. I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THE VERY SAME ISSUES FOR CUSTOMERS WITH THE SAME TYPE VEHICLES. I HAVE ALSO SEEN THE LAWSUIT …

Read full complaint

FIRST I WAS TOLD IT WAS THE BATTERY THEN IT WAS THE ALTERNATOR THEN IT WAS THE KEY FOB. AFTER ALL THESE REPAIRS THE DODGE DEALERSHIP SAYS NOW IT'S THE TIMP MODULE. THIS VAN ONLY HAS 65000 MILES. I HAVE SEEN HUNDREDS OF COMPLAINTS ABOUT THE VERY SAME ISSUES FOR CUSTOMERS WITH THE SAME TYPE VEHICLES. I HAVE ALSO SEEN THE LAWSUIT AND RECALL FOR DEFECTIVE TIMP FROM 2013 AND 2014. MY VEHICLE IS ONE THAT WAS LISTED AS AN ADDENDUM LAWSUIT THAT MAY BE AFFECTED BY THIS MODULE. THIS VEHICLE WAS PURCHASED IN FLORIDA IN 2012.

NHTSA ODI #10788980

80,000 miles · Oct 21, 2015
Electrical SystemEngine

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED. AFTER SEVERAL ATTEMPTS, THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TOTALLY INTEGRATED POWER MODULE NEEDED TO BE REPLACED. THE VEHI…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED. AFTER SEVERAL ATTEMPTS, THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TOTALLY INTEGRATED POWER MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

NHTSA ODI #10785031

77,861 miles · Oct 3, 2015
Engine

IT BEGAN WHEN THE VEHICLE WAS ABOUT 6 MONTHS OLD, THE WINDOWS WOULD OPERATE ON THERE OWN, THE ELECTRONIC VEHICLE INFROMATION CENTER WOULD CHANGE ON IT'S OWN, AND LAST MONTH THE VEHICLE WOULD NOT ALWAYS START, HAD TO REPLACE THE TIPM

NHTSA ODI #10779468

150,000 miles · Aug 12, 2015
Electrical SystemEngineFuel/propulsion System

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, WHILE DRIVING AT 40 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE DEALER DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS…

Read full complaint

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, WHILE DRIVING AT 40 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE DEALER DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ODI #10748083

93,000 miles · Aug 2, 2015
Electrical SystemEngineFuel/propulsion System

WE HAVE HAD OUR 2011 DODGE GRAND CARAVAN FOR 2 YEARS AND APPROXIMATELY 30,000 MILES. WE HAD TO HAVE THE TIPM REPLACED IN JULY 2015. WE HAVE HAD SEVERAL INSTANCES THAT REQUIRED A TOW AS THE VEHICLE WOULD NOT START OR STAY RUNNING. THE TIPM BURNED THE FUEL PUMP OUT AND THAT WAS THE LAST STRAW. THE TIPM WAS REPLACED UNDER THE AFTER…

Read full complaint

WE HAVE HAD OUR 2011 DODGE GRAND CARAVAN FOR 2 YEARS AND APPROXIMATELY 30,000 MILES. WE HAD TO HAVE THE TIPM REPLACED IN JULY 2015. WE HAVE HAD SEVERAL INSTANCES THAT REQUIRED A TOW AS THE VEHICLE WOULD NOT START OR STAY RUNNING. THE TIPM BURNED THE FUEL PUMP OUT AND THAT WAS THE LAST STRAW. THE TIPM WAS REPLACED UNDER THE AFTER MARKET WARRANTY THAT WE PAID FOR BUT WHAT OTHER DAMAGE COULD THIS PART HAVE CAUSED TO OUR VEHICLE? IT CONTROLS EVERYTHING THE CAR DOES FOR THE MOST PART. WILL THERE BE AN INVESTIGATION OF THE DODGE TIPM? THERE NEEDS TO BE A RECALL FOR ALL VEHICLES AFFECTED WHICH SEEMS TO BE QUITE A LOT.

NHTSA ODI #10745669

79,000 miles · Jul 8, 2015
Engine

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WITHOUT WARNING. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

NHTSA ODI #10732651

95,000 miles · May 14, 2015
Electrical SystemEngineSteering

I WAS DRIVING APPROXIMATELY 30 MPH AND THE VEHICLE JUST SHUT DOWN, THE POWERING STEERING WENT OUT AND THE ENGINE STALLED WHICH WE LATER FOUND OUT WAS DUE TO THE FAULTY TIPM. WE HAD ALSO BEEN HAVING A FEW ISSUES WITH THE FUEL PUMP.....THE FUEL PUMP WAS NOT SHUTTING OFF AND ALL LEAD TO PROBLEMS WITH BEING ABLE TO START THE VEHICL…

Read full complaint

I WAS DRIVING APPROXIMATELY 30 MPH AND THE VEHICLE JUST SHUT DOWN, THE POWERING STEERING WENT OUT AND THE ENGINE STALLED WHICH WE LATER FOUND OUT WAS DUE TO THE FAULTY TIPM. WE HAD ALSO BEEN HAVING A FEW ISSUES WITH THE FUEL PUMP.....THE FUEL PUMP WAS NOT SHUTTING OFF AND ALL LEAD TO PROBLEMS WITH BEING ABLE TO START THE VEHICLE SOMETIMES IT TOOK SEVERAL ATTEMPTS TO EVEN GET VEHICLE STARTED.

NHTSA ODI #10716449

169,000 miles · Apr 16, 2015
Engine

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE THE VEHICLE WAS PARKED, THE ENGINE AND ELECTRONIC THROTTLE CONTROL WARNING LIGHTS ILLUMINATED AND THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 169,000.

NHTSA ODI #10706150

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den