VEHICLE COMPLETELY SHUT DOWN WHILE IN MOTION - TREMENDOUS SAFETY ISSUE WITH WIFE AND 4 KIDS IN THIS VEHICLE. THIS IS A HIGHLY REPORTED ISSUE AND OBVIOUS DEFECT IN MODEL YEAR FOR THIS MANUFACTURER. VEHICLE HAS HAD ESCALATING ELECTRICAL ISSUES FOR MORE THAN 4 YEARS.
2011 Dodge Grand Caravan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
383 reports with mileage · 147 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
92 reportsTHE VAN'S ENGINE SHUTDOWN WHILE MY WIFE WAS DRIVING THE VAN AT NIGHT AND BARELY HAD ENOUGH TIME TO PULL TO THE SIDE OF THE ROAD BEFORE LOSING CONTROL OF STEERING. SHE HAD JUST MADE A RIGHT TURN ONTO THE HIGHWAY. TOWED THE VAN TO A LOCAL DEALER AND FOUND THE ISSUE TO BE THE DIODE ON THE ALTERNATOR FAILING CAUSING ELECTRICAL FEEDB…
Read full complaint
THE VAN'S ENGINE SHUTDOWN WHILE MY WIFE WAS DRIVING THE VAN AT NIGHT AND BARELY HAD ENOUGH TIME TO PULL TO THE SIDE OF THE ROAD BEFORE LOSING CONTROL OF STEERING. SHE HAD JUST MADE A RIGHT TURN ONTO THE HIGHWAY. TOWED THE VAN TO A LOCAL DEALER AND FOUND THE ISSUE TO BE THE DIODE ON THE ALTERNATOR FAILING CAUSING ELECTRICAL FEEDBACK TO THE POWERTRAIN CONTROL MODULE (PCM). SO HAD TO SPEND A LOT OF MONEY TO HAVE THE ALTERNATOR AND PCM REPLACED. I AM AWARE OTHER VEHICLE LINES OF 2011 HAVE A RECALL FOR THIS SPECIFIC ISSUE AND AM UNSURE WHY THE DODGE GRAND CARAVAN IS NOT ON THE LIST. THERE NEEDS TO BE AN INVESTIGATION AND HAVE THIS VEHICLE ADDED TO THE RECALL.
I HAVE BEEN HAVING PROBLEMS WITH STARTING MY VEHICLE. IT WANTS TO START BUT WILL NOT KICK OVER. I HAVE TO CALL A TOW TRUCK AND THEY BRING IT TO DODGE AND THEY CONTINUE TO TELL ME THERE IS NOTHING WRONG. IT STARTS AGAIN. THIS HAS BEEN GOING ON FOR MONTHS AN FINALY DODGE SAID IT WAS MY ALTERNATOR. IT WAS REPLACED AND AFTER A WEEK…
Read full complaint
I HAVE BEEN HAVING PROBLEMS WITH STARTING MY VEHICLE. IT WANTS TO START BUT WILL NOT KICK OVER. I HAVE TO CALL A TOW TRUCK AND THEY BRING IT TO DODGE AND THEY CONTINUE TO TELL ME THERE IS NOTHING WRONG. IT STARTS AGAIN. THIS HAS BEEN GOING ON FOR MONTHS AN FINALY DODGE SAID IT WAS MY ALTERNATOR. IT WAS REPLACED AND AFTER A WEEK THE SAME THING HAS HAPPENED. IT HAS DONE IT A FEW OTHER TIMES BUT WILL START AFTER A FEW TIMES. THE VEHICLE IS PARKED.
MY VAN HAS HAD ELECTRICAL TYPE ISSUES SINCE WE PURCHASED IT, BUT IN THE LAST COUPLE YEARS THEY HAVE IMAGNIFIED. EVERY ISSUE STARTS WITH THE CAR SMOKING AND SOME SORT OF LIGHT COMING ON (ENGINE, BATTERY ETC..) MANY TIMES I TAKE IT IN AND THE DASH LIGHT IS NO LONGER ILLUMINATED OR THEY CAN NOT FIND ANYTHING WRONG WITH IT AND RESET…
Read full complaint
MY VAN HAS HAD ELECTRICAL TYPE ISSUES SINCE WE PURCHASED IT, BUT IN THE LAST COUPLE YEARS THEY HAVE IMAGNIFIED. EVERY ISSUE STARTS WITH THE CAR SMOKING AND SOME SORT OF LIGHT COMING ON (ENGINE, BATTERY ETC..) MANY TIMES I TAKE IT IN AND THE DASH LIGHT IS NO LONGER ILLUMINATED OR THEY CAN NOT FIND ANYTHING WRONG WITH IT AND RESET THE ELECTRICAL PANEL. I HAVE REPLACED THE BATTERY NUMEROUS TIMES, ALTERNATOR THREE TIMES (LAST TIME IT WAS COMPLETELY BURNT OUT AND THE TIME BEFORE IT WAS COMPLETELY MELTED). TRANSMISSION LINES AND COOLANT LINES. THE LAST TIME MY HEADLIGHTS WERE REPLACED THE WIRES WERE CHARRED AND FRAYED. LAST NIGHT MY SON WAS PULLED OVER BY THE POLICE BECAUSE THE OFFICER NOTICED THE CAR WAS SMOKING. HE POPPED THE HOOD TO LET THE SMOKE CLEAR (MY SON SAID THE SMOKE HAD A COPERY TASTE). AFTER IT CLEARED THE VAN STARTED AND DROVE FINE. THIS IS AFTER HAVING THE ALTERNATOR REPLACED (FOR THE THIRD TIME) JUST LAST WEEK. THE TECHNICIANS AT THE SHOP HAVE NEVER SEEN THESE KINDS OF PROBLEMS BEFORE AND THE GUY AT INTERSTATE BATTERY SAID HE HAS NEVER SEEN A CAR DEPLETE A BATTERY LIKE MINE DOES. WITH ALL THESE ISSUE BEING ASSOCIATED WITH THE WORDS MELTING, CHARRING, SMOKING, IT REALLY CONCERNS ME THAT ONE DAY MY VAN IS GOING TO CATCH ON FIRE OR BLOW UP AND THIS IS NOT NORMAL FOR ANY VEHICLE, BUT ESPECIALLY ONE THAT HAS BEEN TAKEN CARE OF AND MAINTAINED. I HAVE FRIENDS WITH THE SAME VAN AND SIMILAR MILEAGE (155,000) AND THEY HAVE NOT HAD ANY OF THESE ISSUES. I CONTACTED DODGE WHO REFERRED ME TO THE NHTSA AND THE LOCAL DEALERSHIP. PLEASE HELP!!!
2011 DODGE GRAND CARAVAN R/T 79900 MILES INTERMITTENT FAILURE TO START. INTERMITTENT STALLING AFTER STARTING. STALLED ON STREET AFTER LEAVING DRIVEWAY. NO CHECK ENGINE LIGHT INDICATED ON DASH. JUST BOUGHT THE CAR USED FROM A DEALER.
TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING AT ANY SPEED, THE ENGINE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AFTER A FEW MINUTES AND WAS TAKEN TO HAASZ AUTOMALL OF RAVENNA (4886 OH-59, RAVENNA, OH 44266, 330-296-2866) WHERE THE TECHNICIAN STATED THAT THERE WAS NO RECALL. A DIAGNOSTIC TEST WAS PERFORMED…
Read full complaint
TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING AT ANY SPEED, THE ENGINE SHUT OFF WITHOUT WARNING. THE VEHICLE RESTARTED AFTER A FEW MINUTES AND WAS TAKEN TO HAASZ AUTOMALL OF RAVENNA (4886 OH-59, RAVENNA, OH 44266, 330-296-2866) WHERE THE TECHNICIAN STATED THAT THERE WAS NO RECALL. A DIAGNOSTIC TEST WAS PERFORMED, BUT THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE TECHNICIAN RECOMMENDED A MORE EXTENSIVE TEST, BUT THE CONTACT DECLINED TO PAY THE HIGH COST FOR THE TEST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
2011 DODGE CARAVAN PURCHASED 3/2017. MOTOR HAD A SLIGHT KNOCKING SOUND TOOK IT BACK TO DEALER THEY SENT ME TO THEIR MECHANIC. I WAS ASSURED THAT IT WAS FINE. THEN BRAKES WENT REALLY LOW AND DID NOT STOP RIGHT. TOLD IT WAS A MASTER CYLINDER.INSTALLED THAT THEN IT HAPPENED AGAIN SO WAS TOLD THAT IT WAS A BAD MASTER CYLINDER. INSTA…
Read full complaint
2011 DODGE CARAVAN PURCHASED 3/2017. MOTOR HAD A SLIGHT KNOCKING SOUND TOOK IT BACK TO DEALER THEY SENT ME TO THEIR MECHANIC. I WAS ASSURED THAT IT WAS FINE. THEN BRAKES WENT REALLY LOW AND DID NOT STOP RIGHT. TOLD IT WAS A MASTER CYLINDER.INSTALLED THAT THEN IT HAPPENED AGAIN SO WAS TOLD THAT IT WAS A BAD MASTER CYLINDER. INSTALLED ANOTHER ONE. DID NOT FIX THE PROBLEM AFTER A FEW DAYS.????? THEN I WAS TOLD WE NEEDED A BRAKE BOOSTER. INSTALLED THAT AND IT DID SEEM LIKE THAT WAS IT FIXED, THEN THE BRAKE LIGHT CAME ON AND BRAKE PEDAL WENT LOW. NOW IT HAS A VERY HORRIBLE SOUND AND THE TRANY AT TIMES DOES NOT WANT TO SHIFT AND THE RPM'S GO UP AND I HAVE TO PULL OVER AND SHUT OFF THE VEHICLE AND TURN IT BACK ON AND IT WILL SHIFT.???? ELECTRONICAL.??? I HAVE READ COMPLAINTS ON NHTSA AND I FEEL LIKE DODGE SHOULD REPAIR THE BRAKES AND THE TRANY PROBLEM. FROM WHAT I CAN READ IT IS A DEFECTIVE PART OF THE PROGRAMMING. THE HORRIBLE NOSIE WHEN YOU PULL OFF, I DONT KNOW WHAT IT IS BUT SOUNDS BAD.. I CALLED DODGE DEALERSHIP RIGHT AFTER I BOUGHT THE VAN AND THEY WERE VERY RUDE AND SAID THERE WERE NOT ANY RECALLS FOR THIS 2011 VAN AND I SEE THAT THERE IS AND SOME SAYS COMPLETE. WELL IF THEY ARE COMPLETE SEEMS TO ME LIKE IT NEEDS TO BE REPAIRED AGAIN BECAUSE IT IS DOING WHAT I SEE THAT PEOPLE ARE COMPLAINING ABOUT. I OWE NEARLY 14,000 ON THIS VAN. . DOGE/CHRYSLER SHOULD MAKE IT GOOD. THE COMPLETE ON THE RECALLS LIKE I SAID IS NOT COMPLETE. PLEASE HELP ME IF YOU CAN. I DONT HAVE MUCH FAITH AFTER THE PERSON AT THE DODGE DEALERSHIP WAS SO RUDE TO ME, BUT MAYBE YOU ALL THERE CAN HELP ME GET IT REPAIRED. THIS IS A SAFETY ISSUE.THE WINDOWS SOMETIMES DONT WANT TO COME DOWN AND YALL HAVE SOMETHING ABOUT IT MIGHT CATCH ON FIRE.THE KEYBOB WILL NOT OPEN THE SIDE DOORS.
AL ENCENDERLO AVECES NO ARRANCA TENGO ESTE PROBLEMA COMO 7 MESES Y A LA SEGUNDO INTENTO PRENDE O AVECES UNE TERCERA VEZ MEDICEN QUE ES EL SWITCH
DRIVING DOWN THE ROAD AT 55 MPH VAN STARTED MAKING WEIRD CLUNKING SOUNDS LIGHTS BEGAN TO DIM LOST ACCELERATOR CONTROL, BRAKES PULLED TO SIDE OF ROAD MANAGE TO COME TO A STOP VEHICLE STILL WAS MAKING SOUNDS AND LIGHTS WERE FLASHING I PUT IT IN PARK VEHICLE STALLED OUT I TRIED TO RESTART AND NOTHING WOULDN'T EVEN TURN OVER JUST CL…
Read full complaint
DRIVING DOWN THE ROAD AT 55 MPH VAN STARTED MAKING WEIRD CLUNKING SOUNDS LIGHTS BEGAN TO DIM LOST ACCELERATOR CONTROL, BRAKES PULLED TO SIDE OF ROAD MANAGE TO COME TO A STOP VEHICLE STILL WAS MAKING SOUNDS AND LIGHTS WERE FLASHING I PUT IT IN PARK VEHICLE STALLED OUT I TRIED TO RESTART AND NOTHING WOULDN'T EVEN TURN OVER JUST CLICKED. HAD IT TOWED ONLY CAME BACK AS LOW VOLTAGE THEY REPLACED BATTERY TRIED TO RESTART ENGINE STILL MADE CLUNKING NOISE VAN STILL WOULDN'T START, OIL PAN WAS DROPPED AND HAD CHUNKS OF METAL IN IT. FINAL CONCLUSION ENGINE BLOWN I HAVE SEEN SOME RECALLS ON THIS ENGINE 3.6 VVT ALSO PREVIOUSLY HAD A PROBLEM WITH TIPM I ALSO SEE HAS AN ONGOING. POSSIBLE RECALL AND IS RECALLED IN OTHER VEHICLES THAT USE SAME PART. WOULD REALLY LOVE MY VAN FIXED AS THIS ENGINE IS KNOWN TO HAVE PROBLEMS
TL* THE CONTACT OWNED A 2011 DODGE GRAND CARAVAN. WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED A TOTAL LOSS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE…
Read full complaint
TL* THE CONTACT OWNED A 2011 DODGE GRAND CARAVAN. WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED A TOTAL LOSS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Official recalls
425V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:
Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
17V376000 · Air Bags:frontal
Jun 13, 2017
Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.
Consequence & remedy
Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.
Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.
14V234000 · Electrical System
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
11V315000 · Steering:column
Jun 8, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.
Consequence & remedy
Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.
Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
Illustration