← New search

2011 Dodge Grand Caravan

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2011 Dodge Grand Caravan do not stand out strongly from the model-year median of 284.

About this comparison →

When problems were reported

Mileage at the reported incident

383 reports with mileage · 147 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 332 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 92 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

9 crash reports17 fire reports15 injury reports

Engine complaints

92 reports
Clear category filter
Mileage unknown · Jun 26, 2021
Electrical SystemEngineFuel/propulsion System

purchased van no problem mechanic gave great review following week wouldnt start mechanic said tipm is bad we had tipm rep[laced already 3 times and now its bad again this time i was with my family when van completly shut off on highway doing 70 miles a hour we have to carry a jumper battery pack with us to start van i called cr…

Read full complaint

purchased van no problem mechanic gave great review following week wouldnt start mechanic said tipm is bad we had tipm rep[laced already 3 times and now its bad again this time i was with my family when van completly shut off on highway doing 70 miles a hour we have to carry a jumper battery pack with us to start van i called crysler and they informed me there is no problems with my vans tipm well thats funny google has over 45 thousand articles about these problems and nobody does anything about it till people die

NHTSA ODI #11422425

130,000 miles · Jun 24, 2021
EngineFire

The contact owned a 2011 Dodge Grand Caravan. The contact stated while driving at 65 mph, the vehicle stalled. The contact was able to pull off to the side of the road where she saw smoke emerging from the front of the vehicle. Upon exiting the vehicle, the contact opened the hood to see the fire behind the engine. The fire dep…

Read full complaint

The contact owned a 2011 Dodge Grand Caravan. The contact stated while driving at 65 mph, the vehicle stalled. The contact was able to pull off to the side of the road where she saw smoke emerging from the front of the vehicle. Upon exiting the vehicle, the contact opened the hood to see the fire behind the engine. The fire department was contacted and was able to extinguish the fire. A police report was filed. The vehicle was towed to an impound lot. The contact has not notified a local dealer. The vehicle has not been diagnosed or repaired. The vehicle was destroyed. The contact was relating the failure to an unknown recall. The manufacturer had not been informed of the failure. The failure mileage was 130,000.

NHTSA ODI #11422184

110,000 miles · May 1, 2021
Electrical SystemEngineVehicle Speed Control

I WAS DRIVING ON THE ROAD AT ABOUT 30 MPH GOING STRAIGHT (WITH MY WIFE/KIDS) AND THE CAR JUST TURNED OFF COMPLETELY. THERE WAS NO ELECTRICAL, NO PROPULSION, POWER STEERING WENT OUT. THE ELECTRICAL BLINKED ON AND OFF A COUPLE TIMES LIKE IT WAS TRYING TO COME BACK ON BUT I HAD TO PULL OVER (LUCKILY WE WERE ON A RURAL ROAD) AND T…

Read full complaint

I WAS DRIVING ON THE ROAD AT ABOUT 30 MPH GOING STRAIGHT (WITH MY WIFE/KIDS) AND THE CAR JUST TURNED OFF COMPLETELY. THERE WAS NO ELECTRICAL, NO PROPULSION, POWER STEERING WENT OUT. THE ELECTRICAL BLINKED ON AND OFF A COUPLE TIMES LIKE IT WAS TRYING TO COME BACK ON BUT I HAD TO PULL OVER (LUCKILY WE WERE ON A RURAL ROAD) AND TURN THE CAR OFF AND BACK ON.

NHTSA ODI #11414748

70,000 miles · Apr 25, 2021
EngineVehicle Speed Control

ENGINE LIGHT HAS BEEN ON FOR QUITE SOME TIME. DEALERS UNABLE TO LOCATE PROBLEM. THOUGHT IT WAS CAMSHAFT SENSOR, REPLACED AND SAME ISSUES. CHECK ENGINE LIGHT IS NOT ALWAYS ON, SEEMS TO COME ON AFTER EXTENDED DRIVING. ON HIGHWAY, WITH ENGINE LIGHT ON TRACTION LIGHT WILL COME ON AND THE I WILL NOT BE ABLE TO ACCELERATE PAST ABOUT 6…

Read full complaint

ENGINE LIGHT HAS BEEN ON FOR QUITE SOME TIME. DEALERS UNABLE TO LOCATE PROBLEM. THOUGHT IT WAS CAMSHAFT SENSOR, REPLACED AND SAME ISSUES. CHECK ENGINE LIGHT IS NOT ALWAYS ON, SEEMS TO COME ON AFTER EXTENDED DRIVING. ON HIGHWAY, WITH ENGINE LIGHT ON TRACTION LIGHT WILL COME ON AND THE I WILL NOT BE ABLE TO ACCELERATE PAST ABOUT 60 MPH EVEN WHEN PRESSING GAS TO FLOOR. ON HIGHWAY THIS IS VERY SCARY AND DANGEROUS. I SEE SIMILAR COMPLAINTS AND I AM FRUSTRATED THAT NO ONE CAN FIGURE OUT THE PROBLEM WITH MY VEHICLE. BEEN DEALING WITH THIS FOR ALMOST TWO YEARS.

NHTSA ODI #11413822

75,000 miles · Nov 27, 2020
Electrical SystemEngine

FUEL PUMP RELAY WENT BAD. ALSO FOUND BROKEN OIL FILTER VALVE, BROKEN FLEX PIPE TO EXHAUST AND LEAKY TRANSMISSION LINES.

NHTSA ODI #11376730

121,000 miles · Sep 11, 2020
EngineFuel/propulsion SystemPower Train

VAN WILL BOG DOWN AND THEN JUST SHUT OFF. WILL ALSO TAKE 5-6 TIMES BEFORE IT WILL RESTART. THE ELECTRICAL GOES HAYWIRE RANDOMLY. FOUND OUT THE TIPM IS BAD AND THERE WAS A RECALL ON OTHER VEHICLES DOING THE SAME EXACT THING DURING THE SAME YEARS.

NHTSA ODI #11354480

190,000 miles · Jul 12, 2020
Engine

WHILE ON THE HIGHWAY THE ENGINE BEGAN TO LOSE POWER/SPEED. THE DEALER STATED THAT THE ENGINE WAS LOSING COMPRESSION IN THE CYLINDER DUE TO A DEFECTIVE LIFTER THAT CAUSES DAMAGE TO THE CAM

NHTSA ODI #11338855

138,000 miles · Jun 29, 2020
Engine

THESE VEHICLES HAVE AN ONGOING ISSUE OF HAVING THE CYLINDER 4 MISFIRE. YOU CAN HAVE THE SPARK PLUG, SPARK PLUG WIRE, THE COIL PACK, CYLINDER HEAD VALVE, FUEL INJECTOR, VACUUM, SHAFTS AND EVERYTHING ELSE REPLACED AND THE CHECK ENGINE LIGHT WILL STILL COME ON SAYING THAT THIS CYLINDER IS MISFIRING. I HAVE HEARD AND READ MANY ARTIC…

Read full complaint

THESE VEHICLES HAVE AN ONGOING ISSUE OF HAVING THE CYLINDER 4 MISFIRE. YOU CAN HAVE THE SPARK PLUG, SPARK PLUG WIRE, THE COIL PACK, CYLINDER HEAD VALVE, FUEL INJECTOR, VACUUM, SHAFTS AND EVERYTHING ELSE REPLACED AND THE CHECK ENGINE LIGHT WILL STILL COME ON SAYING THAT THIS CYLINDER IS MISFIRING. I HAVE HEARD AND READ MANY ARTICLES THAT SAY THIS IS A COMMON ISSUE WITH THESE VEHICLES AND EVERYONE IS SURPRISED THAT THERE HAS NOT BEEN A RECALL TO REPAIR THIS ISSUE. AT THIS POINT, YOUR ONLY OPTION TO HAVE A RE-MANUFACTURED ENGINE INSTALLED WHICH CAN END UP COSTING MORE THAN YOU OWE ON THE CAR WHICH MANY PEOPLE CANNOT AFFORD. HOW CAN YOU ALLOW A VEHICLE TO HAVE THIS ISSUE AND NOT HAVE A SOLUTION TO FIX IT? THIS CODE APPEARED ON MARCH 2019 AFTER A WEEK OF PURCHASING THIS VEHICLE. I HAVE REPLACED EVERY PART THAT WOULD CAUSE THIS ERROR CODE AND THE ONLY OPTION IT TO REPLACE THE ENGINE. THIS IS JUST NOT FEASIBLE AS THIS IS A COMMON ISSUE WITH THIS CAR AND SHOULD BE REPLACED. *TR

NHTSA ODI #11331437

Mileage unknown · Feb 23, 2020
Electrical SystemEnginePower Train

I THINK THE 2011 DODGE GRAND CARAVAN MAINSTREET SHOULD BE RECALLED. THE CARS ELECTRICAL SYSTEM IS ALWAYS FALLING LIGHTS COME ON WHILE IM DRIVING AND WON'T TURN OFF FOR A HALF HOUR LAYER NO MATTER WHAT I DO. THE AIR BAG LIGHTS ARE ALWAYS COMING ON AND THE TRANSMISSION IS FAILING WHEN YOU SHIFT INTO GEAR THERE'S ALWAYS A BIG GUMPI…

Read full complaint

I THINK THE 2011 DODGE GRAND CARAVAN MAINSTREET SHOULD BE RECALLED. THE CARS ELECTRICAL SYSTEM IS ALWAYS FALLING LIGHTS COME ON WHILE IM DRIVING AND WON'T TURN OFF FOR A HALF HOUR LAYER NO MATTER WHAT I DO. THE AIR BAG LIGHTS ARE ALWAYS COMING ON AND THE TRANSMISSION IS FAILING WHEN YOU SHIFT INTO GEAR THERE'S ALWAYS A BIG GUMPING SOUND AND THE SHIFT GETS STUCK IN PARKED GEAR FOR MINUTES BEFORE IT WANTS TO SHIFT INTO GEAR. I'VE READ A LOT OF THE SAME PROBLEMS WITH THIS MAKE AND MODEL CAR THEY SHOULD BE RECALLED ITS DANGEROUS

NHTSA ODI #11310815

100,000 miles · Jan 29, 2020
Engine

FOUND A PUDDLE OF OIL IN MY DRIVEWAY, TOOK TO MECHANIC, INFORMED ME THE ENGINE OIL FILTER HOUSING WAS BROKEN, AND HE HAD 10 OF THESE RECENTLY. ALSO TOLD ME WHEN HE CONTACTED DEALER FOR PARTS, THEY SAID THIS IS A COMMON OCCURRENCE, THATS WHY THEY KEEP A LOT IN STOCK.

NHTSA ODI #11302748

Official recalls

4

25V876000 · Equipment Adaptive/mobility:wheelchair Restraints/securement:latch/anchor:

Dec 17, 2025

Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.

Consequence & remedy

Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.

Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.

17V376000 · Air Bags:frontal

Jun 13, 2017

Chrysler (FCA US LLC) is recalling certain 2011-2012 Dodge Grand Caravan vehicles. In the affected vehicles, the driver's frontal air bag may unexpectedly deploy if the air bag wiring harness gets chafed within the steering wheel and short circuits.

Consequence & remedy

Consequence: Unexpected deployment of the driver's frontal air bag increases the risk of a crash or driver injury.

Remedy: Chrysler will notify owners, and dealers will inspect the air bag wiring within the steering wheel, replacing it if necessary. A protective cover will also be installed. These repairs will be made free of charge. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T33.

14V234000 · Electrical System

May 7, 2014

Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.

Consequence & remedy

Consequence: An overheated switch may result in a vehicle fire.

Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.

11V315000 · Steering:column

Jun 8, 2011

CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011DODGE JOURNEY, JEEP WRANGLER, CHRYSLER 200, CHRYSLER 200 CONVERTIBLE, DODGE AVENGER, DODGE NITRO, JEEP LIBERTY, DODGE CALIBER, JEEP COMPASS, JEEP PATRIOT, DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES. SOME OF THESE VEHICLES MAY HAVE BEEN BUILT WITH A MISSING OR INCORRECTLY INSTALLED STEERING COLUMN PIVOT RIVET.

Consequence & remedy

Consequence: A MISSING OR INCORRECTLY INSTALLED RIVET COULD COMPROMISE THE ABILITY OF THE STEERING COLUMN TO SUPPORT THE OCCUPANT LOADS IN THE EVENT OF A FRONTAL CRASH, DECREASING THE EFFECTIVENESS OF THE FRONTAL IMPACT SAFETY SYSTEM. AS A RESULT, THE CONDITION MAY INCREASE THE POTENTIAL FOR INJURY IN A FRONTAL CRASH.

Remedy: DEALERS WILL INSPECT FOR RIVET PRESENCE AND ALIGNMENT AND REPAIR THE STEERING COLUMN PIVOT AS REQUIRED, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

PE19014 · Active Head Rest Inadvertent Deployment

Opened Sep 9, 2019 · Closed Feb 25, 2026

Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Seats

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Seats:front Assembly:head Restraint

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

DP14004 · Totally Integrated Power Module Failure

Opened Sep 25, 2014 · Closed Jul 24, 2015

Status: closed (inferred from source dates) · Electrical System

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den