NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
868 reports20,000 miles · Aug 31, 2012
Service Brakes
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE BRAKES WERE DEPRESSED AND THE VEHICLE VIBRATED ABNORMALLY. IN ADDITION, THE VEHICLE FAILED TO STOP PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THAT THE BRAKE PADS AND ROTORS NEEDED TO BE REPLACED. THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH, THE BRAKES WERE DEPRESSED AND THE VEHICLE VIBRATED ABNORMALLY. IN ADDITION, THE VEHICLE FAILED TO STOP PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THAT THE BRAKE PADS AND ROTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 45,000.
NHTSA ODI #10473185
69,000 miles · Aug 7, 2012
Electrical System
AFTER APPROXIMATELY 30 MINUTES OF OPERATION AT 50MPH MY ENTIRE DASH LIGHT WARNING SYSTEM LIGHT UP & THEN WENT DARK. THE VEHICLE ENGINE DIED. AS I WAS SLOWLY COASTING TO A STOP, THE LIGHTS & VEHICLE SPONTANEOUSLY CAME BACK ON & RESUMED NORMAL OPERATION. A CHECK OF THE DIAGNOSTIC CODES RECORDED NO INCIDENT & I CANNOT RECREATE T…
Read full complaint
AFTER APPROXIMATELY 30 MINUTES OF OPERATION AT 50MPH MY ENTIRE DASH LIGHT WARNING SYSTEM LIGHT UP & THEN WENT DARK. THE VEHICLE ENGINE DIED. AS I WAS SLOWLY COASTING TO A STOP, THE LIGHTS & VEHICLE SPONTANEOUSLY CAME BACK ON & RESUMED NORMAL OPERATION. A CHECK OF THE DIAGNOSTIC CODES RECORDED NO INCIDENT & I CANNOT RECREATE THE FAILURE. ABOUT 2 WEEKS AFTER THAT INCIDENT, I STARTED MY ENGINE, BEGAN TO REVERSE OUT OF A PARKING SPOT, WHEN THE A/C UNIT STOPPED BLOWING & LIGHTS WENT OUT, CLOCK & DASH WENT DARK. I PULLED BACK INTO THE SPOT, PARKED, TURNED OFF THE IGNITION & RESTARTED THE VEHICLE, AND THE A/C, RADIO, PANEL HAS WORKED FINE EVER SINCE. STILL NO CODES REPORTED DURING A DIAGNOSTIC. SOMEONE IS GOING TO GET KILLED DRIVING THE 2010 DODGE GRAND CARAVAN! ALL THE WHILE, THE MANUFACTURE DENIES THAT THERE IS A PROBLEM WITH THEIR VEHICLES. I PURCHASED THIS VEHICLE NEW, THIS ISN'T THE FIRST TIME I'VE HAD PROBLEMS WITH THIS VEHICLE. I AM FASTIDIOUS ABOUT SERVICE & MAINTENANCE OF MY VEHICLE, AND HAVE THE RECEIPTS TO PROVE IT. *TR
NHTSA ODI #10469584
20,000 miles · Jul 18, 2012
Electrical SystemEngine
OUR 2010 DODGE GRAND CARAVAN MINIVAN, HAS BEEN FOR THE PAST 6 MONTHS BEEN STALLING SPORADICALLY. TODAY, IT CAME TO A HEAD. WE WERE 45 MINUTES NORTH OF OUR HOUSE AND HEADING HOME. 10 MINUTES OF DRIVING TO GET TO THE FREEWAY AND 20 MINUTES ON THE FREEWAY, IN THE CENTER LANE, 3 LANES WIDE, POURING OUTSIDE, IT IS 8:50PM, AND LIG…
Read full complaint
OUR 2010 DODGE GRAND CARAVAN MINIVAN, HAS BEEN FOR THE PAST 6 MONTHS BEEN STALLING SPORADICALLY. TODAY, IT CAME TO A HEAD. WE WERE 45 MINUTES NORTH OF OUR HOUSE AND HEADING HOME. 10 MINUTES OF DRIVING TO GET TO THE FREEWAY AND 20 MINUTES ON THE FREEWAY, IN THE CENTER LANE, 3 LANES WIDE, POURING OUTSIDE, IT IS 8:50PM, AND LIGHTENING OUT AS WELL. OUR MINIVAN JUST DIED ON THE FREEWAY, WITH A FAIR AMOUNT OF TRAFFIC. WE WERE ABLE TO PULL OVER QUICKLY AS THE MINIVAN SHOOK TO A HALT, WE WERE GOING 70 MILES PER HOUR. YESTERDAY, WHEN I TRIED STARTING IT DIED RIGHT AWAY, TWICE. THE DEALERSHIP KNOWS ABOUT THIS AS THEY SEE THE MINIVAN FOR THIS ABOUT EVERY MONTH, AND THEY ALWAYS SAY NOTHING COMES UP ON THE COMPUTER, NOTHING IS WRONG WITH IT. I HAVE COMPLAINED TO CHRYSLER ABOUT THIS. THEY SAY IT IS BECAUSE IT HAPPENS RIGHT AFTER WE HAVE FILLED UP WITH GAS. WELL, WE DIDN'T JUST FILL UP WITH GAS TODAY, AND HAVE ONLY A HALF TANK OF GAS, WHEN THIS HAPPENED. OUT OF THE COUNTLESS TIMES THIS HAS DIED ON US, IT HAS ONLY DIED 2 TIMES AFTER FILLING UP. THERE IS NO RHYME OR REASON WHEN THIS HAPPENS, CAN BE MORNING OR AFTERNOON, WE RARELY DRIVE IN THE EVENING. COLD OR HOT DAYS. CHRYSLER HAS SAID THAT THIS ISSUE IS RELATED TO THE NEW KEY, AND RECALLED IT, WELL WE HAVE HAD THAT CHANGED AT LEAST 3 TIMES ALREADY. *TR
NHTSA ODI #10466535
32,000 miles · Jul 15, 2012
Electrical System
WE HAD OUR IGNITION REPAIRED 2 TIMES ALREADY. ONCE BECAUSE THE IGNITION SHUT OFF THE ENGINE AT 60 MILES PER HOUR. THEN AGAIN FOR THE RECALL FOR THE IGNITION MODULAR THAT WAS WHY THE ENGINE WAS GETTING SHUT OFF BY THE IGNITION AND NOW THE KEY WILL NOT COME OUT OF THE IGNITION. WE TOOK THE VAN TO THE DEALERSHIP AND EXPLAINED THAT …
Read full complaint
WE HAD OUR IGNITION REPAIRED 2 TIMES ALREADY. ONCE BECAUSE THE IGNITION SHUT OFF THE ENGINE AT 60 MILES PER HOUR. THEN AGAIN FOR THE RECALL FOR THE IGNITION MODULAR THAT WAS WHY THE ENGINE WAS GETTING SHUT OFF BY THE IGNITION AND NOW THE KEY WILL NOT COME OUT OF THE IGNITION. WE TOOK THE VAN TO THE DEALERSHIP AND EXPLAINED THAT THE KEY WILL NOT COME OUT UNLESS WE PLAY WITH TURNING ON AND OFF THE VAN, PUTTING IT IN REVERSE THEN FORWARD, OUT OF PARK INTO DRIVE AND WASTING A LOT OF TIME AND GAS JUST TO GET IT TO COME OUT. THE SERVICE TECH SAID FIRST THE KEY WAS INTO TOO LOOSE BEFORE THE RECALL AND NOW IT IS IN TOO TIGHT AFTER THE RECALL PART WAS PUT IN. SO AFTER DRIVING 100 MILES FOR SERVICE WE ARE TOLD MAKE SURE TO PUT THE VAN IN PARK AND THE KEY SHOULD COME OUT. WELL IT DOES NOT. NOTHING SHOWS UP ON THEIR COMPUTERS SO THEY WILL NOT FIX THE PROBLEM. THE KEY WILL NOT TURN OFF THE ENGINE SO IF THE KEY IS LEFT IN THE BATTERY COULD GO DEAD. I HAVE TO GO THROUGH OFF AND ON, DRIVE, REVERSE TO GET THE KEY OUT. I AM AFRAID THAT THE IGNITION PROBLEM COULD TURN THE ENGINE OFF AGAIN AT 60 MILES AN HOUR. NO ONE IS HELPING US BECAUSE, IN MY OPINION, THIS IS THE THIRD REPAIR ON THE IGNITION, MAKING THE VAN A LEMON. SO THIS IS WHY WE GOT NO RECEIPT OF SERVICE FOR THE TECH TELLING US TO PUT THE VAN IN PARK. MY HUSBAND WAS A STATE TROOPER AND TAUGHT DEFENSIVE DRIVING CLASSES AT THE POLICE ACADEMY. I HAVE BEEN DRIVING FOR 45 YEARS. SO WE BOTH KNOW HOW TO PUT THE VAN IN PARK AND HOW TO REMOVE A KEY FROM AN IGNITION. CHRYSLER HAS NOT RESPONDED TO OUR COMPLAINT. *TR
NHTSA ODI #10465717
43,026 miles · Jul 6, 2012
TiresWheels
TWICE IN THE PAST TWO MONTHS THE ALUMINUM VALVE STEMS THAT HOLD THE TPMS SENSORS ON OUR GRAND CARAVAN HAVE BROKEN OFF. 1ST INCIDENT IN APRIL WHILE VEHICLE WAS PARKED IN DRIVEWAY AND SECOND WHILE MY WIFE AND CHILDREN, AGE 5 AND 4 YEARS, WERE TRAVELING AT HIGHWAY SPEEDS. THE SECOND INCIDENT STRANDED MY WIFE AND CHILDREN IN 100+ …
Read full complaint
TWICE IN THE PAST TWO MONTHS THE ALUMINUM VALVE STEMS THAT HOLD THE TPMS SENSORS ON OUR GRAND CARAVAN HAVE BROKEN OFF. 1ST INCIDENT IN APRIL WHILE VEHICLE WAS PARKED IN DRIVEWAY AND SECOND WHILE MY WIFE AND CHILDREN, AGE 5 AND 4 YEARS, WERE TRAVELING AT HIGHWAY SPEEDS. THE SECOND INCIDENT STRANDED MY WIFE AND CHILDREN IN 100+ DEGREE F HEAT FOR CLOSE TO AN HOUR WHILE THEY HAD TO WAIT FOR AAA TO ARRIVE AND CHANGE THE SPARE FOR THEM. THANKFULLY IT WAS A REAR TIRE THAT BLEW OUT AND NOT A FRONT. COULD HAVE ENDED MUCH WORSE. UPON INSPECTION NOTICED THAT TIRE SIDEWALL HAD EXCESSIVE WEAR FROM LOOSING AIR AT HIGHWAY SPEEDS AND BEING DRIVEN TO SAFE STOPPING POSITION. DECIDED TO GO AHEAD AND PURCHASE FOUR NEW TIRES BECAUSE WIFE AND CHILDREN WILL BE TAKING AN EXTENDED DRIVING TRIP SOON. NOTICED THAT THE 2011 AND 2012 MODELS NOW HAVE THE MUCH MORE RELIABLE RUBBER VALVE STEMS AND SENSORS INSTEAD OF THE FAILING ALUMINUM STEMS. A LITTLE RESEARCH SHOWS THAT THEY WILL INTERCHANGE DIRECTLY. ASKED DEALER IF THEY WOULD REPLACE ALL FOUR WITH MORE RELIABLE STEM AT TIME OF TIRE CHANGE. SAID YES, BUT ONLY IF I PAY FOR THEM. AMOUNT? CLOSE TO $400.00 WHY SHOULD THE CUSTOMER PAY FOR A PART THAT IS POORLY DESIGNED AND KNOWN FOR FAILURE. A LITTLE RESEARCH OF THE NHTSA WEBSITE FOR MULTIPLE MODEL YEARS OF DODGE AND CHRYSLER VEHICLE SHOWS THAT THIS HAS BEEN AN ISSUE FOR A NUMBER OF YEARS NOW AND HAS AMASSED A LARGE NUMBER OF COMPLAINTS. ARE WE JUST WAITING UNTIL SOME PERSON GETS SERIOUSLY INJURED OR KILLED BEFORE THIS GETS ADDRESSED? LUCKILY MY WIFE AND CHILDREN WERE NOT INJURED, I JUST HOPE EVERYONE ELSE IS JUST AS LUCKY. *TR
NHTSA ODI #10464394
29,000 miles · Jun 30, 2012
Service Brakes
I WAS DRIVING AND THE REAR BRAKES SEIZED. I PULLED INTO MY DRIVEWAY AND THEY WERE BURNING. I HAD COMPLAINED TO THE DEALER 2 MONTHS PRIOR THAT I THOUGHT SOMETHING WAS WRONG WITH THE BRAKES. I HAD A LOT OF PULSING IN THE STEERING WHEEL AND DIDN'T FEEL LIKE I COULD STOP QUICK ENOUGH. THEY SAID EVERYTHING WAS OKAY. AFTER THE BR…
Read full complaint
I WAS DRIVING AND THE REAR BRAKES SEIZED. I PULLED INTO MY DRIVEWAY AND THEY WERE BURNING. I HAD COMPLAINED TO THE DEALER 2 MONTHS PRIOR THAT I THOUGHT SOMETHING WAS WRONG WITH THE BRAKES. I HAD A LOT OF PULSING IN THE STEERING WHEEL AND DIDN'T FEEL LIKE I COULD STOP QUICK ENOUGH. THEY SAID EVERYTHING WAS OKAY. AFTER THE BRAKES SEIZED ON 6/28/12, I TOOK IT TO THE DEALER AND THEY SAID THE REAR BRAKES WERE ALL CORRODED. THE ROTORS, BRAKE PADS AND CLIPS HAD TO BE ALL REPLACED. MONTHS AGO, DODGE HAD PUT AN ADDITIONAL WARRANTY ON THE FRONT BRAKES FOR THIS VERY REASON (PRE-MATURE CORROSION) INSTEAD OF DOING A RECALL. BUT THE BACK BRAKES WERE NOT COVERED. I SEARCHED THE INTERNET AND OTHER PEOPLE HAVE HAD THE SAME EXPERIENCE WITH CORRODED REAR BRAKES SEIZING AT LOW MILEAGE. PLEASE LOOK IT IN THIS. I DIDN'T EXPECT SOMETHING LIKE TO HAPPEN ON A VEHICLE WITH RELATIVELY LOW MILEAGE. *TR
NHTSA ODI #10463651
33,447 miles · Jun 18, 2012
Service Brakes
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKE DISTANCE HAD INCREASED AND THE TIRES WERE NOT STABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE PAD AND ROTORS WERE WORN PREMATURELY. THE VEHICLE WAS NOT REPAIRED BECAUSE THE PARTS NEEDED FOR REPAIR WERE NOT AV…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKE DISTANCE HAD INCREASED AND THE TIRES WERE NOT STABLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE PAD AND ROTORS WERE WORN PREMATURELY. THE VEHICLE WAS NOT REPAIRED BECAUSE THE PARTS NEEDED FOR REPAIR WERE NOT AVAILABLE AND THE DEALER DID NOT HAVE AN ESTIMATED DATE OF WHEN THE PART WOULD BECOME AVAILABLE FOR THE REPAIR. THE FAILURE AND THE CURRENT MILEAGE WAS 33,447.
NHTSA ODI #10462127
35,000 miles · Jun 18, 2012
Electrical System
THE WINDSHIELD WIPERS CAME ON BUT WOULD NOT TURN OFF. THE WINDOWS WOULD NOT WORK, THE CONTROL PANEL WOULD NOT REGISTER. ALL WARNING LIGHTS LIT UP. THE POSSIBLE COMPLICATIONS ARE MULTIPLE. THE VEHICLE IS CONSIDERED UNSAFE TO OPERATE BY THE OWNERS. *TR
NHTSA ODI #10462065
23,900 miles · Jun 7, 2012
Electrical SystemExterior LightingService Brakes
REAR PASSENGER WHEEL GETS EXTREMELY HOT WHILE DRIVING. IT APPEARS THAT THE CALIPER MAY BE LOCKING UP. THE REAR WHEEL ON THE DRIVER SIDE ALSO MAKES A HIGH PITCHED WHINE, WHICH IS INTERMITTENT AND USUALLY GOES AWAY BY TAPPING THE BRAKE PEDAL. WE TOOK IT TO THE DEALER AND THEY SAID WE NEEDED A REAR BRAKE JOB. HOWEVER, I BELIEVE…
Read full complaint
REAR PASSENGER WHEEL GETS EXTREMELY HOT WHILE DRIVING. IT APPEARS THAT THE CALIPER MAY BE LOCKING UP. THE REAR WHEEL ON THE DRIVER SIDE ALSO MAKES A HIGH PITCHED WHINE, WHICH IS INTERMITTENT AND USUALLY GOES AWAY BY TAPPING THE BRAKE PEDAL. WE TOOK IT TO THE DEALER AND THEY SAID WE NEEDED A REAR BRAKE JOB. HOWEVER, I BELIEVE THIS IS DUE TO DEFECTIVE CALIPERS WHICH ARE NOT RELEASING THE PADS FROM THE ROTORS. THE REAR BRAKES ON EVERY CAR I HAVE OWNED ALWAYS LAST SIGNIFICANTLY LONGER THAN THE FRONT. THE FACT THAT THE REAR PADS ARE WORN EXCESSIVELY WHILE FRONT ARE NOT INDICATES A DEFECT IN THE REAR BRAKE ASSEMBLY. THE IGNITION WAS REPAIRED AS PART OF A RECALL. HOWEVER, AFTER STARTING THE CAR, THE KEY DOES NOT RETURN TO THE "ON" POSITION. THIS ALLOWS THE CAR TO RUN AND BE DRIVEN, HOWEVER NONE OF MY LIGHTS OR DIRECTIONALS WORK. I CAN WIGGLE THE KEY TO GET IT INTO THE CORRECT POSITION, BUT SOMETIMES IT IS NOT OBVIOUS THAT THE KEY IS IN THE WRONG POSITION. THIS RESULTS IN ME DRIVING WITHOUT HEADLIGHTS IN THE RAIN AND THINKING THAT I AM SIGNALING PROPERLY IN TURNS WHEN IN FACT EVERYTHING IS OFF. *JS
NHTSA ODI #10460884
27,000 miles · May 25, 2012
Seats
VEHICLE HAS AN ELDORADO AMERIVAN 14" LOWERED FLOOR CONVERSION. THE FRONT DRIVER AND PASSENGER SEATS INCLUDING LOWERED FLOOR SEAT BASES WOULD NOT STAY LOCKED TO THE FLOOR SECUREMENT SYSTEM. SLIGHT PRESSURE APPLIED TO BOTH WOULD CAUSE THEM TO BECOME UNLOCKED FROM THE VEHICLE FLOOR. FAMILY DROVE AROUND WITH THIS DEFICIENCY IN TH…
Read full complaint
VEHICLE HAS AN ELDORADO AMERIVAN 14" LOWERED FLOOR CONVERSION. THE FRONT DRIVER AND PASSENGER SEATS INCLUDING LOWERED FLOOR SEAT BASES WOULD NOT STAY LOCKED TO THE FLOOR SECUREMENT SYSTEM. SLIGHT PRESSURE APPLIED TO BOTH WOULD CAUSE THEM TO BECOME UNLOCKED FROM THE VEHICLE FLOOR. FAMILY DROVE AROUND WITH THIS DEFICIENCY IN THE DRIVER SEAT FOR APPROXIMATELY ONE MONTH BEFORE NOTICING. FRONT PASSENGER SEAT HAD BEEN REMOVED TO ALLOW FOR AN OCCUPIED WHEELCHAIR POSITION. *TR
NHTSA ODI #10459668
Official recalls
6Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Mar 1, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE JOURNEY, GRAND CARAVAN, AND CHRYSLER TOWN & COUNTRY VEHICLES MANUFACTURER FROM AUGUST 3, 2009, THROUGH JUNE 17, 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: ENGINE SHUT OFF WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration