NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
868 reports75,000 miles · Jan 10, 2017
Vehicle Speed Control
ON JANUARY 7, 2017, I TRIED TO START MY 2010 CARAVAN. IT WOULDN'T START. THE LIGHT WAS ON FOR THE ELECTRONIC THROTTLE CONTROL, AS WAS THE CHECK ENGINE LIGHT. THIS IS THE THIRD TIME THAT THIS HAS HAPPENED SINCE MID-DECEMBER. THE OTHER TWO TIMES AFTER WAITING FOR UP TO A WEEK, IT HAS STARTED. AFTER CHECKING AROUND, I HAVE FOU…
Read full complaint
ON JANUARY 7, 2017, I TRIED TO START MY 2010 CARAVAN. IT WOULDN'T START. THE LIGHT WAS ON FOR THE ELECTRONIC THROTTLE CONTROL, AS WAS THE CHECK ENGINE LIGHT. THIS IS THE THIRD TIME THAT THIS HAS HAPPENED SINCE MID-DECEMBER. THE OTHER TWO TIMES AFTER WAITING FOR UP TO A WEEK, IT HAS STARTED. AFTER CHECKING AROUND, I HAVE FOUND THAT THIS IS HAPPENING QUITE A BIT TO OTHERS AS WELL. APPARENTLY, DEALERSHIPS HAVE NO CLUE EITHER, AS TO WHAT IS CAUSING THIS ISSUE. IT COULD BE THE THROTTLE CONTROL, IT COULD BE THE MAIN ELECTRICAL MODULE, NO ONE SEEMS TO KNOW FOR SURE. I'M PRETTY MUCH STUCK, AS I DON'T WANT TO BE OUT ON THE ROAD AND HAVE MY VAN STOP, CAUSING AN ACCIDENT.
NHTSA ODI #10944020
Mileage unknown · Jan 6, 2017
Electrical System
AFTER NOTICING THE IGNITION SWITCH WAS NOT ALWAYS WORKING, I CONTACTED THE DEALER AND LEARNED THERE WAS A RECALL ON THE IGNITION SWITCH. AFTER GIVING THEM MY VIN # THEY SAID THEY WILL NOT REPLACE THE IGNITION SWITCH UNDER THE RECALL. IF I WANT TO REPLACE THE SWITCH IT WILL BE AT MY OWN EXPENSE. I FILL IF THERE IS A SAFETY RECALL…
Read full complaint
AFTER NOTICING THE IGNITION SWITCH WAS NOT ALWAYS WORKING, I CONTACTED THE DEALER AND LEARNED THERE WAS A RECALL ON THE IGNITION SWITCH. AFTER GIVING THEM MY VIN # THEY SAID THEY WILL NOT REPLACE THE IGNITION SWITCH UNDER THE RECALL. IF I WANT TO REPLACE THE SWITCH IT WILL BE AT MY OWN EXPENSE. I FILL IF THERE IS A SAFETY RECALL FOR MY VEHICLE IT SHOULD BE AT THERE EXPENSE!! PLEASE ADVISE. *TR
NHTSA ODI #10940160
70,000 miles · Jan 6, 2017
Electrical SystemElectronic Stability Control (esc)Unknown Or Other
MY VAN JUST SHUT OFF WHILE DOING 55 MPH ON A HIGHWAY. NO WARNING SIGNS OR CHECK ENGINE LIGHTS CAME ON. I HAD NO STEERING, GAS, OR BREAKS WHEN IT SHUT OFF. THE A FEW DAYS LATER ALL THE LIGHTS ON THE DASH CAME ON THEN WENT OFF BUT NEVER SHUT OFF UNTIL A FEW BLOCKS LATER WHEN IT TURNED OFF WHILE DRIVING ON A STREET. AND EVERYTIME I…
Read full complaint
MY VAN JUST SHUT OFF WHILE DOING 55 MPH ON A HIGHWAY. NO WARNING SIGNS OR CHECK ENGINE LIGHTS CAME ON. I HAD NO STEERING, GAS, OR BREAKS WHEN IT SHUT OFF. THE A FEW DAYS LATER ALL THE LIGHTS ON THE DASH CAME ON THEN WENT OFF BUT NEVER SHUT OFF UNTIL A FEW BLOCKS LATER WHEN IT TURNED OFF WHILE DRIVING ON A STREET. AND EVERYTIME IT SHUTS OFF I PUT IT IN PARK TAKE THE KEYS OUT AND THEN RESTART THE VAN AND IT ACTS LIKE NOTHING EVER HAPPENED. *TR
NHTSA ODI #10940086
58,500 miles · Dec 29, 2016
Electrical SystemEngine
WHILE DRIVING THE CAR, THE ENGINE SHUTS OFF UNEXPECTEDLY AND WE LOSE POWER STEERING AND BRAKES. WE HAVE TO COAST TO A STOP, PUT IT BACK IN PARK AND RESTART ENGINE AND PROCEED. THIS HAPPENS WITH NO PREDICTABILITY WHICH MAKES THIS DANGEROUS. THE TIMES THAT IT HAS HAPPENED, THE ROADS HAVE BEEN WET OR SNOW COVERED. IT HAS ALSO HAPPE…
Read full complaint
WHILE DRIVING THE CAR, THE ENGINE SHUTS OFF UNEXPECTEDLY AND WE LOSE POWER STEERING AND BRAKES. WE HAVE TO COAST TO A STOP, PUT IT BACK IN PARK AND RESTART ENGINE AND PROCEED. THIS HAPPENS WITH NO PREDICTABILITY WHICH MAKES THIS DANGEROUS. THE TIMES THAT IT HAS HAPPENED, THE ROADS HAVE BEEN WET OR SNOW COVERED. IT HAS ALSO HAPPENED ON DRY ROADS. TRAVELING AT A HIGH RATE OF SPEED MAKES THIS A DANGEROUS CIRCUMSTANCE. SINCE IT IS UNPREDICTABLE, WE ARE VERY NERVOUS TO TAKE THIS CAR ON A HIGHWAY. WE HAVE HAD THE CAR IN TO SHAPIRO LEON MOTOR SALES SEVERAL TIMES AND THEY CANNOT FIND ANYTHING THAT COMES UP ON THEIR DIAGNOSTICS.THEY DID REPLACE THE POWERTRAIN CONTROL MODULE. THIS DID NOT MAKE A DIFFERENCE. IT CONTINUED TO SHUT DOWN. THERE IS NO RHYME OR REASON. THEY HAVE DRIVEN IT BUT IT DID NOT SHUT DOWN FOR THEM. I GOT IT INANE SHORTLY AFTER LEAVING , IT SHUT DOWN. WE KNOW THAT THERE WAS A RECALL ON THE IGNITION SWITCH THROUGH JUNE 2010 BUT OUR CAR WAS MANUFACTURED SEPT 2010. HOWEVER ALL THE SYMPTOMS THAT ARE LISTED ON THAT RECALL FIT OUR VAN'S PROBLEM PERFECTLY. THE DEALERSHIP DOES NOT AGREE A PER THEIR TESTING. THIS IS NOT SOMETHING THAT WE CAN HAVE HAPPEN TO US WHILE TRAVELING 65 DOWN THE INTERSTATE. THE ONLY THING THAT SHOWS UP ON THE DASH IS THE TRACTION CONTROL WHEN WE LOSE ENGINE POWER. PLEASE ADDRESS THIS PROBLEM. *TR
NHTSA ODI #10938658
71,000 miles · Dec 27, 2016
Electrical SystemExterior LightingUnknown Or Other
I HAVE HAD MY 2010 DODGE GRAND CARAVAN FOR 1 YEAR. FIRST THE ALTERNATOR WENT OUT THEN THE KEY MODULE THEN THE TRANSMISSION THEN THE SHIFTING HARNESSES CABLE AND NOW THE LIGHTS KEEP BLINKING ON AND OFF AND THE VAN FEELS LIKE IT HAS NO POWER THE BATTERY WAS JUST CHANGED A MONTH AGO. THIS HAS BEEN THE WORST VEHICLE EVER AND WE ARE …
Read full complaint
I HAVE HAD MY 2010 DODGE GRAND CARAVAN FOR 1 YEAR. FIRST THE ALTERNATOR WENT OUT THEN THE KEY MODULE THEN THE TRANSMISSION THEN THE SHIFTING HARNESSES CABLE AND NOW THE LIGHTS KEEP BLINKING ON AND OFF AND THE VAN FEELS LIKE IT HAS NO POWER THE BATTERY WAS JUST CHANGED A MONTH AGO. THIS HAS BEEN THE WORST VEHICLE EVER AND WE ARE SCARED THAT IT IS GOING TO CAUSE A DEADLY ACCIDENT. THE VEHICLE GETS STUCK IN GEARS. AND AND NOW KEEPS SHUTTING OFF AND THE HEADLIGHTS KEEP BLINKING ON AND OFF AS WELL AS ALL THE LIGHTS IN THE VAN. IF THESE ARE KNOW ISSUES WHY HAS THERE NOT BEEN A TOTAL RECALL ON ALL THESE VEHICLES BEFORE A DEADLY ACCIDENT DOES HAPPEN. OR IS IT GOING TO TAKE SOMEONE TO ACTUALLY DIE BEFORE SOMETHING IS DONE ABOUT ALL THE KNOWN ISSUES THE MAKERS OF THESE VEHICLES ARE AWARE OF.
NHTSA ODI #10937771
116,000 miles · Dec 24, 2016
Electrical System
THE VAN WILL INTERMITTENTLY FAIL TO START, OR IT SPUTTERS WHEN IT STARTS. BYPASSING THE FUEL PUMP RELAY ON THE TIPM MODULE WILL FIX THE PROBLEM, HOWEVER IT IS NOT A SAFE PERMANENT SOLUTION. OTHER MAKES AND MODELS HAVE BEEN RECALLED FOR THE SAME ISSUE, HOWEVER THE 2010 DODGE CARAVAN WAS NOT INCLUDED IN THE RECALL EVEN THOUGH THE …
Read full complaint
THE VAN WILL INTERMITTENTLY FAIL TO START, OR IT SPUTTERS WHEN IT STARTS. BYPASSING THE FUEL PUMP RELAY ON THE TIPM MODULE WILL FIX THE PROBLEM, HOWEVER IT IS NOT A SAFE PERMANENT SOLUTION. OTHER MAKES AND MODELS HAVE BEEN RECALLED FOR THE SAME ISSUE, HOWEVER THE 2010 DODGE CARAVAN WAS NOT INCLUDED IN THE RECALL EVEN THOUGH THE SAME DEFECT AND PROBLEM IS EVIDENT. THIS IS A BAD DESIGN AND DODGE SHOULD STICK BY THEIR MISTAKES AND PROVIDE A FIX.
NHTSA ODI #10937337
125,000 miles · Nov 27, 2016
Electrical SystemUnknown Or Other
OUR 2010 DODGE GRAND CARAVAN STALLED 14 TIMES THIS HOLIDAY WEEKEND (MORE THAN USUAL). IT STALLS AT ANY SPEED AND AT ANY TIME (WARM OR COLD) AND LOSES ALL POWER. HAVE YOU EVER HAD TO SHIFT A VEHICLE INTO NEUTRAL AT 70 MPH AND RESTART IT ON AN EXPRESSWAY IN HOLIDAY TRAFFIC (WITH NO POWER STEERING OR POWER BRAKES)? WELL IT REALL…
Read full complaint
OUR 2010 DODGE GRAND CARAVAN STALLED 14 TIMES THIS HOLIDAY WEEKEND (MORE THAN USUAL). IT STALLS AT ANY SPEED AND AT ANY TIME (WARM OR COLD) AND LOSES ALL POWER. HAVE YOU EVER HAD TO SHIFT A VEHICLE INTO NEUTRAL AT 70 MPH AND RESTART IT ON AN EXPRESSWAY IN HOLIDAY TRAFFIC (WITH NO POWER STEERING OR POWER BRAKES)? WELL IT REALLY PUTS THE FAMILY IN A JOLLY MOOD. DEALER CLAIMS NOT TO BE ABLE TO FIGURE IT OUT (BECAUSE THE ERROR CODES ARE NOT RECORDED IN THE VEHICLE COMPUTER SINCE THERE IS NO POWER). BASED ON ALL OF THE EXACT SAME COMPLAINTS I SEE FOR THIS VEHICLE, IT'S OBVIOUS TO ME THAT IT'S A TOTALLY INTEGRATED POWER MODULE (TIPM) ISSUE. ANY IDIOT PERFORMING A LITTLE RESEARCH ON GOOGLE CAN FIGURE IT OUT. HOWEVER, NHTSA CAN'T SEEM TO FIGURE IT OUT. SEE NHTSA ACTION NUMBER: DP14004. NHTSA ' THERE'S ENOUGH COMPLAINTS OUT THERE TO SUPPORT FURTHER INVESTIGATION. FEEL FREE TO CONTACT ME IF YOU WANT TO TAKE OUR ROLLING DEATH TRAP FOR A FUN-FILLED FAMILY TRIP.
NHTSA ODI #10928147
60,500 miles · Nov 18, 2016
Electrical System
VAN INTERMITTENTLY STOP SHIFTING WHILE DRIVING (CITY OR HIGHWAY) AND I HAVE TO PULL OVER AND RESTART TO DRIVE AGAIN. AIR CONDITIONING BLOWER ALSO GOES OUT INTERMITTENTLY. LOTS OF ERROR CODES REPORTED VIA OBD2 AND ALL ARE ELECTRICAL RELATED. TOOK IT TO MULTIPLE AUTO PART STORES AND LOCAL DODGE DEALERSHIP, ALL SAID IT WAS A FAUL…
Read full complaint
VAN INTERMITTENTLY STOP SHIFTING WHILE DRIVING (CITY OR HIGHWAY) AND I HAVE TO PULL OVER AND RESTART TO DRIVE AGAIN. AIR CONDITIONING BLOWER ALSO GOES OUT INTERMITTENTLY. LOTS OF ERROR CODES REPORTED VIA OBD2 AND ALL ARE ELECTRICAL RELATED. TOOK IT TO MULTIPLE AUTO PART STORES AND LOCAL DODGE DEALERSHIP, ALL SAID IT WAS A FAULTY TIPM.
NHTSA ODI #10926852
225,000 miles · Nov 16, 2016
Electrical System
IN LATE 2014, THE VAN STARTED HAVING INTERMITTENT ISSUES STARTING & WOULD OCCASIONALLY STALL WHILE DRIVING. ISSUES STARTED TO PROGRESSIVELY GET WORSE OVER THE NEXT YEAR. THE VAN WOULD HAVE TO BE JUMPED TO START ON A DAILY BASIS. THE VAN WAS IN FOR SERVICE AT A DODGE DEALERSHIP IN NOVEMBER 2015, BUT THEY STATED IT WAS A BATTER…
Read full complaint
IN LATE 2014, THE VAN STARTED HAVING INTERMITTENT ISSUES STARTING & WOULD OCCASIONALLY STALL WHILE DRIVING. ISSUES STARTED TO PROGRESSIVELY GET WORSE OVER THE NEXT YEAR. THE VAN WOULD HAVE TO BE JUMPED TO START ON A DAILY BASIS. THE VAN WAS IN FOR SERVICE AT A DODGE DEALERSHIP IN NOVEMBER 2015, BUT THEY STATED IT WAS A BATTERY ISSUE. THE BATTERY WAS 1 YEAR OLD AND WE HAD IT TESTED AT WAL-MART, WHERE WE PURCHASED IT AND IT TESTED OK. WE THEN HAD IT TESTED AT ADVANCE AUTO & AUTO ZONE AND IT TESTED OK THERE AS WELL. WE DID NOT BELIEVE IT WAS A BATTERY ISSUE, WE BELIEVE THE TIPM IS THE ISSUE. IN DECEMBER 2015 WE NOTICED WE COULD HEAR SOMETHING RUNNING AFTER THE VAN'S IGNITION WAS OFF AND THE KEY WAS OUT. THE FUEL PUMP WAS STILL RUNNING AND WOULD DRAIN THE BATTERY EVERYDAY. AN EXTERNAL FUEL PUMP RELAY WAS INSTALLED AND THE FUEL PUMP NO LONGER RAN AFTER THE VAN WAS OFF. THE VAN WOULD STILL HAVE INTERMITTENT STARTING AND STALLING ISSUES. AFTER READING ALL THE ISSUES OTHER 2010 DODGE PRODUCTS WERE HAVING ASSOCIATED WITH THE TIPM, I ASKED A DODGE SERVICE GUY ABOUT MY VAN. HE AGREED THAT THE TIPM WOULD EXPLAIN ALL THE ISSUES THAT I HAVE WITH MY VAN, BUT THERE WAS NO OPEN RECALL AND THE PART WAS ON A NATIONAL BACKORDER. THE PART IS NOW AVAILABLE FOR >$800! ON JANUARY 25, 2016, THE VAN STALLED AGAIN AND I COULD NOT GET IT TO START. I HAD TO GET SOMEONE TO COME JUMP IT OFF, HOWEVER, THIS TIME IT TOOK A WHILE TO GET THE VAN TO START EVEN BEING JUMPED. I BOUGHT ANOTHER CAR THE NEXT DAY AND PARKED THAT VAN AT OUR HOME. IT HAS BEEN SITTING THERE SINCE JANUARY 2016. CHRYSLER IS WELL AWARE OF THESE ISSUES IN THE 2010 GRAND CARAVAN, BUT THEY REFUSE TO TAKE OWNERSHIP. THIS IS DISAPPOINTING ESPECIALLY SINCE CHRYSLER KNOWS THE RECALLED TIPMS IN THE 2010 DURANGOS & GRAND CHEROKEES ARE THE SAME IN THE 2010 GRAND CARAVANS. I WAS A LOYAL CHRYSLER CUSTOMER UNTIL THIS!
NHTSA ODI #10926443
104,000 miles · Nov 16, 2016
Electrical System
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE THE VEHICLE WAS OPERATED AT VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CA…
Read full complaint
TL* THE CONTACT OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE THE VEHICLE WAS OPERATED AT VARIOUS SPEEDS. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V373000 (ELECTRICAL SYSTEM), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 104,000.
NHTSA ODI #10926393
Official recalls
6Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Mar 1, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE JOURNEY, GRAND CARAVAN, AND CHRYSLER TOWN & COUNTRY VEHICLES MANUFACTURER FROM AUGUST 3, 2009, THROUGH JUNE 17, 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: ENGINE SHUT OFF WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration