NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes complaints
70 reportsClear category filter54,100 miles · May 10, 2015
Air BagsService BrakesSteering
THE MINI VAN ENGINE UNEXPECTEDLY SHUT OFF WHILE DRIVING AT A STEADY SPEED OF 45 MPH. I PULLED OVER AND RESTARTED THE ENGINE AND CONTINUED ON NORMALLY. THIS WAS A DANGEROUS CONDITION SINCE I LOST BRAKE AND STEERING ASSIST. I WAS ALMOST REAR ENDED BY TRAFFIC BEHIND ME. THERE IS A 2010 DODGE IGNITION RECALL THAT EXACTLY DES…
Read full complaint
THE MINI VAN ENGINE UNEXPECTEDLY SHUT OFF WHILE DRIVING AT A STEADY SPEED OF 45 MPH. I PULLED OVER AND RESTARTED THE ENGINE AND CONTINUED ON NORMALLY. THIS WAS A DANGEROUS CONDITION SINCE I LOST BRAKE AND STEERING ASSIST. I WAS ALMOST REAR ENDED BY TRAFFIC BEHIND ME. THERE IS A 2010 DODGE IGNITION RECALL THAT EXACTLY DESCRIBES MY INCIDENT. HOWEVER THE RECALL ONLY COVERS MINIVANS BUILT BEFORE JUNE 17, 2010. MY VEHICLE WAS BUILT ON NOVEMBER 8, 2010. I BELIEVE THIS RECALL SHOULD BE EXPANDED TO ALL GRAND CARAVANS BUILT IN 2010.
NHTSA ODI #10715511
103,000 miles · Apr 13, 2015
Power TrainService BrakesSteering
I WAS DRIVING SLOWLY, MAKING A TURN, AND THE POWER STEERING STOPPED WORKING, THEN THE BRAKING STOPPED, AND THE CAR HAD NO POWER. THE STABILITY CONTROL LIGHT CAME ON. THIS HAS HAPPENED INTERMITTENTLY MULTIPLE TIMES, AND THE DEALERSHIP CANNOT GET THE CAR TO REPEAT THE ERROR. IT DID HAVE ONE KEY FOB ERROR ON THE CODES, BUT THAT WAS…
Read full complaint
I WAS DRIVING SLOWLY, MAKING A TURN, AND THE POWER STEERING STOPPED WORKING, THEN THE BRAKING STOPPED, AND THE CAR HAD NO POWER. THE STABILITY CONTROL LIGHT CAME ON. THIS HAS HAPPENED INTERMITTENTLY MULTIPLE TIMES, AND THE DEALERSHIP CANNOT GET THE CAR TO REPEAT THE ERROR. IT DID HAVE ONE KEY FOB ERROR ON THE CODES, BUT THAT WAS MANY STARTS IN THE PAST. OTHER VIN'S IN THIS MODEL/YEAR HAVE BEEN RECALLED DUE TO ELECTRICAL/IGNITION PROBLEMS. THIS IS PROBABLY WHAT IS WRONG WITH THIS CAR, BUT IT IS NOT UNDER RECALL, AND THE DEALERSHIP CANNOT FIGURE OUT HOW TO FIX IT. *TR
NHTSA ODI #10705400
51,500 miles · Mar 28, 2015
EngineService BrakesSteering
IN THE FIRST DRIVE OF THE DAY (NO MATTER WHAT TIME OF THE DAY) WITHIN 4 BLOCKS OF MY HOME, THE VEHICLE STALLS WHILE DRIVING. THIS HAS SO FAR HAPPENED 8 TIMES OVER THE LAST 9 MONTHS. THIS INCIDENT HAS OCCURRED WITH 3 DIFFERENT DRIVERS AND IN THE SAME EXACT LOCATION 7 OUT OF THE 8 TIMES. VEHICLE IS ALWAYS COASTING (NOT ACCELERATIN…
Read full complaint
IN THE FIRST DRIVE OF THE DAY (NO MATTER WHAT TIME OF THE DAY) WITHIN 4 BLOCKS OF MY HOME, THE VEHICLE STALLS WHILE DRIVING. THIS HAS SO FAR HAPPENED 8 TIMES OVER THE LAST 9 MONTHS. THIS INCIDENT HAS OCCURRED WITH 3 DIFFERENT DRIVERS AND IN THE SAME EXACT LOCATION 7 OUT OF THE 8 TIMES. VEHICLE IS ALWAYS COASTING (NOT ACCELERATING) AROUND 20 MILES PER HOUR. WHEN THIS INCIDENT OCCURS, THE ENGINE TURNS OFF, WHICH DISABLES THE STEERING, BRAKES, AND ACCELERATION. THIS LEAVES THE DRIVER AND ITS PASSENGERS IN SERIOUS, POTENTIALLY LETHAL, DANGER. WE HAVE TAKEN THIS VEHICLE MULTIPLE TIMES TO THE DEALERSHIP, AND THEY CLAIM THAT THIS VEHICLE IS NOT INCLUDED IN THE RECALL. THEY STATE THAT THERE ARE NO ERROR CODES. *TR
NHTSA ODI #10702383
85,000 miles · Mar 7, 2015
EngineService BrakesSteering
THE VEHICLE CUTS OFF AT NORMAL OPERATING SPEED ON BUMPY SURFACES OR AFTER GOING OVER BUMPS IN THE ROAD. VEHICLE LOST POWER STEERING, BRAKING, AND THE ENGINE CUTS OFF. THIS RESULTED IN AND EMERGENCY EXIT FROM THE LANE OF TRAVEL. THIS HAS HAPPENED MULTIPLE TIMES OVER THE PAST 12 MONTHS. THIS APPEARS TO BE THE SAME SYMPTOMS OF …
Read full complaint
THE VEHICLE CUTS OFF AT NORMAL OPERATING SPEED ON BUMPY SURFACES OR AFTER GOING OVER BUMPS IN THE ROAD. VEHICLE LOST POWER STEERING, BRAKING, AND THE ENGINE CUTS OFF. THIS RESULTED IN AND EMERGENCY EXIT FROM THE LANE OF TRAVEL. THIS HAS HAPPENED MULTIPLE TIMES OVER THE PAST 12 MONTHS. THIS APPEARS TO BE THE SAME SYMPTOMS OF A CURRENT RECALL FOR THE IGNITION SWITCH ON SIMILAR VEHICLES OF THIS MODEL. DODGE MAKES NO ATTEMPT TO ASSIST WITH VERIFYING THAT THERE IS AN ISSUE. *TR
NHTSA ODI #10692708
38,000 miles · Jan 26, 2015
Service Brakes
TL*THE CONTACT A OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE REAR BRAKE ALIGNMENT NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NO…
Read full complaint
TL*THE CONTACT A OWNS A 2010 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE REAR BRAKE ALIGNMENT NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.
NHTSA ODI #10678820
78,884 miles · Jan 22, 2015
Electronic Stability Control (esc)Service BrakesSteering
WHILE DRIVING APPROXIMATELY 40 MPH UNDER NORMAL CONDITIONS (50 DEGREES F, NO RAIN/SNOW), THE OPERATOR NOTICED A SUDDEN AND UNEXPECTED LOSS OF POWER STEERING. UPON SCANNING THE DASH, THE EPS (STABILITY CONTROL) LIGHTS WAS ILLUMINATED. A FEW SECONDS (MAYBE 5 - 15) LATER, THE POWER BREAKING APPEARED TO BE LOST. OPERATOR IS UNSUR…
Read full complaint
WHILE DRIVING APPROXIMATELY 40 MPH UNDER NORMAL CONDITIONS (50 DEGREES F, NO RAIN/SNOW), THE OPERATOR NOTICED A SUDDEN AND UNEXPECTED LOSS OF POWER STEERING. UPON SCANNING THE DASH, THE EPS (STABILITY CONTROL) LIGHTS WAS ILLUMINATED. A FEW SECONDS (MAYBE 5 - 15) LATER, THE POWER BREAKING APPEARED TO BE LOST. OPERATOR IS UNSURE IF THESE FUNCTIONS WERE "SIMPLY" LOST, OR IF THE VEHICLE WAS ACTUALLY POWERED DOWN. STEERING AND BREAKING WAS EXTREMELY DIFFICULT TO THE EXTENT THAT IT WAS VERY DIFFICULT TO PHYSICALLY CONTROL THE VEHICLE ENOUGH TO MOVE TO THE SIDE OF THE ROAD WITHOUT HITTING ANY OBJECTS. EVEN BRAKING WAS EXTREMELY DIFFICULT TO DO WITH SIGNIFICANT FORCE. AFTER GETTING SAFELY ON THE SIDE OF THE ROAD, THE ENGINE WAS IMMEDIATELY TURNED OFF. A FEW MINUTES LATER, THE CAR WAS RE-STARTED AND APPEARED TO BE FUNCTIONING NORMALLY, ALTHOUGH OPERATOR WAS UNWILLING TO RISK PUTTING CAR INTO "DRIVE". CAR WAS TOWED TO DEALER FOR ANALYSIS. IF THIS HAD HAPPENED AT HIGHER SPEED, OR WHEN A QUICK STOP WAS NECESSARY, A SEVERE CRASH LIKELY WOULD HAVE OCCURRED. *TR
NHTSA ODI #10678428
14,000 miles · Oct 8, 2014
Service Brakes
BRAKES WERE CHECKED BY DEALER AND SAID TO BE FINE. AFTER A FEW MILES AT ROAD SPEED, I STOPPED AND SMELLED HOT BRAKES. REAR DRIVER'S WAS SMOKING. LUBE ON GUIDES WAS BOILING AND ROTORS WERE BLUE. DEALER CLAIMS THERE IS NO PROBLEM. CLAIMS IT IS OUR ROUGH WINTERS HERE IN CENTRAL NY. BUT THEY HAD JUST CHECKED THEM AND NO SALT OR WINT…
Read full complaint
BRAKES WERE CHECKED BY DEALER AND SAID TO BE FINE. AFTER A FEW MILES AT ROAD SPEED, I STOPPED AND SMELLED HOT BRAKES. REAR DRIVER'S WAS SMOKING. LUBE ON GUIDES WAS BOILING AND ROTORS WERE BLUE. DEALER CLAIMS THERE IS NO PROBLEM. CLAIMS IT IS OUR ROUGH WINTERS HERE IN CENTRAL NY. BUT THEY HAD JUST CHECKED THEM AND NO SALT OR WINTER IN JULY. I HAVE RUINED 4 SETS OF REAR BRAKES AND ROTORS SINCE THEN. JUST REPLACED THE FRONT FOR THE FIRST TIME AT 70,000 MILES. THERE IS SOMETHING WRONG WITH THE SYSTEM THAT IS APPLYING THE REAR BRAKES WHEN NOT NEEDED. SOMETIMES I FIND THE RIGHT SIDE SMOKING AND SOMETIMES THE LEFT. WE HAVE DONE EVERYTHING ACCORDING TO SPEC. FILED THE GUIDES, LUBED THE GUIDES TO BE SURE EVERYTHING IS FREE. NOTHING HELPS. IT IS DANGEROUS BECAUSE ALL I HAVE IS THE FRONT BRAKES TO STOP IN AN EMERGENCY. YOUR DEALER CLAIMS THIS IS NORMAL TO ONLY GET 14000 MILES ON A SET OF REAR BRAKES. THEY DID REPLACE ONE CALIPER BUT IT MADE NO DIFFERENCE. THANKS *TR
NHTSA ODI #10643417
60,000 miles · Sep 25, 2014
Service Brakes
JUST HAD 2010 VAN THAT WAS PURCHASED NEW IN FOR A ROUTINE OIL CHANGE. WAS TOLD THAT WE NEED TO REPLACE REAR BRAKE PADS, ROTORS AND CALIPERS. 61,000 MILES. THIS WILL BE THE 3RD SET OF PADS AND ROTORS ON THE REAR. BASED ON THE TYPE OF DRIVING WE DO THIS SHOULD NOT BE HAPPENING. INTERESTINGLY ENOUGH AROUND 15,000 MILES CHRYSLER…
Read full complaint
JUST HAD 2010 VAN THAT WAS PURCHASED NEW IN FOR A ROUTINE OIL CHANGE. WAS TOLD THAT WE NEED TO REPLACE REAR BRAKE PADS, ROTORS AND CALIPERS. 61,000 MILES. THIS WILL BE THE 3RD SET OF PADS AND ROTORS ON THE REAR. BASED ON THE TYPE OF DRIVING WE DO THIS SHOULD NOT BE HAPPENING. INTERESTINGLY ENOUGH AROUND 15,000 MILES CHRYSLER REPLACED THE FRONT ROTORS AND PADS BECAUSE OF A KNOWN ISSUE. IF I REMEMBER CORRECTLY IT WAS BECAUSE OF A CALIPER STICKING ON THE FRONT. THESE PADS, ROTORS AND CALIPERS HAVE NOT NEEDED TO BE REPLACED OR SERVICED IN OVER 45,000 MILES BASED ON ALL THE FEEDBACK ONLINE AND A CONVERSATION WITH AN ASE CERTIFIED MECHANIC IT IS A VERY COMMON ISSUE. *TR
NHTSA ODI #10639134
5,000 miles · Aug 26, 2014
Service Brakes
SINCE BASICALLY BRAND NEW THE BRAKES FELT FUNNY TO ME. MY WIFE SAID IT WAS JUST ME. HAD DEALER CHECK THEM UNDER 1 YEAR AND THEY SAID NOTHING WAS WRONG. WITHIN 6 MONTH OF THAT VISIT THE RECALL CAME OUT AND FRONT BRAKES COULD BE REPLACED. COST ME THE DEDUCTIBLE. WELL THAT FIX HAS NEVER FELT RIGHT EITHER AND IT'S GETTING WORSE…
Read full complaint
SINCE BASICALLY BRAND NEW THE BRAKES FELT FUNNY TO ME. MY WIFE SAID IT WAS JUST ME. HAD DEALER CHECK THEM UNDER 1 YEAR AND THEY SAID NOTHING WAS WRONG. WITHIN 6 MONTH OF THAT VISIT THE RECALL CAME OUT AND FRONT BRAKES COULD BE REPLACED. COST ME THE DEDUCTIBLE. WELL THAT FIX HAS NEVER FELT RIGHT EITHER AND IT'S GETTING WORSE. THE SHAKE IS VIOLENT NOW IN ADDITION TON THE GRINDING THAT HAPPENS EVERY TIME THE CAR JUST STARTS UP FOR THE DAY OR GOD FORBID YOU HAVE TO HIT THEM HARD FOR A QUICK STOP. TONS OF GROANING AND CREAKS NOT TOO MENTION AND DRAGGED OUT STOP. YOU ALSO CAN'T TELL ME THIS KIND OF SHAKING IS GOOD FOR THE OTHER FRONT END PARTS. AS I SEE IT I CAN KEEP GOING THROUGH SETS OF BRAKES THAT WILL WARP FAST AND NOT PROVIDE ME AND MY FAMILY THE SAFETY WE NEED TO BE COMFORTABLE OR GET RID OF IT. GIVE YOU ONE GUESS WHICH DIRECTION I'M HEADING. SAID COMMERCIAL FOR DODGE AND THEIR QUALITY. I HAVE OWNED MANY DODGE VEHICLES BUT WILL LIKELY MOVE ON ALL TOGETHER FROM THEM. ALREADY REPLACED MY DODGE DURANGO 2004 THAT DID QUITE WELL WITH 2012 NISSAN ARMADA. I WILL BE WATCHING IN MY REAR VIEW FOR DODGE MIN-VANS AND BE SURE TO MOVE OUT THE WAY NOT KNOWING IF THEY CAN STOP BEFORE HITTING ME. THE WORST BRAKING I HAVE FELT ON A CAR EVER AND I'VE DRIVEN SOME TERRIBLE 1970'S MACHINES. BOO DODGE ON THIS ONE FOR NOT STEPPING UP AND FIXING THE ENTIRE PROBLEM. GUESS POTENTIAL LAWSUITS WILL COST THEM LESS. HOW DO THEY SLEEP AT NIGHT. THAT FELT GOOD TO GET OFF MY CHEST I TRULY HATE THIS VEHICLE. *TR
NHTSA ODI #10628356
55,000 miles · Aug 8, 2014
Service Brakes
THE CALIPERS LOCKED UP ON MY REAR DRIVER SIDE WHEEL. THERE WAS A TERRIBLE SMELL AND LOUD SOUND WHEN IT HAPPENED. I WAS OUT OF TOWN WITH MY DAUGHTER. I HAD TO LEAVE THE VAN ON A COUNTRY ROAD AND COME BACK FOR IT LATER IN ORDER TO LET IT COOL SO IT DIDN'T CATCH FIRE. THE COST TO REPAIR WAS $750 TO HAVE ALL 4 CALIPERS REPLACED. …
Read full complaint
THE CALIPERS LOCKED UP ON MY REAR DRIVER SIDE WHEEL. THERE WAS A TERRIBLE SMELL AND LOUD SOUND WHEN IT HAPPENED. I WAS OUT OF TOWN WITH MY DAUGHTER. I HAD TO LEAVE THE VAN ON A COUNTRY ROAD AND COME BACK FOR IT LATER IN ORDER TO LET IT COOL SO IT DIDN'T CATCH FIRE. THE COST TO REPAIR WAS $750 TO HAVE ALL 4 CALIPERS REPLACED. I HAD A 2006 DODGE CARAVAN THAT HAD THE SAME THING HAPPEN 3 YEARS AGO. WHEN IT HAPPENED TO ME IN 2011, IT SMOKED AND 911 WAS CALLED TO CHECK OUT THE ISSUE. HAVING HAD 2 OF THE SAME TYPES OF VANS HAVE THE SAME PROBLEM INDICATES TO ME THAT THERE IS SOMETHING WRONG WITH DODGE'S DESIGN OF THEIR VEHICLES. THERE ARE INSTANCES OF THIS PROBLEM ALL OVER THE INTERNET WITH SEVERAL DODGE MODELS. A FRIEND OF MINE SEVERAL YEARS AGO HAD THE SAME PROBLEM WITH A BRAND NEW DODGE DAKOTA THAT SHE HAD FOR 2 WEEKS. THIS IS A DANGEROUS PROBLEM THAT SHOULD BE ADDRESSED BY DODGE. HAVING BRAKES CATCH FIRE IS A DANGEROUS SITUATION. I CAN NO LONGER TAKE MY VAN OUT OF TOWN FOR FEAR OF IT HAPPENING AGAIN. *TR
NHTSA ODI #10620827
Official recalls
6Dec 17, 2025
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
May 7, 2014
Chrysler Group, LLC (Chrysler) is recalling certain model year 2010-2014 Chrysler Town and Country and Dodge Grand Caravan vehicles manufactured August 25, 2010, through October 31, 2013. The affected vehicles may experience overheating of the vent window switch in the driver's door armrest.
Consequence & remedy
Consequence: An overheated switch may result in a vehicle fire.
Remedy: Chrysler will notify owners, and dealers will replace the vent window switch with a newer version, free of charge. The owner notification letter was issued and the remedy campaign launched on on December 31, 2014. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P25.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Mar 1, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE JOURNEY, GRAND CARAVAN, AND CHRYSLER TOWN & COUNTRY VEHICLES MANUFACTURER FROM AUGUST 3, 2009, THROUGH JUNE 17, 2010. SOME VEHICLES MAY EXPERIENCE INADVERTENT IGNITION KEY DISPLACEMENT FROM THE RUN TO ACCESSORY POSITION WHILE DRIVING CAUSING THE ENGINE TO SHUT OFF.
Consequence & remedy
Consequence: ENGINE SHUT OFF WHILE DRIVING COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE WIN MODULES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration