2007 Dodge Grand Caravan

EVERY TIME THE FUEL TANK IS FILLED UP, AND AFTER WE START DRIVING, THE ENGINE WILL JUST STALL. IT COULD LEAD TO AN ACCIDENT IF THIS HAPPENS IN TRAFFIC. LUCKILY THIS HASN'T HAPPENED YET. THERE ARE SEVERAL OTHER CASES ON THE INTERNET,FOR EXAMPLE, ON THIS WEBSITE: HTTP://EN.ALLEXPERTS.COM/Q/CHRYSLER-REPAIR-807/F/STALLING-REFUELING.HTM

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE REFUELING THE VEHICLE, THE FUEL STOPPED FLOWING THROUGH THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. MA 09/22 UPDATED 11/14/2017*CN

VEHICLE STALLS INTERMITTENTLY WHILE DRIVING SHORTLY AFTER FILLING UP WITH FUEL. VEHICLE CONTINUES TO STALL PERIODICALLY WITHOUT ANY KNOWN CONSISTENCY. DURING THE STALL, THE ENGINE CUTS OUT AND THE STEERING WHEEL LOCKS UP. THIS HAS OCCURRED SEVERAL TIMES IN THE PARKING LOT AFTER FILLING UP AND WHILE ENTERING THE ROADWAY AFTER FILLING UP. THIS A VERY DANGEROUS AND SERIOUS CONCERN FOR WHEN A LOSS OF POWER OCCURS ON THE ROADWAY SERIOUS AND POTENTIALLY FATAL ACCIDENTS MAY OCCUR. *TR

THE LAST FEW TIMES I HAVE COMPLETELY FILLED UP MY GAS TANK - THE VEHICLE HAS STALLED. I HAVE HAD TO TRIED TO STOP AND RESTART THE IGNITION/ENGINE A NUMBER OF TIMES FOR THE VEHICLE TO RUN. THIS IS HAPPENING WITH FULL GAS FULL-UP AND HAPPENED TO ME AGAIN LAST NIGHT. I HAVE SEEN THIS AS BEING A COMMON PROBLEM FOR CHRYSLER/DODGE MINIVANS IN A FEW ON-LINE FORUMS. SOME REPORTS HAVE THE VEHICLES STALLING ON HIGHWAYS AND/OR WHEN DRIVING. MY VEHICLE IS A 2007 DODGE GRAND CARAVAN SXT. *TR

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STALLED AFTER THE VEHICLE WAS REFUELED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. IMMEDIATELY AFTER ADDING FUEL TO THE VEHICLE AND RESTARTING THE ENGINE, THE VEHICLE STALLED WITHOUT WARNING. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 90,000. UPDATED 8/21/15*CN THE CONSUMER STATED THE VEHICLE STALLS INTERMITTENTLY, NOT ON EVERY FILL UP. USUALLY, THE STALL WOULD OCCUR AFTER FILL UP AND A FEW MINUTES AFTER LEAVING THE PUMP. UPDATED 10/14/2015*JS

THE ENGINE STALLED TWICE WITHIN 5 MINUTES OF REFUELING. THE VEHICLE WAS FILLED WITH UNLEADED 87 OCTANE GAS TO FULL. THE GAS PUMP AUTO STOPPED WHEN FULL, AND THE TANK WAS NOT TOPPED OFF. THE FIRST STALL HAPPENED WHILE THE VEHICLE WAS IDLING AT A STOP SIGN APPROXIMATELY 1 MINUTE AFTER FUELING. THE ENGINE RESTARTED, BUT STALLED AGAIN APPROXIMATELY 2 MINUTES LATER. THE SECOND STALL OCCURRED WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 15-20 MPH AND TURNING LEFT. THE STALL LEFT THE VEHICLE WITHOUT POWER STEERING, AND THE VEHICLE COASTED INTO A DRIVEWAY. THERE WAS NO ACCIDENT BECAUSE OF LIGHT TRAFFIC. UNDER DIFFERENT CIRCUMSTANCES OR TRAFFIC PATTERNS, A STALLED ENGINE LEAVING A MOVING VEHICLE POWERLESS LIKELY WOULD CAUSE AN ACCIDENT RESULTING IN POSSIBLE INJURY OR DEATH. THIS SAME PROBLEM HAS OCCURRED APPROXIMATELY 5-6 TIMES IN THE LAST 2 YEARS, HOWEVER I CAN NOT BE SPECIFIC ON DATES. IT WAS ONLY WHEN MY WIFE AND I WERE TOGETHER THIS LAST TIME THAT WE BOTH COMMENTED ON THE PROBLEM, AND FOUND THAT IT HAS HAPPENED TO EACH OF US SEVERAL TIMES. I BELIEVE ANY MANUFACTURER DEFECT WHICH CAUSES A MOVING VEHICLE TO LOSE POWER AND BECOME UNCONTROLLABLE WHILE IN MOTION IS AN EXTREMELY SERIOUS AND POTENTIALLY DEADLY PROBLEM. *TR

THE VEHICLE STALLS AFTER RE-FUELING. WE RE-FUEL AT DIFFERENT GAS STATIONS (BRANDS) AND THE ISSUE REMAINS. EVERY TIME WE FILL THE TANK AND PULL OUT OF THE GAS STATION INTO TRAFFIC, THE ENGINE SPUTTERS AFTER DRIVING APPROXIMATELY TWO BLOCKS, AS IF IT IS NOT RECEIVING ENOUGH FUEL. THE ENGINE THEN STALLS. THE ENGINE CAN BE RESTARTED AND WILL NOT SPUTTER OR STALL UNTIL THE NEXT TIME WE RE-FUEL IT. WE ENCOUNTER THIS ISSUE WEEKLY, AFTER EVERY FILL UP. IT IS A POTENTIALLY DANGEROUS ISSUE BECAUSE THE VEHICLE STALLS IN TRAFFIC AND COULD CAUSE A TRAFFIC ACCIDENT. *TR