2007 Dodge Grand Caravan

AS I WAS DRIVING IN TOWN THE VEHICLE STARTED RUNNING VERY ROUGH, I PULLED OVER INTO A PARKING LOT AND THEN IT WOULDN'T RUN AT ALL. I HAD IT TOWED TO AN AUTO REPAIR PLACE. THEY REPLACED A SENSOR. THAT DID NOT FIX THE PROBLEM, SO AFTER A FEW WEEKS THEY FINALLY DIAGNOSED IT AS NEEDING A VALVE JOB. I BOUGHT THIS VEHICLE NEW IN 2007 AND HAD IT REGULARLY SERVICED.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 25 MPH AND ATTEMPTING TO MAKE A TURN, THE POWER STEERING FAILED AND THE BATTERY AND TEMPERATURE GAUGE LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TIMING BELT FRACTURED AND THE TIMING CHAIN AND ENGINE COVER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 153,000.

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE MAKING A RIGHT TURN AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE VIN WAS UNAVAILABLE.

1ST OCCURRENCE: WHILE DRIVING ON FREEWAY ON A HOT DAY THE CAR STALLED WITHOUT WARNING. ON ATTEMPTED RESTARTS CAR WOULD FIRE FOR A COUPLE OF SECONDS AND QUIT. TRIED OTHER KEY: NO HELP. AFTER ABOUT 7 OR 8 ATTEMPTS THE CAR WOULD NOT CRANK AND SOLENOID CLICKED. TOWED HOME. CAR SET CODES P0339 AND P0344(INTERMITTENT CRANK AND CAM SENSOR). CHARGED BATTERY . REPLACED BOTH SENSORS CAR INITIALLY WOULD NOT START, THEN MYSTERIOUSLY FIRED UP AND RAN FINE. OK FOR ABOUT A MONTH. BATTERY TESTED OK CHARGING VOLTAGE GOOD WHEN RUNNING. NOT RELATED TO HAVING JUST (OVER)FILLED GAS TANK. (MUCH ON INTERNET ABOUT THIS: BAD VALVE IN TANK ALLOWS EVAP TO FLOOD) 2ND OCCURRENCE. ONCE AGAIN DRIVING ON HIGHWAY HOT DAY. ONCE AGAIN STALLED WITHOUT WARNING. SAME SYMPTOMS ON ATTEMPTED RESTART. AFTER WAITING ABOUT 15 MINUTES, CAR RESTARTED, RAN ABOUT 4 MILES AND STALLED AGAIN. ATTEMPTED FOUR OR FIVE RESTARTS, THEN BATTERY APPEARED TO RUN DOWN. HEADLIGHTS WOULD DIM ON START ATTEMPT. AFTER A WHILE THE CAR STARTED AGAIN BUT RAN ROUGHLY ON ACCELERATION. ONCE AGAIN SET SAME CODES. AT THIS POINT I NOTICED SOME ELECTRICAL ANOMALIES. UPON KEY ON, THE TEMP, FUEL, AND TACH GAUGES WOULD PEG HIGH AND THEN FALL BACK TO NORMAL. THE POWER WINDOWS BEGAN TO OPERATE WITHOUT THE KEY ON. TOW TRUCK ARRIVED AND GOT IT HOME. CAR RESTARTED IN GARAGE. REPLACED BOTH SENSORS AGAIN AND BATTERY (SUSPECTED INTERMITTENT OPEN). 3RD OCCURRENCE ON TEST DRIVE GOT ABOUT 5 MILES AND ONTO HIGHWAY. ONCE AGAIN STALLED. THIS TIME RESTARTED, TURNED AROUND AND GOT ABOUT 2 MILES THEN QUIT AGAIN. THIS TIME NO RESTART( SAME 2-3 SECONDS). THIS TIME SET CODE P0344 ONLY(CAM SENSOR INTERMITTENT). CAR RESTARTED LATER BACK IN SHOP. RESEARCH ON THE INTERNET HAS GOT ME THINKING ABOUT THE TIPM (TOTALLY INTEGRATED POWER MODULE)

THE LAST FEW TIMES I HAVE COMPLETELY FILLED UP MY GAS TANK - THE VEHICLE HAS STALLED. I HAVE HAD TO TRIED TO STOP AND RESTART THE IGNITION/ENGINE A NUMBER OF TIMES FOR THE VEHICLE TO RUN. THIS IS HAPPENING WITH FULL GAS FULL-UP AND HAPPENED TO ME AGAIN LAST NIGHT. I HAVE SEEN THIS AS BEING A COMMON PROBLEM FOR CHRYSLER/DODGE MINIVANS IN A FEW ON-LINE FORUMS. SOME REPORTS HAVE THE VEHICLES STALLING ON HIGHWAYS AND/OR WHEN DRIVING. MY VEHICLE IS A 2007 DODGE GRAND CARAVAN SXT. *TR

THE ENGINE STALLED TWICE WITHIN 5 MINUTES OF REFUELING. THE VEHICLE WAS FILLED WITH UNLEADED 87 OCTANE GAS TO FULL. THE GAS PUMP AUTO STOPPED WHEN FULL, AND THE TANK WAS NOT TOPPED OFF. THE FIRST STALL HAPPENED WHILE THE VEHICLE WAS IDLING AT A STOP SIGN APPROXIMATELY 1 MINUTE AFTER FUELING. THE ENGINE RESTARTED, BUT STALLED AGAIN APPROXIMATELY 2 MINUTES LATER. THE SECOND STALL OCCURRED WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 15-20 MPH AND TURNING LEFT. THE STALL LEFT THE VEHICLE WITHOUT POWER STEERING, AND THE VEHICLE COASTED INTO A DRIVEWAY. THERE WAS NO ACCIDENT BECAUSE OF LIGHT TRAFFIC. UNDER DIFFERENT CIRCUMSTANCES OR TRAFFIC PATTERNS, A STALLED ENGINE LEAVING A MOVING VEHICLE POWERLESS LIKELY WOULD CAUSE AN ACCIDENT RESULTING IN POSSIBLE INJURY OR DEATH. THIS SAME PROBLEM HAS OCCURRED APPROXIMATELY 5-6 TIMES IN THE LAST 2 YEARS, HOWEVER I CAN NOT BE SPECIFIC ON DATES. IT WAS ONLY WHEN MY WIFE AND I WERE TOGETHER THIS LAST TIME THAT WE BOTH COMMENTED ON THE PROBLEM, AND FOUND THAT IT HAS HAPPENED TO EACH OF US SEVERAL TIMES. I BELIEVE ANY MANUFACTURER DEFECT WHICH CAUSES A MOVING VEHICLE TO LOSE POWER AND BECOME UNCONTROLLABLE WHILE IN MOTION IS AN EXTREMELY SERIOUS AND POTENTIALLY DEADLY PROBLEM. *TR

THE VEHICLE STALLS AFTER RE-FUELING. WE RE-FUEL AT DIFFERENT GAS STATIONS (BRANDS) AND THE ISSUE REMAINS. EVERY TIME WE FILL THE TANK AND PULL OUT OF THE GAS STATION INTO TRAFFIC, THE ENGINE SPUTTERS AFTER DRIVING APPROXIMATELY TWO BLOCKS, AS IF IT IS NOT RECEIVING ENOUGH FUEL. THE ENGINE THEN STALLS. THE ENGINE CAN BE RESTARTED AND WILL NOT SPUTTER OR STALL UNTIL THE NEXT TIME WE RE-FUEL IT. WE ENCOUNTER THIS ISSUE WEEKLY, AFTER EVERY FILL UP. IT IS A POTENTIALLY DANGEROUS ISSUE BECAUSE THE VEHICLE STALLS IN TRAFFIC AND COULD CAUSE A TRAFFIC ACCIDENT. *TR