NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
995 reports45,000 miles · Oct 24, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE, THE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE EMISSION GAS RECIRCULATION VALVE (EGR) HAD TO BE REPLACED. THE MANUFACTURER WAS CONTACTED WHO COINCIDED WITH THE DEALERSHIP DETERMINATION. THE CONTACT WAS VERY CON…
Read full complaint
DT*: THE CONTACT STATED WHILE STARTING THE VEHICLE, THE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO DETERMINED THE EMISSION GAS RECIRCULATION VALVE (EGR) HAD TO BE REPLACED. THE MANUFACTURER WAS CONTACTED WHO COINCIDED WITH THE DEALERSHIP DETERMINATION. THE CONTACT WAS VERY CONCERNED BECAUSE THE EGR VALVE WAS PART OF THE EMISSION CONTROL. UPDATED 11/30/2006 - THE CONSUMER PURCHASED AND INSTALLED THE PART HIMSELF. *NM
NHTSA ODI #10171744
40,384 miles · Oct 18, 2006
Suspension
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH, THERE WAS A CLUNKING NOISE COMING FROM UNDER THE VEHICLE WHENEVER IT WAS DRIVEN OVER AN UNEVEN SURFACE. THIS WAS ACCOMPANIED BY LOOSENESS IN THE STEERING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THE FRONT SWAY LINKS AND BUSHINGS NEEDED REPLACEMENT. THE PARTS WERE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 30 MPH, THERE WAS A CLUNKING NOISE COMING FROM UNDER THE VEHICLE WHENEVER IT WAS DRIVEN OVER AN UNEVEN SURFACE. THIS WAS ACCOMPANIED BY LOOSENESS IN THE STEERING. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHO DETERMINED THE FRONT SWAY LINKS AND BUSHINGS NEEDED REPLACEMENT. THE PARTS WERE REPLACED, WHICH CORRECTED THE PROBLEM.
NHTSA ODI #10171214
18,000 miles · Oct 1, 2006
Electrical SystemEngine And Engine Cooling
VEHICLE STOPS. MOTOR SHUTS OFF, NO POWER AVAILABLE. AT HIGHWAY SPEEDS. VERY DANGEROUS LOSS OF CONTROL IN TRAFFIC! HAPPENED AT LEAST 4 TIMES FROM DATE OF PURCHASE MAY 2005 TO AUGUST 2006, BUT ONLY AT START UP IN PARKING LOT. THEN IT HAPPENED AT HIGHWAY SPEED ON THE HIGHWAY WITH 4 CHILDREN IN VAN AGES 1, 2, 8 AND 10 YEARS OLD! …
Read full complaint
VEHICLE STOPS. MOTOR SHUTS OFF, NO POWER AVAILABLE. AT HIGHWAY SPEEDS. VERY DANGEROUS LOSS OF CONTROL IN TRAFFIC! HAPPENED AT LEAST 4 TIMES FROM DATE OF PURCHASE MAY 2005 TO AUGUST 2006, BUT ONLY AT START UP IN PARKING LOT. THEN IT HAPPENED AT HIGHWAY SPEED ON THE HIGHWAY WITH 4 CHILDREN IN VAN AGES 1, 2, 8 AND 10 YEARS OLD! HAVE NO FAITH IN SAFETY OF VEHICLE! DEALER STILL WANTS ME TO DRIVE AROUND WITH THE KIDS IN THIS CONDITION AND I CANNOT PUT MY CHILDREN IN DANGER. *JB
NHTSA ODI #10169668
Mileage unknown · Sep 27, 2006
VisibilityInjury
I OWN A 2005 DODGE GRAND CARAVAN THAT IS APPROXIMATELY ONE YEAR OLD. ON 8/18/06, I WAS DRIVING AND A COOLANT SPRAYED ONTO MY LEG CAUSING BURNING AND PERMANENT SCARING. I WAS ABLE TO CONTROL THE VEHICLE TO THE SIDE OF THE ROAD. DEALER TECH INDICATED THAT THE HEATER CORE TUBE BROKE INSIDE THE VEHICLE AT THE HEATER CORE. I CALLED T…
Read full complaint
I OWN A 2005 DODGE GRAND CARAVAN THAT IS APPROXIMATELY ONE YEAR OLD. ON 8/18/06, I WAS DRIVING AND A COOLANT SPRAYED ONTO MY LEG CAUSING BURNING AND PERMANENT SCARING. I WAS ABLE TO CONTROL THE VEHICLE TO THE SIDE OF THE ROAD. DEALER TECH INDICATED THAT THE HEATER CORE TUBE BROKE INSIDE THE VEHICLE AT THE HEATER CORE. I CALLED THE MANUFACTURER NUMBER AND WAS ADVISED THAT I WOULD RECEIVE A WRITTEN CORRESPONDENCE WITHIN 12 DAYS. WITHIN ONE WEEK OF THE ACCIDENT A MANUFACTURERS REPRESENTATIVE INSPECTED THE VAN. TODAY IS 9/27/06, I HAVE LEFT SEVERAL MESSAGES TO THE NUMBER PROVIDED BUT HAVE RECEIVED NO RESPONSE. I'M NOT SURE WHAT THE ROOT CAUSE OF THE PROBLEM IS OR IF THE CAR WILL BE SAFE AGAIN TO DRIVE. I HOPE YOU CAN HELP,ASIDE FROM PHYSICAL AND ECONOMIC DAMAGES INCURRED, I AM CONCERNED THAT IF A SIMILAR ACCIDENT OCCURS AN EVEN MORE TRAGIC RESULT MAY OCCUR. THE VAN IS NOW AT THE DEALER THAT WE PURCHASED THE VEHICLE FROM. *NM
NHTSA ODI #10169475
53,280 miles · Sep 24, 2006
Engine And Engine Cooling
LAST SATURDAY 09/16/2006 MY HUSBAND AND I WENT TO DROP OFF A KEY FOR THE OTHER CAR WE OWN. MY HUSBAND WAS DRIVING. HE DROVE OUT OF THE PARKING LOT THE VAN STALLED. HE TRIED TO RESTART THE VAN, IT WAS NOT STARTING. WE SWITCHED PLACES TO GET THE VAN OUT OF TRAFFIC. CALLED AAA AND HAD THE VAN TOWED TO TARPON DODGE LOCATED IN TARP…
Read full complaint
LAST SATURDAY 09/16/2006 MY HUSBAND AND I WENT TO DROP OFF A KEY FOR THE OTHER CAR WE OWN. MY HUSBAND WAS DRIVING. HE DROVE OUT OF THE PARKING LOT THE VAN STALLED. HE TRIED TO RESTART THE VAN, IT WAS NOT STARTING. WE SWITCHED PLACES TO GET THE VAN OUT OF TRAFFIC. CALLED AAA AND HAD THE VAN TOWED TO TARPON DODGE LOCATED IN TARPON SPRINGS FL. THEY CHECKED THE VAN OUT AND SAID THE ENGINE WAS MESSED UP. IT WAS ENGINE BLOCK. THERE WAS NO WARNING LIGHTS TO INDICATE ANY PROBLEM. WE HAD OUR OIL CHANGED WE HAVE ONE RECEIPT ABOUT ONE OR TWO WEEKS OLD, CAN NOT LOCATE THE OTHER RECEIPTS. THEY CLAIM THEY TESTED THE OIL AND IT IS DIRTY. DAILMER CHRYSLER CORPORATION IS TURNING US DOWN ON REPAIRS AND WE ARE ONLY GOING TO RECEIVE 1 DAY RENTAL CHANGE OF $35.00. THE DEALER SAID TELL WOULD TAKE $150.00 OFF OUR $3800.00 PLUS BILL NOT INCLUDING TAXES. THERE HAS BEEN OTHER COMPLAINTS ABOUT THIS SAME PROBLEM. FIRST I TOLD THEM TO REPAIR THE 2005 DODGE GRAND CARAVAN SO IT WOULD NOT VOID THE SO CALLED WARRANTY AFTER THE SHOCK OF THE BAD NEWS. FIRST I WOULD LIKE YOU TO INVESTIGATE THIS. SECOND I HOPE THAT OTHERS WILL BE PROTECTED BY YOUR INVESTIGATION, SO THEY WILL NOT HAVE TO GO THROUGH THIS ORDEAL. THIRD RENTAL CAR COST IS GOING TO BE AROUND $1500.00 APPROX. AND THEY SHOULD COVER THE COST WHILE THE REPAIR UNTIL THE VAN IS REPAIRED. I AM HOPEFUL THAT MAYBE THROUGH YOUR INVESTIGATION THAT SOME IF NOT ALL OF THE COST WOULD BE COVERED. BUT AS I STATED BEFORE IF YOU CAN ASSIST OTHERS SO THEY DO NOT HAVE TO GO THROUGH THIS ORDEAL IT WOULD HELP OTHER CONSUMERS THAT WOULD BE THE BEST OUT COME. *NM
NHTSA ODI #10169150
13,500 miles · Aug 30, 2006
Power Train
DT*: THE CONTACT STATED WHILE DRIVING 20 MPH ON A CITY STREET, THE LEFT FRONT DRIVER SIDE AXLE FRACTURED WITHOUT WARNING. THE CONTACT MANAGED TO PULL THE VEHICLE OVER WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE LEFT FRONT FRACTURED AXLE. AFTERWARDS, WHILE DRIVING 45 MPH ON A CITY STREET, THE RIGHT …
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 20 MPH ON A CITY STREET, THE LEFT FRONT DRIVER SIDE AXLE FRACTURED WITHOUT WARNING. THE CONTACT MANAGED TO PULL THE VEHICLE OVER WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE LEFT FRONT FRACTURED AXLE. AFTERWARDS, WHILE DRIVING 45 MPH ON A CITY STREET, THE RIGHT PASSENGER SIDE FRACTURED WHICH CAUSED A LOSS OF VEHICLE CONTROL. A CRASH WAS AVOIDED BY USING BRAKE PRESSURE. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE RIGHT FRONT FRACTURED AXLE. THE MANUFACTURER WAS ALERTED. UPDATED 09/16/06. *JB
NHTSA ODI #10167041
32,000 miles · Aug 25, 2006
Visibility
2005 GRAND CARAVAN WITH PRIVACY GLASS, I WAS STANDING 10' FROM CAR PARKED IN DRIVEWAY PAST 14 HRS, LEFT REAR SIDE WINDOW EXPLODED OUTWARD SENDING GLASS SHARDS 10' PERIMETER. AMBIENT TEMP WAS 67'F. *JB
NHTSA ODI #10166510
30,709 miles · Aug 19, 2006
EquipmentSteering
MY 2005 DODGE CARAVAN (ID4GP24RX5B305163) HAD THE RACK AND PINION REPLACED AT 30,709 MILES. AT 47,208 MILES THE RACK AND PINION AND PUMP HAD TO REPLACED AGAIN. THE VEHICLE WAS SEEN BY DEALER BEFORE SEVERAL TIMES BEFORE THEY CONFIRMED THE PROBLEM WITH THE RACK AND PINION. *NM
NHTSA ODI #10166020
37,000 miles · Jul 31, 2006
Latches/locks/linkages
DT*: THE CONTACT STATED THAT THE POWER DOOR LOCKS DO NOT FUNCTION PROPERLY. THE DOORS HAVE TO BE LOCKED MANUALLY. THE DEALERSHIP DETERMINED THE LOCKS NEEDED TO BE UPDATED WITH NEW SOFTWARE.
NHTSA ODI #10163962
30,900 miles · Jul 24, 2006
Structure
DT*: THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH THROUGH A FLOODED AREA, WATER SEEPED IN THROUGH THE PLUG OPENING FOR THE SPARE TIRE. DUE TO THE WATER, THE PLASTIC COVER WAS PULLED HALFWAY OFF THE TIRE, CAUSING IT TO DRAG ON THE ASPHALT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DETERMINED THE CAUSE OF T…
Read full complaint
DT*: THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH THROUGH A FLOODED AREA, WATER SEEPED IN THROUGH THE PLUG OPENING FOR THE SPARE TIRE. DUE TO THE WATER, THE PLASTIC COVER WAS PULLED HALFWAY OFF THE TIRE, CAUSING IT TO DRAG ON THE ASPHALT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE DEALER DETERMINED THE CAUSE OF THE DEFECT WAS DUE TO WATER SPRAYING UNDER THE COVER OF THE TIRE THEREFORE WEIGHING IT DOWN.
NHTSA ODI #10163337
NHTSA investigations
7DP14002 · Engine Stall After Refueling
Opened Sep 5, 2014 · Closed Apr 6, 2015
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
This defect petition evaluates July 7, 2014 allegations from an owner of a model year (MY) 2007 Dodge Grand Caravan minivan that engine stall occurs in these vehicles without warning after refueling.The petitioner's vehicle is a Chrysler RS platform minivan.The RS platform includes MY 2003 through 2007 Dodge Grand Caravan, Dodge Caravan, Chrysler Town and Country and Chrysler Voyager minivans.NHTSA evaluated the petition by analyzing consumer complaints submitted to the Agency, analyzing field data, reviewing technical information provided in Chrysler's response to an Agency information request and testing an RS minivan identified by its owner as experiencing post-refuel engine stalls.After completing this evaluation, NHTSA has concluded that further investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists.The stalls occurring in these vehicles only occur immediately after filling up the fuel tank and happen at low engine speeds. The failure rate is low, even after 8 to 13 years of the vehicles being in service, and there are no reports of crashes or injuries resulting from the stall condition.In the Agency's view, additional investigation is unlikely to result in finding the existence of a safety-related defect in the subject vehicles.Given the need to allocate and prioritize NHTSA's limited resources to best accomplish the Agency's safety mission, the petition is denied.This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency will take further action if warranted by future circumstances. More details concerning our review can be found in the Federal Register Notice for this action.The following 161 VOQs are included in the petition evaluation: 10209242, 10229468, 10240708, 10260923, 10275939, 10276532, 10296487, 10298175, 10328669, 10330144, 10346517, 10349789, 10354758, 10363689, 10372112, 10372368, 10372514, 10378031, 10379764, 10382938, 10387448, 10394063, 10398877, 10413918, 10418652, 10420924, 10427063, 10437525, 10445392, 10446902, 10470028, 10471249, 10473733, 10502231, 10503114, 10504260, 10509862, 10511988, 10512120, 10512385, 10512650, 10513147, 10538154, 10549841, 10551763, 10555188, 10555418, 10556754, 10565367, 10574012, 10574398, 10586555, 10587212, 10587559, 10593433, 10607841, 10607913, 10608922, 10615810, 10622468, 10628141, 10632112, 10632128, 10632172, 10632175, 10632231, 10632262, 10632266, 10632270, 10632305, 10632316, 10632326, 10632370, 10632385, 10632399, 10632492, 10632542, 10632765, 10632833, 10632928, 10633197, 10633281, 10633409, 10633421, 10633483, 10633507, 10637752, 10637804, 10637950, 10637975, 10638032, 10638289, 10638290, 10638401, 10638968, 10639218, 10639623, 10641157, 10641603, 10641614, 10641836, 10644339, 10644705, 10649713, 10649895, 10649932, 10650313, 10652590, 10653147, 10653783, 10654533, 10655226, 10658900, 10659679, 10660320, 10662588, 10662645, 10662662, 10663473, 10667056, 10667437, 10668081, 10668094, 10668131, 10668612, 10668969, 10668970, 10669584, 10669678, 10669729, 10669775, 10669866, 10669895, 10669992, 10670422, 10670506, 10676348, 10676732, 10677120, 10679795, 10679934, 10680057, 10680290, 10680342, 10680714, 10681512, 10682584, 10682906, 10683022, 10683114, 10683549, 10683620, 10683697, 10683743, 10689898, 10690761, 10691284, 10691556, 10691751, 10693061, 10694300
EA11010 · Loss Of Headlight Illumination
Opened Sep 6, 2011 · Closed Nov 29, 2012
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Additional source detail variants (4)
Electrical System
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
Exterior Lighting:headlights:switch
The subject vehicle (SV) population includes MY 2005-2006 vehicles built between March 2004 and December 2005 manufactured with a TRW supplied headlight switch assembly (HSA).The HSA was the primary focus of the investigation; earlier and later vehicles utilized different HSAs.Consumers complain that the headlights in the subject vehicles do not illuminate when the HSA is turned on, or that the headlights extinguish while on (subject failure).No other driving lights are affected.The front marker, tail, and instrument lamps operate.Also, the high beams can be illuminated by holding the turn signal stalk in the up position.As reported by consumers, turning the HSA off and on typically corrects the failure.Initially the failures occur infrequently but they become progressively more frequent with age.Chrysler has indicated its intention to offer of an extended lifetime warranty on the HSA, so that consumers with this problem can have their HSA replaced at no charge when they begin experiencing the subject failure.Commencing sometime in early 2013, Chrysler will send letters to SV owners notifying them of the lifetime warranty.The SV headlight system design is essentially the same as that described in EA 05-009, which involved headlight anomalies in earlier model Chrysler minivans; refer to it to for additional information.The subject failure is caused by friction between the plastic cam and metal surfaces of the electrical contacts in the HSA, which results in the production of plastic particles (debris).Analysis shows that debris can collect on the electrical contact that controls the headlights, resulting in an open circuit and preventing the headlights from turning on.Subsequent operation of the HSA may temporarily displace the debris, at which time the headlights operate correctly.Lubricant was applied to the plastic cam beginning in December 2005, reducing debris production.Consequently, subsequent failure levels were lower.The report counts shown above include only those that involve the subject failure.Reports involving other failure modes which were identified have not been included either because they were not safety related, or if they were safety related, because there was no defect trend.The single crash event listed in the Failure Report Summary Table above involved a deer strike allegedly due to loss of headlights in February 2006.No injuries were reported in this crash.An April 2004 non-crash incident (?Other? above) involved a momentary loss of headlights.The consumer drove into a ditch, and one minor injury was alleged. The subject vehicles experienced a 2.2% warranty claim rate.While standing alone this would appear to be significant, a portion of these warranty claims likely involve other problems with the HSA unrelated to the subject failure.In view of the on road experience of drivers in rapidly restoring headlight illumination by turning the headlight switch off and on again, the rate and particularly the recent trend in problems with the switch, and Chrysler?s extended lifetime warranty coupled with the owner notification of that extended warranty, further investigation does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Chrysler?s lifetime HSA warranty extension for the SV population will be available in the public file for this investigation.
AQ10001 · Fleet Vehicle Recall Completion Audit
Opened Nov 18, 2010 · Closed Dec 28, 2015
Status: closed (inferred from source dates) · Unknown Or Other
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.
PE10022 · Loss Of Headlight Illumination
Opened Jul 12, 2010 · Closed Sep 13, 2011
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Additional source detail variants (3)
Electrical System
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
Exterior Lighting:headlights:switch
To date, ODI has interviewed several complainants who confirmed that the headlights fully extinguish, and remain extinguished, on an intermittent basis.In most cases this occurred while the vehicle was in motion.The occurrences do not show a repeatable pattern, and the problem occurs at a low frequency, typically one or more weeks between failures.For this reason most complainants have not attempted diagnosis or repair of the problem, so the cause is unknown, and the problem continues to occur.In the cases where repairs have been attempted, which consisted mainly of headlight switch and body control module replacements, mixed success is reported.In interviews complainants advised ODI that they can usually toggle the headlight switch, or turn on the high beams by actuating the column stalk (pulling it upward), when the headlights unexpectedly turn off.Complainants report that toggling the switch is usually effective, and the high beams have always been available when the column is used.During the course of the interviews ODI was able to obtain a few suspect headlamp switches for further evaluation.No verifiable crashes or injuries have been identified in the vehicle owner complaints (VOQs).Chrysler notes that its complaints also include allegations of dimming or flickering of the headlights in addition to loss of headlamps, and that their analysis of available data indicates a declining trend occurring in the field.Chrysler data reports two alleged crash incidents; one where a consumers vehicle lost forward lighting and struck a deer, and one where a consumer alleged their lighting stopped working, causing them to depart the roadway and drive into a ditch.A minor injury is alleged in this second incident.Both incidents occurred several years ago, and neither allegation has been confirmed by ODI.ODI is upgrading this investigation to an Engineering Analysis (EA11-010) to continue its analysis of the alleged defect and its consequences, which will include additional analysis of consumer reports, their frequency and trend, and Chrysler's technical information for the headlight system and its components.Additionally testing will be conducted to evaluate possible root cause(s) of the alleged defect, and will include analysis of suspect components collected from the field, and/or assessment of subject vehicles that have reportedly experienced the condition.
RQ09003 · Front Air Bag Crash Sensor Failure
Opened Jul 1, 2009 · Closed Feb 18, 2010
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (3)
Air Bags:frontal
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:driver Side:inflator Module
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 312,442 MODEL YEAR (MY) 2005 AND 2006 CHRYSLER MINIVANS (RECALL 10V-008).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH ULTRADUR BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND WERE BUILT BETWEEN JANUARY 19, 2005 AND APRIL 5, 2006.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 185,000 MY 2005-2006 MINIVANS, ARE NOT INCLUDED IN THE RECALL.ALTHOUGH THESE VEHICLES USE THE SAME CRASH SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.ALSO, MY 2006-2007 MINIVANS BUILT AFTER APRIL 5, 2006, ARE NOT INCLUDED IN THE RECALL.THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH CRASTIN BRAND PLASTIC HOUSINGS AND STEEL BUSHINGS AND EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES COMPARED TO THE RECALLED VEHICLES.NHTSA AND CHRYSLER DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, CHRYSLER IS IMPLEMENTING STEPS TO REPLACE THE FRONT CRASH SENSORS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
EA06003 · Front Air Bag Crash Sensor Failure
Opened Mar 8, 2006 · Closed May 22, 2007
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Additional source detail variants (2)
Air Bags:frontal
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
Air Bags:frontal:sensor/control MODULE-INACTIVE
DAIMLERCHRYSLER (DCC) WILL REPLACE THE FRAME RAIL-MOUNTED FRONT AIR BAG CRASH SENSORS IN APPROXIMATELY 270,958 MY 2005 DAIMLERCHRYSLER MINIVANS (NHTSA RECALL NO. 07V-192).THESE VEHICLES ARE EQUIPPED WITH FRONT CRASH SENSORS WITH BRASS BUSHINGS AND WERE BUILT BETWEEN APRIL 24, 2003 AND FEBRUARY 2, 2005.THIS ACTION COVERS VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED, IN 27 STATES (ALASKA, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA AND WISCONSIN) AND THE DISTRICT OF COLUMBIA.VEHICLES SOLD OR CURRENTLY REGISTERED OUTSIDE OF THESE STATES, APPROXIMATELY 133,128 MY 2005 MINIVANS, WILL RECEIVE A LIFETIME WARRANTY ON THE FRONT CRASH SENSORS.ALTHOUGH THESE VEHICLES USE THE SAME BRASS BUSHING SENSORS AND WERE BUILT DURING THE SAME PERIOD AS THE ONES DESCRIBED ABOVE, THEY EXPERIENCE SIGNIFICANTLY LOWER FAILURE RATES BECAUSE OF REDUCED ROAD SALT EXPOSURE.DCC WILL ALSO PROVIDE WRITTEN NOTIFICATION TO ALL AFFECTED VEHICLE OWNERS.NHTSA AND DCC DIFFER REGARDING THE SIGNIFICANCE AND IMPACT OF THE DEFECT, BUT IN THE INTEREST OF REMEDYING THE AFFECTED VEHICLES EXPEDITIOUSLY AND TO AVOID A PROTRACTED DISPUTE, DCC IS IMPLEMENTING STEPS TO REPLACE THE SUBJECT COMPONENTS.BASED ON THESE ACTIONS, THE AGENCY HAS DECIDED THAT FURTHER USE OF ITS RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS IN THE SUBJECT VEHICLES.THE AGENCY WILL MONITOR THE ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SELECT DOCUMENT SEARCH FOR ADDITIONAL INFORMATION.
PE05061 · Front Air Bag Crash Sensor Failure
Opened Nov 10, 2005 · Closed Mar 8, 2006
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Additional source detail variants (2)
Air Bags:frontal
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Air Bags:frontal:sensor/control MODULE-INACTIVE
THE MODEL YEAR (MY) 2005 DAIMLERCHRYSLER (DC) MINIVANS HAVE THE NEW ADVANCED FRONTAL AIR BAG SYSTEMS WITH TWO FRONT CRASH SENSORS MOUNTED ON THE FRAME RAILS BEHIND THE FRONT BUMPER AND A MAIN CRASH SENSOR INSIDE THE AIR BAG CONTROL MODULE MOUNTED IN THE PASSENGER COMPARTMENT.ACCORDING TO DC, THE FRONT CRASH SENSORS ARE DESIGNED TO OPTIMIZE DETECTION OF FRONTAL OFFSET AND ANGULAR CRASHES.THE ADVANCED AIR BAG SYSTEM OFFERS DIFFERENT LEVELS OF AIR BAG INFLATION BASED ON INPUT FROM THE CRASH SENSORS.THIS INVESTIGATION REVEALED THAT THE FRONT CRASH SENSORS CAN CORRODE FROM WATER ENTERING THE SENSOR ASSEMBLY.DC IS STILL INVESTIGATING ALL POTENTIAL ROOT CAUSES OF SENSOR FAILURES.A CORRODED SENSOR CAN SET A FAULT CODE, ILLUMINATE THE AIR BAG WARNING LAMP, AND BECOME DISABLED.IT APPEARS THAT FAILURE OF ONE OR BOTH FRONT CRASH SENSORS CAN POTENTIALLY RESULT IN NO/LATE DEPLOYMENT OF FRONTAL AIR BAGS AND NON-DEPLOYMENT OF DRIVER'S HIGHER INFLATION LEVELS IN CERTAIN FRONTAL CRASHES.IT SHOULD BE NOTED THAT OCCUPANTS OF VEHICLES INVOLVED IN A CRASH MAY NOT BE AWARE OF LATE OR IMPROPERLY REDUCED LEVEL OF AIR BAG INFLATION AND THUS FIELD REPORTING OF SUCH EVENTS MAY BE SUPPRESSED.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-003) FOR FURTHER INVESTIGATION OF MY 2005 (AND 2006) DC MINIVANS.NOTE: TOTAL NUMBER OF ODI AND MANUFACTURER COMPLAINTS INCLUDES SOME DUPLICATE REPORTS.
Illustration